Application of Biofloc-Down flow hanging sponge system to remove nitrogen components in recirculating zero water exchange aquaculture system.

This study presents a novel approach to sustainable aquaculture by integrating biofloc technology (BFT) with a compact down-flow hanging sponge (DHS) reactor. The integrated BFT-DHS system effectively removed nitrogen compounds while maintaining ammonia-nitrogen (NH4+-N) concentrations below 1 mg-N L-1 without water exchange. Application of this system in a tank bred with juvenile Oreochromis niloticus showed a high NH4+-N removal rate of up to 97 % and nitrite (NO2- -N) concentrations were maintained at 0.1 ±â€¯0.1 mg-N L-1. Microbial analysis revealed Gordonia as the predominant genus in the biofloc contributing to heterotrophic nitrification, while the Peptostreptococcaceae family dominated the DHS reactor. Heterotrophic nitrification seemed to be the primary process for enhanced nitrogen removal. Pathogenic bacteria, Vibrio sp. was absent throughout the study. This study highlights the potential integration of BFT and DHS system for sustainable aquaculture practice with effective nitrogen removal.

Combination of a membrane bioreactor with a rotating biological contactor holding several diverse metazoans can reduce excess sludge with fouling mitigation.

In a membrane bioreactor (MBR) system, in situ sludge reduction techniques induce membrane fouling. To address this challenge, we incorporated a rotating mesh carrier, which can adsorb organic matter and provide a habitat for metazoans, into the anoxic tank of a conventional anoxic/oxic-MBR (A/O-MBR) system, termed rotating biological contactor-MBR (RBC-MBR), and evaluated treatment performance. Over 151 days, lab-scale RBC-MBR and A/O-MBR were used to treat municipal sewage. Both reactors showed similar COD and NH4+ removal rates. However, RBC-MBR reduced excess sludge by approximately 45 % compared with A/O-MBR. Microscopic observation and 18S rRNA gene-based microbial analysis revealed the persistence of microfauna and metazoans (oligochaetes, nematodes, and rotifers) in RBC, which are typically absent in activated sludge. Additionally, the metazoan's population in the RBC-MBR membrane tank was two-fold that of A/O-MBR, indicating enhanced sludge reduction through predation. Despite these reductions, the increase in transmembrane pressure was similar between RBC-MBR and A/O-MBR, suggesting that sludge holding by RBC mesh media degrade fouling substances, such as proteins and polysaccharides and improves sludge filterability, resulting in membrane fouling mitigation. Microbial communities in both reactors were similar, indicating that the installation of RBC did not alter the microbial community of sludge. Network analysis suggested potential symbiotic or prey-predator relationships between bacteria and metazoans. This study reveals that RBC-MBR effectively reduced the excess sludge while mitigating membrane fouling, highlighting one of the promising technology for applying metazoan predation into MBR.

Integration of down-flow hanging sponge reactor to oreochromis niloticus - Brassica oleracea aquaponics system.

Aquaponics is a promising solution for addressing food security concerns. Nonetheless, an effective water-purification system is necessary to achieve high and stable yields of fish and vegetables. This study aimed to evaluate the nitrification and oxygen transfer performance of a laboratory-scale down-flow hanging sponge (DHS) reactor with a Brassica oleracea aquaponics system to treat water in an Oreochromis niloticus closed-aquaculture system. The DHS reactor showed a higher oxygen transfer coefficient (KLa) than the conventional aerator and provided an adequate dissolved oxygen (DO) concentration of approximately 5.5 mg/L essential for O. niloticus growth throughout the experimental period. The evaluated DHS-based aquaponic system maintained high water quality in an aquaculture tank, with a survival rate of 97%. The O. niloticusgrew at a low feed conversion ratio of 1.5-2.1 and a low feeding rate of 0.5% at high stocking densities of 17.5-22.2 kg-fish-weight/m3. 16S rRNA gene sequencing indicated that the DHS sponge carrier effectively retained nitrifying bacteria such as Nitrosomonas and Nitrospira. This study demonstrated that the DHS reactor provided a high DO concentration and that a simultaneous DHS reactor with a hydroponic tank provided a low-cost aquaponic system that could be applied for food production in the aquaculture industry.

Nitrification characteristics and microbial community changes during conversion of freshwater to seawater in down-flow hanging sponge reactor.

In recirculating aquaculture systems (RAS), maintaining water quality in aquaculture tanks is a paramount factor for effective fish production. A down-flow hanging sponge (DHS) reactor, a trickling filter system used for water treatment of RAS that employs sponges to retain biomass, has high nitrification activity. However, nitrification in seawater RAS requires a long start-up time owing to the high salinity stress. Therefore, this study aimed to evaluate the nitrification characteristics and changes in the microbial community during the conversion of freshwater to seawater in a DHSreactor fed with ammonia-based artificial seawater. The total ammonia nitrogen concentration reached 1.0 mg-N·L-1 (initial concentration 10 mg-N·L-1) within 11 days of operation, and nitrate production was observed. The 16 S rRNA gene sequence of the DHS-retained sludge indicated that the detection rate of the ammonia-oxidizing archaeon Candidatus Nitrosocosmicus decreased from 23.9 % to 14.0 % and 25.8-17.6 % in the upper and lower parts of the DHS reactor, respectively, after the introduction of seawater. In contrast, the nitrite-oxidizing bacteria Nitrospira spp. increased from 0.1 % to 9.5 % and from 0.5 % to 10.5 %, respectively. The ammonia oxidation rates of 0.12 ± 0.064 and 0.051 ± 0.0043 mg-N·g-MLVSS-1·h-1 on the 37th day in the upper and bottom layers, respectively. Thus, nitrification in the DHS reactor performed well, even under high-salinity conditions with short operational days. This finding makes the transition from freshwater to saltwater fish in the RAS system simple and economical, and has the potential for early start-up of the RAS.

Azo dye anaerobic treatment in anaerobic reactors coupled with PVA/Fe/Starch gel bead.

A novel bio-carrier, PVA/Fe/starch gel bead, was fabricated and developed to enhance the anaerobic treatment performance of synthetic azo dye-containing wastewater. PVA-gel beads with 5 % magnetite and 0.5 % starch were optimal for physical strength and treatment performance. A pair of 2 L-up-flow anaerobic sludge blankets (UASB), one with the bead (UB) and another without (U) as a controller, operated continuously at 30 °C and an HRT of 11-24 h for 302 days. UB showed better performance than U in most phases, especially with influent dye of 200 mg·L-1, suggesting a greater tolerance to dye toxicity of UB than U. Microbial analysis revealed that the PVA/Fe/starch gel beads successfully captured the dye degrader Clostridium. Diversity indices indicated that PVA/Fe/Starch gel beads effectively support microbial diversity and resilience under varying dye concentrations. Overall, these findings demonstrate the potential of PVA/Fe/Starch gel beads to improve the stability and efficiency of the dye treatment system.

Distinct comammox Nitrospira in high-rate down-flow hanging sponge reactor treating municipal wastewater.

A down-flow hanging sponge (DHS) reactor is a trickling filter system used for wastewater treatment, which employs sponges to retain biomass. This study assessed the process performance of a compact DHS combined with a sedimentation tank with seven phases at varying hydraulic retention times (HRT) over 500 days. The BOD of the DHS effluent was maintained at 4.0 ± 0.5 mg·L-1 for the shortest HRT 0.3 ± 0.1 h. The nitrification efficiency was considerably impacted by the reduced HRT, with NH4+-N and NO3--N concentrations of 9.0 ± 1.2 mgN·L-1 and 2.2 ± 0.5 mgN·L-1, respectively. Nevertheless, the effluent complied with effluent discharge standards throughout the trial period. The number of comammox 16S rRNA gene copies ranged from 5.58 to 13.2 × 107 copies·mL-1, indicating that sponges biomass retained carrier can provide favorable conditions for comammox growth and could contribute to nitrification in the high-rate DHS reactor.

Harnessing iron materials for enhanced decolorization of azo dye wastewater: A comprehensive review.

Highly colored azo dye-contaminated wastewater poses significant environmental threats and requires effective treatment before discharge. The anaerobic azo dye treatment method is a cost-effective and environmentally friendly solution, while its time-consuming and inefficient processes present substantial challenges for industrial scaling. Thus, the use of iron materials presents a promising alternative. Laboratory studies have demonstrated that systems coupled with iron materials enhance the decolorization efficiency and reduce the processing time. To fully realize the potential of iron materials for anaerobic azo dye treatment, a comprehensive synthesis and evaluation based on individual-related research studies, which have not been conducted to date, are necessary. This review provides, for the first time, an extensive and detailed overview of the utilization of iron materials for azo dye treatment, with a focus on decolorization. It assesses the treatment potential, analyzes the influencing factors and their impacts, and proposes metabolic pathways to enhance anaerobic dye treatment using iron materials. The physicochemical characteristics of iron materials are also discussed to elucidate the mechanisms behind the enhanced bioreduction of azo dyes. This study further addresses the current obstacles and outlines future prospects for industrial-scale application of iron-coupled treatment systems.

Identification and cultivation of anaerobic bacterial scavengers of dead cells.

The cycle of life and death and Earth's carbon cycle(s) are intimately linked, yet how bacterial cells, one of the largest pools of biomass on Earth, are recycled back into the carbon cycle remains enigmatic. In particular, no bacteria capable of scavenging dead cells in oxygen-depleted environments have been reported thus far. In this study, we discover the first anaerobes that scavenge dead cells and the two isolated strains use distinct strategies. Based on live-cell imaging, transmission electron microscopy, and hydrolytic enzyme assays, one strain (designated CYCD) relied on cell-to-cell contact and cell invagination for degrading dead food bacteria where as the other strain (MGCD) degraded dead food bacteria via excretion of lytic extracellular enzymes. Both strains could degrade dead cells of differing taxonomy (bacteria and archaea) and differing extents of cell damage, including those without artificially inflicted physical damage. In addition, both depended on symbiotic metabolic interactions for maximizing cell degradation, representing the first cultured syntrophic Bacteroidota. We collectively revealed multiple symbiotic bacterial decomposition routes of dead prokaryotic cells, providing novel insight into the last step of the carbon cycle.

Investigate the anaerobic degradation of high-acetone latex wastewater with magnetite supplement.

This study evaluated the effects of acetone on the anaerobic degradation of synthetic latex wastewater, which was simulated from the wastewater of the deproteinized natural rubber production process, including latex, acetate, propionate, and acetone as the main carbon sources, at a batch scale in 5 cycles of a total of 60 days. Fe3O4 was applied to accelerate the treatment performance from cycle 3. Acetone was added in concentration ranges of 0%, 0.05%, 0.1%, 0.15%-included latex, and 0.15%-free latex (w/v). In the Fe3O4-free cycles, for latex-added vials, soluble chemical oxygen demand (sCOD) was removed at 43.20%, 43.20%, and 12.65%, corresponding to the input acetone concentrations varying from 0.05% to 0.15%, indicating the interference of acetone for COD reduction. After adding Fe3O4, all flasks reported a significant increase in COD removal efficiency, especially for acetone-only and latex-only vials, from 36.9% to 14.30%-42.95% and 83.20%, respectively. Other highlighted results of COD balance showed that Fe3O4 involvement improved the degradation process of acetate, propionate, acetone, and the other COD parts, including the intermediate products of latex reduction. Besides, during the whole batch process, the order of reduction priority of the carbon sources in the synthetic wastewater was acetate, propionate and acetone. We also found that the acetate concentration appeared to be strongly related to reducing other carbon sources in natural rubber wastewater. Microbial community analysis revealed that protein-degrading bacteria Bacteroidetes vadinHA17 and Proteinniphilum and methylotrophic methanogens might play key roles in treating simulated deproteinized-natural-rubber wastewater.

Characteristics of organic removal for supermarket wastewater treatment with an anaerobic baffled reactor and efficacy evaluation of changing HRT.

An anaerobic baffled reactor (ABR) is one of the useful wastewater treatment technologies, but the knowledge about its treatment performance for actual wastewater with load fluctuation is limited. The organic removal performance of an ABR for treating supermarket wastewater was evaluated. The ABR, which consisted of eight columns, was examined under four hydraulic retention time (HRT) conditions of 19.4, 12.9, 8.0, and 4.4 h. As a result, the unfiltered chemical oxygen demand (COD) removal efficiency was 80 (±8) % at an HRT of 19.4 h. When the HRT was shortened to 12.9 h, the average unfiltered COD removal efficiency decreased to 58 (±15) %. However, it showed buffering effect against high load inflow in the first column, indicating that it is useful as a pretreatment system under this condition. At an HRT of 4.4 h, the unfiltered COD removal efficiency decreased to 9%, indicating the system failed. The results of the microbial community structure analysis showed that the detection frequency of acidogenic bacteria decreased in proportion to the extension of residence time in the reactor. These results indicate that the ABR is useful for the treatment of supermarket wastewater with load fluctuations as a main treatment system at a HRT of 19.4 h and as a pretreatment system at a HRT of 12.9 h.

An increase in sludge loading rate induces gel fouling in membrane bioreactors treating real sewage.

The main objective of this study was to investigate the cause of gel fouling in membrane bioreactors (MBRs) treating real sewage in terms of soluble microbial products (SMPs) and microbial aspects. Two anoxic/oxic-MBRs were operated as the control reactor (S1) and the sludge loading rate increased reactor (S2). The reactors were operated under low-temperature around 11 °C conditions. Membrane permeability substantially decreased in S2, and gel layer biofilm was formed on membrane surface. In contrast, the permeability of S1 gradually decreased and cake layer formed. When gel fouling occurred, the protein and polysaccharide of SMP in S2 were 47 and 23 mg L-1, which were significantly lower than those recorded in S1 accounted for 118 and 68 mg L-1, respectively. Furthermore, the total organic carbon concentration of SMPs was 24 mg L-1, which was lower than the influent in S2, accounted for 62 mg L-1. Finally, Campylobacteraceae which exists in sewage and uncultured OD1, dominated the gel layer biofilm in S2, unlike the cake layer biofilm in S1. These results indicated that the gel layer biofilm might be composed of influent substances, demonstrating the importance of influent decomposition in MBR for gel fouling mitigation.

Effects of denitrifying granular sludge addition on activated sludge and anaerobic-aerobic systems for municipal sewage treatment.

Conventional activated sludge (AS) systems are widely used to treat domestic sewage worldwide. However, the removal of nitrogen in the AS system is limited, and its concentration in the effluent exceeds the recommended values in the discharge standards. In this study, a pilot experiment was conducted to improve nitrogen removal during municipal sewage treatment by operating AS and anaerobic-aerobic (AO) systems under low dissolved oxygen (DO) conditions of less than 0.5 mg L-1 and by adding denitrifying granular sludge. The low DO operation of the AS and AO systems led to the sludge washout and increased the organic content and ammonia and nitrate concentration of the effluent. In contrast, the nitrate concentrations of the effluents produced by the AS and AO systems were 9.4 ± 3.6 and 8.4 ± 0.7 mg-N L-1, respectively, indicated that denitrifying granular sludge addition enhanced denitrification during sewage treatment. The total nitrogen (TN) removal efficiency increased by 13% and 9% for the AS and AO systems despite a decrease in the temperature of 6 °C for the water in the aeration tank. Thus, adding denitrifying granular sludge to the aeration tank is a simple and effective approach to improve organic and nitrogen removal during wastewater treatment.

Manganese oxidation and prokaryotic community analysis in a polycaprolactone-packed aerated biofilm reactor operated under seawater conditions.

Biogenic manganese oxides (BioMnOx) have been receiving increasing attention for the removal of environmental contaminants and recovery of minor metals from water environments. However, the enrichment of heterotrophic Mn(II)-oxidizing microorganisms for BioMnOx production in the presence of fast-growing coexisting heterotrophs is challenging. In our previous work, we revealed that polycaprolactone (PCL), a biodegradable aliphatic polyester, can serve as an effective solid organic substrate to enrich Mn-oxidizing microbial communities under seawater conditions. However, marine BioMnOx-producing bioreactor systems utilizing PCL have not yet been established. Therefore, a laboratory-scale continuous-flow PCL-packed aerated biofilm (PAB) reactor was operated for 238 days to evaluate its feasibility for BioMnOx production under seawater conditions. After the start-up of the reactor, the average dissolved Mn removal rates of 0.4-2.3 mg/L/day, likely caused by Mn(II) oxidation, were confirmed under different influent dissolved Mn concentrations (2.5-14.0 mg/L on average) and theoretical hydraulic retention time (0.19-0.77 day) conditions. The 16S rRNA gene amplicon sequencing analysis suggested the presence of putative Mn(II)-oxidizing and PCL-degrading bacterial lineages in the reactor. Two highly dominant operational units (OTUs) in the packed PCL-associated biofilm were assigned to the genera Marinobacter and Pseudohoeflea, whereas the genus Lewinella and unclassified Alphaproteobacteria OTUs were highly dominant in the MnOx-containing black/dark brown precipitate-associated biofilm formed in the reactor. Excitation-emission matrix fluorescence spectroscopy analysis revealed the production of tyrosine- and tryptophane-like components, which may serve as soluble heterotrophic organic substrates in the reactor. Our findings indicate that PAB reactors are potentially applicable to BioMnOx production under seawater conditions.

Growth of nitrite-oxidizing Nitrospira and ammonia-oxidizing Nitrosomonas in marine recirculating trickling biofilter reactors.

Aerobic ammonia and nitrite oxidation reactions are fundamental biogeochemical reactions contributing to the global nitrogen cycle. Although aerobic nitrite oxidation yields 4.8-folds less Gibbs free energy (∆Gr ) than aerobic ammonia oxidation in the NH4 + -feeding marine recirculating trickling biofilter reactors operated in the present study, nitrite-oxidizing and not ammonia-oxidizing Nitrospira (sublineage IV) outnumbered ammonia-oxidizing Nitrosomonas (relative abundance; 53.8% and 7.59% respectively). CO2 assimilation efficiencies during ammonia or nitrite oxidation were 0.077 µmol-14 CO2 /µmol-NH3 and 0.053-0.054 µmol-14 CO2 /µmol-NO2 - respectively, and the difference between ammonia and nitrite oxidation was much smaller than the difference of ∆Gr . Free-energy efficiency of nitrite oxidation was higher than ammonia oxidation (31%-32% and 13% respectively), and high CO2 assimilation and free-energy efficiencies were a determinant for the dominance of Nitrospira over Nitrosomonas. Washout of Nitrospira and Nitrosomonas from the trickling biofilter reactors was also examined by quantitative PCR assay. Normalized copy numbers of Nitrosomonas amoA were 1.5- to 1.7-folds greater than Nitrospira nxrB and 16S rRNA gene in the reactor effluents. Nitrosomonas was more susceptible for washout than Nitrospira in the trickling biofilter reactors, which was another determinant for the dominance of Nitrospira in the trickling biofilter reactors.

Effect of formic acid inflow on microbial properties of the anaerobic granular sludge in a UASB reactor.

In the production of natural rubber, formate or acetate is added to the latex solution to coagulate the rubber; therefore, the wastewater contains high concentrations of organic acids, requiring the application of anaerobic treatment technology. In this study, a two-phase continuous flow experiment using a laboratory-scale upflow anaerobic sludge blanket (UASB) was conducted to investigate the influence of formate inflow on the microbial and physical characteristics of the retained granular sludge. In phase 1, acetate-based wastewater was used as feed, while in phase 2, formate-based wastewater was used as feed. In phase 1, the UASB exhibited high COD removal efficiency (97.2%); in addition, the retained sludge showed increased methane production from acetate and proliferation of acetate-utilizing Methanosaeta species. In phase 2, the UASB performed as well as phase 1, with 98.2% COD removal efficiency. Microbial community structure analysis confirmed that relatives of Methanobacterium formicicum present in the retained sludge were responsible for the degradation of formate in phase 2. However, decreased diameter and slight deterioration of granular sludge settleability were observed. In conclusion, formate inflow has low risk of interference with the process performance of the UASB, but it has negative effects on the physical properties of the granular sludge.

A potential zero water exchange system for recirculating aquarium using a DHS-USB system coupled with ozone.

Partial water exchange is one of the most common conventional methods used to maintain water quality and aesthetic beauty in recirculating aquarium systems (RASs). However, this method uses substantial amount of water. The ozone-down-flow hanging sponge-up-flow sludge blanket (ozone-DHS-USB) system attempts to be a more responsible method for aquarium maintenance. It eliminates the necessity for water exchange in aquarium by maintaining nitrogen concentrations at a safe level and by reducing yellow substances. Also, the impact of O3 on the DHS-USB system was investigated. The system was assayed using an on-site freshwater aquarium influenced by ambient temperature ranging from 23°C to 34°C. During ozonation Phases 1 and 3, the colour of the water in the aquarium was successfully maintained below 10 colour units. The 16S rRNA gene analysis of microorganisms in the DHS revealed that constant application of O3 has caused a decrease in nitrite-oxidizing bacteria (NOB). Nevertheless, NH3 and NO2- were maintained within 0.1 mg N L-1, and NO3- was maintained at 14.6 ± 9.20 mg N L-1 throughout the study. Carps survived for 425 days without any water exchange performed. Our study supports that the ozone-DHS-USB system has a high potential towards creating low-maintenance aquaria.

Hexavalent Chromium Removal and Prokaryotic Community Analysis in Glass Column Reactor Packed with Aspen Wood as Solid Organic Substrate.

Microbial hexavalent chromium (Cr(VI)) reduction is a promising method for Cr(VI)-laden wastewater treatment. However, the soluble organic substrate required for heterotrophic microbial Cr(VI) reduction necessitates constant supervision, and an excessive supply of soluble organic substrate can result in deterioration of the quality of the effluent. In this study, we evaluated aspen wood, a low-cost lignocellulose biomass, as a solid organic substrate for heterotrophic Cr(VI) reduction. A laboratory-scale aspen wood-packed glass column reactor inoculated with activated sludge was operated for 148 days for evaluation. Following reactor operation, an effective average dissolved Cr(VI) removal rate of 0.75 mg L-1 h-1 was confirmed under an average dissolved Cr(VI) loading rate of 0.90 mg L-1 h-1. Subsequently, 16S ribosomal ribonucleic acid gene amplicon sequencing analysis revealed that the dominant prokaryotic operational taxonomic units detected in the reactor were associated with prokaryotic lineages with the capacity for lignocellulose biodegradation, Cr compound resistance, and Cr(VI) reduction. Proteobacteria and Chloroflexi were two major prokaryotic phyla in the reactor. Our data indicate that aspen wood is an effective solid organic substrate for the development of simplified, effective, and low-cost microbial Cr(VI)-removing reactors.

Efficiency of high rate treatment of low-strength municipality sewage by a pilot-scale combination system of a sedimentation tank and a down-flow hanging sponge reactor.

Down-flow hanging sponge (DHS) reactor that is sponge-based trickling filter was considered to be an alternative aerobic treatment system for low strength sewage treatment under tropical conditions. This study aims to determine the process performance of the DHS reactor combined with a pre-treatment sedimentation tank (SED) system installed at the municipality sewage treatment plant in Khon Kaen, Thailand over, 1,600 days. The DHS reactor was operated with three operational periods: low (0.2 kgBODm3 per day), high (0.5-1.3 kgBODm3 per day), and super rates (1.7-2.2. kgBODm3 per day). The results showed effective reductions in biochemical oxygen demand (BOD) and suspended solids by more than 74% and 78%, respectively, during the entire experimental period. Moreover, the final effluent met the Thailand discharge standard with an external short hydraulic retention time of 0.2 h. In addition, the combined system facilitates simultaneous nitrification and denitrification and effectively removed up to 43% of total nitrogen. The self-degradation of the organic compounds occurs owing to the retained sludge in the DHS reactor; this leads to undisputed clogging in sponge media. Therefore, the combined SED-DHS system could be an appropriate sewage treatment system for tropical conditions.

Enhanced decolorization of dyeing wastewater in a sponges-submerged anaerobic reactor.

This study was conducted to assess the potential of a sponges-submerged anaerobic baffled reactor (SS-ABR) for enhancing the processing performance of azo dye-contaminated wastewater. A lab-scale four-compartment SS-ABR, with a total volume of 10 L, was operated at 30 °C for 180 days. A total of 14 polyurethane sponges were added in each compartment to treat synthetic wastewater including a commercial azo dye Hellozol HSR Reactive Black. During the entire operation, in synthetic wastewater, starch was used as a sole carbon source, and the true color level was maintained at 1050 ± 98 Pt/Co. Meanwhile, the hydraulic retention time (HRT) and total COD (T-COD) in the influent were changed to evaluate the SS-ABR treatment performance. After the start-up phase, true color and T-COD removal efficiencies were recorded as 65 ± 3% and 83 ± 2%, 68 ± 5% and 81 ± 4%, and 70 ± 5% and 84 ± 2% for HRT and influent T-COD concentration of 18.6 h and 260 mg L-1, 14.6 h and 260 mg L-1, and 14.6 h and 460 mg L-1, respectively. The microbial community analysis showed that bacterial groups involved in dye degradation, such as Clostridium sp., and sulfate-reducing bacteria Desulfomonile sp. and Desulfovibrio sp. were detected prominently in the SS-ABR. Interestingly, the SS-ABR exhibited the dominance of both Geobacter sp. and Methanosarcina sp., and their occurrences in all columns were proportional to each other, revealing the formation of syntrophic relationships.

Development of UASB-DHS system for anaerobically-treated tofu processing wastewater treatment under ambient temperature.

Tofu is widely processed in East and Southeast Asian countries. During the production, highly polluted wastewater is discharged. This wastewater is commonly treated using a high-rate anaerobic wastewater treatment process; however, several organic compounds and nitrogen remain in the anaerobic effluent. The aim of this study was to develop a combined upflow anaerobic sludge blanket (UASB) and downflow hanging sponge (DHS) biosystem that that serves as a post-treatment for an expanded granular sludge blanket reactor used for treating tofu-processing wastewater in Japan for 699 days. The UASB reactor played a role in treating of COD, with 58 ± 16% and 74 ± 20% of total COD and soluble COD removed anaerobically. Besides, methane was recovered from removed soluble COD were 63 ± 28% and 87 ± 64% at winter and summer. Meanwhile, the DHS reactor showed its potential in treatment of BOD and TSS. The final effluents were recorded as 67 ± 38 mg L-1, 50 ± 26 mg L-1, and 22 ± 16 mg L-1 of total COD, BOD and total suspended solids, respectively. This indicates that the proposed UASB-DHS system has proven its suitability as post-treatment system for anaerobically treated tofu-processing wastewater.