The secondary metabolites from Beauveria bassiana PQ2 inhibit the growth and spore germination of Gibberella moniliformis LIA.

Fungal secondary metabolites with antimicrobial properties are used for biological pest control. Their production is influenced by several factors as environment, host, and culture conditions. In the present work, the secondary metabolites from fermented extracts of Beauveria bassiana PQ2 were tested as antifungal agents against Gibberella moniliformis LIA. The L18 (21 × 37) orthogonal array from Taguchi methodology was used to assess 8 parameters (pH, agitation, sucrose, yeast extract, KH2PO4, MgSO4, NH4NO3, and CaCl2) in B. bassiana PQ2 submerged fermentation. The ability of the fermented extracts to slow down the growth rate of G. moniliformis LIA was evaluated. The results from 18 trials were analyzed by Statistica 7 software by evaluating the signal-to-noise ratio (S/N) to find the lower-the-better condition. Optimal culture conditions were pH, 5; agitation, 250 rpm; sucrose, 37.5 g/L-1; yeast extract, 10 g/L-1; KH2PO4, 0.8 g/L-1; MgSO4, 1.2 g/L-1; NH4NO3, 0.1 g/L-1; and CaCl2, 0.4 g/L-1, being the agitation at the highest level the most significant factor. The optimal conditions were validated in a sparged bottle bioreactor resulting in a higher S/N value (12.48) compared to the estimate. The extract obtained has the capacity to inhibit the germination of G. moniliformis spores at 24 h. HPLC-ESI-MS2 allowed to identify the water-soluble red pigment as oosporein (m/z 304.9). The secondary metabolites from B. bassiana PQ2 are a suitable alternative to control the growth and sporulation of G. moniliformis.

A simple quantitative method using TLC-image analysis to determine fructooligosaccharides (FOS) in food samples.

The thin-layer chromatography technique (TLC) is a simple and inexpensive analysis commonly used to identify qualitatively the presence of carbohydrates in food samples such as mono- di and oligosaccharides particularly. TLC assay could be improved using image processing software for the semiquantitative determination of this type of compound. In the present work, TLC-image analysis with Silica Gel 60 TLC plates was used for the semiquantitative determination of 6 standards of carbohydrates (glucose, fructose, sucrose, 1-kestose, nystose, and fructofuranosylnystose). Subsequently, the areas of the spots of each compound were determined by digitizing in a conventional office scanner. Then, the segmentation of the images is carried out using software for image processing. The calibration curves were plotted in the Excel software using the average of the areas of the pigmentations obtained in pixels. In this study, the technique of thin-layer chromatography was also used to quantitatively determine the presence of carbohydrates in food samples such as honey, garlic, and onion. Values of determination coefficient (R2) greater than 0.97 in all the calibration curves were obtained. This technique could be useful for detecting carbohydrates (monosaccharides, disaccharides, and oligosaccharides) in analytical assays and food samples without needing specialized analytical equipment. In this work, it was possible to determine the concentration of carbohydrates in samples of garlic and onion that showed the presence of prebiotic carbohydrates in addition to sucrose, glucose, and fructose.

Characterization of a Biofilm Bioreactor Designed for the Single-Step Production of Aerial Conidia and Oosporein by Beauveria bassiana PQ2.

Beauveria bassiana is an entomopathogenic fungus that is used for the biological control of different agricultural pest insects. B. bassiana is traditionally cultivated in submerged fermentation and solid-state fermentation systems to obtain secondary metabolites with antifungal activity and infective spores. This work presents the design and characterization of a new laboratory-scale biofilm bioreactor for the simultaneous production of oosporein and aerial conidia by B. bassiana PQ2. The reactor was built with materials available in a conventional laboratory. KLa was determined at different air flows (1.5-2.5 L/min) by two different methods in the liquid phase and in the exhaust gases. The obtained values showed that an air flow of 2.5 L/min is sufficient to ensure adequate aeration to produce aerial conidia and secondary metabolites by B. bassiana. Under the conditions studied, a concentration of 183 mg oosporein per liter and 1.24 × 109 spores per gram of support was obtained at 168 h of culture. These results indicate that the biofilm bioreactor represents a viable alternative for the production of products for biological control from B. bassiana.

Effect of ultrasound treatment on the extraction of antioxidants from Ardisia compressa Kunth fruits and identification of phytochemicals by HPLC-ESI-MS.

The influence of ultrasound-assisted extraction of phytochemicals from Ardisia compressa Kunth on the antioxidant capacity was investigated. The factors evaluated were: ultrasound extraction time (10, 20 and 30 min), ethanol concentration (0, 35, 70 %) and solid/liquid ratio (1:4, 1:8 and 1:12 g mL-1). The L9 (3)3 array was applied, and the DPPH• scavenging capacity of treatments was evaluated to obtain optimal extraction conditions. Finally, the phytochemicals were characterized by high-performance liquid chromatography electrospray ionization mass spectrometry (HPLC-ESI-MS). Ten minutes of ultrasound extraction using 0 % of ethanol and solid/liquid ratio 1:12 g mL-1 were the optimal conditions of extraction. The HPLC-ESI-MS analysis revealed the presence of gluconic acid, quercetin-3-O-glucoside, isorhamnetin-3-O-rutinoside, demethylligstroside, ponicidin, 4-caffeoylquinic acid, rosmarinic acid, and galloyl-hexoside. The optimal ultrasound-assisted extraction conditions were defined by applying the Taguchi methodology. The phytochemicals identified in A. compressa fruits suggest its use as a potential source of bioactive compounds.