The use of distillers dried grains plus solubles as a feed ingredient on air emissions and performance from laying hens.

The objectives of the current study were to evaluate the effect of feeding diets containing 0, 10, or 20% distillers dried grains plus solubles (DDGS) to laying hens (21 to 26 wk of age) on emissions of NH3 and H2S. Hy-Line W-36 hens (n = 640) were allocated randomly to 8 environmental rooms for a 5-wk period (hens in 3 rooms were offered the 10% and 20% DDGS diets each; hens in 2 rooms were offered the 0% DDGS diet). Diets were formulated to contain similar CP levels (18.3%), nonphytate P (0.46%), and Ca (4.2%). On an analyzed basis, the 0, 10, and 20% DDGS diets contained 0.22, 0.27, and 0.42% S. Egg weight (50.9 g), egg production (85%), and feed intake (87.9 g/hen per d) were unaffected by diet (P > 0.05) over the study period. Daily NH3 emissions from hens fed diets containing 0, 10, and 20% DDGS were 105.4, 91.7, and 80.2 mg/g of N consumed, respectively (P < 0.05). Daily H2S emissions from hens fed commercial diets containing 0, 10, and 20% DDGS were 2.6, 2.4, and 1.1 mg/g of S consumed, respectively. Overall, feeding 21- to 26-wk-old laying hens diets containing 20% DDGS decreased daily NH3 emissions by 24% and H2S emissions by 58%. Each hen emitted approximately 280 mg of NH3 and 0.5 mg of H2S daily when fed a control diet containing 18% CP and 0.2% S. The results of this study demonstrate that 20% DDGS derived from ethanol production can be fed to laying hens, resulting in lower emissions of NH3 and H2S with no apparent adverse effects on hen performance.

Nutrient digestibility and mass balance in laying hens fed a commercial or acidifying diet.

The objectives of the current study were to evaluate the effect of an acidifying diet (gypsum) combined with zeolite and slightly reduced crude protein (R) vs. a control diet (C) on nutrient retention in laying hens and compare 3 approaches to estimating nutrient excretion from hens: 1) mass balance calculation (feed nutrients - egg nutrient), 2) use of an indigestible marker with analyzed feed and excreta nutrient content, and 3) an environmental chamber that allowed for capturing all excreted and volatilized nutrients. Hens (n = 640) were allocated randomly to 8 environmental chambers for 3-wk periods. Excreta samples were collected at the end of each trial to estimate apparent retention of N, S, P, and Ca. No diet effects on apparent retention of N were observed (53.44%, P > 0.05). Apparent retention of S, P, and Ca decreased in hens fed R diet (18.7, - 11.4, and 22.6%, respectively) compared with hens fed the C diet (40.7, 0.3, and 28.6%, respectively; P < 0.05). Total N excretion from hens fed the C and R diet was not different (1.16 g/hen/d); however, mass of chamber N remaining in excreta following the 3-wk period was less from hens fed the C diet (1.27 kg) than from hens fed the R diet (1.43 kg). Gaseous emissions of NH(3) over the 3-wk period from hens fed the C diet (0.74 kg per chamber) were greater than emissions from hens fed the R diet (0.45 kg). The 3-wk S excretion mass (estimated using the calculation, indigestible marker, and environmental chamber methods, respectively) was greater from hens fed the R diet (1.85, 1.54, and 1.27 kg, respectively) compared with hens fed the C diet (0.24, 0.20, and 0.14 kg, respectively). The 3-wk P excretion was similar between diets (0.68 kg). Results demonstrate that feeding the acidified diet resulted in decreased N emissions, but because of the acidulant fed, greatly increased S excretion and emissions.

Effect of an acidifying diet combined with zeolite and slight protein reduction on air emissions from laying hens of different ages.

The objectives of the study were to evaluate the effectiveness of a reduced-emission (RE) diet containing 6.9% of a CaSO(4)-zeolite mixture and slightly reduced CP to 21-, 38-, and 59-wk-old Hy-Line W-36 hens (trials 1, 2, and 3, respectively) on egg production and emissions of NH(3), H(2)S, NO, NO(2), CO(2), CH(4), and non-CH(4) total hydrocarbons as compared with feeding a commercial (CM) diet. At each age, 640 hens were allocated, randomly to 8 environmental chambers for a 3-wk period. On an analyzed basis, the CM diet contained 18.0, 17.0, and 16.2% CP and 0.25, 0.18, and 0.20% S in trials 1, 2, and 3, and the RE diet contained 17.0, 15.5, and 15.6% CP and 0.99, 1.20, and 1.10% S in trials 1, 2, and 3. Diets were formulated to contain similar Ca and P contents. Average daily egg weight (56.3 g), average daily egg production (81%), average daily feed intake (92.4 g), and BW change (23.5 g), across ages, were unaffected by diet (P > 0.05) over the study period. Age effects were observed for all performance variables and NH(3) emissions (P < 0.05). In trials 1, 2, and 3, daily NH(3) emissions from hens fed the RE diets (185.5, 312.2, and 333.5 mg/bird) were less than emissions from hens fed the CM diet (255.1, 560.6, and 616.3 mg/bird; P < 0.01). Daily emissions of H(2)S across trials from hens fed the RE diet were 4.08 mg/bird compared with 1.32 mg/bird from hens fed the CM diet (P < 0.01). Diet (P < 0.05) and age (P < 0.05) affected emissions of CO(2) and CH(4). A diet effect (P < 0.01) on NO emissions was observed. No diet or age effects (P > 0.05) were observed for NO(2) or non-CH(4) total hydrocarbons. Results demonstrated that diet and layer age influence air emissions from poultry operations.