Establishment of In Vitro Dissolution Based on Similarity with In Vivo Dissolution: A Case Study on Aripiprazole.

In vitro dissolution that predicts the in vivo performance of solid preparations is extremely important in formulation optimization. Fraction absorbed (Fa) has been used to screen in vitro dissolution protocols based on the idea of in vitro-in vivo correlation (IVIVC) but failed to increase the success rate due to the inaccuracy of the Fa. The essence of IVIVC is the correlation between in vitro dissolution and in vivo dissolution. We tried to establish in vitro dissolution protocol via similarity with in vivo dissolution using aripiprazole (APZ) as a model drug. Hybrid APZ crystals (APZ-HCs) were prepared by physically embedding aggregation-caused quenching (ACQ) fluorophores inside the lattice to measure the in vivo dissolution. The process did not change the physicochemical properties and crystallinity of APZ. The fluorophore illuminated APZ crystals but was quenched upon dissolution of APZ-HCs in aqueous media, enabling monitoring intact APZ-HCs in real-time. The good correlation between fluorescent quenching and dissolution of APZ-HCs justified reliable quantification of intact APZ crystals. The residual percentage of fluorescence intensity in rats treated by APZ-HCs was recorded with time, which was converted to in vivo dissolution by the difference from 100%. The in vivo dissolution was validated with the Fa. The in vitro dissolution profile of APZ was set up via a similarity factor larger than 50 in comparison with the in vivo dissolution. The study provides a novel idea and method to establish in vitro dissolution protocol.

In vivo dissolution of poorly water-soluble drugs: Proof of concept based on fluorescence bioimaging.

In vitro‒in vivo correlation (IVIVC) of solid dosage forms should be established basically between in vitro and in vivo dissolution of active pharmaceutical ingredients. Nevertheless, in vivo dissolution profiles have never been accurately portrayed. The current practice of IVIVC has to resort to in vivo absorption fractions (F a). In this proof-of-concept study, in vivo dissolution of a model poorly water-soluble drug fenofibrate (FNB) was investigated by fluorescence bioimaging. FNB crystals were first labeled by near-infrared fluorophores with aggregation-caused quenching properties. The dyes illuminated FNB crystals but quenched immediately and absolutely once been released into aqueous media, enabling accurate monitoring of residual drug crystals. The linearity established between fluorescence and crystal concentration justified reliable quantification of FNB crystals. In vitro dissolution was first measured following pharmacopoeia monograph protocols with well-documented IVIVC. The synchronicity between fluorescence and in vitro dissolution of FNB supported using fluorescence as a measure for determination of dissolution. In vitro dissolution correlated well with in vivo dissolution, acquired by either live or ex vivo imaging. The newly established IVIVC was further validated by correlating both in vitro and in vivo dissolution with F a obtained from pharmacokinetic data.

The biological fate of orally administered mPEG-PDLLA polymeric micelles.

The biological fate of polymeric micelles (PMs) following oral administration was investigated in this study to better understand the contribution of transport of integral PMs to oral absorption. To track integral PMs, near-infrared fluorophores with aggregation-caused quenching properties were utilized to label PMs comprised of methoxy poly(ethylene glycol)-poly(D,L-lactic acid) (mPEG-PDLLA) copolymers and methoxy poly(ethylene glycol)-distearoyl phosphoethanolamine (DSPE-PEG). The particle size of PMs prepared from mPEG2.5k-PDLLA1.25k, mPEG2.5k-PDLLA2.5k, mPEG5k-PDLLA3k, mPEG5k-PDLLA5k and DSPE-PEG2k was 24.5, 29.5, 34.0, 41.4 and 15.6 nm, respectively. After oral administration by gavage to rats, PMs were retained in the gastrointestinal tract for at least 4 h, and the copolymer block chain lengths did not have significant influence. The emergence of fluorescence in the blood and liver served as direct evidence to support oral absorption of integral PMs. Approximately 1-2% of intact particles were absorbed via the lymphatic pathway, but the total amount of PMs that reach the systemic circulation await further elucidation. Confocal laser scanning microscopy added more evidence to support the penetration of integral PMs into the basolateral tissues of microvilli. Cellular uptake efficiency was about 4-7% in Caco-2 cell lines for all PM groups, but was reduced to 1-3% in Caco-2/HT29-MTX co-culture models due to the hindrance by the mucus layers. Approximately 6-12% of integral PMs were transported across Caco-2/HT29-MTX/Raji monolayers, whereas only approximately one-tenth of that amount was transported across Caco-2 and Caco-2/HT29-MTX monolayers. Differences, but not statistically significant, were observed between PM groups in lymphatic uptake, biodistribution, cellular uptake and trans-monolayer transport, possibly owing to difference in block chain lengths as well as particle size. In conclusion, evidence obtained in this study supports penetration of integral PMs across the enteric epithelia, but the total amount may be limited.

Loss of integrity of doxorubicin liposomes during transcellular transportation evidenced by fluorescence resonance energy transfer effect.

The aim of this work was to elucidate the influence of liposome characteristics on the transcellular process by in vitro studies that would enable designing more efficient oral formulations. Various liposomes with different properties were prepared, including 100-500 nm, anionic, cationic and PEGylated liposomes. All liposomes were labeled by fluorescence resonance energy transfer (FRET) probes to evaluate their integrity in cellular uptake and transport. The FRET fluorescent intensity is proportional to the amount of intact liposomes, which was used to calculate the amount of intact liposomes in cellular uptake and transport. The liposomal structures were found to lose their integrity during or after uptake and only about 20% intact liposomes were detected in cells. However, more cationic liposomes were transported integrally across cell monolayer and accounted for 40.49% of total transport by triple culture models of Caco-2/HT29-MTX/Raji B. These results suggest that liposomes could improve cellular uptake and transport of the payloads significantly, but only a small fraction of liposomes are transported integrally across epithelial monolayer. The study is therefore helpful to rationally fabricate more efficient oral liposomes for poorly water-soluble drugs or biomacromolecules.

Self-discriminating fluorescent hybrid nanocrystals: efficient and accurate tracking of translocation via oral delivery.

The in vivo fate of nanocrystals is a controversial topic, i.e. dissolving versus integral absorption through the intestinal membrane. This is due to the lack of functional strategies to identify integral nanocrystals. In this study, the in vivo fate of quercetin hybrid nanocrystals (QT-HNCs) via the oral route is explored by physically embedding an environment-responsive probe in the crystal lattices of quercetin. The specific property of the probe is the water-initiated aggregation-caused quenching (ACQ) ability, by which integral QT-HNCs can be self-discriminated. Instead of dissolving instantly, QT-HNCs can be retained in the gastrointestinal tract for 12-16 h, and can then be absorbed and distributed into various organs with the liver as the primary terminal. The ileum provides better absorption than the jejunum. Cellular studies prove that both trans-epithelial and M cell-mediated routes are involved in the absorption of integral QT-HNCs, which may be impeded by the mucous layer. Moreover, the particle size affects the in vivo behavior and the ex vivo cellular interaction of QT-HNCs, with moderate size, such as 550 nm, being preferred. The results not only validate the idea of using ACQ fluorophores for bioimaging of integral nanocrystals but also support the intestinal absorption of nanocrystals.