Enhancement of algae ponds for rural domestic sewage treatment by prolonging daylight using artificial lamps.

Algal ponds (APs) are widely used as treatment facilities for domestic sewage in sparsely populated rural areas. However, few AP studies have focused on daylight length to enhance pollutants removal. In this study, four algae ponds were set up, daylight was prolonged by 0, 2, 4, and 6 h with an illuminating intensity of 3000 lx. The highest removal efficiencies of total nitrogen, ammonium, and total phosphorus were 37.36%, 41.20%, and 21.56% due to the highest microbial abundance under optimum conditions (2 h PD), respectively. Excessive PD (4 h and 6 h) could inhibit the removal abilities. PD also increased the maximum relative electron transport rate of algae, leading to an increase in the photosynthetic capacity of APs. Meanwhile, the high microbial abundance indicates that chemoheterotrophic bacteria are the main influencing factor for the removal of nitrogen and phosphorus by the APs. Moreover, the system with PD using artificial lamps was proven to be feasible for engineering applications and potentially utilized in rural domestic wastewater treatment.

Evaluation of high rate ponds operational and design strategies for algal biomass production and domestic wastewater treatment.

This study evaluated the effect of high rate ponds (HRPs) depth on algal biomass production during domestic wastewater treatment. HRPs were evaluated for 20, 30, and 40 cm depths, with and without CO2 supplementation. In addition, 40 cm deep HRP with ultraviolet (UV) pre-disinfection was evaluated. The concentration of chlorophyll-a as a function of time for each evaluated condition was represented by logistic models that were after submitted to cluster analysis. The 20 cm HRPs presented higher chlorophyll-a concentration, reaching a maximum of 5.8 and 4.3 mg L-1, in the HRPs with and without CO2 addition, respectively. Ammonia nitrogen and soluble phosphorus were greater removed in shallower HRPs. The addition of CO2 influenced the nutrient removal processes, optimizing nutrient recovery by biomass assimilation. HRP configuration did not influence organic matter removal (~40% of removal efficiency in all HRPs), predominant microalgae genera (Chlorella sp. and Scenedesmus), and E. coli inactivation (removal of ~2 log units), except for the 20 cm HRP without CO2 that had removal of 4 log units due to high pH values. For HRPs with CO2 addition and UV pre-disinfection, the models for 40 cm were grouped together with those obtained for 30 cm HRPs, indicating the same behavior for chlorophyll-a production as a function of time. Thus, it can be concluded that the evaluated strategies represent alternatives for reducing HRP area requirements. Moreover, results may represent advancement and major contributions for HRP design criteria.

Understanding the biological activity of high rate algae ponds through the calculation of oxygen balances.

Microalgae culture in high rate algae ponds (HRAP) is an environmentally friendly technology for wastewater treatment. However, for the implementation of these systems, a better understanding of the oxygenation potential and the influence of climate conditions is required. In this work, the rates of oxygen production, consumption, and exchange with the atmosphere were calculated under varying conditions of solar irradiance and dilution rate during six months of operation in a real scale unit. This analysis allowed determining the biological response of these dynamic systems. The rates of oxygen consumption measured were considerably higher than the values calculated based on the organic loading rate. The response to light intensity in terms of oxygen production in the bioreactor was described with one of the models proposed for microalgae culture in dense concentrations. This model is based on the availability of light inside the culture and the specific response of microalgae to this parameter. The specific response to solar radiation intensity showed a reasonable stability in spite of the fluctuations due to meteorological conditions. The methodology developed is a useful tool for optimization and prediction of the performance of these systems.

Microbial community structures in high rate algae ponds for bioconversion of agricultural wastes from livestock industry for feed production.

Dynamics of seasonal microbial community compositions in algae cultivation ponds are complex. However, there is very limited knowledge on bacterial communities that may play significant roles with algae in the bioconversion of manure nutrients to animal feed. In this study, water samples were collected during winter, spring, summer, and fall from the dairy lagoon effluent (DLE), high rate algae ponds (HRAP) that were fed with diluted DLE, and municipal waste water treatment plant (WWTP) effluent which was included as a comparison system for the analysis of total bacteria, Cyanobacteria, and microalgae communities using MiSeq Illumina sequencing targeting the 16S V4 rDNA region. The main objective was to examine dynamics in microbial community composition in the HRAP used for the production of algal biomass. DNA was extracted from the different sample types using three commercially available DNA extraction kits; MoBio Power water extraction kit, Zymo fungi/bacterial extraction kit, and MP Biomedicals FastDNA SPIN Kit. Permutational analysis of variance (PERMANOVA) using distance matrices on each variable showed significant differences (P=0.001) in beta-diversity based on sample source. Environmental variables such as hydraulic retention time (HRT; P<0.031), total N (P<0.002), total inorganic N (P<0.002), total P (P<0.002), alkalinity (P<0.002), pH (P<0.022), total suspended solid (TSS; P<0.003), and volatile suspended solids (VSS; P<0.002) significantly affected microbial communities in DLE, HRAP, and WWTP. Of the operational taxonomic units (OTUs) identified to phyla level, the dominant classes of bacteria identified were: Cyanobacteria, Alpha-, Beta-, Gamma-, Epsilon-, and Delta-proteobacteria, Bacteroidetes, Firmicutes, and Planctomycetes. Our data suggest that microbial communities were significantly affected in HRAP by different environmental variables, and care must be taken in extraction procedures when evaluating specific groups of microbial communities for specific functions.

Evaluation of High Rate Algae Ponds for treatment of anaerobically digested wastewater: Effect of CO2 addition and modification of dilution rate.

High Rate Algae Ponds (HRAP) are the simplest way to grow microalgae biomass and an interesting alternative for wastewater treatment. In this work the performance of these systems was evaluated using anaerobically digested wastewater as culture medium. Two variables were studied in long-term mode: the carbon dioxide supply and the modification of the dilution rates. The results showed that CO2 supply increases the productivity but less than expected considering the potential biomass generation calculated based on the ratios of carbon to nitrogen of microalgae and wastewater. The assimilation into biomass only accounted for 57% of the inlet nitrogen under the best conditions because nitrification and volatilization reduced the availability of this element. The operation under short hydraulic retention times presented a more interesting performance with higher biomass productivities. The biomass produced was efficiently harvested with in a Dissolved Air Flotation (DAF) unit.

Winter-time CO2 addition in high rate algal mesocosms for enhanced microalgal performance.

Carbon limitation in domestic wastewater high rate algal ponds is thought to constrain microalgal photo-physiology and productivity and CO2 augmentation is often used to overcome this limitation in summer. However, the implications of carbon limitation during winter are poorly understood. This paper investigates the effects of 0.5%, 2%, 5% and 10% CO2 addition on the winter-time performance of wastewater microalgae in high rate algal mesocosms. Performance was measured in terms of light absorption, photosynthetic efficiency, biomass production and nutrient removal rates, along with community composition. Varying percentage CO2 addition and associated change in culture pH resulted in 3 distinct microalgal communities. Light absorption by the microalgae increased by up to 144% with CO2 addition, while a reduction in the package effect meant that there was less internal self-shading thereby increasing the efficiency of light absorption. Carbon augmentation increased the maximum rate of photosynthesis by up to 172%, which led to increased microalgal biovolume by up to 181% and an increase in total organic biomass for all treatments except 10% CO2. While 10% CO2 improved light absorption and photosynthesis this did not translate to enhanced microalgal productivity. Increased microalgal productivity with CO2 addition did not result in increased dissolved nutrient (nitrogen and phosphorus) removal. This experiment demonstrated that winter-time carbon augmentation up to 5% CO2 improved microalgal light absorption and utilisation, which ultimately increased microalgal biomass and is likely to enhance total annual microalgal areal productivity in HRAPs.