Effects of phytase inclusion in diets containing rice protein concentrate (RPC) on the nutrient digestibility, growth and chemical characteristics of rohu (Labeo rohita).

The objective of the current study was to assess the impact of dietary phytase supplementation on Labeo rohita fingerlings and to examine the effects on growth, nutrient digestibility and chemical characteristics of diets containing rice protein concentrate (RPC) as a major protein source. Six experimental diets were made, i.e., a positive control (fishmeal-based diet with no phytase), FM0; a negative control (RPC-based diet with no phytase), RPC0; and four supplemental phytase levels (250, 500, 1000, and 2000 FTU/kg). Fingerlings with an average weight of 9.42 ± 0.02 grams (mean ± SD) were randomly distributed into six experimental groups of three replicates, each containing 25 fish per tank (75 liters of water), provided with experimental diets at a rate equivalent to 5% of their body weight for 90 days, and uneaten feed was collected after 2 hours to determine feed consumption. The feces were collected before feeding to estimate digestibility. Phytase in combination with the RPC-based diet significantly (p < 0.05) enhanced phytate phosphorus in vitro hydrolysis; growth performance; nutrient (crude protein, crude fat, moisture and gross energy) and mineral (P, Ca, Mg, Na, K, Zn, Mn and Cu) digestibility; digestive enzyme (protease, lipase and amylase) activity; and mineral deposition up to 1000 FTU/kg phytase. However, the hepatosomatic and viscerosomatic indices and carcass composition were not influenced (p > 0.05) by phytase supplementation. Increasing phytase supplementation in the RPC-based diets led to a significant (p < 0.05) decrease in the serum biochemical parameters (alkaline phosphatase activity, aspartate aminotransferase, alanine aminotransferase), which resulted in improved liver health. In conclusion, phytase-supplemented RPC-based diets improved the growth, mineral/nutrient digestibility, digestive enzymes, serum biochemistry, and mineral deposition of L. rohita fingerlings up to 1000 FTU/kg. Broken line regression analysis revealed that the optimum phytase concentration in the RPC-based diet for L. rohita was 874.19 FTU/kg.

Characterization of recombinant phytase of Klebsiella sp. and the influence of novel 3-phytase on mineral solubility in broiler diets under an in vitro digestion assay.

Phytate (inositol hexaphosphate) is the major storage form of phosphorus (P) in nature, and phytases catalyze the hydrolysis of P from phytate and the formation of inositol phosphate isomers. In this study, a bacterium that produces phytase was isolated in a phytase screening medium. The bacterium was identified as Klebsiella sp. using phenotypic and molecular techniques. The PhyK phytase gene was successfully amplified from the genome, inserted into the pET-21a (+) vector, and expressed as a recombinant protein in E. Coli BL21. The efficiency of a laboratory phytase (Lab-Ph, PhyK phytase) was determined and compared with a commercial phytase (Com-Ph, Quantum Blue 40P phytase, AB Vista) under an in vitro digestion assay. The native signal peptide effectively facilitated the translocation of the protein to the periplasmic space of E. Coli BL21, resulting in the proper folding of the protein and the manifestation of desirable enzyme activity. The Lab-Ph displayed the temperature and pH optima at 50 °C and 5 respectively. In addition, the Lab-Ph was inactivated at 80 °C. Under an in vitro digestion assay condition, Lab-Ph improved the P solubility coefficient in broiler diets. In comparison, the Com-Ph significantly increased the P solubility coefficient even when compared with the Lab-Ph. In summary, this study has shown that Lab-Ph possesses the necessary biochemical properties to be used in various industrial applications. However, Lab-Ph is extremely sensitive to heat treatment. The Lab-Ph and Com-Ph under an in vitro digestion assay improved the solubility coefficient of P in the broiler diet.

Improved Thermal Stability of a Novel Acidophilic Phytase.

Phytase increases the availability of phosphate and trace elements by hydrolyzing the phosphomonoester bond in phytate present in animal feed. It is also an important enzyme from an environmental perspective because it not only promotes the growth of livestocks but also prevents phosphorus contamination released into the environment. Here we present a novel phytase derived from Turicimonas muris, TmPhy, which has distinctive structure and properties compared to other previously known phytases. TmPhy gene expressed in the Pichia system was confirmed to be 41 kDa in size and was used in purified form to evaluate optimal conditions for maximum activity. TmPhy has a dual optimum pH at pH3 and pH6.8 and exhibited the highest activity at 70°C. However, the heat tolerance of the wildtype was not satisfactory for feed application. Therefore, random mutation, disulfide bond introduction, and N-terminal mutation were performed to improve the thermostability of the TmPhy. Random mutation resulted in TmPhyM with about 45% improvement in stability at 60°C. Through further improvements, a total of three mutants were screened and their heat tolerance was evaluated. As a result, we obtained TmPhyMD1 with 46.5% residual activity, TmPhyMD2 with 74.1%, and TmPhyMD3 with 66.8% at 80°C heat treatment without significant loss of or with increased activity.

Dynamics of bone mineralization in primiparous sows as a function of dietary phosphorus and calcium during lactation.

To maximize the efficiency of dietary P utilization in swine production, understanding the mechanisms of P utilization in lactating sows is relevant due to their high P requirement and the resulting high inorganic P intake. Gaining a better knowledge of the Ca and P quantities that can be mobilized from bones during lactation, and subsequently replenished during the following gestation, would enable the development of more accurate P requirements incorporating this process of bone dynamics. The objective was to measure the amount of body mineral reserves mobilized during lactation, depending on dietary digestible P and phytase addition and to measure the amount recovered during the following gestation. Body composition of 24 primiparous sows was measured by dual-energy x-ray absorptiometry 2, 14, 26, 70 and 110 days after farrowing. Four lactation diets were formulated to cover nutritional requirements, with the exception of Ca and digestible P: 100% (Lact100; 9.9 g Ca and 3.0 g digestible P/kg), 75% (Lact75), 50% without added phytase (Lact50) and 50% with added phytase (Lact50 + FTU). The gestation diet was formulated to cover the nutritional requirements of Ca and digestible P (8.2 g Ca and 2.6 g digestible P/kg). During the 26 days of lactation, each sow mobilized body mineral reserves. The mean amount of mobilized bone mineral content (BMC) was 664 g, representing 240 g Ca and 113 g P. At weaning, the BMC (g/kg of BW) of Lact50 sows tended to be lower than Lact100 sows (-12.8%, linear Ca and P effect × quadratic time effect) while the BMC of Lact50 + FTU sows remained similar to that of Lact100 sows. During the following gestation, BMC returned to similar values among treatments. Therefore, the sows fed Lact50 could recover from the higher bone mineral mobilization that occurred during lactation. The P excretion was reduced by 40 and 43% in sows fed Lact50 and Lact50 + FTU, respectively, relative to sows fed Lact100. In conclusion, the quantified changes in body composition during the lactation and following gestation of primiparous sows show that bone mineral reserves were mobilized and recovered and that its degree was dependent on the dietary P content and from phytase supplementation during lactation. In the future, considering this potential of the sows' bone mineralization dynamics within the factorial assessment of P requirement and considering the digestible P equivalency of microbial phytase could greatly limit the dietary use of inorganic phosphates and, thus, reduce P excretion.

Harnessing alkaline-pH regulatable promoters for efficient methanol-free expression of enzymes of industrial interest in Komagataella Phaffii.

BACKGROUND: The yeast Komagataella phaffii has become a very popular host for heterologous protein expression, very often based on the use of the AOX1 promoter, which becomes activated when cells are grown with methanol as a carbon source. However, the use of methanol in industrial settings is not devoid of problems, and therefore, the search for alternative expression methods has become a priority in the last few years. RESULTS: We recently reported that moderate alkalinization of the medium triggers a fast and wide transcriptional response in K. phaffii. Here, we present the utilization of three alkaline pH-responsive promoters (pTSA1, pHSP12 and pPHO89) to drive the expression of a secreted phytase enzyme by simply shifting the pH of the medium to 8.0. These promoters offer a wide range of strengths, and the production of phytase could be modulated by adjusting the pH to specific values. The TSA1 and PHO89 promoters offered exquisite regulation, with virtually no enzyme production at acidic pH, while limitation of Pi in the medium further potentiated alkaline pH-driven phytase expression from the PHO89 promoter. An evolved strain based on this promoter was able to produce twice as much phytase as the reference pAOX1-based strain. Functional mapping of the TSA1 and HSP12 promoters suggests that both contain at least two alkaline pH-sensitive regulatory regions. CONCLUSIONS: Our work shows that the use of alkaline pH-regulatable promoters could be a useful alternative to methanol-based expression systems, offering advantages in terms of simplicity, safety and economy.

Evaluation of exogenous phytase in high-phytate diets for broiler chickens and pigs.

There is a gap in the understanding of the relationship between dietary phytate levels and the relative efficacy of phytase to improve amino acid (AA) digestibility in pigs and chickens. Two experiments were conducted to investigate the effect of exogenous phytase on standardized ileal digestibility (SID) of AA and the apparent ileal digestibility (AID) of P in both standard- (SP) and high-phytate (HP) diets for broilers and swine. There were either 40 cages of Cobb 500 male broilers or 10 crossbred barrows (35 kg) fitted with ileal T-cannulas. Both studies were allotted to five dietary treatments (8 replicates). Treatments consisted of four corn-soybean meal-based diets arranged in a 2 × 2 factorial of standard or high phytate and exogenous phytase at 0 or 1 000 phytase units (FYT)/kg; and one N-free diet. Birds were fed a common starter diet from d 0 to 20 and fed experimental diets from d 20 to 25. Birds were euthanized on d 25 via CO2 asphyxiation, and digesta were collected from the terminal ileum. Pigs were fed for a total of four 7-d periods, where digesta were collected on d 6 and 7 of each period. Diet and digesta samples were analyzed for DM, N, Ti, AA, and P to determine AA and P digestibility. The SID of AA was determined by correcting the AID of AA for the basal endogenous losses estimated using the N-free diet. Main effects of the diet type (standard or HP) and phytase (0 or 1 000 FYT/kg), and the interaction of diet type and phytase were evaluated. For both experiments, the HP diets produced lower SID of AA compared to the SP (P < 0.001). For broilers, there was a phytase effect (P < 0.001) for the SID of all AAs evaluated regardless of the diet type. For pigs, phytase improved (P < 0.05) the SID of Met, Lys, Cys, Glu and Ser and tended to improve (P < 0.10) Arg, Leu, Thr, and Tyr. There were no significant interactions for either experiment. For both experiments, AID of P was lower for the HP diets (P < 0.01), and phytase produced greater AID of P for both diet types (P < 0.01). These data indicate that phytase greatly improves the digestibility of P for broilers and pigs and has the ability to significantly increase the digestibility of amino acids for these animals, regardless of the dietary phytate P.

Effects of phytase supplementation on broilers fed with calcium and phosphorus-reduced diets, challenged with Eimeria maxima and Eimeria acervulina: influence on growth performance, body composition, bone health, and intestinal integrity.

An experiment was conducted to evaluate the effects of phytase in calcium (Ca) and available phosphorous (avP)-reduced diet on growth performance, body composition, bone health, and intestinal integrity of broilers challenged with Eimeria maxima and Eimeria acervulina. A total of 672 14-day-old male broilers were allocated to a 2 × 4 factorial arrangement with 6 replicates per treatment and 14 birds per replicate. Two factors were Eimeria challenge and 4 dietary treatments: 1) a positive control (PC; 0.84% Ca and 0.42% avP); 2) a negative control (NC; 0.74% Ca and 0.27% avP); 3) NC + 500 FTU/Kg of phytase (NC + 500PHY); and 4) NC + 1,500 FTU/Kg of phytase (NC + 1500PHY). On d 14, birds in the Eimeria-challenged groups received a solution containing 15,000 sporulated oocysts of E. maxima and 75,000 sporulated oocysts of E. acervulina via oral gavage. At 5 d postinoculation (DPI), the challenged birds showed a higher (P < 0.01) FITC-d level than the unchallenged birds. While the permeability of the NC group did not differ from the PC group, the phytase supplementation groups (NC + 500PHY and NC + 1500PHY) showed lower (P < 0.05) serum FITC-d levels compared to the NC group. Interaction effects (P < 0.05) of Eimeria challenge and dietary treatments on feed intake (FI), mucin-2 (MUC2) gene expression, bone ash concentration, and mineral apposition rate (MAR) were observed. On 0 to 6 and 0 to 9 DPI, Eimeria challenge decreased (P < 0.01) body weight (BW), body weight gain (BWG), FI, bone mineral density (BMD), bone mineral content (BMC), bone area, fat free bone weight (FFBW), bone ash weight, bone ash percentage and bone ash concentration; and it showed a higher FCR (P < 0.01) compared to the unchallenged group. The reduction Ca and avP in the diet (NC) did not exert adverse effects on all parameters in birds, and supplementing phytase at levels of 500 or 1,500 FTU/Kg improved body composition, bone mineralization, and intestinal permeability, with the higher dose of 1,500 FTU/Kg showing more pronounced enhancements. There was an observed increase in FI (P < 0.01) when phytase was supplemented at 1,500 FTU/Kg during 0 to 6 DPI. In conclusion, results from the current study suggest that dietary nutrients, such as Ca and avP, can be moderately reduced with the supplementation of phytase, particularly in birds infected with Eimeria spp., which has the potential to save feed cost without compromising growth performance, bone health, and intestinal integrity of broilers.

Research Note: Evaluation of phytic acid disappearance, ileal P digestibility, and total tract P retention in canola meal supplemented with increasing levels of exogenous phytase using conventional and cecectomized precision-fed roosters and growing chicks.

Apparent ileal digestibility (AID) of P, apparent total tract retention (ATTR) of P, and phytic acid disappearance in canola meal were evaluated in the presence of increasing levels of exogenous phytase. In Experiment 1, a precision-fed rooster assay was used to determine phytic acid (myo-inositol 1,2,3,4,5,6-hexakis; InsP6) and inositol phosphate (InsP6-3; InsP-P) disappearance in conventional and cecectomized Leghorn roosters. Roosters were crop intubated with 25 g of canola meal mixed with 0, 500, 1,000, or 2,000 FTU/kg of exogenous phytase. In Experiment 2, InsP6 and InsP-P disappearance and AID and ATTR of P were determined using ad libitum-fed broiler chickens. Treatments consisted of semi-purified diets containing 45% canola meal as the sole source of P. Phytase was added to increase phytase activity by 0, 500, 1,000, or 2,000 FTU/kg. Experiments contained 6 replicates per treatment. Canola meal contained a high phytase activity (1,630 FTU/kg as-fed) due to contamination with a commercially available phytase at the feed mill from which the canola meal was sourced. In Experiment 1 with precision-fed roosters, there was no effect (P > 0.05) of phytase or bird type on InsP6 and InsP-P disappearance; however, phytase linearly reduced (P < 0.05) InsP3 concentrations in excreta. In Experiment 2 with ad libitum-fed chickens, phytase linearly increased (P < 0.05) ileal InsP6 and InsP-P disappearance, and phytase had a quadratic effect (P < 0.05) on excreta InsP6 and InsP-P disappearance. Increasing dietary phytase activity resulted in a linear increase (P < 0.05) in AID of P and phytase had a quadratic effect (P < 0.05) on ATTR of P. In conclusion, titration of high levels of phytase (1,600 to 3,600 FTU/kg as-fed) reduced InsP3 concentrations in precision-fed roosters but did not affect overall phytic acid hydrolysis, which was 78% or greater for all treatments; however, increasing the total phytase activity from 700 to 2,700 FTU in ad libitum-fed broiler chickens increased phytic acid disappearance and P digestibility.

Fluorescent ratiometric supramolecular tandem assays for phosphatase and phytase enzymes.

Ratiometric fluorescent assays have a built-in correction factor which enhances assay accuracy and reliability. We have developed fluorescent ratiometric supramolecular tandem assays for phosphatase and phytase enzymes using a mixture of three molecular components. One of the molecules is a tetra-cationic fluorescence quencher called CalixPyr which can bind and quench the polyanionic pyrene fluorophore, CMP, that emits at 430 nm. Polyphosphates can disrupt the CMP/CalixPyr complex and alter the fluorescence intensity (responsive signal). CalixPyr has no effect on the fluorescence emission of cationic pentamethine cyanine fluorophore, cCy5, which emits at 665 nm and acts as a non-responsive reference signal. The continuous ratiometric fluorescent assay for alkaline phosphatase monitored hydrolytic consumption of adenosine triphosphate (ATP). The continuous ratiometric fluorescent assay for phytase activity monitored hydrolytic consumption of phytate. With further development this latter assay may be useful for high throughput assessment of phytase activity in individual batches of fortified animal feed. It is likely that the three-molecule mixture (CMP, CalixPyr, cCy5) can become a general assay platform for other enzymes that catalyse addition/removal of phosphate groups from appropriate molecular substrates.

Insoluble-Phytate Improves Plant Growth and Arsenic Accumulation in As-Hyperaccumulator Pteris vittata: Phytase Activity, Nutrient Uptake, and As-Metabolism.

Phytate, the principal P storage in plant seeds, is also an important organic P in soils, but it is unavailable for plant uptake. However, the As-hyperaccumulator Pteris vittata can effectively utilize soluble Na-phytate, while its ability to utilize insoluble Ca/Fe-phytate is unclear. Here, we investigated phytate uptake and the underlying mechanisms based on the phytase activity, nutrient uptake, and expression of genes involved in As metabolisms. P. vittata plants were cultivated hydroponically in 0.2-strength Hoagland nutrient solution containing 50 µM As and 0.2 mM Na/Ca/Fe-phytate, with 0.2 mM soluble-P as the control. As the sole P source, all three phytates supported P. vittata growth, with its biomass being 3.2-4.1 g plant-1 and Ca/Fe-phytate being 19-29% more effective than Na-phytate. Phytate supplied soluble P to P. vittata probably via phytase hydrolysis, which was supported by 0.4-0.7 nmol P min-1 g-1 root fresh weight day-1 phytase activity in its root exudates, with 29-545 µM phytate-P being released into the growth media. Besides, compared to Na-phytate, Ca/Fe-phytate enhanced the As contents by 102-140% to 657-781 mg kg-1 in P. vittata roots and by 43-86% to 1109-1447 mg kg-1 in the fronds, which was accompanied by 21-108% increase in Ca and Fe uptake. The increased plant As is probably attributed to 1.3-2.6 fold upregulation of P transporters PvPht1;3/4 for root As uptake, and 1.8-4.3 fold upregulation of arsenite antiporters PvACR3/3;1/3;3 for As translocation to and As sequestration into the fronds. This is the first report to show that, besides soluble Na-phytate, P. vittata can also effectively utilize insoluble Ca/Fe-phytate as the sole P source, which sheds light onto improving its application in phytoremediation of As-contaminated sites.

Investigating the effect of sesame meal replacement for soybean meal in diets with different levels of calcium and phytase enzyme in broiler chickens.

BACKGROUND: As a major part of the cost of broiler farms is related to their feed, breeders are looking for diets at a reasonable price. One of these affordable ingredients is sesame meal (SM), which can be used to replace soybean meal (SBM) in diets. OBJECTIVES: This study aims to investigate the effect of replacing SBM with SM in diets with different levels of calcium (Ca) and phytase (Phy) during the grower (11-24 days), finisher (25-42 days) and whole phases (11-42 days) on the growth performance, carcass characteristics and blood serum parameters of broiler chickens. METHODS: A total of 600 1-day-old Ross 308 broiler male chicks were randomly dispensed to 12 dietary treatments with five replicates (10 birds per replicate) based on a completely randomized design in a factorial arrangement of 3 × 2 × 2 with 3 levels of SM (0%, 10% and 20%), 2 levels of Ca (standard (0.87% and 0.79% for grower and finisher phases, respectively) and 0.2% higher than the standard amount) and 2 levels of Phy (0 and 700 FTU/kg diet). RESULTS: During the study, the significant effects of SM, Ca and Phy on the daily average body weight gain (DAWG) and daily feed intake (DFI) were observed, whereas for the feed conversion ratio, only the effect of SM was significant (p < 0.05). During the finisher and whole phases, the SM and Ca levels influenced the DAWG and DFI, whereas the interaction between Phy and Ca was also significant for DAWG (p < 0.05). The main effects of SM and Ca on the relative weights of breast, heart and liver were significant (p < 0.05). Application of 20% of SM significantly reduced serum Ca concentration (p < 0.05). CONCLUSION: Generally, the inclusion of more than 10% of SM in the broilers diet is not recommended. In addition, the use of Phy and Ca levels 0.2% higher than standard in broilers diet could improve the birds' performance.

Online monitoring of phytate content in plant residuals during wet-treatment.

The occurrence of organically bound phosphorus (P) as phytate in plant-based feeding material is a challenge for livestock farming due to limited utilization during the digestion by the animal. Its excretion into the environment through the manure pathway, poses a challenge, due to increased eutrophication and restrictions for P. Hence, while the routine supplementation of phytase enzymes in monogastric diets is common practice, metabolically triggering endogenous plant enzymes by wet-treatment prior to feeding can also lead to a better utilization of phytate bound P and increased digestibility by the animal. Nonetheless, traditional quantification of residual phytate content in plant material is both labor- and chemical-intense. The aim of this study is, therefore, to predict the remaining phytate content during wet-treatment through a straightforward and flexible methodological approach based on real-time analysis. For this, rye bran is used as a model substrate. A partial least squares regression algorithm relates the infrared spectra to the concentrations and predict the amount of P species that are transferred from the bran matrix to the liquid phase. By applying a mass balance for P and considering the effect of water compression, the amount of residual phytate content in rye bran at different time points of wet-treatment is determined. Results are compared to wet chemical methods, resulting in a RMSEP of 0.28 gphytate∙100 gbran-1. In addition, the study demonstrates the feasibility of this approach and provides insights into phytate degradation in plant residuals. The method holds the potential for further applications for the screening and investigation of feed material conditioning and also offers the possibility to employ various real-time analytical techniques for assessing phytate remnants in biological samples during wet-treatment.

CO2-based production of phytase from highly stable expression plasmids in Cupriavidus necator H16.

BACKGROUND: Existing plasmid systems offer a fundamental foundation for gene expression in Cupriavidus necator; however, their applicability is constrained by the limitations of conjugation. Low segregational stabilities and plasmid copy numbers, particularly in the absence of selection pressure, pose challenges. Phytases, recognized for their widespread application as supplements in animal feed to enhance phosphate availability, present an intriguing prospect for heterologous production in C. necator. The establishment of stable, high-copy number plasmid that can be electroporated would support the utilization of C. necator for the production of single-cell protein from CO2. RESULTS: In this study, we introduce a novel class of expression plasmids specifically designed for electroporation. These plasmids contain partitioning systems to boost segregation stability, eliminating the need for selection pressure. As a proof of concept, we successfully produced Escherichia coli derived AppA phytase in C. necator H16 PHB- 4 using these improved plasmids. Expression was directed by seven distinct promoters, encompassing the constitutive j5 promoter, hydrogenase promoters, and those governing the Calvin-Benson-Bassham cycle. The phytase activities observed in recombinant C. necator H16 strains ranged from 2 to 50 U/mg of total protein, contingent upon the choice of promoter and the mode of cell cultivation - heterotrophic or autotrophic. Further, an upscaling experiment conducted in a 1 l fed-batch gas fermentation system resulted in the attainment of the theoretical biomass. Phytase activity reached levels of up to 22 U/ml. CONCLUSION: The new expression system presented in this study offers a highly efficient platform for protein production and a wide array of synthetic biology applications. It incorporates robust promoters that exhibit either constitutive activity or can be selectively activated when cells transition from heterotrophic to autotrophic growth. This versatility makes it a powerful tool for tailored gene expression. Moreover, the potential to generate active phytases within C. necator H16 holds promising implications for the valorization of CO2 in the feed industry.

Investigation of the potential of yeast strains for phytase biosynthesis in a two-step screening procedure.

Research into phytase production is useful for improving the efficiency of animal production, reducing environmental impact, and contributing to the development of sustainable and efficient animal production systems. This study aims to investigate the potential of yeast strains for phytase biosynthesis in nutrient media. Phytase is a phosphomonoesterase (E.C 3.1.3.8) catalyzing in a ladder-like manner the dephosphorylation of phytic acid and its salts, with various resulting myo-inositol phosphates and phosphoric acid. Yeasts of the genera Saccharomyces, Zygosaccharomyces, Candida, and Pichia were evaluated in a two-step screening procedure for phytase production. One hundred and eighteen strains were screened in the first stage, which was conducted on four types of solid culture media containing calcium phytate as the selected background. On PSM medium, many strains were found to form halos as early as the 24th hour of development. Several strains with significant potential for enzyme production were evaluated in the second step of the screening. It was conducted in a liquid culture medium. In conclusion, the strain C. melibiosica 2491 was selected for further studies when cultured in a YPglu culture medium. Further research will focus on finding suitable conditions that increase the biosynthesis of the enzyme, which is of significant technological and practical interest for animal nutrition.

Effect of an Escherichia coli-derived phytase and a carbohydrase-protease cocktail derived from Bacillus spp. on performance, digestibility, bone mineralization and gut morphology in broilers fed different nutrient density diets.

BACKGROUND: Enzyme combinations, particularly phytase (PHY) with various carbohydrases and proteases, are utilized in commercial broiler production to enhance nutrient and energy bioavailability. OBJECTIVE: A feeding study was undertaken to determine whether the efficiency of an Escherichia coli-derived PHY and a feed enzyme complex (FEC) derived from Bacillus spp. containing carbohydrase and protease as main activities in broiler chickens is dependent on diet quality. A total of 900 male one-day-old broiler chickens (Ross 308) were assigned to a 2 × 3 factorial arrangement of the treatments with 2 different nutrient density diets, standard nutrient diet (SN diet) and a low-nutrient diet (LN diet; -100 kcal/kg for AMEn and -5% for crude protein [CP] and limiting amino acids), and 3 enzyme treatments (control [no enzymes], PHY and PHY + FEC). Each treatment group was composed of 6 replicates of 25 birds each. RESULTS: The LN diet caused a decrease in performance index, tibia length and diameter, tibia calcium content and jejunal villus surface area (VSA). The interaction effects between diet and enzyme supplementation were observed (p < 0.05) on overall average daily gain (ADG), performance index, tibia ash content and jejunal villus height (VH) and VSA, with the favourable benefits of PHY + FEC treatment being more pronounced in the LN diets. Regardless of dietary nutrient density, supplementation with PHY alone or combined with FEC enhanced (p < 0.05) final body weight, overall ADG and jejunal villus height (VH)/crypt depth, with the highest values observed in the PHY + FEC group. The PHY + FEC treatment also improved (p < 0.05) overall feed conversion ratio, apparent ileal digestibility of dry matter, organic matter, CP, and energy, and tibia phosphorus content compared to the control treatment. CONCLUSIONS: The results indicate that the simultaneous addition of PHY and FEC to the LN diets improved the growth rate, bone mineralization and gut morphology.

Cyclic extraction of phosphate from soybean meal using immobilized Aspergillus oryzae SBS50 phytase.

Phytase enzyme found in plants, animals, and microorganisms is mainly involved in catalyzing the systematic removal of a phosphate group from phytic acid. Enzyme immobilization is one of the cost-effective methods for the wide usage of enzymes in the industrial sector. This paper reports the covalent immobilization of phytase on glutaraldehyde-activated aluminum oxide beads. The immobilization yield, efficiency, and activation energy were found to be 47.8%, 71.5%, and 15.78 J/mol, respectively. The bound enzyme displayed a shift in pH optima from 5.5 to 4.5, which is more beneficial to increase digestibility in comparison with the free enzyme. Immobilized phytase retained 42.60% of its activity after 1.0 h incubation at 80 °C, whereas free enzyme retained only 4.20% of its activity. Thermodynami increase in half-lives, D-values, enthalpy and free energy change after covalent immobilization could be credited to the enhanced stability. Immobilized phytase could be reused for five consecutive cycles retaining 51% of its initial activity with sodium phytate. The immobilized phytase was also found effective to hydrolyze the soybean meal, thus increasing the digestibility of poultry feed. The hydrolyzing reaction of soybean meal was carried out for six consecutive cycles and immobilized phytase retained nearly 50% of activity till the fifth cycle. The amount of phosphorus released after treatment with immobilized phytase was far higher than that from free phytase. Immobilization on this support is significant, as this support can sustain high mechanical resistance at high pH and temperature. This considerable stability and reusability of the bound enzyme may be advantageous for its industrial application.

Screening and Identification of a Strain with Protease and Phytase Activities and Its Application in Soybean Meal Fermentation.

The aims of the study were to degrade the anti-nutritional factors (ANFs) such as phytic acid, glycinin, and ß-conglycinin and improve the values of soybean meal (SBM). Firstly, in this study, a strain PY-4B which exhibited the best enzymatic activities of protease (403.3 ± 17.8 U/mL) and phytase (62.9 ± 2.9 U/mL) was isolated and screened among the isolates. Based on the analysis of physiological and biochemical characteristics and 16S rDNA sequence, the strain PY-4B was identified and named as Pseudomonas PY-4B. Next, Pseudomonas PY-4B was applied to fermentation of SBM. The results showed that the contents of glycinin and ß-conglycinin were decreased by 57-63%, and the phytic acid was remarkably degraded by 62.5% due to the fermentation of SBM by Pseudomonas PY-4B. The degradation of glycinin and ß-conglycinin resulted in increase of contents of water-soluble proteins and amino acids in fermented SBM. Moreover, Pseudomonas PY-4B exhibited no hemolytic activity and slight inhibitory effect on the growth of pathogen Staphylococcus aureus and the wide range of pH tolerance (3 to 9). In summary, our study indicates that isolated strain Pseudomonas PY-4B is a safe and applicable strain and has the ability to effectively degrade the ANFs (phytic acid, glycinin, and ß-conglycinin) in SBM by fermentation.

Endofungal bacteria and ectomycorrhizal fungi synergistically promote the absorption of organic phosphorus in Pinus massoniana.

Ectomycorrhizal fungi (ECMFs) that are involved in phosphorus mobilisation and turnover have limited ability to mineralise phytate alone. The endofungal bacteria in the ectomycorrhizal fruiting body may contribute to achieving this ecological function of ECMFs. We investigated the synergistic effect and mechanisms of endofungal bacteria and ECMF Suillus grevillea on phytate mineralisation. The results showed that soluble phosphorus content in the combined system of endofungal bacterium Cedecea lapagei and S. grevillea was 1.8 times higher than the sum of C. lapagei and S. grevillea alone treatment under the phytate mineralisation experiment. The S. grevillea could first chemotactically assist C. lapagei in adhering to the surface of S. grevillea. Then, the mineralisation of phytate was synergistically promoted by increasing the biomass of C. lapagei and the phosphatase and phytase activities of S. grevillea. The expression of genes related to chemotaxis, colonisation, and proliferation of C. lapagei and genes related to phosphatase and phytase activity of S. grevillea was also significantly upregulated. Furthermore, in the pot experiment, we verified that there might exist a ternary symbiotic system in the natural forest in which endofungal bacteria and ECMFs could synergistically promote phytate uptake in the plant Pinus massoniana via the ectomycorrhizal system.

Effect of day-old chick weight on the response of broilers to high doses of exogenous phytase.

A total of 360 Ross 708 male broiler chicks were used in an 8 treatment and 9 replicate cage study to explore the influence of day-old chick weight on the efficacy of exogenous phytase. Treatments were arranged as a 2 × 4 factorial with the factors being diet (a positive (PC) and negative control (NC) varying in nutrient density fed without or with 2 concentrations of exogenous phytase) and chick weight (light; <38.5 g or heavy; >42 g). Chicks were sourced from the same breeder flock, with light and heavy chicks being selected from the naturally occurring heterogeneity in the population. The diets were corn-soybean meal based and the PC was formulated to meet the nutrient requirements of male broiler chicks. The NC was formulated to contain 120 kcal/kg, 0.5, 0.18, and 0.18% less apparent metabolizable energy (AME), crude protein (CP), calcium (Ca), and phosphorus (P), respectively, than the PC. Amino acid (AA) density in the NC was also reduced in line with the reduction in CP and the manufacturers' recommendations for the effect of phytase on amino acid digestibility. Phytase at either 1,000 FYT/kg or 3,000 FYT/kg was added only to the NC to create a total of 4 diets. Water and mash feed were available ad libitum and were offered to 8 replicate cages, each containing 5 chicks. The experiment was conducted over a period of 3 wk and diets were offered in 2 phases (starter from d 1 to 10 and grower from d 11 to 21). Growth performance was monitored at the end of each diet phase and on d 21 ileal digesta were collected for estimation of apparent digestibility of energy (DE), nitrogen (N), Ca, P, dry matter (DM), and AA. There were no statistically significant interactions between diet and day-old chick weight for any of the measured parameters. Light chicks had significantly lower weight gain (approx. 5%) at both d 10 and d 21 compared with heavy chicks. This effect was principally associated with reduced feed intake and there was no significant effect of chick weight on feed conversion ratio (FCR). Chick weight had no effect on ileal nutrient digestibility. The reduction in nutrient density from the PC to the NC generated a significant reduction in weight gain (around 12%) and a significant increase in FCR (1.68 vs. 1.83). This effect was associated with a significant reduction in ileal DE (approximately 150 kcal/kg) and in the digestibility of several AA. Exogenous phytase significantly increased weight gain, reduced FCR and generated a significant increase in the ileal digestibility of energy, N, P, and several AA. Although chick weight and diet did not interact statistically, heavy chicks benefited more than light chicks from high doses of exogenous phytase across almost all measured end points which was confirmed by regression analysis. In conclusion, light chicks have inferior performance outcomes than heavy chicks principally because of reduced feed intake, but putatively not in digestive capacity per se. Exogenous phytase is effective in improving performance and nutrient digestibility in nutrient deficient diets. The effect of chick weight per se, and also breeder flock age, on the utility of supra-nutritional inclusion concentrations of exogenous phytase warrants further study.

Phosphorus equivalency of exogenous phytase relative to phosphorus in monosodium phosphate in broiler chickens.

The objective of this study was to estimate phosphorus (P) equivalency of exogenous phytase relative to P from monosodium phosphate (MSP) in broiler chickens. To attain this objective, the impact of dietary MSP or exogenous phytase on growth performance, ileal digestibility of P, and bone characteristics in broiler chickens was assessed. Six experimental diets consisting of a P-deficient basal diet based on corn and soybean meal, basal diet plus 0.9 or 1.8 g/kg of inorganic P from MSP, and basal diet plus 500, 1,000, or 2,000 FYT/kg of exogenous phytase. Calcium to P ratio in all diets was maintained at 1.5:1. A total of 576 male broiler chickens (Cobb 500; initial BW = 190 ± 17 g) on d 8 post hatching were allotted to the 6 dietary treatments in a randomized complete block design using BW as a blocking factor. Each dietary treatment contained 8 replicate cages with 12 birds per cage. On d 11 post hatching, 7 birds from each cage were euthanized by CO2 asphyxiation and dissected for the collection of ileal digesta. On d 18, ileal digesta were also collected from the remaining 5 birds in each cage. The left femur and tibia were collected from the bird with the median BW on d 11 and 18 from each cage, and analyzed for bone breaking strength and bone ash. Weight gain and gain-to-feed ratio linearly or quadratically increased (P < 0.05) in every period as the inclusion rate of MSP or phytase increased. Ileal digestibility of P linearly increased (P < 0.05) on d 11 with increasing MSP, but there was no significant effect on d 18. Increasing phytase concentration linearly increased (P < 0.05) ileal digestibility of P on d 11 and 18. Increasing dietary MSP or phytase linearly increased ileal digestible P concentration in diets (P < 0.05). Bone breaking strength and bone ash linearly or quadratically increased (P < 0.05) with increasing inclusion rate of MSP or phytase on d 11 and 18. The equivalency of 1,000 FYT/kg of exogenous phytase based on dietary ileal digestible P concentration was 1.5 and 1.2 g/kg of inorganic P in diets on d 11 and 18, respectively. The current results showed that the supplementation of MSP or exogenous phytase can increase growth performance, ileal P digestibility, bone breaking strength, and bone ash in young broiler chickens.