Effects of Impeller Geometry on the 11α-Hydroxylation of Canrenone in Rushton Turbine-Stirred Tanks.

The 11α-hydroxylation of canrenone can be catalyzed by Aspergillus ochraceus in bioreactors, where the geometry of the impeller greatly influences the biotransformation. In this study, the effects of the blade number and impeller diameter of a Rushton turbine on the 11α-hydroxylation of canrenone were considered. The results of fermentation experiments using a 50 mm four-blade impeller showed that 3.40% and 11.43% increases in the conversion ratio were achieved by increasing the blade number and impeller diameter, respectively. However, with an impeller diameter of 60 mm, the conversion ratio with a six-blade impeller was 14.42% lower than that with a four-blade impeller. Data from cold model experiments with a large-diameter six-blade impeller indicated that the serious leakage of inclusions and a 22.08% enzyme activity retention led to a low conversion ratio. Numerical simulations suggested that there was good gas distribution and high fluid flow velocity when the fluid was stirred by large-diameter impellers, resulting in a high dissolved oxygen content and good bulk circulation, which positively affected hyphal growth and metabolism. However, a large-diameter six-blade impeller created overly high shear compared to a large-diameter four-blade impeller, thereby decreasing the conversion ratio. The average shear rates of the former and latter cases were 43.25 s-1 and 35.31 s-1, respectively. We therefore concluded that appropriate shear should be applied in the 11α-hydroxylation of canrenone. Overall, this study provides basic data for the scaled-up production of 11α-hydroxycanrenone.

Effects of Light on the Ochratoxigenic Fungi Aspergillus ochraceus and A. carbonarius.

Ochratoxin A (OTA) usually contaminates agricultural products such as grapes, oatmeal, coffee and spices. Light was reported as an effective strategy to control spoilage fungi and mycotoxins. This research investigated the effects of light with different wavelengths on the growth and the production of OTA in Aspergillus ochraceus and Aspergillus carbonarius. The results showed that the growth of both fungi were extremely inhibited by UV-B. Short-wavelength (blue, violet) significantly inhibited the production of OTA in both fungi, while the inhibitory effect of white was only demonstrated on A. ochraceus. These results were supported by the expression profiles of OTA biosynthetic genes of A. ochraceus and A. carbonarius. To clarify, the decrease in OTA production is induced by inhibition or degradation; therefore, the degradation of OTA under different wavelengths of light was tested. Under UV-B, the degradation rate of 10 µg/mL OTA standard pure-solution samples could reach 96.50% in 15 days, and the degradation effect of blue light was relatively weak. Furthermore, infection experiments of pears showed that the pathogenicity of both fungi was significantly decreased under UV-B radiation. Thus, these results suggested that light could be used as a potential target for strategies in the prevention and control of ochratoxigenic fungi.

iTRAQ proteome analysis of the antifungal mechanism of citral on mycelial growth and OTA production in Aspergillus ochraceus.

BACKGROUND: Aspergillus ochraceus causes food spoilage and produces mycotoxin ochratoxin A (OTA) during storage of agricultural commodities. In this study, citral was used to inhibit A. ochraceus growth and OTA accumulation, proteomic analysis was employed to verify the mechanism of citral. RESULTS: Citral was found to significantly inhibit fungal growth and mycotoxin production in A. ochraceus. Specifically, 75, 125, 150 and 200 µL L-1 citral suppressed mycelial growth by 33%, 46%, 50% and 100%, respectively. Additionally, 75 µL L-1 citral inhibited OTA accumulation by 25%. Proteomic analysis was performed to elucidate the inhibitory mechanism of citral on mycelial growth and OTA production at subinhibitory concentrations (75 µL L-1 ). Proteomics analysis identified 2646 proteins in A. ochraceus fc-1, of which 218 were differentially expressed between control and 75 µL L-1 citral treatment samples. Differentially expressed proteins were identified by Gene Ontology (GO) and Kyoto Encyclopedia of Genes and Genomes (KEGG) analyses of biological process, cellular component and molecular function terms. Potential factors affecting mycelial growth and OTA production were analysed, and OTA production was revealed to be a complex process involving many associated factors related to various processes including nutrient intake, sterol biosynthesis, ribosome biogenesis, energy metabolism, oxidative stress and amino acid metabolism. In addition, citral at 75 µL L-1 down-regulated OTA biosynthetic genes including pks and nrps, but slightly up-regulated the global regulatory factors veA, velB and laeA. CONCLUSION: The findings further demonstrate the potential of citral for the preservation of grains and other agricultural products, and provide new insight into its antifungal mechanisms at subinhibitory concentrations. © 2021 Society of Chemical Industry.

Carbon Catabolite Repression Gene AoCreA Regulates Morphological Development and Ochratoxin A Biosynthesis Responding to Carbon Sources in Aspergillus ochraceus.

Carbon is one of the most important nutrients for the development and secondary metabolism in fungi. CreA is the major transcriptional factor mediating carbon catabolite repression, which is employed in the utilization of carbon sources. Aspergillus ochraceus contaminates various food and feed containing different carbon sources by producing ochratoxin A (OTA). However, little is known about the function of AoCreA in regulating the morphology and OTA production of A. ochraceus. To give an insight into the mechanism of the carbon sources regulating development of A. ochraceus and OTA production, we have identified AoCreA in A. ochraceus. The homologous recombination strategy was used to generate the AoCreA deletion mutant (ΔAoCreA). We have investigated the morphology and OTA production of the wild type (WT) and ΔAoCreA of A. ochraceus with media containing different carbon sources (glucose, fructose, maltose, D-xylose, D-mannose, acetate, D-galactose, D-mannitol and lactose). ΔAoCreA showed a significant growth and conidiation defect on all media as compared with WT. Glucose and maltose were the most inducing media for OTA production by A. ochraceus, followed by sucrose and the nutrient-rich Yeast Extract Sucrose (YES) and Potato Dextrose Agar (PDA). The deletion of AoCreA led to a drastic reduction of OTA production on all kinds of media except PDA, which was supported by the expression profile of OTA biosynthetic genes. Furthermore, infection studies of ΔAoCreA on oats and pears showed the involvement of AoCreA in the pathogenicity of A. ochraceus. Thus, these results suggest that AoCreA regulates morphological development and OTA biosynthesis in response to carbon sources in A. ochraceus.

The effect of cold atmospheric pressure plasma on Aspergillus ochraceus and ochratoxin A production.

Aspergillus ochraceus is a soil fungus known to produce ochratoxin A, a harmful secondary metabolite. Prevention and control of fungal pathogens mostly rely on chemical fungicides, which is one of the contributing factors in the emergence of the fungal resistance, hence novel methods for fungal eradication have been extensively researched. The cold atmospheric pressure (CAP) plasma generated in ambient air has been recently applied in microbial decontamination. Here we used the diffuse coplanar surface barrier discharge in inactivation of a toxigenic strain A. ochraceus. The plasma-treated conidia and mycelium exhibited morphological changes such as ruptures and desiccation. Mycelium dehydration and changes in the chemical composition of hyphal surface accompanied plasma treatment. The growth of 26 h old mycelia were significantly restricted after 30 s of plasma treatment. The conidial vitality declined 4 logs after 180 s of plasma exposure leading to almost complete decontamination. After shorter plasma treatment of conidia, the ochratoxin A (OTA) production increased at the early stage of cultivation, but the overall level was significantly reduced compared to untreated samples after longer cultivation. Our results indicated that the fungal growth and the OTA production were significantly changed by plasma treatment and underscored CAP plasma as a promising method in the decontamination of A. ochraceus without a risk to generate strains with increased OTA production.

The Influence of NaCl and Glucose Content on Growth and Ochratoxin A Production by Aspergillus ochraceus, Aspergillus carbonarius and Penicillium nordicum.

Ochratoxin A (OTA) is a nephrotoxic mycotoxin, which deserves particular attention for its widespread contamination of a variety of food and feed. Aspergillus ochraceus, Aspergillus carbonarius, and Penicillium nordicum are an important source of OTA in three different kinds of food commodities, including cereals, grape and dried fruit products, and dry-cured meat products. Deeper knowledge of OTA production and mycelium growth related to the high-sugar or NaCl-rich environments was gained in this manuscript. A. ochraceus and P. nordicum were likely to have greater growth rates in medium supplied with certain concentrations of NaCl (0-80 g/L), and the colony diameter was the largest at the salt content of 40 g/L. P. nordicum was more suitable to grow in NaCl-riched medium, the OTA production was increased to 316 ppb from 77 ppb when 20 g/L NaCl was added. The capability of OTA production was inhibited when salt content was 40 g/L and 60 g/L in A. ochraceus and P. nordicum, respectively. As the glucose content increased to 250 g/L, the capacity of mycelium growth and sporulation was increased significantly in A. ochraceus and A. carbonarius. A. carbonarius was more suitable to grow in high-sugar grape products. OTA production was significantly promoted with an added 100 g/L glucose in A. carbonarius. OTA production was inhibited when glucose content was 150 g/L and in 200 g/L in A. ochraceus and A. carbonarius, respectively. NaCl and glucose have an effect on fungal growth and OTA production, and the activation of biosynthetic genes of OtaA. These results would allow designing new strategies to prevent OTA accumulation on sugar or NaCl-riched foodstuffs and achieve the objective to manufacture cereals, dried vine fruits and dry-cured ham, free of OTA.

Extracellular Tannase from Aspergillus ochraceus: Influence of the Culture Conditions on Biofilm Formation, Enzyme Production, and Application.

Aspergillus ochraceus biofilm, developed on an inert support, can produce tannase in Khanna medium containing 1.5% (w/v) tannic acid as the carbon source, at an initial pH of 5.0, for 72 h at 28 °C. Addition of 0.1% yeast extract increased enzyme production. The enzyme in the crude filtrate exhibited the highest activity at 30 °C and pH 6.0. At 50 °C, the half-life was 60 min and 260 min at pH 6.0. In general, addition of detergents and surfactants did not affect tannase activity significantly. Tannase has potential applications in various biotechnological processes such as the production of propyl gallate and in the treatment of tannin-rich effluents. The content of tannins and total phenolic compounds in effluents from leather treatment was reduced by 56-83% and 47-64%, respectively, after 2 h of enzyme treatment. The content of tannins and total phenolic compounds in the sorghum flour treated for 120 h with tannase were reduced by 61% and 17%, respectively. Interestingly, the same A. ochraceus biofilm was able to produce tannase for three sequential fermentative process. In conclusion, fungal biofilm is an interesting alternative to produce high levels of tannase with biotechnological potential to be applied in different industrial sectors.

Bioactive coatings from nano-biopolymers/plant extract composites for complete protection from mycotoxigenic fungi in dates.

BACKGROUND: Contamination of date fruit with mycotoxigenic fungi is a hazardous threat. The present study investigated the effectiveness of natural derivatives for controlling this. Chitosan (Cts) was produced from Aspergillus niger mycelia and characterized and then nanochitosan (NCt) particles were synthesized from fungal Cts. Edible-coating films were formulated based on Cts, NCt, pomegranate peel extract (PPE) and their composites and these were evaluated as antifungal materials against mycotoxigenic fungi, Aspergillus flavus, Aspergillus ochraceus and Fusarium moniliforme. RESULTS: The Cts produced had 88.7% deacetylation, a molecular weight of 24.5 kDa and 98% solubility in diluted acetic acid, whereas the particle diameters of synthesized NCts ranged from 35 to 65 nm. The inhibition zone assay emphasized the antifungal effectiveness of the entire coating films. The most effective agent for preparing edible film was the blend of NCt + PPE followed by Cts + PPE based films. The practical application of antifungal films for date decontamination with respect to mycotoxigenic fungi demonstrates that the films were very effective for controlling the entire fungal strain and preventing growth on the fruits. CONCLUSION: The NCt + PPE and Cts + PPE based films were found to be the most effective because they could completely eliminate the growth of any fungal spore on date fruit after 48 h from the coating experiment. © 2019 Society of Chemical Industry.

Effect of Cinnamaldehyde on Morphological Alterations of Aspergillus ochraceus and Expression of Key Genes Involved in Ochratoxin A Biosynthesis.

Ochratoxin A (OTA) is a potent nephrotoxic, hepatotoxic, and teratogenic compound which is a significant mycotoxin contaminates cereals during storage. Aspergillus ochraceus is the most common producer of OTA in cereals and cereal-derived products. Cinnamaldehyde is a natural substance derived from plant cinnamon playing an important role in the reduction of OTA contamination. In this study, the antifungal and antitoxigenic effect of cinnamaldehyde was investigated with its mechanisms of inhibition of fungal growth at the morphological and ultrastructural levels, and inhibition of OTA biosynthesis at the transcriptional level. Significant A. ochraceus growth was inhibited at 0.4⁻1.6 mmol/L with fumigation. A. ochraceus exposed to 0.4 mmol/L of cinnamaldehyde indicated irreversible harmful morphological and ultrastructural modifications such as the folding of the cell, the loss of integrity of the cell wall, the disruption of plasma membrane, the destruction of the mitochondria, and the absence of intracellular organelles. These alterations may be attributed to its inhibition of enzymatic reactions that regulate cell wall synthesis, thus disturbing the morphogenesis and growth of A. ochraceus. In the presence of cinnamaldehyde, the tested biosynthetic and regulatory genes like pks, nrps, veA, laeA and velB were highly downregulated. Moreover, the downregulation effect of cinnamaldehyde increased proportionally with the concentrations. These results suggest that the decrease of OTA production by cinnamaldehyde is attributed to the downregulation of the transcriptional levels of OTA biosynthetic and regulatory genes besides the inhibition of fungal growth. The study reveals the mechanisms of the antifungal and antitoxigenic activities of cinnamaldehyde against A. ochraceus, and further emphasizes that cinnamaldehyde could be a safe and effective natural agents against OTA contamination during cereals storage.

Influence of high-pressure processing on the generation of γ-aminobutyric acid and microbiological safety in coffee beans.

BACKGROUND: The aim of this study was to investigate the influence of high-pressure processing (HPP) on γ-aminobutyric acid (GABA) content, glutamic acid (Glu) content, glutamate decarboxylase (GAD) activity, growth of Aspergillus fresenii, and accumulated ochratoxin A (OTA) content in coffee beans. RESULTS: The results indicated that coffee beans subjected to HPP at pressures ≥50 MPa for 5 min increased GAD activity and promoted the conversion of Glu to GABA, and showed a significantly doubling of GABA content compared with unprocessed coffee beans. Additionally, investigation of the influence of HPP on A. fresenii growth on coffee beans showed that application ≥400 MPa reduced A. fresenii concentrations to <1 log. Furthermore, during a 50-day storage period, we observed that a processing pressure of 600 MPa completely inhibited A. fresenii growth, and on day 50 the OTA content of coffee beans subjected to processing pressures of 600 MPa was 0.0066 µg g-1 , which was significantly lower than the OTA content of 0.1143 µg g-1 in the control group. CONCLUSION: This study shows that HPP treatment can simultaneously increase GABA content and inhibit the growth of A. fresenii, thereby effectively reducing the production and accumulation of OTA and maintaining the microbiological safety of coffee beans. © 2018 Society of Chemical Industry.

Biocontrol of ochratoxigenic moulds (Aspergillus ochraceus and Penicillium nordicum) by Debaryomyces hansenii and Saccharomycopsis fibuligera during speck production.

Speck is a meat product obtained from the deboned leg of pork that is salted, smoked and seasoned for four to six months. During speck seasoning, Eurotium rubrum and Penicillium solitum grow on the surface and collaborate with other moulds and tissue enzymes to produce the typical aroma. Both of these strains usually predominate over other moulds. However, moulds producing ochratoxins, such as Aspergillus ochraceus and Penicillium nordicum, can also co-grow on speck and produce ochratoxin A (OTA). Consequently, speck could represent a potential health risk for consumers. Because A. ochraceus and P. nordicum could represent a problem for artisanal speck production, the aim of this study was to inhibit these mould strains using Debaryomyces hansenii and Saccharomycopsis fibuligera. Six D. hansenii and six S. fibuligera strains were tested in vitro to inhibit A. ochraceus and P. nordicum. The D. hansenii DIAL 1 and S. fibuligera DIAL 3 strains demonstrated the highest inhibitory activity and were selected for in vivo tests. The strains were co-inoculated on fresh meat cuts for speck production with both of the OTA-producing moulds prior to drying and seasoning. At the end of seasoning (six months), OTA was not detected in the speck treated with both yeast strains. Because the yeasts did not adversely affect the speck odour or flavour, the strains are proposed as starters for the inhibition of ochratoxigenic moulds.

Efficiency of Artemisia nilagirica (Clarke) Pamp. essential oil as a mycotoxicant against postharvest mycobiota of table grapes.

BACKGROUND: In order to get a potent botanical fungicide for the management of fungal decay of table grapes, an experiment was conducted in which 20 essential oils of higher plants were screened at 0.33 µL mL(-1) against dominant fungi causing decay of table grapes, including Aspergillus flavus, A. niger and A. ochraceus. Furthermore, the minimum inhibitory/fungicidal concentration, fungitoxic spectrum and mycotoxin inhibition activity of the most potent oil were determined. The efficacy of the most potent oil in preservation of table grapes, along with organoleptic evaluation, was also carried out by storing 1 kg of grapes in the oil vapour. RESULTS: Artemisia nilagirica oil was found to be most toxic, exhibiting 100% mycelia inhibition of all test fungi. Moreover, 0.29 µL mL(-1) A. nilagirica oil was fungistatic and 0.58 µL mL(-1) was fungicidal for all tested species of Aspergillus. The oil exhibited a broad range of fungitoxicity against other grape berry-rotting fungi. Artemisia nilagirica oil completely suppressed the growth and mycotoxin (AFB1 and OTA) secretion of aflatoxigenic and ochratoxigenic strains of Aspergillus at 1.6 µL mL(-1) . During the in vivo experiment, fumigation of 1 kg of table grapes with 200 and 300 µL dosage of A. nilagirica oil enhanced the shelf life for up to 9 days. The oil did not show any phytotoxic effect. Besides, oil application did not substantively change the sensory properties of the fruits. CONCLUSION: Artemisia nilagirica oil can be used as an alternative botanical fungicide for the control of fruit-rotting fungi of stored grapes.

Inhibitory effect of essential oils on Aspergillus ochraceus growth and ochratoxin A production.

Ochratoxin A (OTA) is a mycotoxin which is a common contaminant in grains during storage. Aspergillus ochraceus is the most common producer of OTA. Essential oils play a crucial role as a biocontrol in the reduction of fungal contamination. Essential oils namely natural cinnamaldehyde, cinnamon oil, synthetic cinnamaldehyde, Litsea citrate oil, citral, eugenol, peppermint, eucalyptus, anise and camphor oils, were tested for their efficacy against A. ochraceus growth and OTA production by fumigation and contact assays. Natural cinnamaldehyde proved to be the most effective against A. ochraceus when compared to other oils. Complete fungal growth inhibition was obtained at 150-250 µL/L with fumigation and 250-500 µL/L with contact assays for cinnamon oil, natural and synthetic cinnamaldehyde, L. citrate oil and citral. Essential oils had an impact on the ergosterol biosynthesis and OTA production. Complete inhibition of ergosterol biosynthesis was observed at ≥ 100 µg/mL of natural cinnamaldehyde and at 200 µg/mL of citral, but total inhibition was not observed at 200 µg/mL of eugenol. But, citral and eugenol could inhibit the OTA production at ≥ 75 µg/mL and ≥ 150 µg/mL respectively, while natural cinnamaldehyde couldn't fully inhibit OTA production at ≤ 200 µg/mL. The inhibition of OTA by natural cinnamaldehyde is mainly due to the reduction in fungal biomass. However, citral and eugenol could significant inhibit the OTA biosynthetic pathway. Also, we observed that cinnamaldehyde was converted to cinnamic alcohol by A. ochraceus, suggesting that the antimicrobial activity of cinnamaldehyde was mainly attributed to its carbonyl aldehyde group. The study concludes that natural cinnamaldehyde, citral and eugenol could be potential biocontrol agents against OTA contamination in storage grains.

Fumigant antifungal activity of Myrtaceae essential oils and constituents from Leptospermum petersonii against three Aspergillus species.

Commercial plant essential oils obtained from 11 Myrtaceae plant species were tested for their fumigant antifungal activity against Aspergillus ochraceus, A. flavus, and A. niger. Essential oils extracted from Leptospermum petersonii at air concentrations of 56 × 10(-3) mg/mL and 28 × 10(-3) mg/mL completely inhibited the growth of the three Aspergillus species. However, at an air concentration of 14 × 10(-3) mg/mL, inhibition rates of L. petersonii essential oils were reduced to 20.2% and 18.8% in the case of A. flavus and A. niger, respectively. The other Myrtaceae essential oils (56 × 10(-3) mg/mL) only weakly inhibited the fungi or had no detectable affect. Gas chromatography-mass spectrometry analysis identified 16 compounds in L. petersonii essential oil. The antifungal activity of the identified compounds was tested individually by using standard or synthesized compounds. Of these, neral and geranial inhibited growth by 100%, at an air concentration of 56 × 10(-3) mg/mL, whereas the activity of citronellol was somewhat lover (80%). The other compounds exhibited only moderate or weak antifungal activity. The antifungal activities of blends of constituents identified in L. petersonii oil indicated that neral and geranial were the major contributors to the fumigant and antifungal activities.

Inactivation of A. ochraceus spores and detoxification of ochratoxin A in coffee beans by gamma irradiation.

UNLABELLED: Ochratoxin A (OTA) produced in food by Aspergillus ochraceus is known to cause adverse health effects. Among the plantation products, green coffee beans are prone to fungal attack and get contaminated with OTA frequently. A fungal strain isolated from green coffee beans was characterized by morphological analyses as well as internal transcribed spacer (ITS) and 5.8S rDNA sequencing, turned out to be A. ochraceus, however, nontoxigenic. Hence, additional strains of A. ochraceus were procured and characterized for toxin production. Presterilized green coffee beans were spiked with a toxigenic strain and treated with gamma radiation. Minimum inhibitory dose (MID) of gamma radiation for 10(4) and 10(8) spores of A. ochraceus strain per 10 g of green coffee beans was found to be approximately 1 and approximately 2.5 kGy, respectively. The radiation treatment (10 kGy) almost degraded the preformed or in vitro added OTA (50 ppb) in coffee beans. OTA degradation was found to be enhanced with increase in moisture content. Cytotoxicity in terms of cell viability was found to be reduced significantly for radiation treated OTA in MTT [3-(4,5-dimethylthiazole-2yl)-2,5-diphenyl tetrazolium bromide] assay as well as flow cytometric analysis when studied using human intestinal epithelial (Int-407) cells. Similar finding was also observed with E. coli MG1655 cells. Thus the inclusion of gamma radiation treatment in the postharvest processing chain of green coffee beans could help in eliminating toxigenic fungi as well as destroying preformed OTA without affecting the sensory attributes. PRACTICAL APPLICATION: In general, mycotoxins including ochratoxin A (OTA) are highly stable to detoxifying agents. Green coffee beans are prone to fungal attack and could get frequently contaminated with the OTA due to improper drying or rehydration during storage. Gamma radiation processing of green coffee beans was found to eliminate the A. ochraceus spores as well as inactivate OTA without affecting its sensory attributes. Thus inclusion of gamma radiation in the postharvest processing chain of green coffee beans would be very useful for consumer safety and coffee trade.

Prevention of Aspergillus ochraceus growth on and Ochratoxin a contamination of sausages using ozonated air.

Mycotoxigenic moulds can grow on the surface of sausages and reduce the safety of these sausages for consumption. The aim of this study was to prevent the growth of Aspergillus ochraceus and the presence of Ochratoxin A (OTA) on the surface of Milano-type sausages using ozonated air. Spores of A. ochraceus were used to inoculate the casings of the sausages after casing. A portion of the lot (35 samples) was ripened in typical rooms, and another portion (35 samples) was dried and ripened in a separate room that was treated with gaseous ozone. The gas was delivered at night (8 h/day) at a concentration of ∼1 ppm. The temperature and relative humidity during the drying and ripening were the same for both rooms. Our results demonstrate that the gaseous ozone treatment prevented the growth of A. ochraceus and, consequently, the presence of OTA. In contrast, A. ochraceus grew and produced OTA on the untreated sausages. Moreover, the use of ozone did not influence the ripening, physico-chemical parameters, peroxide value or sensorial characteristics of the sausages.

Exploration of Islamic medicine plant extracts as powerful antifungals for the prevention of mycotoxigenic Aspergilli growth in organic silage.

BACKGROUND: Feed contamination with mycotoxins is a major risk factor for animals and humans as several toxins can exist as residues in meat and milk products, giving rise to carry-over to consumers via ingestion of foods of animal origin. The starting point for prevention, in this chain, is to eliminate the growth of mycotoxigenic fungi in the animal forage. Ten plant extracts, recommended in Islamic medicine, were evaluated as antifungal agents against mycotoxigenic Aspergilli, i.e. Aspergillus flavus and A. ochraceus, growth in organic maize silage. RESULTS: Most extracts had remarkable antifungal activities using both qualitative and quantitative evaluation methods. Cress (Lepidium sativum) seed extract was proven to be the most powerful among the plants examined. Blending of the most effective extracts (garden cress seed, pomegranate peel and olive leaf extracts), individually at their minimal fungicidal concentrations, with maize silage resulted in the reduction of inoculated A. flavus colony counts by 99.9, 99.6 and 98.7%, respectively, whereas silage blending with the combined extracts completely prohibited fungal growth for up to 30 days of incubation under aerobic conditions. CONCLUSION: Besides the health promoting effects, silage blending with the bioactive plant extracts examined could lead to the required protection from pathogenic and mycotoxigenic fungi.

Modelling the effect of temperature and water activity in the growth boundaries of Aspergillus ochraceus and Aspergillus parasiticus.

The aim of this work was to model the growth of Aspergillus parasiticus and Aspergillus ochraceus, both mycotoxin producers, near to the growth/no growth boundaries and validate those models in sterile maize grain, peanuts and coffee beans. Malt extract agar was adjusted to six different water activities: 0.93, 0.91, 0.89, 0.87, 0.85 and 0.80. Plates were incubated at 10, 15, 20, 25, 30, 37 and 42 °C. For each of the 42 conditions, 10 Petri dishes were inoculated. Both kinetic and probability models were applied to colony growth data. The results of the present study indicate that the developed probability modelling approach could be satisfactorily employed to quantify the combined effect of temperature and water activity on the growth responses of A. ochraceus and A. parasiticus. However, validation of kinetic results led to poor goodness of prediction. In this study, the validation samples were placed near to the expected boundaries of the models in order to test them under the worst situation. Probability of growth prediction under extreme growth conditions was somewhat compromised, but it can be considered acceptable.

Growth inhibition of Aspergillus ochraceus ZMPBF 318 and Penicillium expansum ZMPBF 565 by four essential oils.

Fungi produce a large variety of extracellular proteins, organic acids, and other metabolites and can adapt to several environmental conditions. Mycotoxin-producing moulds of the genera Aspergillus and Penicillium are common food contaminants. One of the natural ways to protect food from mould contamination is to use essential oils. In this study, we evaluated the effect of essential oils of cinnamon, lavender, rosemary, and sage at 1 % (v/v) concentration in yeast media inoculated with spores (final concentration 106 mL-1 media) of Aspergillus ochraceus ZMPBF 318 and Penicillium expansum ZMPBF 565, alone or in combination, on fungal biomass. Cinnamon showed the best inhibitory effect (100 %). Lavender oil best inhibited the growth of Aspergillus ochraceus (nearly 100 %), and was less successful with Penicillium expansum (having dropped to 57 % on day 28). With cultivation time the inhibitory effect of sage and rosemary oil grew for Aspergillus ochraceus and dropped for Penicillium expansum.These results suggest that fungi can be controlled with essential oils, especially with cinnamon oil.

Effect of ozone on spore germination, spore production and biomass production in two Aspergillus species.

The ability of ozone gas to reduce food spoilage is relatively well documented, but the developmental effects of the gas on food spoilage fungi are not well known. In this study two model aspergilli, Aspergillus nidulans and Aspergillus ochraceus were used to study the effects of ozone on spore germination, sporulation and biomass production. These effects were examined under three levels of ozone; two high level ozone exposures (200 and 300 micromol mol(-1)) and one low level exposure (0.2 micromol mol(-1)). The two species behaved noticeably different to each other. Ozone was more effective in reducing growth from spore inocula than mycelia. No spore production could be detected in A. nidulans exposed to continuous low level O3, whereas the same treatment reduced spores produced in A. ochraceus by 94%. Overall the work suggests that ozone exposure is an effective method to prevent spread of fungal spores in a food storage situation.