ABSTRACT
Vitamin B1 , also known as thiamine, is an important vitamin that, besides its role in human health, is converted to meat aromas upon exposure to high temperatures. Therefore, it is relevant for the production of vegan meat-like flavours. In this study, we investigated 48 Saccharomyces cerevisiae strains for their thiamine production capacity by measuring the intracellular and extracellular vitamins produced in the thiamine-free minimal medium after 72 h of growth. We found approximately an 8.2-fold difference in overall thiamine yield between the highest and lowest-producing strains. While the highest thiamine yield was 254.6 nmol/L, the highest thiamine-specific productivity was 160.9 nmol/g DW. To assess whether extracellular thiamine was due to leakage caused by cell damage, we monitored membrane permeabilization using propidium iodide (PI) staining and flow cytometry. We found a good correlation between the percentage of extracellular thiamine and PI-stained cells (Spearman's ρ = 0.85). Finally, we compared S. cerevisiae CEN.PK113-7D (wild type [WT]) to three strains evolved in a thiamine-free medium for their thiamine production capacity. On average, we saw an increase in the amount of thiamine produced. One of the evolved strains had a 49% increase in intracellular thiamine-specific productivity and a biomass increase of 20% compared with the WT. This led to a total increase in thiamine yield of 60% in this strain, reaching 208 nmol/L. This study demonstrated that it is possible to achieve thiamine overproduction in S. cerevisiae via strain selection and adaptive laboratory evolution.
Subject(s)
Saccharomyces cerevisiae Proteins , Saccharomyces cerevisiae , Humans , Saccharomyces cerevisiae/metabolism , Thiamine , Saccharomyces cerevisiae Proteins/metabolism , VitaminsABSTRACT
Fermentation employing Saccharomyces cerevisiae has produced alcoholic beverages and bread for millennia. More recently, S. cerevisiae has been used to manufacture specific metabolites for the food, pharmaceutical, and cosmetic industries. Among the most important of these metabolites are compounds associated with desirable aromas and flavors, including higher alcohols and esters. Although the physiology of yeast has been well-studied, its metabolic modulation leading to aroma production in relevant industrial scenarios such as winemaking is still unclear. Here we ask what are the underlying metabolic mechanisms that explain the conserved and varying behavior of different yeasts regarding aroma formation under enological conditions? We employed dynamic flux balance analysis (dFBA) to answer this key question using the latest genome-scale metabolic model (GEM) of S. cerevisiae. The model revealed several conserved mechanisms among wine yeasts, for example, acetate ester formation is dependent on intracellular metabolic acetyl-CoA/CoA levels, and the formation of ethyl esters facilitates the removal of toxic fatty acids from cells using CoA. Species-specific mechanisms were also found, such as a preference for the shikimate pathway leading to more 2-phenylethanol production in the Opale strain as well as strain behavior varying notably during the carbohydrate accumulation phase and carbohydrate accumulation inducing redox restrictions during a later cell growth phase for strain Uvaferm. In conclusion, our new metabolic model of yeast under enological conditions revealed key metabolic mechanisms in wine yeasts, which will aid future research strategies to optimize their behavior in industrial settings.
Subject(s)
Saccharomyces cerevisiae , Wine , Saccharomyces cerevisiae/genetics , Saccharomyces cerevisiae/metabolism , Wine/analysis , Fermentation , Esters/metabolism , Carbohydrates/analysisABSTRACT
Lactococcus lactis strains residing in the microbial community of a complex dairy starter culture named "Ur" are hosts to prophages belonging to the family Siphoviridae. L. lactis strains (TIFN1 to TIFN7) showed detectable spontaneous phage production and release (109 to 1010 phage particles/ml) and up to 10-fold increases upon prophage induction, while in both cases we observed no obvious cell lysis typically described for the lytic life cycle of Siphoviridae phages. Intrigued by this phenomenon, we investigated the host-phage interaction using strain TIFN1 (harboring prophage proPhi1) as a representative. We confirmed that during the massive phage release, all bacterial cells remain viable. Further, by monitoring phage replication in vivo, using a green fluorescence protein reporter combined with flow cytometry, we demonstrated that the majority of the bacterial population (over 80%) is actively producing phage particles when induced with mitomycin C. The released tailless phage particles were found to be engulfed in lipid membranes, as evidenced by electron microscopy and lipid staining combined with chemical lipid analysis. Based on the collective observations, we propose a model of phage-host interaction in L. lactis TIFN1 where the phage particles are engulfed in membranes upon release, thereby leaving the producing host intact. Moreover, we discuss possible mechanisms of chronic, or nonlytic, release of LAB Siphoviridae phages and its impact on the bacterial host. IMPORTANCE In complex microbial consortia such as fermentation starters, bacteriophages can alter the dynamics and diversity of microbial communities. Bacteriophages infecting Lactococcus lactis are mostly studied for their detrimental impact on industrial dairy fermentation processes. In this study, we describe a novel form of phage-bacterium interaction in an L. lactis strain isolated from a complex dairy starter culture: when the prophages harbored in the L. lactis genome are activated, the phage particles are engulfed in lipid membranes upon release, leaving the producing host intact. Findings from this study provide additional insights into the diverse manners of phage-bacterium interactions and coevolution, which are essential for understanding the population dynamics in complex microbial communities like fermentation starters.
Subject(s)
Bacteriophages , Lactococcus lactis , Siphoviridae , Bacteriophages/genetics , Fermentation , Prophages/genetics , Siphoviridae/geneticsABSTRACT
BACKGROUND: Propionibacterium freudenreichii is used in biotechnological applications to produce vitamin B12. Although cultured mainly in anaerobic conditions, microaerobic conditions can greatly enhance biomass formation in P. freudenreichii. Since B12 yields may be coupled to biomass formation, microaerobic conditions show great potential for increasing B12 yields in P. freudenreichii. RESULTS: Here we show biomass formation increases 2.7 times for P. freudenreichii grown in microaerobic conditions on lactate versus anaerobic conditions (1.87 g/L vs 0.70 g/L). Consumption of lactate in microaerobic conditions resulted first in production of pyruvate, propionate and acetate. When lactate was depleted, pyruvate and propionate were oxidised with a concomitant sixfold increase in the B12 titer compared to anaerobic conditions, showing potential for propionate and pyruvate as carbon sources for B12 production. Consequently, a fed-batch reactor with anaerobically precultured lactate-grown cells was fed propionate in microaerobic conditions resulting in biomass increase and production of B12. Vitamin yields increased from 0.3 [Formula: see text] B12 per mmol lactate in anaerobic conditions to 2.4 [Formula: see text] B12 per mmol lactate and 8.4 [Formula: see text] B12 per mmol propionate in microaerobic conditions. Yield per cell dry weight (CDW) increased from 41 [Formula: see text] per g CDW in anaerobic conditions on lactate to 92 [Formula: see text] per g CDW on lactate and 184 [Formula: see text] per g CDW on propionate in microaerobic conditions. CONCLUSIONS: Here we have shown both B12 yield per substrate and per CDW were highest on cells oxidising propionate in microaerobic conditions, showing the potential of propionate for biotechnological production of vitamin B12 by P. freudenreichii.
Subject(s)
Propionibacterium freudenreichii , Propionibacterium freudenreichii/metabolism , Propionates/metabolism , Propionibacterium , Vitamin B 12 , Lactic Acid/metabolism , Pyruvates/metabolism , Vitamins/metabolismABSTRACT
In this study we show increased biomass formation for four species of food-grade propionic acid bacteria (Acidipropionibacterium acidipropionici, Acidipropionibacterium jensenii, Acidipropionibacterium thoenii and Propionibacterium freudenreichii) when exposed to oxygen, implicating functional respiratory systems. Using an optimal microaerobic condition, P. freudenreichii DSM 20271 consumed lactate to produce propionate and acetate initially. When lactate was depleted propionate was oxidized to acetate. We propose to name the switch from propionate production to consumption in microaerobic conditions the 'propionate switch'. When propionate was depleted the 'acetate switch' occurred, resulting in complete consumption of acetate. Both growth rate on lactate (0.100 versus 0.078 h-1 ) and biomass yield (20.5 versus 8.6 g* mol-1 lactate) increased compared to anaerobic conditions. Proteome analysis revealed that the abundance of proteins involved in the aerobic and anaerobic electron transport chains and major metabolic pathways did not significantly differ between anaerobic and microaerobic conditions. This implicates that P. freudenreichii is prepared for utilizing O2 when it comes available in anaerobic conditions. The ecological niche of propionic acid bacteria can conceivably be extended to environments with oxygen gradients from oxic to anoxic, so-called microoxic environments, as found in the rumen, gut and soils, where they can thrive by utilizing low concentrations of oxygen.
Subject(s)
Propionibacterium freudenreichii , Carbon Dioxide , Lactic Acid , Propionates , PropionibacteriaceaeABSTRACT
BACKGROUND: Metabolomics coupled with genome-scale metabolic modeling approaches have been employed recently to quantitatively analyze the physiological states of various organisms, including Saccharomyces cerevisiae. Although yeast physiology in laboratory strains is well-studied, the metabolic states under industrially relevant scenarios such as winemaking are still not sufficiently understood, especially as there is considerable variation in metabolism between commercial strains. To study the potential causes of strain-dependent variation in the production of volatile compounds during enological conditions, random flux sampling and statistical methods were used, along with experimental extracellular metabolite flux data to characterize the differences in predicted intracellular metabolic states between strains. RESULTS: It was observed that four selected commercial wine yeast strains (Elixir, Opale, R2, and Uvaferm) produced variable amounts of key volatile organic compounds (VOCs). Principal component analysis was performed on extracellular metabolite data from the strains at three time points of cell cultivation (24, 58, and 144 h). Separation of the strains was observed at all three time points. Furthermore, Uvaferm at 24 h, for instance, was most associated with propanol and ethyl hexanoate. R2 was found to be associated with ethyl acetate and Opale could be associated with isobutanol while Elixir was most associated with phenylethanol and phenylethyl acetate. Constraint-based modeling (CBM) was employed using the latest genome-scale metabolic model of yeast (Yeast8) and random flux sampling was performed with experimentally derived fluxes at various stages of growth as constraints for the model. The flux sampling simulations allowed us to characterize intracellular metabolic flux states and illustrate the key parts of metabolism that likely determine the observed strain differences. Flux sampling determined that Uvaferm and Elixir are similar while R2 and Opale exhibited the highest degree of differences in the Ehrlich pathway and carbon metabolism, thereby causing strain-specific variation in VOC production. The model predictions also established the top 20 fluxes that relate to phenotypic strain variation (e.g. at 24 h). These fluxes indicated that Opale had a higher median flux for pyruvate decarboxylase reactions compared with the other strains. Conversely, R2 which was lower in all VOCs, had higher median fluxes going toward central metabolism. For Elixir and Uvaferm, the differences in metabolism were most evident in fluxes pertaining to transaminase and hexokinase associated reactions. The applied analysis of metabolic divergence unveiled strain-specific differences in yeast metabolism linked to fusel alcohol and ester production. CONCLUSIONS: Overall, this approach proved useful in elucidating key reactions in amino acid, carbon, and glycerophospholipid metabolism which suggest genetic divergence in activity in metabolic subsystems among these wine strains related to the observed differences in VOC formation. The findings in this study could steer more focused research endeavors in developing or selecting optimal aroma-producing yeast stains for winemaking and other types of alcoholic fermentations.
Subject(s)
Metabolic Flux Analysis/methods , Metabolome , Models, Biological , Saccharomyces cerevisiae/metabolism , Volatile Organic Compounds/metabolism , Wine/microbiology , Fermentation , Food Microbiology , Metabolomics/methods , Odorants/analysis , Saccharomyces cerevisiae/genetics , Volatile Organic Compounds/analysis , Wine/analysisABSTRACT
Folate is a B-vitamin with an important role in health and disease. The optimal folate status with regard to human health remains controversial. A low intake of natural folate as well as excessive intake of synthetic folic acid, were previously linked to an increased risk of colorectal cancer or with aberrant molecular pathways related to carcinogenesis in some studies. Importantly, most studies conducted so far, solely focused on dietary intake or circulating levels of folate in relation to cancer risk. Notably, diet or dietary supplements are not the only sources of folate. Several bacteria in the gastrointestinal tract can synthesize B-vitamins, including folate, in quantities that resemble dietary intake. The impact of bacterial folate biosynthesis concerning human health and disease remains unexplored. This review highlights current insights into folate biosynthesis by intestinal bacteria and its implications for processes relevant to cancer development, such as epigenetic DNA modifications and DNA synthesis. Moreover, we will reflect on the emerging question whether food-grade or intestinal bacteria can be considered a potential target to ensure sufficient levels of folate in the gastrointestinal tract and, hence the relevance of bacterial folate biosynthesis for disease prevention or treatment.
Subject(s)
Colorectal Neoplasms/epidemiology , Folic Acid/metabolism , Vitamin B Complex , Bacteria , Diet , HumansABSTRACT
Mabisi is a fermented milk product, traditionally produced in a calabash by uncontrolled fermentation. Due to high costs and a reduced availability of calabashes, nowadays plastic containers are also used for Mabisi production. However, the effect of this change in production practice on the properties of the product has not been documented. Therefore, we aimed at determining the effect of fermentation vessels and types of back-slopping on acidification and microbial communities during fermentation. A series of fifteen experiments using two types of fermentation vessels (plastic buckets and calabashes) in combination with different types of back-slopping (no back-slopping, passive back-slopping, and active back-slopping) were set up at a field site in rural Zambia. In each of the fifteen fermentations we analysed acidification rate of traditional Mabisi fermentation and bacterial diversity over time. No significant difference was found in terms of microbial diversity during and at the end of fermentation between fermentations performed in buckets or previously used calabashes. Bacterial communities in general decreased in diversity over time, where the drop in pH correlated with a decrease in Shannon Index. In case of active back-slopping, the pH drop started right after inoculation while in the no back-slopping and passive back-slopping fermentations, there was a clear lag phase before acidification started. All experimental series resulted in a microbial community dominated by Lactococcus lactis and a Shannon Index, as a measure for diversity, between 0.6 and 2.0. The use of plastic buckets for Mabisi fermentation can be a valuable alternative to the use of calabashes as this study showed no biological and physico-chemical differences between Mabisi resulting from both fermentation vessels, although the reason for perceived differences should be further investigated.
Subject(s)
Bacteria/classification , Bacteriological Techniques/instrumentation , Cultured Milk Products/microbiology , Bacteria/genetics , Bacteria/growth & development , Bacteria/isolation & purification , DNA, Bacterial/genetics , Fermentation , Food Microbiology , Hydrogen-Ion Concentration , Phylogeny , Sequence Analysis, DNA , ZambiaABSTRACT
BACKGROUND: Vitamin K2 (menaquinone, MK-n) is a lipid-soluble vitamin that functions as a carboxylase co-factor for maturation of proteins involved in many vital physiological processes in humans. Notably, long-chain vitamin K2 is produced by bacteria, including some species and strains belonging to the group of lactic acid bacteria (LAB) that play important roles in food fermentation processes. This study was performed to gain insights into the natural long-chain vitamin K2 production capacity of LAB and the factors influencing vitamin K2 production during cultivation, providing a basis for biotechnological production of vitamin K2 and in situ fortification of this vitamin in food products. RESULTS: We observed that six selected Lactococcus lactis strains produced MK-5 to MK-10, with MK-8 and MK-9 as the major MK variant. Significant diversities between strains were observed in terms of specific concentrations and titres of vitamin K2. L. lactis ssp. cremoris MG1363 was selected for more detailed studies of the impact of selected carbon sources tested under different growth conditions [i.e. static fermentation (oxygen absent, heme absent); aerobic fermentation (oxygen present, heme absent) and aerobic respiration (oxygen present, heme present)] on vitamin K2 production in M17 media. Aerobic fermentation with fructose as a carbon source resulted in the highest specific concentration of vitamin K2: 3.7-fold increase compared to static fermentation with glucose, whereas aerobic respiration with trehalose resulted in the highest titre: 5.2-fold increase compared to static fermentation with glucose. When the same strain was applied to quark fermentation, we consistently observed that altered carbon source (fructose) and aerobic cultivation of the pre-culture resulted in efficient vitamin K2 fortification in the quark product. CONCLUSIONS: With this study we demonstrate that certain LAB strains can be employed for efficient production of long-chain vitamin K2. Strain selection and optimisation of growth conditions offer a viable strategy towards natural vitamin K2 enrichment of fermented foods, and to improved biotechnological vitamin K2 production processes.
Subject(s)
Carbon/metabolism , Energy Metabolism , Lactococcus lactis/metabolism , Oxygen/metabolism , Temperature , Vitamin K 2/metabolism , Culture Media , Fermentation , Glucose/metabolism , Industrial MicrobiologyABSTRACT
Lactococcus lactis subsp. lactis biovar diacetylactis and Leuconostoc mesenteroides are considered to be the main aroma producers in Dutch-type cheeses. Both species of lactic acid bacteria were grown in retentostat mono- and co-cultures to investigate their interaction at near-zero growth rates and to determine if co-cultivation enhances the aroma complexity compared to single species performance. During retentostat mono-cultures, the growth rates of both species decreased to less than 0.001 h-1 and a large fraction of the cells became viable but not culturable. Compared to Lc. mesenteroides, L. lactis reached a 3.4-fold higher biomass concentration caused by i) a higher ATP yield on substrate, ii) a higher biomass yield on ATP and iii) a lower maintenance requirement (mATP). Dynamic models estimated that the mATP of both species decreased approximately 7-fold at near-zero growth rates compared to high growth rates. Extension of these models by assuming equal substrate distribution resulted in excellent prediction of the biomass accumulation in retentostat co-cultures with L. lactis dominating (100:1) as observed in ripened cheese. Despite its low abundance (â¼1%), Lc. mesenteroides contributed to aroma production in co-cultures as indicated by the presence of all 5 specific Lc. mesenteroides compounds. This study provides insights in the production of cheese aroma compounds outside the cheese matrix by co-cultures of L. lactis and Lc. mesenteroides, which could be used as food supplements in dairy or non-dairy products.
Subject(s)
Food Microbiology , Lactococcus lactis/metabolism , Leuconostoc mesenteroides/metabolism , Odorants/analysis , Volatile Organic Compounds/analysis , Animals , Bacteriological Techniques , Cheese/microbiology , Fermentation , Lactococcus lactis/growth & development , Leuconostoc mesenteroides/growth & development , Microbial Interactions , Milk/microbiologyABSTRACT
Co-cultivation of brewers' yeast (Saccharomyces cerevisiae) with Cyberlindnera fabianii makes it possible to steer aroma and alcohol levels by changing the inoculation ratio of the two yeasts. A dynamic model was developed based on mono-culture performance of brewers' yeast and C. fabianii in controlled bioreactors with aerated wort as medium, describing growth rate, carbohydrate utilization, ethanol production, maintenance, oxygen consumption and ergosterol biosynthesis/use for cell membrane synthesis (the last one only for brewers' yeast). The parameters were estimated by fitting models to experimental data of both mono-cultivations. To predict the fermentation outcome of brewers' yeast and C. fabianii in co-cultivation, the two models were combined and the same parameter settings were used. The co-cultivation model was experimentally validated for the inoculum ratios 1:10 and 1:100 brewers' yeast over C. fabianii. The use of predictive modelling supported the hypothesis that performance of brewers' yeast in co-cultivation is inhibited by oxygen depletion which is required for the biosynthesis of ergosterol. This dynamic modelling approach and the parameters involved may also be used to predict the performance of brewers' yeast in the co-cultivation with other yeast species and to give guidance to optimize the fermentation outcome.
Subject(s)
Coculture Techniques , Fermentation , Microbial Interactions , Saccharomyces cerevisiae/metabolism , Saccharomycetales/metabolism , Ergosterol/biosynthesis , Ethanol/metabolism , Oxygen/metabolismABSTRACT
BACKGROUND: Important industrial traits have been linked to plasmids in Lactococcus lactis. RESULTS: The dairy isolate L. lactis subsp. lactis biovar diacetylactis FM03P was sequenced revealing the biggest plasmidome of all completely sequenced and published L. lactis strains up till now. The 12 plasmids that were identified are: pLd1 (8277 bp), pLd2 (15,218 bp), pLd3 (4242 bp), pLd4 (12,005 bp), pLd5 (7521 bp), pLd6 (3363 bp), pLd7 (30,274 bp), pLd8 (47,015 bp), pLd9 (15,313 bp), pLd10 (39,563 bp), pLd11 (9833 bp) and pLd12 (3321 bp). Structural analysis of the repB promoters and the RepB proteins showed that eleven of the plasmids replicate via the theta-type mechanism, while only plasmid pLd3 replicates via a rolling-circle replication mechanism. Plasmids pLd2, pLd7 and pLd10 contain a highly similar operon involved in mobilisation of the plasmids. Examination of the twelve plasmids of L. lactis FM03P showed that 10 of the plasmids carry putative genes known to be important for growth and survival in the dairy environment. These genes encode technological functions such as lactose utilisation (lacR-lacABCDFEGX), citrate uptake (citQRP), peptide degradation (pepO and pepE) and oligopeptide uptake (oppDFBCA), uptake of magnesium and manganese (2 mntH, corA), exopolysaccharides production (eps operon), bacteriophage resistance (1 hsdM, 1 hsdR and 7 different hsdS genes of a type I restriction-modification system, an operon of three genes encoding a putative type II restriction-modification system and an abortive infection gene) and stress resistance (2 uspA, cspC and cadCA). Acquisition of these plasmids most likely facilitated the adaptation of the recipient strain to the dairy environment. Some plasmids were already lost during a single propagation step signifying their instability in the absence of a selective pressure. CONCLUSIONS: Lactococcus lactis FM03P carries 12 plasmids important for its adaptation to the dairy environment. Some of the plasmids were easily lost demonstrating that propagation outside the dairy environment should be minimised when studying dairy isolates of L. lactis.
Subject(s)
Dairy Products/microbiology , Dairying/methods , Genome, Bacterial , Genomic Instability , Lactococcus lactis/genetics , Plasmids/genetics , DNA Replication/genetics , DNA, Bacterial/genetics , Drug Resistance, Microbial/genetics , Interspersed Repetitive Sequences/genetics , Lactococcus lactis/growth & development , Plasmids/physiologyABSTRACT
Lactic acid bacteria can carry multiple plasmids affecting their performance in dairy fermentations. The expression of plasmid-borne genes and the activity of the corresponding proteins are severely affected by changes in the numbers of plasmid copies. We studied the impact of growth rate on the dynamics of plasmid copy numbers at high growth rates in chemostat cultures and down to near-zero growth rates in retentostat cultures. Five plasmids of the dairy strain Lactococcus lactis FM03-V1 were selected, and these varied in size (3 to 39 kb), in replication mechanism (theta or rolling circle), and in putative (dairy-associated) functions. The copy numbers ranged from 1.5 to 40.5, and the copy number of theta-type replicating plasmids was negatively correlated to the plasmid size. Despite the extremely wide range of growth rates (0.0003 h-1 to 0.6 h-1), the copy numbers of the five plasmids were stable and only slightly increased at near-zero growth rates, showing that the plasmid replication rate was strictly controlled. One low-copy-number plasmid, carrying a large exopolysaccharide gene cluster, was segregationally unstable during retentostat cultivations, reflected in a complete loss of the plasmid in one of the retentostat cultures. The copy number of the five plasmids was also hardly affected by varying the pH value, nutrient limitation, or the presence of citrate (maximum 2.2-fold), signifying the stability in copy number of the plasmids.IMPORTANCELactococcus lactis is extensively used in starter cultures for dairy fermentations. Important traits for the growth and survival of L. lactis in dairy fermentations are encoded by genes located on plasmids, such as genes involved in lactose and citrate metabolism, protein degradation, oligopeptide uptake, and bacteriophage resistance. Because the number of plasmid copies could affect the expression of plasmid-borne genes, it is important to know the factors that influence the plasmid copy numbers. We monitored the plasmid copy numbers of L. lactis at near-zero growth rates, characteristic for cheese ripening. Moreover, we analyzed the effects of pH, nutrient limitation, and the presence of citrate. This showed that the plasmid copy numbers were stable, giving insight into plasmid copy number dynamics in dairy fermentations.
Subject(s)
Cheese/microbiology , DNA Copy Number Variations , Fermentation , Lactococcus lactis/growth & development , Lactococcus lactis/genetics , Plasmids/genetics , Citric Acid/metabolism , DNA Replication , Dairying , Hydrogen-Ion Concentration , Multigene Family , Nutrients/metabolismABSTRACT
BACKGROUND: In complex microbial ecosystems such as the marine environment, the gastrointestinal tract, but also in mixed culture fermentations, bacteriophages are frequently found to be a part of the microbial community. Moreover, prophages or prophage-like elements are frequently identified in sequenced bacterial genomes. The mixed undefined starter cultures represent an ecosystem which is shaped by long term evolution under relatively defined environmental conditions and provides an interesting model to study co-evolution of phages and their hosts as well as the impact of diversity on microbial community stability. RESULTS: In the present study we investigated the presence, identity and behaviour of prophages in lactococci being part of a complex cheese starter culture. Genome analysis of representative strains of the 7 genetic lineages of Lactococcus lactis constituting the culture indicated the presence of prophages in all strains. Exposure of potential lysogens to mitomycin C confirmed the release of ~ 1010·ml- 1 phage particles from all tested strains. Furthermore, phages were also released in substantial amounts due to spontaneous induction: more than 108·ml- 1 phage particles were present in cultures under non-inducing conditions. This observation suggests continuous release of phage particles by the lactococci. The released bacteriophages exhibited an unusual morphology. For most strains tested, tailless icosahedral phage heads were found. The competitive advantage of lysogens compared to their cured derivatives and their high abundance in the culture suggests that the released tailless bacteriophages play an important role in the ecosystem. CONCLUSIONS: The results of this study indicate that chromosomal genetic elements are active participants in the stable complex microbial community of the starter culture. We show that prophages are abundant in such a community, are produced continuously in large amounts and, despite the huge metabolic burden imposed on the cells by phage particle production, provide a selective advantage to the host.
Subject(s)
Bacteriophages/physiology , Cheese/microbiology , Lactococcus lactis/virology , Prophages/physiology , Bacteriophages/genetics , Biological Evolution , Fermentation , Genome, Bacterial , Host-Pathogen Interactions , Lactococcus lactis/genetics , Lactococcus lactis/metabolism , Lysogeny , Prophages/genetics , Virus ActivationABSTRACT
BACKGROUND: Cheese ripening is a complex, time consuming and expensive process, which involves the generation of precursors from carbohydrates, proteins and fats and their subsequent conversion into a wide range of compounds responsible for the flavour and texture of the cheese. This study aims to investigate production of cheese aroma compounds outside the cheese matrix that could be applied for instance as food supplements in dairy or non-dairy products. RESULTS: In this study, aroma formation by a dairy Lactococcus lactis was analysed as a function of the growth medium [milk, hydrolysed micellar casein isolate (MCI) and chemically defined medium (CDM)] and the cultivation conditions (batch culture, retentostat culture and a milli-cheese model system). In the retentostat cultures, the nutrient supply was severely restricted resulting in low growth rates (~ 0.001 h-1), thereby mimicking cheese ripening conditions in which nutrients are scarce and bacteria hardly grow. In total 82 volatile organic compounds were produced by the bacteria. Despite the use of a chemically defined medium, retentostat cultures had the biggest qualitative overlap in aroma production with the milli-cheese model system (36 out of 54 compounds). In the retentostat cultures, 52 known cheese compounds were produced and several important cheese aroma compounds and/or compounds with a buttery or cheese-like aroma increased in retentostat cultures compared to batch cultures and milli-cheeses, such as esters, methyl ketones, diketones and unsaturated ketones. In cultures on CDM and MCI, free fatty acids and their corresponding degradation products were underrepresented compared to what was found in the milli-cheeses. Addition of a mixture of free fatty acids to CDM and MCI could help to enhance flavour formation in these media, thereby even better resembling flavour formation in cheese. CONCLUSIONS: This study demonstrates that retentostat cultivation is the preferred method to produce cheese flavours outside the cheese matrix by mimicking the slow growth of bacteria during cheese ripening.
Subject(s)
Cheese/microbiology , Culture Media/chemistry , Fermentation , Food Microbiology , Lactococcus lactis/metabolism , Odorants/analysis , Animals , Bacteriological Techniques , Caseins/chemistry , Lactococcus lactis/growth & development , Milk/chemistry , Taste , Volatile Organic Compounds/analysisABSTRACT
During food fermentation processes like cheese ripening, lactic acid bacteria (LAB) encounter long periods of nutrient limitation leading to slow growth. Particular LAB survive these periods while still contributing to flavour formation in the fermented product. In this study the dairy Lactococcus lactis biovar diacetylactis FM03-V1 is grown in retentostat cultures to study its physiology and aroma formation capacity at near-zero growth rates. During the cultivations, the growth rate decreased from 0.025 h-1 to less than 0.001 h-1 in 37 days, while the viability remained above 80%. The maintenance coefficient of this dairy strain decreased by a factor 7â¯at near-zero growth rates compared to high growth rates (from 2.43⯱â¯0.35 to 0.36⯱â¯0.03â¯mmol ATP.gDW-1.h-1). In the retentostat cultures, 62 different volatile organic compounds were identified by HS SPME GC-MS. Changes in aroma profile resembled some of the biochemical changes occurring during cheese ripening and reflected amino acid catabolism, metabolism of fatty acids and conversion of acetoin into 2-butanone. Analysis of complete and cell-free samples of the retentostat cultures showed that particular lipophilic compounds, mainly long-chain alcohols, aldehydes and esters, accumulated in the cells, most likely in the cell membranes. In conclusion, retentostat cultivation offers a unique tool to study aroma formation by lactic acid bacteria under industrially relevant growth conditions.
Subject(s)
Cheese/microbiology , Lactococcus lactis/metabolism , Volatile Organic Compounds/metabolism , Cheese/analysis , Fermentation , Flavoring Agents/chemistry , Flavoring Agents/metabolism , Gas Chromatography-Mass Spectrometry , Humans , Lactococcus lactis/growth & development , Odorants/analysis , Taste , Volatile Organic Compounds/chemistryABSTRACT
The objectives of this study were to evaluate the growth and survival of the model probiotic strain Lactobacillus plantarum WCFS1 in co-culture with traditional yoghurt starters and to investigate the impact of preculturing on their survival and metabolite formation in set-yoghurt. L. plantarum WCFS1 was precultured under sublethal stress conditions (combinations of elevated NaCl and low pH) in a batch fermentor before inoculation in milk. Adaptive responses of L. plantarum WCFS1 were evaluated by monitoring bacterial population dynamics, milk acidification and changes in volatile and non-volatile metabolite profiles of set-yoghurt. The results demonstrated that sublethal preculturing did not significantly affect survival of L. plantarum WCFS1. On the other hand, incorporation of sublethally precultured L. plantarum WCFS1 significantly impaired the survival of Lactobacillus delbrueckii subsp. bulgaricus which consequently reduced the post-acidification of yoghurt during refrigerated storage. A complementary metabolomics approach using headspace SPME-GC/MS and (1)H NMR combined with multivariate statistical analysis revealed substantial impact of sublethally precultured L. plantarum WCFS1 on the metabolite profiles of set-yoghurt. This study provides insight in the technological implications of non-dairy model probiotic strain L. plantarum WCFS1, such as its good stability in fermented milk and the inhibitory effect on post-acidification.
Subject(s)
Food Microbiology , Lactobacillus plantarum/growth & development , Lactobacillus plantarum/metabolism , Stress, Physiological , Yogurt/microbiology , Fermentation , Hydrogen-Ion Concentration , Lactobacillus delbrueckii/metabolism , Lactobacillus plantarum/drug effects , Metabolomics , Probiotics , Sodium Chloride/pharmacology , Yogurt/analysisABSTRACT
Among fermentative yeast species, Saccharomyces cerevisiae is most frequently used as a model organism, although other yeast species may have special features that make them interesting candidates to apply in food-fermentation processes. In this study, we used three yeast species isolated from fermented masau (Ziziphus mauritiana) fruit, S. cerevisiae 131, Pichia fabianii 65 and Pichia kudriavzevii 129, and determined the impact of nitrogen and/or glucose limitation on surface growth mode and the production of volatile organic compounds (VOCs). All three species displayed significant changes in growth mode in all nutrient-limited conditions, signified by the formation of metafilaments or pseudohyphae. The timing of the transition was found to be species-specific. Transition in growth mode is suggested to be linked to the production of certain fusel alcohols, such as phenylethyl alcohol, which serve as quorum-sensing molecules. Interestingly, we did not observe concomitant increased production of phenylethyl alcohol and filamentous growth. Notably, a broader range of esters was found only for the Pichia spp. grown on nitrogen-limited agar for 21 days compared to nutrient-rich agar, and when grown on glucose- and glucose- plus nitrogen-limited agar. Our data suggest that for the Pichia spp., the formation of esters may play an important role in the switch in growth mode upon nitrogen limitation. Further biological or ecological implications of ester formation are discussed.
Subject(s)
Culture Media/metabolism , Pichia/metabolism , Saccharomyces cerevisiae/metabolism , Culture Media/analysis , Esters/analysis , Esters/metabolism , Fermentation , Glucose/analysis , Glucose/metabolism , Hyphae/growth & development , Hyphae/metabolism , Nitrogen/analysis , Nitrogen/metabolism , Pichia/growth & development , Saccharomyces cerevisiae/growth & developmentABSTRACT
This paper describes the molecular and metabolic adaptations of Lactococcus lactis during the transition from a growing to a near-zero growth state by using carbon-limited retentostat cultivation. Transcriptomic analyses revealed that metabolic patterns shifted between lactic- and mixed-acid fermentations during retentostat cultivation, which appeared to be controlled at the level of transcription of the corresponding pyruvate dissipation-encoding genes. During retentostat cultivation, cells continued to consume several amino acids but also produced specific amino acids, which may derive from the conversion of glycolytic intermediates. We identify a novel motif containing CTGTCAG in the upstream regions of several genes related to amino acid conversion, which we propose to be the target site for CodY in L. lactis KF147. Finally, under extremely low carbon availability, carbon catabolite repression was progressively relieved and alternative catabolic functions were found to be highly expressed, which was confirmed by enhanced initial acidification rates on various sugars in cells obtained from near-zero-growth cultures. The present integrated transcriptome and metabolite (amino acids and previously reported fermentation end products) study provides molecular understanding of the adaptation of L. lactis to conditions supporting low growth rates and expands our earlier analysis of the quantitative physiology of this bacterium at near-zero growth rates toward gene regulation patterns involved in zero-growth adaptation.
Subject(s)
Adaptation, Physiological , Gene Expression Regulation, Bacterial , Lactococcus lactis/growth & development , Lactococcus lactis/genetics , Carbon/metabolism , Gene Expression Profiling , Molecular Sequence Data , Sequence Analysis, DNAABSTRACT
This paper describes the transcriptional adaptations of nongrowing, retentostat cultures of Lactococcus lactis to starvation. Near-zero-growth cultures (µ = 0.0001 h(-1)) obtained by extended retentostat cultivation were exposed to starvation by termination of the medium supply for 24 h, followed by a recovery period of another 24 h by reinitiating the medium supply to the retentostat culture. During starvation, the viability of the culture was largely retained, and the expression of genes involved in transcription and translational machineries, cell division, and cell membrane energy metabolism was strongly repressed. Expression of these genes was largely recovered following the reinitiation of the medium supply. Starvation triggered the elevated expression of genes associated with synthesis of branched-chain amino acids, histidine, purine, and riboflavin. The expression of these biosynthesis genes was found to remain at an elevated level after reinitiation of the medium supply. In addition, starvation induced the complete gene set predicted to be involved in natural competence in L. lactis KF147, and the elevated expression of these genes was sustained during the subsequent recovery period, but our attempts to experimentally demonstrate natural transformation in these cells failed. Mining the starvation response gene set identified a conserved cis-acting element that resembles the lactococcal CodY motif in the upstream regions of genes associated with transcription and translational machineries, purine biosynthesis, and natural transformation in L. lactis, suggesting a role for CodY in the observed transcriptome adaptations to starvation in nongrowing cells.