Discrimination of stereoisomers by one-dimensional 13 C NMR: All 16 stereoisomers of 4-hydroxy-α-tocopherol resolved.

All 16 resolved! A vitamin E-derived compound containing four chiral centers is the first example where all stereoisomers, that is, eight diastereomeric pairs of enantiomers, could be discriminated in a single NMR run. Measurement at 176 MHz in the presence of Pirkle's alcohol as a chiral solvating agent is a relatively robust, simple, easy-to-set-up, and fast method.

Detection of 4a,5-dihydropravastatin as Impurity in the Cholesterol Lowering Drug Pravastatin.

Dihydro analogues are known byproducts of the fermentative production of statins and cannot be detected with existing pharmacopoeia analysis methods. We detected dihydropravastatin in most commercial formulations of pravastatin with LC-MS, in some cases in levels requiring identification. In fermentation broth samples of the single step production of pravastatin, we detected and identified for the first time 4a,5-dihydropravastatin, and confirmed that after several recrystallization steps this impurity can be fully removed from the pravastatin powder.

Microextraction of Reseda luteola-Dyed Wool and Qualitative Analysis of Its Flavones by UHPLC-UV, NMR and MS.

Detailed knowledge on natural dyes is important for agronomy and quality control as well as the fastness, stability, and analysis of dyed textiles. Weld (Reseda luteola L.), which is a source of flavone-based yellow dye, is the focus of this study. One aim was to reduce the required amount of dyed textile to ≤50 µg for a successful chromatographic analysis. The second aim was to unambiguously confirm the identity of all weld flavones. By carrying out the extraction of 50 µg dyed wool with 25 µL of solvent and analysis by reversed-phase UHPLC at 345 nm, reproducible chromatographic fingerprints could be obtained with good signal to noise ratios. Ten baseline separated peaks with relative areas ≥1% were separated in 6 min. Through repeated polyamide column chromatography and prepHPLC, the compounds corresponding with the fingerprint peaks were purified from dried weld. Each was unequivocally identified, including the position and configuration of attached sugars, by means of 1D and 2D NMR and high-resolution MS. Apigenin-4'-O-glucoside and luteolin-4'-O-glucoside were additionally identified as two trace flavones co-eluting with other flavone glucosides, the former for the first time in weld. The microextraction might be extended to other used dye plants, thus reducing the required amount of precious historical textiles.

Pathway for the Biosynthesis of the Pigment Chrysogine by Penicillium chrysogenum.

Chrysogine is a yellow pigment produced by Penicillium chrysogenum and other filamentous fungi. Although the pigment was first isolated in 1973, its biosynthetic pathway has so far not been resolved. Here, we show that deletion of the highly expressed nonribosomal peptide synthetase (NRPS) gene Pc21g12630 (chyA) resulted in a decrease in the production of chrysogine and 13 related compounds in the culture broth of P. chrysogenum Each of the genes of the chyA-containing gene cluster was individually deleted, and corresponding mutants were examined by metabolic profiling in order to elucidate their function. The data suggest that the NRPS ChyA mediates the condensation of anthranilic acid and alanine into the intermediate 2-(2-aminopropanamido)benzoic acid, which was verified by feeding experiments of a ΔchyA strain with the chemically synthesized product. The remainder of the pathway is highly branched, yielding at least 13 chrysogine-related compounds.IMPORTANCEPenicillium chrysogenum is used in industry for the production of ß-lactams, but also produces several other secondary metabolites. The yellow pigment chrysogine is one of the most abundant metabolites in the culture broth, next to ß-lactams. Here, we have characterized the biosynthetic gene cluster involved in chrysogine production and elucidated a complex and highly branched biosynthetic pathway, assigning each of the chrysogine cluster genes to biosynthetic steps and metabolic intermediates. The work further unlocks the metabolic potential of filamentous fungi and the complexity of secondary metabolite pathways.

One-Dimensional 13C NMR Is a Simple and Highly Quantitative Method for Enantiodiscrimination.

The discrimination of enantiomers of mandelonitrile by means of 1D 13C NMR and with the aid of the chiral solvating agent (S)-(+)-1-(9-anthryl)-2,2,2-trifluoroethanol (TFAE) is presented. ¹H NMR fails for this specific compound because proton signals either overlap with the signals of the chiral solvating agent or do not show separation between the (S)-enantiomer and the (R)-enantiomer. The 13C NMR method is validated by preparing artificial mixtures of the (R)-enantiomer and the racemate, and it is shown that with only 4 mg of mandelonitrile a detection limit of the minor enantiomer of 0.5% is obtained, corresponding to an enantiomeric excess value of 99%. Furthermore, the method shows high linearity, and has a small relative standard deviation of only 0.3% for the minor enantiomer when the relative abundance of this enantiomer is 20%. Therefore, the 13C NMR method is highly suitable for quantitative enantiodiscrimination. It is discussed that 13C NMR is preferred over ¹H NMR in many situations, not only in molecules with more than one chiral center, resulting in complex mixtures of many stereoisomers, but also in the case of molecules with overlapping multiplets in the ¹H NMR spectrum, and in the case of molecules with many quaternary carbon atoms, and therefore less abundant protons.

Identification of a Polyketide Synthase Involved in Sorbicillin Biosynthesis by Penicillium chrysogenum.

UNLABELLED: Secondary metabolism in Penicillium chrysogenum was intensively subjected to classical strain improvement (CSI), the resulting industrial strains producing high levels of ß-lactams. During this process, the production of yellow pigments, including sorbicillinoids, was eliminated as part of a strategy to enable the rapid purification of ß-lactams. Here we report the identification of the polyketide synthase (PKS) gene essential for sorbicillinoid biosynthesis in P. chrysogenum We demonstrate that the production of polyketide precursors like sorbicillinol and dihydrosorbicillinol as well as their derivatives bisorbicillinoids requires the function of a highly reducing PKS encoded by the gene Pc21g05080 (pks13). This gene belongs to the cluster that was mutated and transcriptionally silenced during the strain improvement program. Using an improved ß-lactam-producing strain, repair of the mutation in pks13 led to the restoration of sorbicillinoid production. This now enables genetic studies on the mechanism of sorbicillinoid biosynthesis in P. chrysogenum and opens new perspectives for pathway engineering. IMPORTANCE: Sorbicillinoids are secondary metabolites with antiviral, anti-inflammatory, and antimicrobial activities produced by filamentous fungi. This study identified the gene cluster responsible for sorbicillinoid formation in Penicillium chrysogenum, which now allows engineering of this diverse group of compounds.

Genomic mutational analysis of the impact of the classical strain improvement program on ß-lactam producing Penicillium chrysogenum.

BACKGROUND: Penicillium chrysogenum is a filamentous fungus that is employed as an industrial producer of ß-lactams. The high ß-lactam titers of current strains is the result of a classical strain improvement program (CSI) starting with a wild-type like strain more than six decades ago. This involved extensive mutagenesis and strain selection for improved ß-lactam titers and growth characteristics. However, the impact of the CSI on the secondary metabolism in general remains unknown. RESULTS: To examine the impact of CSI on secondary metabolism, a comparative genomic analysis of ß-lactam producing strains was carried out by genome sequencing of three P. chrysogenum strains that are part of a lineage of the CSI, i.e., strains NRRL1951, Wisconsin 54-1255, DS17690, and the derived penicillin biosynthesis cluster free strain DS68530. CSI has resulted in a wide spread of mutations, that statistically did not result in an over- or underrepresentation of specific gene classes. However, in this set of mutations, 8 out of 31 secondary metabolite genes (20 polyketide synthases and 11 non-ribosomal peptide synthetases) were targeted with a corresponding and progressive loss in the production of a range of secondary metabolites unrelated to ß-lactam production. Additionally, key Velvet complex proteins (LeaA and VelA) involved in global regulation of secondary metabolism have been repeatedly targeted for mutagenesis during CSI. Using comparative metabolic profiling, the polyketide synthetase gene cluster was identified that is responsible for sorbicillinoid biosynthesis, a group of yellow-colored metabolites that are abundantly produced by early production strains of P. chrysogenum. CONCLUSIONS: The classical industrial strain improvement of P. chrysogenum has had a broad mutagenic impact on metabolism and has resulted in silencing of specific secondary metabolite genes with the concomitant diversion of metabolism towards the production of ß-lactams.

A Simple ¹³C NMR Method for the Discrimination of Complex Mixtures of Stereoisomers: All Eight Stereoisomers of α-Tocopherol Resolved.

A simple one-dimensional (13)C NMR method is presented to discriminate between stereoisomers of organic compounds with more than one chiral center. By means of this method it is possible to discriminate between all eight stereoisomers of α-tocopherol. To achieve this the chiral solvating agent (S)-(+)-1-(9-anthryl)-2,2,2-trifluoroethanol and the compound of interest were dissolved in high concentrations in chloroform-d, and the nuclear magnetic resonance (NMR) spectrum was recorded at a low temperature. The individual stereoisomers of α-tocopherol were assigned by spikes of the reference compounds. The method was also applied to six other representative examples.

Novel key metabolites reveal further branching of the roquefortine/meleagrin biosynthetic pathway.

Metabolic profiling and structural elucidation of novel secondary metabolites obtained from derived deletion strains of the filamentous fungus Penicillium chrysogenum were used to reassign various previously ascribed synthetase genes of the roquefortine/meleagrin pathway to their corresponding products. Next to the structural characterization of roquefortine F and neoxaline, which are for the first time reported for P. chrysogenum, we identified the novel metabolite roquefortine L, including its degradation products, harboring remarkable chemical structures. Their biosynthesis is discussed, questioning the exclusive role of glandicoline A as key intermediate in the pathway. The results reveal that further enzymes of this pathway are rather unspecific and catalyze more than one reaction, leading to excessive branching in the pathway with meleagrin and neoxaline as end products of two branches.

Mechanism and regulation of sorbicillin biosynthesis by Penicillium chrysogenum.

Penicillium chrysogenum is a filamentous fungus that is used to produce ß-lactams at an industrial scale. At an early stage of classical strain improvement, the ability to produce the yellow-coloured sorbicillinoids was lost through mutation. Sorbicillinoids are highly bioactive of great pharmaceutical interest. By repair of a critical mutation in one of the two polyketide synthases in an industrial P. chrysogenum strain, sorbicillinoid production was restored at high levels. Using this strain, the sorbicillin biosynthesis pathway was elucidated through gene deletion, overexpression and metabolite profiling. The polyketide synthase enzymes SorA and SorB are required to generate the key intermediates sorbicillin and dihydrosorbicillin, which are subsequently converted to (dihydro)sorbillinol by the FAD-dependent monooxygenase SorC and into the final product oxosorbicillinol by the oxidoreductase SorD. Deletion of either of the two pks genes not only impacted the overall production but also strongly reduce the expression of the pathway genes. Expression is regulated through the interplay of two transcriptional regulators: SorR1 and SorR2. SorR1 acts as a transcriptional activator, while SorR2 controls the expression of sorR1. Furthermore, the sorbicillinoid pathway is regulated through a novel autoinduction mechanism where sorbicillinoids activate transcription.

Prevention of Tartrate Crystallization in Wine by Hydrocolloids: The Mechanism Studied by Dynamic Light Scattering.

Young wines are supersaturated in potassium bitartrate, which induces rather uncontrolled crystallization processes. Delayed crystallization may occur even after bottling of the young wines, which is undesirable because it gives rise to a visual defect in the wine. Colloids such as mannoproteins, metatartaric acid, and carboxymethylcellulose are available on the market and may be added to delay crystallization. It has been a matter of debate whether such hydrocolloids prevent nucleation, growth of crystals, or both. It was the objective of this investigation to study the crystallization event by a new approach using dynamic light scattering and to clarify the mode of action of these hydrocolloids. To achieve this, model solutions and standardized wines were enriched with potassium bitartrate (KHT) to trigger crystallization. In this way, it was possible to distinguish between the influence of the hydrocolloids on nucleation and on crystal growth. It was found that the hydrocolloids do not prevent KHT nucleation. Instead, these compounds delay or even arrest the outgrowth of the crystals to a macroscopic, visual size.

A non-canonical NRPS is involved in the synthesis of fungisporin and related hydrophobic cyclic tetrapeptides in Penicillium chrysogenum.

The filamentous fungus Penicillium chrysogenum harbors an astonishing variety of nonribosomal peptide synthetase genes, which encode proteins known to produce complex bioactive metabolites from simple building blocks. Here we report a novel non-canonical tetra-modular nonribosomal peptide synthetase (NRPS) with microheterogenicity of all involved adenylation domains towards their respective substrates. By deleting the putative gene in combination with comparative metabolite profiling various unique cyclic and derived linear tetrapeptides were identified which were associated with this NRPS, including fungisporin. In combination with substrate predictions for each module, we propose a mechanism for a 'trans-acting' adenylation domain.

A robust and universal NMR method for the compositional analysis of polysaccharides.

A method is presented for the detailed and accurate quantitative determination of the monomeric composition of polysaccharides. The method is a modification of the well-known Saeman hydrolysis in combination with 600 MHz (1)H NMR quantification. Experimental conditions for this two-step hydrolysis have been optimized for cellulose and hemicelluloses, and the method has been applied to several other polysaccharides as well. It is shown that even very resistant polysaccharides are hydrolyzed completely, while at the same time degradation of monosaccharides is kept at a minimum. The degradation of monosacharides is corrected for by subjecting a standard mixture represented in the polymer to the same conditions. This correction results in a very accurate and reproducible method with relative deviations down to 1%. It is shown that the duration of hydrolysis and the concentration of sulfuric acid in the second hydrolysis step are the most important factors to determine the reliability of the results.

A branched biosynthetic pathway is involved in production of roquefortine and related compounds in Penicillium chrysogenum.

Profiling and structural elucidation of secondary metabolites produced by the filamentous fungus Penicillium chrysogenum and derived deletion strains were used to identify the various metabolites and enzymatic steps belonging to the roquefortine/meleagrin pathway. Major abundant metabolites of this pathway were identified as histidyltryptophanyldiketopiperazine (HTD), dehydrohistidyltryptophanyldi-ketopiperazine (DHTD), roquefortine D, roquefortine C, glandicoline A, glandicoline B and meleagrin. Specific genes could be assigned to each enzymatic reaction step. The nonribosomal peptide synthetase RoqA accepts L-histidine and L-tryptophan as substrates leading to the production of the diketopiperazine HTD. DHTD, previously suggested to be a degradation product of roquefortine C, was found to be derived from HTD involving the cytochrome P450 oxidoreductase RoqR. The dimethylallyltryptophan synthetase RoqD prenylates both HTD and DHTD yielding directly the products roquefortine D and roquefortine C without the synthesis of a previously suggested intermediate and the involvement of RoqM. This leads to a branch in the otherwise linear pathway. Roquefortine C is subsequently converted into glandicoline B with glandicoline A as intermediates, involving two monooxygenases (RoqM and RoqO) which were mixed up in an earlier attempt to elucidate the biosynthetic pathway. Eventually, meleagrin is produced from glandicoline B involving a methyltransferase (RoqN). It is concluded that roquefortine C and meleagrin are derived from a branched biosynthetic pathway.