Effect of PLGA raw materials on in vitro and in vivo performance of drug-loaded microspheres.

Poly(lactide-co-glycolide) and poly(lactic-co-glycolic acids) (PLGAs) play a critical role in the development of commercial long-acting injectable microsphere formulations. However, very little information is available describing the impact of PLGA manufacturer and monomer distribution along the polymer chain (e.g., glycolic blockiness (Rc) and average lactic block length (LL)) on the degradation and release behavior of PLGA drug carriers in vitro and in vivo. Here, we compared the in vitro and in vivo performance of (a) four leuprolide-loaded microsphere formulations prepared from similar low-molecular-weight acid-capped PLGAs (10-14 kD, i.e., Expansorb® DLG 75-2A, Purasorb® PDLG 7502A, Resomer® RG 752H and Wako® 7515) and (b) two triamcinolone acetonide-loaded (Tr-A) microsphere formulations from similar medium-molecular-weight ester-capped PLGAs (i.e., Expansorb® DLG 75-4E and Resomer® RG 753S). Lupron Depot® and Zilretta® were used as reference commercial products. The six 75/25 PLGAs displayed block lengths that were either above or below values expected from a random copolymer. Drug release and polymer degradation were monitored simultaneously in vitro and in vivo using a cage implant system. The four leuprolide-loaded formulations showed similar release and degradation patterns with some notable differences between each other. Microspheres from the Expansorb® polymer displayed lower LL and higher Rc relative to the other 3 PLGA 75/25 microspheres, and likewise exhibited distinct peptide release and degradation behavior compared to the other 3 formulations. For each formulation, leuprolide release was erosion-controlled up to about 30% release after the initial burst followed by a faster than erosion release phase. In vitro release was similar as that in vivo over the first phase but notably different from the latter release phase, particularly for the most blocky Expansorb® formulation. The Purasorb® and Wako® formulations displayed highly similar performance in release, degradation, and erosion analysis. By contrast, the two ester-capped Expansorb® DLG 75-4E and Resomer® RG 753S used to prepare Tr-A microspheres shared essentially identical LL and higher Rc and behaved similarly although the Expansorb® degraded and released the steroid faster in vivo, suggestive of other factors responsible (e.g., residual monomer). The in vivo release performance for both drugs from the six microsphere formulations was similar to that of the commercial reference products. In summary, this work details information on comparing the similarities and differences in in vitro and in vivo performance of drug-loaded microspheres as a function of manufacturing and microstructural variables of different types of PLGA raw materials utilized and could, therefore, be meaningful in guiding the source control during development and manufacturing of PLGA microsphere-based drug products. Future work will expand the analysis to include a broader range of LL and higher Rc, and add additional important formulation metrics (e.g., thermal analysis, and residual monomer, moisture, and organic solvent levels).

Calcified Sclero-Choroidal Choristomas in Mosaic RASopathies: A Description of a New Imaging Sign.

PURPOSE: To evaluate the imaging and clinical features of unusual calcified lesions seen in the fundus of patients with mosaic RASopathy. DESIGN: Single-center retrospective observational study. SUBJECTS: Ten eyes with calcified fundus lesions in 7 patients with mosaic RASopathy. METHODS: The lesions were evaluated with fundus photography, oral fundus fluorescein angiography, B-scan ultrasonography, magnetic resonance imaging (MRI), and computed tomography (CT) scan where available. MAIN OUTCOME MEASURES: The imaging characteristics of calcified fundus lesions were assessed. RESULTS: We found 7 patients with mosaic RASopathies, 5 men and 2 women (3 with linear sebaceous nevus syndrome, 3 with oculoectodermal syndrome, and 1 with encephalocraniocutaneous lipomatosis) with molecular confirmation in 5 cases, all 5 having KRAS-pathogenic variants. Calcified fundus lesions were identified in 10 eyes (bilateral in 3 patients), appearing as slightly elevated, creamy-yellow lesions around or adjacent to the optic nerve, extending supero-nasally; all but 2 of these lesions involved both the choroid and sclera, with 2 of them only involving the sclera at the time of examination. One case developed a choroidal neovascular membrane necessitating intravitreal bevacizumab injections. All 7 patients had B-scan ultrasonography, and the lesion appeared as a hyperechogenic area with an acoustic shadow posteriorly despite reduced gain. Five patients had MRI, and where fundus lesions were present, there was a focal defect in the sclero-choroidal layer. Four patients had a CT scan, and all 4 showed calcifications affecting both the posteromedial sclero-choroid and adjacent medial rectus muscle. Two of these patients had normal eye movements, 1 had a unilateral fixed adducted eye and a vestigial fibrous medial rectus muscle seen in imaging and intraoperatively, and the fourth had marked exotropia with a right gaze deficit affecting both eyes. CONCLUSIONS: We propose that the lesions seen in this cohort are calcified sclero-choroidal choristomas and should be suspected in mosaic RASopathies when creamy-yellow lesions are seen in the fundus. If identified, the possibility of choroidal neovascularization should be considered during follow-up. In all cases where a CT scan was performed, a novel sign of sclero-muscular calcification involving the medial rectus muscle was seen. FINANCIAL DISCLOSURE(S): The author(s) have no proprietary or commercial interest in any materials discussed in this article.

Phospholipids impact the protective effects of HDL-mimetic nanodiscs against lipopolysaccharide-induced inflammation.

Aim: The impacts of synthetic high-density lipoprotein (sHDL) phospholipid components on anti-sepsis effects were investigated. Methods: sHDL composed with ApoA-I mimetic peptide (22A) and different phosphatidylcholines were prepared and characterized. Anti-inflammatory effects were investigated in vitro and in vivo on lipopolysaccharide (LPS)-induced inflammation models. Results: sHDLs composed with 1,2-dimyristoyl-sn-glycero-3-phosphocholine (22A-DMPC) most effectively neutralizes LPS, inhibits toll-like receptor 4 recruitment into lipid rafts, suppresses nuclear factor κB signaling and promotes activating transcription factor 3 activating. The lethal endotoxemia animal model showed the protective effects of 22A-DMPC. Conclusion: Phospholipid components affect the stability and fluidity of nanodiscs, impacting the anti-septic efficacy of sHDLs. 22A-DMPC presents the strongest LPS binding and anti-inflammatory effects in vitro and in vivo, suggesting a potential sepsis treatment.

Sepsis is triggered by endotoxins released by bacteria. These endotoxins trigger an exaggerated inflammatory response, leading to widespread inflammation and organ damage. Synthetic high-density lipoprotein (sHDL) is a potential treatment of sepsis by neutralizing endotoxins and regulating inflammatory responses. The phospholipid components of sHDL may affect the effectiveness of sHDL against sepsis. In this study, we prepared sHDLs with different phospholipids and compared their anti-septic effects on cells and in animal models. We found that sHDL made from DMPC presented the best anti-septic effects, possibly because DMPC-sHDL had the best fluidity at body temperature.