RESUMO
Essential nutrient concentrations in crops can affect human health. While biochar has the potential as a soil amendment to improve crop yields, it may also affect the concentrations of nutrients such as Ca, Fe, K, Mg, Mn, and Zn in edible portions of crops. To better characterize effects of biochar on important human nutrients in food crops, we evaluated the effects of biochar on lettuce (Lactuca sativa L. cv. Black-Seeded Simpson) leaf and carrot [Daucus carota subsp. sativus (Hoffm.) Schübl. cv. Tendersweet] developing taproot nutrients. Plants were grown in pots in a greenhouse using sandy loam (Coxville, fine, kaolinitic, thermic Typic Paleaquults) and loamy sand (Norfolk, fine-loamy, kaolinitic, thermic Typic Kandiudults,) series soils, amended with biochar produced from four feedstocks: pine chips (PC), poultry litter (PL), swine solids (SS), and switchgrass (SG); and two blends of PC plus PL [Pc/PL, 50%/50% (55) and 80%/20% (82) by weight]. Biochar was produced at 350, 500, and 700 °C from each feedstock. Lettuce leaf and carrot taproot total nutrient concentrations were determined by inductively coupled plasma analysis. Biochar (especially at least in part manure-based, i.e., PL, SS, 55, and 82 at nearly all temperatures) primarily decreased nutrient concentrations in lettuce leaves, with Ca, Mg, and Zn affected most. Carrot taproot nutrient concentrations also deceased, but to a lesser extent. Some biochars increased leaf or taproot nutrient concentrations, especially K. This study indicated that biochar can both decrease and increase leaf and taproot nutrient concentrations important for human health. Thus, potential effects on nutrients in plants should be carefully considered when biochar is used as a soil amendment with vegetable crops.
RESUMO
The incorporation of biochar into soils has been proposed as a means to sequester carbon from the atmosphere. An added environmental benefit is that biochar has been shown to increase soil retention of agrochemicals, and recent research has indicated that biochar may be effective in increasing soil retention of bacteria. In this study we investigate the transport behavior of O157:H7, serovar Typhimurium, and carboxylated polystyrene microspheres in water-saturated column experiments for two soils (fine sand and sandy loam) amended with 2% poultry litter or pine chip biochars pyrolyzed at 350 and 700°C. Adding poultry litter biochar pyrolyzed at 350°C did not improve soil retention of either bacteria in fine sand and even facilitated their transport in sandy loam. Addition of either biochar pyrolyzed at 700°C generally improved retention of bacteria in fine sand, with the pine chip biochars being more effective in limiting their transport. Results from the column studies and auxiliary batch studies suggest that changes in cell retention after biochar amendments were likely due to changes in bacterial attachment in the column and not to physical straining or changes in survivability. We also found that changes in bacterial hydrophobicity after biochar amendments were generally correlated with changes in bacterial retention. The influence of biochar amendment in increasing retention of both bacteria was generally more pronounced in fine sand and indicates that soil texture affects the transport behavior of bacteria through biochar-amended soils.
RESUMO
Partial nitritation (PN) of swine wastewater was investigated in a sequencing batch reactor (SBR) using a high-performance nitrifying sludge. Characteristics of the wastewater used were low content of biodegradable organic matter and a high alkalinity-to-ammonium ratio. The target oxidation of ammonium nitrogen (NH-N) to nitrite nitrogen (NO-N) was 57% (1.32 g NO-N g NH-N), which corresponds with the reaction ratio of the anaerobic ammonium oxidation (anammox). This target was successfully achieved at 32°C by controlling the inflow rate and the corresponding nitrogen loading rate (NLR). An average NLR of 1.47 g NH-N L d was applied to the partial nitritation sequencing batch reactor during a period of 70 d. The nitrite production rate obtained was 0.91 g NO-N L d. No nitrate was produced. The PN effluent contained 1.38 g NO-N g NH-N, which was within 5% of the target ratio. Under steady composition of the wastewater, the pH was shown to be a good indicator of the PN process performance. Furthermore, in a second sequencing batch reactor, the anaerobic ammonium oxidation process was effectively applied to the PN effluent, attaining a nitrogen conversion rate of 0.36 g N L d (14.3 mg N g volatile suspended solids h).
Assuntos
Suínos , Eliminação de Resíduos Líquidos/métodos , Anaerobiose , Animais , Bactérias/metabolismo , Reatores Biológicos , Monitoramento Ambiental , Concentração de Íons de Hidrogênio , Nitratos , Oxirredução , Consumo de Oxigênio , Compostos de Amônio Quaternário , Fatores de Tempo , Poluentes Químicos da Água/químicaRESUMO
Although nutrient-rich manure biochars are expected to be an effective heavy metal stabilizer in agricultural and contaminated soils, systematic studies are lacking to predict the influence of manure variety and pyrolysis temperature on metal-binding potentials. In this study, biochars produced from five manure varieties (dairy, paved feedlot, swine solids, poultry litter, and turkey litter) at two pyrolytic temperatures (350 and 700°C) were examined for the stabilization of Pb, Cu, Ni, and Cd in a weathered, acidic Norfolk loamy sand (fine-loamy, kaolinitic, thermic, Typic Kandiudult). Equilibrium concentrations in the aqueous phase were determined for heavy metals (Cu, Ni, Cd, and Pb) and additional selected elements (Na, P, S, Ca, Mg, Al, and K); these were analyzed by positive matrix factorization to quantitatively determine the factors responsible for the biochar's ability to bind the selected heavy metals in soil. Concurrently with the greatest increase in pH and highest equilibrium Na, S, and K concentrations, poultry litter, turkey litter, and feedlot 700°C biochar exhibited the greatest heavy metal retention. In contrast, manure varieties containing disproportionately high (swine) and low (dairy) ash, P, and other elements were the least effective stabilizers. Regardless of the manure type, proton nuclear magnetic resonance analyses showed the removal of leachable aliphatic and nitrogen-containing heteroaromatic functional groups at the higher (700°C) pyrolysis temperature. Consistently greater Cu retention by the 700°C biochar indicated the mobilization of Cu by 350°C biochar-born dissolved organic carbon; however, the influence of other temperature-dependent biochar characteristics cannot be ruled out.
Assuntos
Carvão Vegetal/química , Esterco/análise , Metais Pesados/química , Solo/química , Animais , Bovinos , Clorofórmio/química , Espectroscopia de Ressonância Magnética , Aves Domésticas , SuínosRESUMO
Biochar has been heralded as an amendment to revitalize degraded soils, improve soil carbon sequestration, increase agronomic productivity, and enter into future carbon trading markets. However, scientific and economic technicalties may limit the ability of biochar to consistently deliver on these expectations. Past research has demonstrated that biochar is part of the black carbon continuum with variable properties due to the net result of production (e.g., feedstock and pyrolysis conditions) and postproduction factors (storage or activation). Therefore, biochar is not a single entity but rather spans a wide range of black carbon forms. Biochar is black carbon, but not all black carbon is biochar. Agronomic benefits arising from biochar additions to degraded soils have been emphasized, but negligible and negative agronomic effects have also been reported. Fifty percent of the reviewed studies reported yield increases after black carbon or biochar additions, with the remainder of the studies reporting alarming decreases to no significant differences. Hardwood biochar (black carbon) produced by traditional methods (kilns or soil pits) possessed the most consistent yield increases when added to soils. The universality of this conclusion requires further evaluation due to the highly skewed feedstock preferences within existing studies. With global population expanding while the amount of arable land remains limited, restoring soil quality to nonproductive soils could be key to meeting future global food production, food security, and energy supplies; biochar may play a role in this endeavor. Biochar economics are often marginally viable and are tightly tied to the assumed duration of agronomic benefits. Further research is needed to determine the conditions under which biochar can provide economic and agronomic benefits and to elucidate the fundamental mechanisms responsible for these benefits.
Assuntos
Agricultura/métodos , Carbono/química , Solo , Agricultura/economia , Produtos Agrícolas/crescimento & desenvolvimento , Meio Ambiente , Poluentes Ambientais/químicaRESUMO
BACKGROUND: State-of-the-art control systems that can guarantee the pyrolytic exposure temperature are needed in the production of designer biochars. These designer biochars will have tailored characteristics that can offer improvement of specific soil properties such as water-holding capacity and cation exchange capacity. RESULTS: A novel stochastic state-space temperature regulator was developed for the batch production of biochar that accurately matched the pyrolytic exposure temperature to a defined temperature input schedule. This system was evaluated by processing triplicate swine manure biochars at two temperatures, 350 and 700 °C. The results revealed a low coefficient of variation (CV) in their composition and near-similar ¹³C nuclear magnetic resonance structure as well as thermal degradation patterns. When pyrolysing at 350 °C, the stochastic state-space regulator generated a biochar with lower CV in ultimate (i.e. CHNS) compositional analysis than the original feedstock. CONCLUSION: This state-space controller had the ability to pyrolyse a feedstock and generate a consistent biochar with similar structural properties and consistent compositional characteristics.
Assuntos
Carvão Vegetal/química , Fertilizantes/análise , Esterco/análise , Criação de Animais Domésticos/economia , Animais , Carvão Vegetal/análise , Carvão Vegetal/economia , Fenômenos Químicos , Fertilizantes/economia , Calefação/instrumentação , Temperatura Alta , Resíduos Industriais/análise , Resíduos Industriais/economia , Cinética , Nitrogênio/química , Controle de Qualidade , Reprodutibilidade dos Testes , Processos Estocásticos , Sus scrofa , Estados UnidosRESUMO
BACKGROUND: The concept of a designer biochar that targets the improvement of a specific soil property imposes the need for production processes to generate biochars with both high consistency and quality. These important production parameters can be affected by variations in process temperature that must be taken into account when controlling the pyrolysis of agricultural residues such as manures and other feedstocks. RESULTS: A novel stochastic state-space temperature regulator was developed to accurately match biochar batch production to a defined temperature input schedule. This was accomplished by describing the system's state-space with five temperature variables--four directly measured and one change in temperature. Relationships were derived between the observed state and the desired, controlled state. When testing the unit at two different temperatures, the actual pyrolytic temperature was within 3 °C of the control with no overshoot. CONCLUSION: This state-space regulator simultaneously controlled the indirect heat source and sample temperature by employing difficult-to-measure variables such as temperature stability in the description of the pyrolysis system's state-space. These attributes make a state-space controller an optimum control scheme for the production of a predictable, repeatable designer biochar.
Assuntos
Carvão Vegetal/química , Fertilizantes/análise , Modelos Químicos , Algoritmos , Ração Animal/análise , Ração Animal/economia , Criação de Animais Domésticos/economia , Carvão Vegetal/análise , Carvão Vegetal/economia , Fenômenos Químicos , Simulação por Computador , Fertilizantes/economia , Calefação/instrumentação , Temperatura Alta , Resíduos Industriais/análise , Resíduos Industriais/economia , Cinética , Esterco/análise , Nitrogênio/química , Controle de Qualidade , Reprodutibilidade dos Testes , Silagem/análise , Silagem/economia , Processos Estocásticos , Estados UnidosRESUMO
The use of biological and thermochemical conversion (TCC) technologies in livestock waste-to-bioenergy treatments can provide livestock operators with multiple value-added, renewable energy products. These products can meet heating and power needs or serve as transportation fuels. The primary objective of this work is to present established and emerging energy conversion opportunities that can transform the treatment of livestock waste from a liability to a profit center. While biological production of methanol and hydrogen are in early research stages, anaerobic digestion is an established method of generating between 0.1 to 1.3m3m(-3)d(-1) of methane-rich biogas. The TCC processes of pyrolysis, direct liquefaction, and gasification can convert waste into gaseous fuels, combustible oils, and charcoal. Integration of biological and thermal-based conversion technologies in a farm-scale hybrid design by combining an algal CO2-fixation treatment requiring less than 27,000m2 of treatment area with the energy recovery component of wet gasification can drastically reduce CO2 emissions and efficiently recycle nutrients. These designs have the potential to make future large scale confined animal feeding operations sustainable and environmentally benign while generating on-farm renewable energy.
Assuntos
Animais Domésticos , Fontes de Energia Bioelétrica , Conservação de Recursos Energéticos/métodos , Animais , TemperaturaRESUMO
Biofilters, designed to facilitate the infiltration of stormwater into soil, are generally ineffective in removing bacteria from stormwater, thereby causing pollution of groundwater and receiving surface waters. The bacterial removal capacity of biofilters has been shown to be lower in the presence of natural organic matter (NOM) and during intermittent infiltration of stormwater. To improve the removal of fecal indicator bacteria (Escherichia coli) under these conditions, we amended sand with 5% (by weight) biochar, a carbonaceous geomedia produced by pyrolysis of biomass, and investigated the removal and remobilization of E. coli. Three types of biochar were used to evaluate the role of biochar properties on the removal. Compared to sand, biochar not only retained up to 3 orders of magnitude more E. coli, but also prevented their mobilization during successive intermittent flows. In the presence of NOM, the removal capacity of biochar was lower, but remained higher than sand alone. The improved retention with the biochar amendment is attributed to an increase in the attachment of E. coli at the primary minimum and to an increase in the water-holding capacity of biochar-amended sand, which renders driving forces such as moving air-water interfaces less effective in detaching bacteria from grain surfaces. Biochars with lower volatile matter and polarity appear to be more effective in removing bacteria from stormwater. Overall, our results suggest that a biochar amendment to biofilter media has the potential to effectively remove bacteria from stormwater.
Assuntos
Carvão Vegetal/química , Escherichia coli/isolamento & purificação , Dióxido de Silício/química , Águas Residuárias/microbiologia , Fezes/microbiologia , Movimentos da ÁguaRESUMO
Improved approaches are needed to assess bioavailability of hydrophobic organic compounds in contaminated soils. Performance of thin-film solid-phase extraction (TF-SPE) using vials coated with ethylene vinyl acetate was compared to earthworm bioassay (Lumbricus terrestris). A DDT and dieldrin contaminated soil was amended with four organic carbon materials to assess the change in bioavailability. Addition of organic carbon significantly lowered bioavailability for all compounds except for 4,4'-DDT. Equilibrium concentrations of compounds in the polymer were correlated with uptake by earthworms after 48d exposure (R(2) = 0.97; p < 0.001), indicating TF-SPE provided an accurate uptake simulation. Bioavailability of residues in soil was compared with a spiked soil aged for 90d in laboratory. Dieldrin and DDX were respectively 18% and 11% less bioavailable in contaminated soil relative to spiked soil despite >40yr of aging. Results show that TF-SPE can be useful in examining potential risks associated with contaminated soils and to test effectiveness of remediation efforts.
Assuntos
DDT/análise , Dieldrin/análise , Oligoquetos/metabolismo , Poluentes do Solo/análise , Animais , DDT/metabolismo , Dieldrin/metabolismo , Humanos , Medição de Risco , Solo/química , Poluentes do Solo/metabolismo , Extração em Fase Sólida/métodosRESUMO
While pyrolysis of livestock manures generates nutrient-rich biochars with potential agronomic uses, studies are needed to clarify biochar properties across manure varieties under similar controlled conditions. This paper reports selected physicochemical results for five manure-based biochars pyrolyzed at 350 and 700°C: swine separated-solids; paved-feedlot manure; dairy manure; poultry litter; and turkey litter. Elemental and FTIR analyses of these alkaline biochars demonstrated variations and similarities in physicochemical characteristics. The FTIR spectra were similar for (1) turkey and poultry and (2) feedlot and dairy, but were distinct for swine biochars. Dairy biochars contained the greatest volatile matter, C, and energy content and lowest ash, N, and S contents. Swine biochars had the greatest P, N, and S contents alongside the lowest pH and EC values. Poultry litter biochars exhibited the greatest EC values. With the greatest ash contents, turkey litter biochars had the greatest biochar mass recoveries, whereas feedlot biochars demonstrated the lowest.
Assuntos
Carvão Vegetal , Temperatura Alta , Esterco , Animais , Bovinos , Aves Domésticas , Espectroscopia de Infravermelho com Transformada de Fourier , SuínosRESUMO
Qualitative identification of sorbed volatile organic compounds (VOCs) on biochar was conducted by headspace thermal desorption coupled to capillary gas chromatographic-mass spectrometry. VOCs may have a mechanistic role influencing plant and microbial responses to biochar amendments, since VOCs can directly inhibit/stimulate microbial and plant processes. Over 70 biochars encompassing a variety of parent feedstocks and manufacturing processes were evaluated and were observed to possess diverse sorbed VOC composition. There were over 140 individual chemical compounds thermally desorbed from some biochars, with hydrothermal carbonization (HTC) and fast pyrolysis biochars typically possessing the greatest number of sorbed volatiles. In contrast, gasification, thermal or chemical processed biochars, soil kiln mound, and open pit biochars possessed low to non-detectable levels of VOCs. Slow pyrolysis biochars were highly variable in terms of their sorbed VOC content. There were no clear feedstock dependencies to the sorbed VOC composition, suggesting a stronger linkage with biochar production conditions coupled to post-production handling and processing. Lower pyrolytic temperatures (⩽350°C) produced biochars with sorbed VOCs consisting of short carbon chain aldehydes, furans and ketones; elevated temperature biochars (>350°C) typically were dominated by sorbed aromatic compounds and longer carbon chain hydrocarbons. The presence of oxygen during pyrolysis also reduced sorbed VOCs. These compositional results suggest that sorbed VOCs are highly variable and that their chemical dissimilarity could play a role in the wide variety of plant and soil microbial responses to biochar soil amendment noted in the literature. This variability in VOC composition may argue for VOC characterization before land application to predict possible agroecosystem effects.
Assuntos
Carvão Vegetal/química , Compostos Orgânicos Voláteis/análise , Adsorção , Cromatografia Gasosa-Espectrometria de Massas , Oxigênio/química , Temperatura , Compostos Orgânicos Voláteis/isolamento & purificaçãoRESUMO
Coastal bermudagrass (Cynodon dactylon L.) may be a potentially important source of bio-based energy in the southern US due to its vast acreage. It is often produced as part of a waste management plan with varying nutrient composition and energy characteristics on fields irrigated with livestock wastewater. The objective of this study was to determine the effect of subsurface drip irrigation with treated swine wastewater on both the quantity and quality of bermudagrass bioenergy. The treated wastewater was recycled from an advanced treatment system and used for irrigation of bermudagrass in two crop seasons. The experiment had nine water and drip line spacing treatments arrayed in a randomized complete block-design with four replicates. The bermudagrass was analyzed for calorific and mineral contents. Bermudagrass energy yields for 2004 and 2005 ranged from 127.4 to 251.4MJ ha(-1). Compared to irrigation with commercial nitrogen fertilizer, the least biomass energy density was associated with bermudagrass receiving treated swine wastewater. Yet, in 2004 the wastewater irrigated bermudagrass had greater hay yields leading to greater energy yield per ha. This decrease in energy density of wastewater irrigated bermudagrass was associated with increased concentrations of K, Ca, and Na. After thermal conversion, these compounds are known to remain in the ash portion thereby decreasing the energy density. Nonetheless, the loss of energy density using treated effluent via SDI may be offset by the positive influence of these three elements for their catalytic properties in downstream thermal conversion processes such as promoting a lesser char yield and greater combustible gas formation.