Effects of physical preparation of diets and inclusion rate of modified wet distillers grains with solubles on production and rumen measurements of lactating dairy cows.

Our objective was to determine if methods for preparing total mixed ration [TMR; horizontal paddle mixer with knives (PK) vs. vertical auger (VA) mixer] would alter the physical form of the TMR and affect utilization of diets with increasing amounts of modified wet distillers grains with solubles (MWDGS). Holstein cows (n = 24 with 12 ruminally cannulated; 144 d in milk ± 31 d at start) were used in a split-plot design with mixer type as the whole plot and MWDGS concentrations as subplots in a replicated 3 × 3 Latin square arrangement with 35-d periods. Inclusion rates of MWDGS were 10, 20, and 30% of dietary dry matter, primarily replacing corn, soybean meal, soyhulls, and whole cottonseed. Feed dry matter intake (DMI) was less for PK (23.8 kg/d) than for VA (25.7 kg/d), but was unaffected by MWDGS concentration. Milk production did not differ by concentration of MWDGS or by interaction of MWDGS × mixer. Milk fat percentage declined with increasing MWDGS but the interaction between mixer and MWDGS showed that decreases were larger with VA mixing. Cows fed the diet containing 30% MWDGS mixed with PK averaged 3.45% (1.24 kg/d) milk fat, whereas cows fed the same diet mixed with VA averaged 2.81% (1.10 kg/d) fat. Concentrations of trans-10,cis-12 C18:2 in milk fat likely explain the differences observed in milk fat yield; the concentration of trans-10,cis-12 C18:2 increased as MWDGS was increased and the MWDGS × mixer interaction showed that VA had greater concentrations. Greater mean particle size and increased variation in particle size with VA may partially explain differences in milk fat via increased sorting that allowed for an altered rumen environment and favored alternative biohydrogenation pathways. Feed conversion efficiency (FCE; energy-corrected milk/DMI) decreased linearly as MWDGS increased, but FCE tended to be maintained when higher MWDGS diets were mixed using PK rather than VA. Ruminal pH and ammonia concentration decreased linearly as MWDGS increased. The PK mixer resulted in greater FCE when higher amounts of MWDGS were fed, primarily because milk fat content and yield were not as depressed and DMI was lower at similar milk yields.

The effects on digestibility and ruminal measures of chemically treated corn stover as a partial replacement for grain in dairy diets.

Alkaline treatment of gramineous crop residues can convert an abundant, minimally utilized, poorly digestible straw into a moderately digestible feedstuff. Given the volatile nature of grain prices, substitution of treated stover for grain was investigated with dairy cows to provide insights on ruminal and digestibility effects of a feed option that makes use of alternative, available resources. The objective of this study was to evaluate changes in diet digestibility and ruminal effects when increasing levels of calcium oxide-treated corn stover (CaOSt) were substituted for corn grain in diets of lactating cows. Mature corn stover was treated with calcium oxide at a level of 50g∙kg(-1) dry matter (DM), brought up to a moisture content of 50% following bale grinding, and stored anaerobically at ambient temperatures for greater than 60d before the feeding experiment. Eight ruminally cannulated Holstein cows averaging 686kg of body weight and 35kg of milk∙d(-1) were enrolled in a replicated 4×4 Latin square, where CaOSt replaced corn grain on a DM basis in the ration at rates of 0, 40, 80, and 120g∙kg(-1) DM. All reported significant responses were linear. The DM intake declined by approximately 1kg per 4% increase in CaOSt inclusion. With increasing replacement of corn grain, dietary neutral detergent fiber (NDF) concentration increased. However, rumen NDF turnover, NDF digestibility, NDF passage rate, and digestion rate of potentially digestible NDF were unaffected by increasing CaOSt inclusion. Total-tract organic matter digestibility declined by 5 percentage units over the range of treatments, approximately 1.5 units per 4-percentage-unit substitution of CaOSt for grain. With increasing CaOSt, the molar proportions of butyrate and valerate declined, whereas the lowest detected ruminal pH increased from 5.83 to 5.94. Milk, fat, and protein yields declined as CaOSt increased and DM intake declined with the result that net energy in milk declined by approximately 1 Mcal per 4% increase in CaOSt. Time spent ruminating (min∙kg(-1) DM intake) increased with increasing CaOSt, though total minutes per day were unaffected. These insights on the effect of substitution of treated corn stover for corn grain may be used to predict the effect on nutrient supply to the cow over a range of substitution levels. The acceptability of the effect will depend on the economics of milk production and availabilities of feedstuffs.

Feeding value of glycerol as a replacement for corn grain in rations fed to lactating dairy cows.

Growth of the corn ethanol industry has created a need for alternatives to corn for lactating dairy cows. Concurrent expansion in soydiesel production is expected to increase availability and promote favorable pricing for glycerol, a primary co-product material. The objective of this study was to determine the feeding value of glycerol as a replacement for corn in diets fed to lactating dairy cattle. Sixty lactating Holstein cows housed in individual tie stalls were fed a base diet consisting of corn silage, legume forages, corn grain, soyhulls, roasted soybeans, and protein supplements. After a 2-wk acclimation period, cows were fed diets containing 0, 5, 10, or 15% refined glycerol for 56 d. Cows were milked twice daily and weekly milk samples were collected. Milk production was 36.3, 37.2, 37.9, and 36.2 +/- 1.6 kg/d and feed intake was 23.8, 24.6, 24.8, and 24.0 +/- 0.7 kg/d for 0, 5, 10, and 15% glycerol treatments, respectively, and did not differ except for a modest reduction in feed intake during the first 7 d of the trial for 15% glycerol (treatment x time effect). Milk composition was not altered by glycerol feeding except that milk urea nitrogen was decreased from 12.5 +/- 0.4 to 10.2 +/- 0.4 mg/dL with glycerol addition. Cows fed diets containing 10 and 15% glycerol gained more weight than those fed rations containing 0 or 5% glycerol but body condition scores did not differ with glycerol feeding. The data indicate that glycerol is a suitable replacement for corn grain in diets for lactating dairy cattle and that it may be included in rations to a level of at least 15% of dry matter without adverse effects on milk production or milk composition.

Effects of feeding processed corn stover and distillers grains on growth performance and metabolism of beef cattle.

Objectives were to evaluate the effects of replacing corn in feedlot finishing diets with processed corn stover (CS), processed by various combinations of chemical and physical methods, and modified wet distillers grain with solubles (MWDGS) on growth performance, carcass characteristics, digestibility, and ruminal metabolism of cattle. Corn stover was physically processed (ground or extruded) and chemically processed with alkaline agents (CaO and NaOH) to reduce the crystallinity of the lignocellulosic structure. In Exp. 1 steers ( = 18, initial BW = 385 ± 32 kg) and heifers ( = 41, initial BW = 381 ± 27 kg) were allotted to 1 of 5 dietary treatments: 1) 55% dry, cracked corn, 35% MWDGS, 5% vitamin-mineral supplement, and 5% untreated ground CS (), 2) CS treated with 5% CaO (DM basis) and stored in an Ag-Bag (BGCS), 3) CS treated with 5% CaO (DM basis) and extruded (5 EXCS), 4) CS treated with 4% CaO and 1% NaOH (DM basis) and extruded (4,1 EXCS), or 5) CS treated with 3% CaO and 2% NaOH (DM basis) and extruded (3,2 EXCS). Extruded CS was hydrated to 34% moisture, then an additional 16% water was added, as a solution carrying CaO or NaOH or both, via a calibrated pump during processing through a dual-shafted encased extruder (Readco Kurimoto Continuous Processor, York, PA) with the desired exiting temperature of 76.7°C ± 2.8°C. All treated CS diets contained 20% CS and 40% MWDGS (DM basis) to replace 20% corn when compared to CON. There were no effects ( ≥ 0.20) of dietary treatment on ADG, G:F, 12th-rib back fat, marbling score, LM area, or yield grade. However, cattle fed CON had increased ( = 0.02) DMI compared to cattle fed the treated CS diets. In Exp. 2, using the same diets as fed in Exp. 1, ruminally cannulated steers ( = 5; initial BW = 417 ± 21 kg) were fed for 90% of ad libitum intake in a 5 × 5 Latin square design. Apparent digestibility of NDF and ADF increased ( < 0.01) when cattle were fed treated CS diets compared with CON, regardless of the treatment applied. Ruminal pH was reduced ( = 0.02) in cattle fed BGCS from 0 to 6 h postfeeding compared with cattle fed all other diets. Cattle fed the treated CS diets had the greatest ( < 0.01) mean acetate concentrations, which increased ( = 0.01) total VFA concentrations. Replacing a portion of the corn with treated CS in feedlot diets containing MWDGS increased fiber digestibility without affecting feedlot cattle gain, efficiency, marbling score, or LM area.

Effects of grind size when alkaline treating corn residue and impact of ratio of alkaline-treated residue and distillers grains on performance of finishing cattle.

Two studies were conducted to optimize use of alkaline-treated corn stover and wheat straw and distillers grains as partial corn replacements. In Exp. 1, a finishing experiment used 30 pens (12 steers/pen) of calf-fed steers (initial BW = 374 ± 23.9 kg) with a 2 × 2 + 1 factorial arrangement of treatments with 6 replications per treatment. Factors were grind size, where corn stover was processed through a 2.54- or 7.62-cm screen, and chemical treatment (corn stover either fed in native, non-treated form [NT; 93.4% DM] or alkaline treated [AT; 5% CaO hydrated to 50% DM]). No interactions (P ≥ 0.38) were noted between grind size and chemical treatment. Feeding AT compared with NT improved (P ≤ 0.02) final BW, ADG, and G:F. Reducing grind size improved (P ≤ 0.01) ADG and G:F, and no interaction with chemical treatment was observed. Steers fed AT had similar DMI, ADG, G:F, and carcass characteristics compared with a 5% roughage control that contained 15 percentage units (DM basis) more corn. In Exp. 2, 60 individually fed steers (initial BW = 402 ± 61.4 kg) were randomly assigned to 10 diets. Six treatments evaluated 10, 25, or 40% dry-rolled corn (DRC), which was replaced with either a 2:1 or 3:1 ratio (DM basis) of modified distillers grains plus solubles (MDGS) and treated corn stover analyzed as a 2 × 3 factorial. An additional 3 treatments were added where a 3:1 ratio of MDGS:straw were compared with a 3:1 ratio of MDGS:stover. As DRC increased, G:F (P = 0.06) quadratically increased for 3:1 MDGS:stover diets. Increasing DRC increased (P = 0.07) G:F in treated stover diets, regardless of ratio. Increasing DRC increased (P = 0.10) ADG for 3:1 ratios for both straw and stover. Reducing grind size, feeding a maximum of 20% treated crop residue, and maintaining at least 25% corn in the diet are strategies for optimizing cattle performance when replacing dry-rolled and high-moisture corn with treated crop residues and distillers grains.

Digestibility and performance of steers fed low-quality crop residues treated with calcium oxide to partially replace corn in distillers grains finishing diets.

Two studies were conducted to identify methods for treating crop residues to improve digestibility and value in finishing diets based on corn grain and corn wet distillers grain with solubles (WDGS). In Exp. 1, 336 yearling steers (initial BW 356 ± 11.5 kg) were used in a 2 × 3 + 1 factorial arrangement of treatments with 6 pens per treatment. Factors were 3 crop residues (corn cobs, wheat straw, and corn stover) and 2 treatments where crop residues were either fed (20% diet DM) in their native form (NT) or alkaline treated with 5% CaO (DM basis) and hydrated to 50% DM before anaerobic storage (AT). Intakes were not affected by diet (F test; P = 0.30). An interaction between chemical treatment and residue (P < 0.01) was noted for final BW, ADG, G:F, and HCW. Greater final BW was observed for treated stover (4.6%) and straw (5.6%) compared with NT residues; however, AT and NT cobs were similar. Treated straw (9.7%) and stover (12.5%) resulted in greater ADG (P < 0.01) and improved G:F (10.7% and 5.0%, respectively; P < 0.01) compared with NT forms. In Exp. 2, ruminally fistulated steers (n = 5) were used in an unbalanced 5 × 7 incomplete Latin square design with a 2 × 3 + 1 factorial arrangement of treatments. Factors were crop residue (corn cobs, wheat straw, and corn stover) and chemical treatment (NT or AT) fed at 25% of diet DM. Greater DM (73.7% vs. 66.1%; P < 0.01), OM (77.0% vs. 68.5%; P < 0.01), fat (89.2 vs. 85.2; P = 0.02), and NDF (66.8% vs. 51.5%; P < 0.01) digestibilities were noted for AT than for NT. However, no difference (P > 0.10) was observed between control (46% corn; DM basis) and AT (31% corn; DM basis) for DM digestibility (70.7% vs. 73.7%) or OM digestibility (72.1% vs. 77.0%). Dry matter intakes were not different between treated and untreated diets (P = 0.38), but lower (P < 0.01) NDF intake was observed for treated diets (3.1 vs. 3.5 kg/d), suggesting that CaO treatment was effective in solubilizing some carbohydrate. These data suggest that 15% replacement of corn and 10% untreated residue with treated forage result in a nutrient supply of OM similar to that of the control. The improvements in total tract fiber digestibility that occurred when treated forages were fed may have been related to increased digestibility of recoverable NDF and not to increased ruminal pH. Feeding chemically treated crop residues and WDGS is an effective strategy for replacing a portion of corn grain and roughage in feedlot diets.

Effects of twenty percent alkaline-treated corn stover without or with yucca extract on performance and nutrient mass balance of finishing steers fed modified distillers grains-based diets.

Two experiments were conducted with 192 steers each (during the winter [November to May] or summer [June to October]) to evaluate 3 diets with or without Yucca schidigera extract in a 3 × 2 factorial on steer growth performance and N mass balance. One factor was diet (DM basis): 1) 5% untreated corn stover, 51% corn, and 40% modified distillers grains plus solubles (MDGS; CON); 2) 20% calcium oxide-treated corn stover (CaO added at 5% of stover DM), 40% MDGS, and 36% corn (TRT); or 3) 20% untreated corn stover, 40% MDGS, and 36% corn (NONTRT). The other factor was dietary extract at 0 (NOYE) or 1.0 g/d per steer (YE). No interaction between diet and YE was detected (P > 0.51) for growth performance and carcass traits in winter and only for DMI in summer. Final BW, ADG, DMI, or G:F were not different (P ≥ 0.28) between cattle fed CON and TRT, whereas cattle fed NONTRT had lesser ADG, HCW, and G:F compared to CON and TRT in the winter experiment. During the summer, final BW and ADG tended to be greater (P ≥ 0.07) for CON compared to TRT. Cattle fed TRT had reduced (P < 0.01) G:F compared to CON. No difference was observed (P ≥ 0.36) between YE and NOYE in the winter experiment for performance or carcass traits. In the summer, cattle fed YE had greater (P < 0.02) HCW, ADG, and DMI compared to NOYE. In the summer experiment, cattle fed YE had greater (P < 0.01) N intake, N excretion, and amount of N lost (kg/steer) compared to NOYE, but no difference (P = 0.33) was observed for percentage of N volatilized (% of excretion). Diet had no effect (P > 0.18) on amount (kg/steer) or percentage of N volatized in the winter or summer. All diets had similar amounts (P > 0.13) of DM and OM removed from the pen surface in both summer and winter. Feeding CaO-treated corn stover as a partial grain replacement had no impact on performance in winter but decreased G:F in summer. Although high-fiber diets increased the amount of OM on pen surfaces, they did not impact N volatilized. Feeding a Y. schidigera extract did not affect N balance or manure characteristics.

Effects of anabolic steroids on nitrogen metabolism and growth of steers fed corn silage and corn-based diets supplemented with urea or combinations of soybean meal and feathermeal.

The objectives of these experiments were to examine whether N retention and feedlot performance by steers administered estradiol 17-beta (E2) alone (metabolism study) or in combination with trenbolone acetate (TAB; feedlot study) could be enhanced by increasing dietary ruminal escape protein. For the metabolism study, 16 Angus steers (average weight = 308 +/- 5 kg) were used in a randomized block design experiment having a 2 x 4 factorial arrangement of treatments. Main factors were E2 administration and supplemental CP source. Steers were fed diets based on corn silage and corn (60:30 DM basis) and were supplemented with urea or three combinations of soybean meal (SBM) and feathermeal (Fth). Combinations and SBM and Fth (SBM:Fth) provided 75:25, 50:50, and 25:75 of supplemental CP on a N basis. Estradiol 17-beta increased (P < .05) N retention and decreased (P < .05) plasma urea N concentrations. Total tract N digestion decreased linearly (P < .05) as the proportion of Fth in the diet increased. However, N retention increased linearly (P < .05) with increased Fth. A CP source x E2 interaction (P < .05) was observed for N retention because retention increased linearly with increasing dietary Fth in cattle receiving E2 but was unaffected (P > .05) in control steers. A growth study was conducted using 128 crossbred steers (400 +/- 19 kg) that received no implant or a combination of E2 (Synovex) and TBA (Finaplix-S). Steers were fed diets containing 75% high-moisture corn, 15% corn silage, and 10% supplement (DM basis) for 84 d (heavy replicate) or 124 d (light replicate).(ABSTRACT TRUNCATED AT 250 WORDS)

Intestinal supply of amino acids in steers fed ruminally degradable and undegradable crude protein sources alone and in combination.

The objective of this study was to examine the effect of combining ruminally degradable and undegradable CP sources on ruminal microbial protein synthesis and postruminal N and amino acid (AA) flows in steers. Six steers fitted with ruminal, duodenal, and ileal cannulas were fed diets containing corn silage and high-moisture corn supplemented with urea, soybean meal (SBM), dry corn gluten feed (DCGF), a combination of corn gluten meal and blood meal (CB), or SBM and DCGF in combination with CB. Estimated ruminal N escapes for SBM, DCGF, and CB were 32, 25, and 68%, respectively. Supplemental CP sources supplied 35 to 40% of diet CP (12.5% CP diets). Dry matter intake was adjusted to 2.3% of BW for each steer in each period. Total N flow at the duodenum decreased (P < .01) when the diet was supplemented with urea vs other proteins due to decreased (P < .01) flow of nonmicrobial N. However, microbial N and AA flows were greater (P < .05) for urea than for other protein supplements. Disappearance of OM and NDF in the stomach decreased (P < .07) or was numerically lower but nonmicrobial N at the duodenum increased (P < .08) as CB replaced SBM or DCGF in the diet. Protein source had little effect on ruminal fermentation characteristics except that ruminal ammonia N (NH3N) concentration was higher (P < .05) for urea than for other treatments. Total AA and essential AA flows to and disappearance from the small intestine increased (P < .06) as CB replaced DCGF. However, substituting CB for SBM had little effect on intestinal flows and disappearance of AA. These data suggest that source of ruminally degradable CP can influence the efficacy of feeding ruminally degradable and undegradable CP in combination. In general, source of supplemental CP had a greater effect on the quantity than on the profile of absorbable AA supplied to the duodenum.

Supplemental protein sources for steers fed corn-based diets: I. Ruminal characteristics and intestinal amino acid flows.

Five cannulated Holstein steers (302 +/- 23 kg) were used in a 4 x 4 Latin square design experiment with extra observations to evaluate the effect of supplemental protein source on postruminal flow and intestinal disappearance of N and amino acids (AA). Diets were formulated to contain 12.5% CP using cracked corn (70%), ground corn cobs (15%), and supplement (15%). Except for an all-urea supplemented control diet, 40% of the total dietary CP was supplied by soybean meal (SBM), a high ruminal escape soybean meal (SoyPLUS; SP), or a corn gluten meal/blood meal combination (CB; 50:50 on a CP basis). The steers were fed twice daily and DMI was restricted to 2.0% of initial BW. Supplementation with CB increased (P < .10) non-microbial N flow at the duodenum but tended to decrease microbial N flow such that no differences (P > .10) in total N flows at the duodenum were detected among treatments. The efficiency of microbial protein synthesis was not affected by treatment but was greatest for urea/and tended to decrease when SP and CB were fed (21.8, 20.5, 19.5, and 15.7 g of N/kg of OM truly digested for urea, SBM, SP, and CB, respectively). A possible shortage of ruminally degradable N, as evidenced by low ruminal NH3 N concentrations (3.6, 4.2, 3.9, and 2.1 mg/dL for urea, SBM, SP, and CB respectively), or other factors, may have limited microbial protein synthesis. However, microbial N flows averaged 60.0% of duodenal N flow across treatments. Duodenal flow of essential, nonessential, and total AA were similar (P > .10) among treatments and averaged 293, 361, and 653 g/d, respectively). Lysine and methionine flows did not differ (P > .10) and averaged 41.6 and 13.3 g/d, respectively. The source of supplemental protein had no impact (P > .10) on small intestinal disappearance of AA or total tract N disappearance. Feeding proteins resistant to ruminal degradation may have limited microbial protein production, resulting in a shift in the proportion of metabolizable protein arriving at the small intestine from dietary and microbial origins. These results suggest that corn-based diets may be limiting in ruminally degradable N, especially when high ruminal escape protein sources are fed as supplemental CP.

Effects of zinc-treated soybean meal on ruminal fermentation and intestinal amino acid flows in steers fed corn silage-based diets.

The objectives of this study were to examine the effects of feeding zinc-treated soybean meal (Zn-SBM) on ruminal fermentation patterns and duodenal AA flows in steers fed diets based on corn silage and corn. Six steers (385 kg) fitted with ruminal, duodenal, and ileal cannulas were used in a replicated 3 x 3 Latin square design experiment with 14-d periods. Diets were supplemented with solvent-extracted soybean meal (SBM), Zn-SBM, or a 50:50 combination (CP basis) of SBM:Zn-SBM. Ruminal escape N content of SBM and Zn-SBM were 30.0 and 57.0%, respectively, based on 12-h Dacron bag incubation. Protein sources provided approximately 30% of total CP in diets containing 12.6% CP (DM basis). Dry matter intake was equalized throughout the study at 2.2% of average initial BW. Total N flow at the duodenum was similar (P = .47) among treatments, but a trend (P = .15) for increased nonmicrobial N flow occurred when SBM and Zn-SBM were fed in combination. Micobial N flow and true efficiency of microbial CP synthesis were not affected by treatment (P = .87 and .37, respectively). Ruminal fermentation characteristics generally were unaffected (P > .10) by protein source. A positive quadratic response (P < .06) was observed for total and essential AA flows to the small intestine because flows of total and essential AA from ruminally undegraded dietary protein tended (P = .12) to increase when SBM and Zn-SBM were fed in combination. Absorption of AA from the small intestine also showed a positive quadratic (P < .06) response for SBM:Zn-SBM. Microbial AA flow to the small intestine was similar (P = .87) among treatments.(ABSTRACT TRUNCATED AT 250 WORDS)

The value of soybean hulls as a replacement for corn in beef cattle diets formulated with or without added fat.

One hundred twenty crossbred yearling steers (average weight = 445 +/- 32 kg) were used in an 84-d randomized complete block design experiment to determine the value of soybean hulls (SH) as a replacement for corn in concentrate diets formulated with or without added fat (lard). The steers were blocked by weight and alloted to one of eight treatments in a 4 x 2 factorial arrangement of treatments. The main factors were amount of SH (0, 20, 40, or 60% of diet DM) and amount of added fat (0 or 5% of diet DM). The basal diet without added fat or SH contained cracked corn (80%), a urea-based protein supplement (15%), and ground corn cobs (5%). Replacing corn with SH linearly (P = .03) decreased ADG, increased DMI (linear, P = .003; quadratic, P = .06), and linearly (P < .001) decreased gain efficiency. Fat addition tended (P = .08) to improve efficiency; ADG and DMI were unaffected (P > .05) by fat addition. Similar diets were fed to 16 wethers (average weight = 47 +/- 2.3 kg) in a randomized complete block design experiment to determine digestibility of NDF and dietary concentration of DE. Replacing corn with SH linearly increased DMI (P = .001) and NDF (P < .001) and linearly decreased (P < .001) the digestibility of DM. The digestibility of NDF tended to increase with increased SH. The digestibility of energy linearly (P = .0001) decreased with increased SH. The amount of fat had no effect (P > .05) on DMI or intake of NDF or digestibilities of these nutrients. The addition of fat tended (P = .07) to improve the intake of DE.(ABSTRACT TRUNCATED AT 250 WORDS)

Effect of source and amount of energy and rate of growth in the growing phase on performance and carcass characteristics of early- and normal-weaned steers.

One hundred eighty-four Angus x Simmental steers (initial BW 161.7 +/- 3.4 kg) were used to determine whether different sources and amounts of energy in the growing phase could extend the growth curve and maintain high amounts of intramuscular fat deposition in early-weaned steers. Steers were allotted by source, age, and BW to one of four growing-phase (119 to 259 d of age) regimens. For three regimens, steers were weaned at 119 d of age and either 1) fed (DM basis) a 50% grain diet ad libitum (ALC); 2) limit-fed a 70% grain diet to achieve a gain of 0.8 kg/d from 119 to 192 d of age, and 1.2 kg/d from 193 to 259 d of age (LFC); or 3) fed a 60% haylage diet ad libitum from 119 to 192 d of age, and a 25% haylage diet ad libitum from 193 to 259 d of age (ALF). For the fourth regimen, steers were normal-weaned at 204 d of age and fed a silage diet from 205 to 259 d of age (NW). From 260 d of age to slaughter, all steers consumed a 70% grain (DM basis) diet. Limit-fed and ALF steers spent the most, and NW the least amount of time (P < 0.01) in the feedlot to achieve a target fat depth of 1.27 cm. Ad libitum-fed steers were the youngest (331 d), and NW the oldest (383 d) at slaughter (P < 0.01). Overall ADG was greatest for ALC and least for NW steers (P < 0.01). Overall, ALF steers consumed the most DM (P < 0.01). While in the feedlot, LFC and ALC steers were more efficient in converting feed to BW gain (P < 0.01) than ALF and NW steers. Normal-weaned had the least and ALC the greatest (P < 0.01) fat depth at 260 d of age. Consequently, NW steers produced the heaviest, and ALC the lightest (P < 0.01) carcasses at slaughter. Normal-weaned steers had the largest, and ALC and LFC steers had the smallest longissimus muscle area (P < 0.06). Growing phase dietary treatments did not affect (P > 0.20) yield grade. Marbling score did not differ (P > 0.35), but laboratory analysis revealed that ALC steers had the lowest percentage of fat (P < 0.02) in the longissimus muscle. Shear force was greatest (P < 0.08) for steaks from ALC and LFC steers, and least for steaks from ALF and NW steers. Feeding steers the ALC diet from 119 to 260 d of age hastened physiological maturity, decreased marbling scores, and decreased muscle tenderness compared with forage feeding (ALF, NW). Limit-feeding a high-grain diet also hastened physiological maturity and decreased muscle tenderness but did not decrease marbling scores. Source and amount of energy affected partitioning of fat deposition.

Effects of dietary energy level and protein source on site of digestion and duodenal nitrogen and amino acid flows in steers.

Six steers (468 kg) with ruminal and duodenal cannulas were fed diets formulated for two levels of energy containing three crude protein (CP) sources in a 6 X 6 Latin square with a 2 X 3 factorial arrangement of treatments. Energy levels were 2.17 and 2.71 Mcal metabolizable energy (ME)/kg dry matter (DM) provided by hay-corn (H) and corn silage-corn (CS) diets, respectively. Soybean mean (SBM), corn gluten meal-urea (CGM) and urea (U) provided 33% of dietary CP in 12% CP diets. Apparent organic matter (OM) digested in the stomach was not affected (P greater than .05) by energy level or CP source, but OM truly digested in the stomach was greater (P less than .05) when steers were fed the CS compared with the H diet. Duodenal flow of non-NH3 N was greater (P less than .05) when steers were fed CS compared with H and when fed SBM or CGM compared with U. Efficiency of bacterial protein synthesis and duodenal bacterial N flow were increased (P less than .05) when steers were fed CS, but non-NH3, nonbacterial N flow to the duodenum was increased (P less than .05) when steers were fed H. When steers were fed CS rather than H, flows (g/d) of bacterial amino acids were greater (P less than .05), but flows of nonbacterial amino acids tended (P less than .08) to be less. Total amino acid flows were not affected (P greater than .05) by energy level. Duodenal flows of total amino acids tended (P less than .06) to be greater when steers were fed CGM compared with SBM or U, due mainly to an increased (P less than .05) flow of nonessential amino acids.

Intestinal supply of amino acids in sheep fed alkaline hydrogen peroxide-treated wheat straw-based diets supplemented with soybean meal or combinations of corn gluten meal and blood meal.

The intestinal supply of amino acids (AA) in sheep fed alkaline hydrogen peroxide-treated wheat straw (AHPWS)-based diets supplemented with soybean meal (SBM) or corn grain plus combinations of corn gluten meal (CGM) and blood meal (BM) was measured in a 5 X 5 latin square. Sheep (avg wt 45 kg) with ruminal, duodenal and ileal cannulas were fed diets containing 65% AHPWS supplemented with the following protein sources: soybean meal (SBM), corn gluten meal (CGM), blood meal (BM), 2/3 CGM:1/3 BM and 1/3 CGM:2/3 BM. Total nitrogen (N) flow at the duodenum was not affected (P greater than .05) by protein source. Flows of bacterial N and AA increased (P less than .05) and flows of nonbacterial N and AA decreased (P less than .05) when wethers were fed SBM vs corn plus other protein sources. When diets contained SBM, quantities of total AA at the duodenum were lower (P less than .05) and the profile of AA supplied to the intestine was altered substantially. Total flows of AA at the duodenum and total quantities of AA disappearing from the small intestine were similar (P greater than .05) for all diets containing BM and CGM, but flows and disappearance of valine, histidine, lysine and arginine increased linearly (P less than .05), whereas flows and disappearance of leucine, isoleucine and methionine decreased linearly (P less than .05) as BM replaced CGM in the diets. Results suggest that quantities of individual AA flowing to the duodenum and disappearing from the intestine of wethers fed AHPWS-based diets can be altered by source of dietary protein. Furthermore, feeding protein sources resistant to ruminal degradation in combination may improve the profile of AA supplied to the intestine.

Effects of dietary energy level and protein source on nutrient digestion and ruminal nitrogen metabolism in steers.

Four Simmental steers with ruminal, duodenal, and ileal cannulas were used to examine effects of dietary forage: concentrate ratio and supply of ruminally degradable true protein on site of nutrient digestion and net ruminal microbial protein synthesis. Steers (345 kg) were fed ammoniated corn cob (high forage; HF)- or corn cob/ground corn/cornstarch (low forage; LF)-based diets supplemented with soybean meal (SBM) or a combination of corn gluten meal and blood meal (CB). Diets were fed at 2-h intervals with average DM intake equal to 2.2% of BW. Feeding LF vs HF increased (P less than .05) OM digestion (percentage of intake) in the stomach, small intestine, and total tract. Efficiency of microbial CP synthesis (EMCP; g of N/kg of OM truly fermented) decreased (P less than .05) for LF vs HF (24.1 vs 26.8), but microbial N and total N flows to the small intestine were similar (P greater than .05) between energy levels (average 112 and 209 g/d, respectively). Total N flows to the small intestine were 13.1% greater (P less than .05) for CB than for SBM because of increased (P less than .05) passage of nonmicrobial N. Feeding SBM vs CB increased (P less than .05) EMCP (27.3 vs 23.3) and microbial N flow to the small intestine (127.5 vs 112.5 g/d), but these increases were not likely due to increased ruminal concentrations of ammonia N (NH3 N). Decreased (P less than .05) incorporation of NH3 N into bacterial N and slower turnover rates of ruminal NH3 N for SBM vs CB suggest that direct incorporation of preformed diet components into cell mass increased when SBM was fed. Results of this study suggest that the inclusion of ruminally degradable protein in the diet may increase the supply of products from proteolysis and that this can increase EMCP and microbial protein flow to the small intestine.

Supplemental protein sources for steers fed corn-based diets: II. Growth and estimated metabolizable amino acid supply.

Seventy Simmental-cross steers (average initial weight 301 +/- 24 kg) were individually fed in a 175-d completely randomized design experiment to evaluate the effects of source and level of protein in the diet on gain and feed efficiency. Steers were allotted to 1 of 10 treatments (seven steers per treatment) in a 3 x 3 factorial arrangement of treatments plus a urea-supplemented control diet. Main factors were source of supplemental protein (soybean meal [SBM], a high ruminal escape soybean meal [SP; SoyPLUS], or a combination of corn gluten meal and blood meal [CB; 50:50 on a nitrogen basis]) and level of each protein source (20, 30, or 40% of total dietary CP). Based on 18-h in situ ruminal incubation, escape N content of the protein sources was 66.0, 82.5, and 90.8% of total N and metabolizable amino acid (MAA) content was 29.1, 33.4, and 67.8 g/100 g of DM for SBM, SP, and CB respectively. The steers were fed 12.5% CP diets based on cracked corn (70%) on d 0 through 70 and were switched to a common 11.5% CP urea-supplemented cracked corn diet (80%) on d 71. The steers were housed in individual confinement stalls and had ad libitum access to feed. Replacing urea with SBM or SP increased (P < .05) 28- and 70-d ADG and DMI and increased (P < .05) 28-d efficiency (kg of gain/100 kg of feed). Replacing urea with CB did not improve (P > .05) 28- or 70-d ADG or DMI but did increase (P < .05) 28-d efficiency. The growth rate of steers at 28 and 70 d was correlated to a greater degree with ME intake (r2 = .83 and .85, respectively) rather than MAA supply, suggesting that the MAA supply was not first-limiting for growth. The source of supplemental protein fed during d 0 through 70 had no effect (P > .05) on 175-d DMI or efficiency; however, feeding SBM increased (P < .05) 175-d ADG compared with feeding urea, SP, or CB. Increasing supplemental true protein tended to linearly increase ADG and DMI at 28 and 70 d, but overall, ADG, DMI, and efficiency were not affected (P > .05) by treatment. Replacing urea with SBM or CB in the first 70 d decreased (P < .05) carcass quality grade, dressing percentage, and longissimus muscle area.(ABSTRACT TRUNCATED AT 400 WORDS)

Energy concentration and amino acid digestibility in corn and corn coproducts from the wet-milling industry fed to growing pigs.

Two experiments were conducted to determine DE and ME and the apparent ileal digestibility (AID) and the standardized ileal digestibility (SID) of CP and AA in corn and corn coproducts (high-fat corn germ [HFCG], corn bran, liquid corn extractives [LCE], and a mixture of corn germ meal and LCE [CGM-LCE]) fed to growing pigs. In Exp. 1, 40 growing barrows (initial BW: 33.4 ± 5.77 kg) were housed individually in metabolism cages and randomly allotted to 1 of 5 diets. A corn-based diet (97.4% corn) and 4 diets that contained both corn and each of the corn coproducts were formulated. Each diet was fed to 8 pigs. Feces and urine samples were collected using the marker to marker method with 5-d adaptation and 5-d collection periods. The DE and ME were calculated using the difference procedure. The concentrations of DE and ME in HFCG, corn bran, LCE, and CGM-LCE were less (P < 0.05) than in corn. Among corn coproducts, the concentration of DE in HFCG was greater (P < 0.05) than in corn bran, but the DE in corn bran was not different from DE values in LCE and CGM-LCE. No differences were observed in the ME concentrations among corn coproducts. In Exp. 2, 6 growing barrows (initial BW: 96.6 ± 1.16 kg) with a T-cannula in the distal ileum were randomly allotted to a 6 × 6 Latin square design with 6 diets and 6 periods. A N-free diet and 5 diets that contained corn, HFCG, corn bran, LCE, or CGM-LCE as the sole source of CP and AA were formulated. Each period lasted 7 d and ileal digesta were collected on d 6 and 7 of each period. The SID of CP and all indispensable AA was greater (P < 0.05) in corn than in all corn coproducts with the exception that the SID of Lys in corn was not different from the SID of Lys in HFCG, and the SID of Trp in corn was also not different from the SID of Trp in CGM-LCE. Among corn coproducts, the SID of CP, Arg, and Lys were greater (P < 0.05) in HFCG and CGM-LCE than in corn bran, the SID of Lys and Val was greater (P < 0.05) in LCE than in corn bran, and the SID of Arg was greater (P < 0.05) in HFCG and CGM-LCE than in LCE, but for the remaining indispensable AA, no differences among corn coproducts were observed. In conclusion, the corn coproducts used in these experiments contain less ME and have reduced SID of most AA compared with corn, but there are no differences in ME among corn coproducts and only few differences in the SID of indispensable AA among HFCG, corn bran, LCE, and CGM-LCE.

Effect of vitamin E source, natural versus synthetic, and quantity on serum and tissue alpha-tocopherol concentrations in finishing swine.

Relative vitamin E status of pigs fed natural or synthetic vitamin E was evaluated based on serum and tissue alpha-tocopherol concentrations. Individually fed finishing gilts at a BW of 70.5 kg (n = 24) were allotted to dietary treatments based on initial BW. The 5 dietary treatments consisted of a positive control diet using synthetic vitamin E acetate (Syn E Ac) supplemented at 22 mg/kg, and 4 dietary levels of natural vitamin E acetate (Nat E Ac) supplemented at 6.71, 8.33, 11.00, and 16.18 mg/kg of diet. Before initiation of the 32-d experiment, pigs were fed a non-vitamin E-fortified diet for 30 d. Diets were formulated to contain true ileal digestible lysine of 0.9 and 0.8% for the pretest and test diets. Serum samples were collected on d 15 and 32, whereas tissue samples were collected on d 32 for alpha-tocopherol analysis. Serum alpha-tocopherol concentrations on d 15 and 32 were greater (P < 0.05) in pigs fed 8.33, 11.00, or 16.18 mg/kg of Nat E Ac than in pigs fed 22 mg/kg of Syn E Ac. When compared with pigs fed 22 mg/kg of Syn E Ac, alpha-tocopherol concentrations were greater (P < 0.05) in 6 tissues (heart, kidney, spleen, liver, lung, and adipose) in pigs fed 16.18 mg/kg of Nat E Ac; greater (P < 0.05) in heart, kidney, spleen, liver, and adipose tissue in pigs fed 11.00 mg/kg of Nat E Ac; and greater (P < 0.05) in spleen, loin, and adipose tissue in pigs fed 8.33 mg/kg of Nat E Ac. As dietary Nat E Ac increased from 6.71 to 16.18 mg/kg, serum alpha-tocopherol increased linearly (P < 0.01) on d 15 and 32 of the experiment. Increasing dietary Nat E Ac linearly increased (P < 0.05) alpha-tocopherol concentrations for lung, heart, kidney, spleen, and liver. These results indicate that Nat E Ac was an effective vitamin E source and its relative bioavailability was substantially greater than 1.36 for finishing swine when compared with Syn E Ac.

Nutrient digestion and performance by lambs and steers fed thermochemically treated crop residues.

Five studies were conducted to determine nutrient digestibility and performance of lambs and steers fed thermochemically treated crop residues and distillers dried grains with solubles (DDGS) as a corn replacement pellet (CRP; 75% residue:25% DDGS, DM basis). Fifteen Hampshire, Suffolk, or Dorset wethers (BW 33.3 +/- 5.0 kg) were utilized to evaluate nutrient digestibility of the unprocessed native (NAT) and CRP [Exp. 1: wheat straw (WS); Exp. 2: corn stover (CS); Exp. 3: switchgrass (SWG) and corn fiber:wheat chaff (CFWC)] when limit fed (Exp. 1 and 2: 1.8% of BW daily; Exp. 3: 2.5% of BW daily) compared with a 60% corn diet. In Exp. 4, 56 individually fed Dorset-cross wether lambs (BW 32.0 +/- 1.4 kg) were utilized to compare performance and digestibility of WS, wheat chaff (WC), corn fiber (CF), a 3:1 blend of corn fiber:wheat straw (CFWS), a 3:1 blend of CFWC, and SWG-CRP fed for ad libitum intake compared with a 45% corn diet. In Exp. 5, 32 individually fed Holstein steers (BW 185.2 +/- 0.9 kg) were used to evaluate performance and digestibility of diets containing corn, WS-CRP, CFWC-CRP, or NAT-WS fed for ad libitum intake. Crop residues were processed with 5% calcium oxide (DM basis) and 35% water in a double-shaft enclosed mixer (Readco Kurimoto Continuous Processor, York, PA) and subsequently pelleted with DDGS to form CRP. Feeding lambs WS-CRP (Exp. 1) or CS-CRP (Exp. 2) increased digestion of DM, NDF, and ADF compared with NAT (P < 0.05). In Exp. 3, feeding CFWC-CRP increased total tract NDF digestibility and ADF digestibility (P < 0.05). Experiment 4 final BW were greatest for control lambs and least for lambs fed CFWS-CRP or SWG-CRP. Body weight gains for lambs fed CRP averaged 15.9% less than control (P < 0.05). Lambs fed CRP diets had greater (P < 0.05) NDF and ADF intake and output. In Exp. 5, steers fed the corn or 2 CRP diets gained similarly and faster (P < 0.05) than those fed the NAT-WS diet. Steers fed the control corn diet were more efficient (P < 0.05) than steers fed other treatments. Steers fed the corn diet, CFWC-CRP, and WS-CRP had greater (P < 0.01) DM digestibility than NAT. The results confirm benefits for nutrient digestion and subsequent animal performance when crop residues are thermochemically processed. Processed crop residues may be fed in combination with DDGS to partially replace corn in ruminant diets.