On-line monitoring of chemical reactions by using bench-top nuclear magnetic resonance spectroscopy.

Real-time nuclear magnetic resonance (NMR) spectroscopy measurements carried out with a bench-top system installed next to the reactor inside the fume hood of the chemistry laboratory are presented. To test the system for on-line monitoring, a transfer hydrogenation reaction was studied by continuously pumping the reaction mixture from the reactor to the magnet and back in a closed loop. In addition to improving the time resolution provided by standard sampling methods, the use of such a flow setup eliminates the need for sample preparation. Owing to the progress in terms of field homogeneity and sensitivity now available with compact NMR spectrometers, small molecules dissolved at concentrations on the order of 1 mmol L(-1) can be characterized in single-scan measurements with 1 Hz resolution. Owing to the reduced field strength of compact low-field systems compared to that of conventional high-field magnets, the overlap in the spectrum of different NMR signals is a typical situation. The data processing required to obtain concentrations in the presence of signal overlap are discussed in detail, methods such as plain integration and line-fitting approaches are compared, and the accuracy of each method is determined. The kinetic rates measured for different catalytic concentrations show good agreement with those obtained with gas chromatography as a reference analytical method. Finally, as the measurements are performed under continuous flow conditions, the experimental setup and the flow parameters are optimized to maximize time resolution and signal-to-noise ratio.

Stability study of a nisin/natamycin blend by LC-MS.

Nisin and natamycin are natural preservatives used in a broad range of food products. In the present study, the stability of an aqueous nisin/natamycin blend (pH 4.0) for the beverage market was tested at room temperature (22 °C) under dark conditions by means of liquid chromatography. Both an HPLC-UV and a UPLC-MS method were developed to monitor the concentration of natamycin and nisin, respectively. After 6 months at room temperature (22 °C) under dark conditions, the nisin/natamycin blend (pH 4.0) still contained 85% of the original amount of nisin and 95% of natamycin. Even after 1 year, 50% of nisin and 90% of natamycin remained in the formulation. The resulting degradation products were studied by means of high resolution mass spectrometry. For both nisin and natamycin, degradation products originating from hydration (natamycin + H2O; nisin + H2O) and oxidation reactions (natamycin + O; nisin + O; nisin + 2O) were observed.

Enantioselective high-performance liquid chromatographic separation of N-methyloxycarbonyl unsaturated amino acids on macrocyclic glycopeptide stationary phases.

This paper describes the enantiomeric resolution of a series of unsaturated N-methyloxycarbonyl-alpha-H-alpha-amino acids (N-MOC-alpha-amino acids) on macrocyclic glycopeptide stationary phases by means of high-performance liquid chromatography (HPLC). Three types of glycopeptide phases, i.e. Chirobiotic T, V and R, were evaluated in both reversed-phase (RP) and polar ionic mode (PIM). The best results in terms of enantioselectivity and resolution were obtained on Chirobiotic R phase, with the PIM mobile phase giving the highest resolution per min. Investigation of the pH of the reversed-phase mobile phase in the pH range 4.1-5.9 showed little effect on enantioselectivity. The method was applied for monitoring the conversion and product enantiomeric excess of an enzymatic hydrolysis reaction using N-MOC-alpha-H-alpha-amino acid esters as substrate.

Determination of the enantiomers of 3-tert.-butylamino-1,2-propanediol by high-performance liquid chromatography coupled to evaporative light scattering detection.

A method for the separation and quantitation of the enantiomers of 3-tert.-butylamino-1,2-propanediol by high-performance liquid chromatography and evaporative light scattering detection has been developed. Separation of the enantiomers was performed in normal-phase liquid chromatography on a Chiralpak AS chiral stationary phase. The influence of the gas nature, gas pressure and temperature of the drift tube of the evaporative light scattering detector on the detection sensitivity was investigated. The method was validated in terms of linearity, limit of quantitation, accuracy and precision. The enantiomeric excess of (S)-3-tert.-butylamino-1,2-propanediol, used for the industrial synthesis of (S)-timolol, was measured from 0 to 94%.

High-performance liquid chromatographic determination of alpha-aminonitrile enantiomers after derivatization with o-phthalaldehyde and chiral thiols.

o-Phthalaldehyde in combination with chiral thiols is described as a chiral reagent for the resolution of the enantiomers of alpha-H-alpha-aminonitriles and alpha-alkyl-alpha-aminonitriles. Separation of the resulting diastereomers was carried out by reversed-phase chromatography and the derivatives were detected at UV 340 nm. The identity of the diastereomeric derivatives was confirmed by LC-MS. Among the chiral thiols tested, N-acetyl-D-penicillamine and beta-mercaptoisobutyric acid gave the best resolution for the alpha-aminonitriles studied. For quantitative enantiomeric excess determination, beta-mercaptoisobutyric acid was chosen as this thiol could be obtained in high enantiomeric purity from a commercial source. The rate of the reaction of various alpha-aminonitriles with o-phthalaldehyde and beta-mercaptoisobutyric acid was studied. The accuracy of the method was investigated by a comparison of theoretical and measured enantiomeric excess.

Thermospray liquid chromatography/mass spectrometry study of diastereomeric isoindole derivatives of amino acids and amino acid amides.

A thermospray liquid chromatography/mass spectrometry (TSP-LC/MS) method is described for determination of the enantiomeric excess of alpha-amino acids and alpha-amino acid amides as their o-phthalaldehyde/N-acetyl-L-cysteine (OPA/NAC) derivatives. The source temperature is an important factor in optimizing the sensitivity of the TSP-LC/MS analysis, whereas the repeller voltage is of minor importance. On-column mass spectra were acquired for the OPA/NAC derivatives of several alpha-amino acids and alpha-amino acid amides. For the main fragment ions, mass spectra fragmentation pathways are proposed. The applicability of the method is demonstrated by means of the enantiomeric excess determination of valine in a sample from an enzymatic hydrolysis experiment. Using single ion monitoring, the detection limit of D-valine in the presence of excess L-valine is 10 pmol. The present TSP-LC/MS method is useful for validating the results obtained from LC/UV or LC/fluorescence methods for the enantiomeric excess determination of alpha-amino acids and alpha-amino acid amides.

Comparative evaluation of four detectors in the high-performance liquid chromatographic analysis of chiral nonaromatic alcohols.

A comparative evaluation of ultraviolet, polarimetric, refractive index, and evaporative light-scattering detection coupled with high-performance liquid chromatography has been developed for the separation and quantitation of the enantiomers of chiral nonaromatic alcohols, some of which are intermediates in the synthesis of chiral drugs. (R,S)-3-tert-butylamino-1,2-propanediol; (R,S)-glycidol; and (R,S)-1-(4-morpholino)-2-octanol are selected as model compounds in order to compare the detection sensitivity and the linearity of the response with the four detectors. Separation of the enantiomers is performed using chiral stationary phases in normal-phase liquid chromatography. A one-day validation is achieved for (S)-3-tert-butylamino-1,2-propanediol with each detector, and limits of quantitation are determined for the three compounds. Advantages and limitations of the four detectors are discussed.

Determination of biocatalyst consumption in an aminopeptidase process using automated sample preparation and high-performance liquid chromatography.

A rapid and sensitive method has been developed for the determination of the biocatalyst consumption in the chemo-enzymic production of optically pure natural and synthetic alpha-H-amino acids. It is based on automated sample preparation from an enzymic reaction mixture, reversed-phase high-performance liquid chromatographic separation, post-column reaction and fluorimetric detection. The assay procedure has been applied to the enzymic conversion of racemic norvaline amide into L-norvaline, catalysed by an L-specific aminopeptidase from Pseudomonas putida. Both norvaline amide and norvaline can be analysed in a single assay in the low nanogram range. The method yields reproducible results and requires 30 min from the time of sampling the enzymic reaction mixture to quantitation. The reaction mixture is automatically sampled and analysed several times during the course of the reaction. With the results obtained a conversion curve can be constructed from which the exact biocatalyst consumption can be calculated. By adaptation of the mobile phase, the method can also be applied to other amino acid amides used as substrates in the aminopeptidase reaction.