Deciphering the Dual Roles of an Alginate-Based Biodegradable Flocculant in Anaerobic Fermentation of Waste Activated Sludge: Dewaterability and Degradability.

Biodegradable flocculants are rarely used in waste activated sludge (WAS) fermentation. This study introduces an alginate-based biodegradable flocculant (ABF) to enhance both the dewatering and degradation of WAS during its fermentation. Alginate was identified in structural extracellular polymeric substances (St-EPS) of WAS, with alginate-producing bacteria comprising ∼4.2% of the total bacterial population in WAS. Owing to its larger floc size, higher contact angle, and lower free energy resulting from the Lewis acid-base interaction, the addition of the prepared ABF with a network structure significantly improved the dewaterability of WAS and reduced capillary suction time (CST) by 72%. The utilization of ABF by an enriched alginate-degrading consortium (ADC) resulted in a 35.5% increase in the WAS methane yield owing to its higher hydrolytic activity on both ABF and St-EPS. Additionally, after a 30 day fermentation, CST decreased by 62% owing to the enhanced degradation of St-EPS (74.4%) and lower viscosity in the WAS + ABF + ADC group. The genus Bacteroides, comprising 12% of ADC, used alginate lyase (EC 4.2.2.3) and pectate lyase (EC 4.2.2.2 and EC 4.2.2.9) to degrade alginate and polygalacturonate in St-EPS, respectively. Therefore, this study introduces a new flocculant and elucidates its dual roles in enhancing both the dewaterability and degradability of WAS. These advancements improve WAS fermentation, resulting in higher methane production and lower CSTs.

Evaluating the potential of different bioaugmented strains to enhance methane production during thermophilic anaerobic digestion of food waste.

Bioaugmentation technology for improving the performance of thermophilic anaerobic digestion (TAD) of food waste (FW) treatment is gaining more attention. In this study, four thermophilic strains (Ureibacillus suwonensis E11, Clostridium thermopalmarium HK1, Bacillus thermoamylovorans Y25 and Caldibacillus thermoamylovorans QK5) were inoculated in the TAD of FW system, and the biochemical methane potential (BMP) batch study was conducted to assess the potential of different bioaugmented strains to enhance methane production. The results showed that the cumulative methane production in groups inoculated with E11, HK1, Y25 and QK5 improved by 2.05%, 14.54%, 19.79% and 9.17%, respectively, compared with the control group with no inoculation. Moreover, microbial community composition analysis indicated that the relative abundance of the main hydrolytic bacteria and/or methanogenic archaea was increased after bioaugmentation, and the four strains successfully became representative bacterial biomarkers in each group. The four strains enhanced methane production by strengthening starch, sucrose, galactose, pyruvate and methane metabolism functions. Further, the correlation networks demonstrated that the representative bacterial genera had positive correlations with the differential metabolic functions in each bioaugmentation group. This study provides new insights into the TAD of FW with bioaugmented strains.

Energetic utilization of corn stalk and elimination of methyl orange in ECMO-like integrated reactor: Co-occurrence of anaerobic digestion and aerobic treatment.

For the simultaneous energetic utilization of corn stalk and azo-dye contaminated wastewater, an ECMO-like integrated reactor was come up to achieve the biogas production and azo-dye degradation during anaerobic digestion (AD). Methyl orange (MO) was selected as the model compound for azo-dye. The ECMO-like reactor included AD main reactor with a spray device and solid-liquid separation components, integrated with an aeration reactor for biogas slurry. Methane yields of corn stalks (100.82 mL/g VS) were highest in the ECMO-like reactor, compared with reactors without aeration. As a stable metabolite, 4-aminobenzenesulfonic acid (4-ABA) was detected in AD, while it was assumed that the metabolites can be further transformed in the ECMO-like reactor (R3), due to the 4-ABA removal efficiency as 92.87 % after 35 days' digestion. Class Alphaproteobacteria and Clostridia were assumed as functional microbes responding to aeration. Overall, this ECMO-like integrated reactor provided a novel biotechnology strategy for agricultural and azo dye waste treatment.

Core-Shell Au@Nanoplastics as a Quantitative Tracer to Investigate the Bioaccumulation of Nanoplastics in Freshwater Ecosystems.

Studies on the adverse effects of nanoplastics (NPs, particle diameter <1000 nm) including physical damage, oxidative stress, impaired cell signaling, altered metabolism, developmental defects, and possible genetic damage have intensified in recent years. However, the analytical detection of NPs is still a bottleneck. To overcome this bottleneck and obtain a reliable and quantitative distribution analysis in complex freshwater ecosystems, an easily applicable NP tracer to simulate their fate and behavior is needed. Here, size- and surface charge-tunable core-shell Au@Nanoplastics (Au@NPs) were synthesized to study the environmental fate of NPs in an artificial freshwater system. The Au core enables the quantitative detection of NPs, while the polystyrene shell exhibits NP properties. The Au@NPs showed excellent resistance to environmental factors (e.g., 1% hydrogen peroxide solution, simulating gastric fluid, acids, and alkalis) and high recovery rates (>80%) from seawater, lake water, sewage, waste sludge, soil, and sediment. Both positively and negatively charged NPs significantly inhibited the growth of duckweed (Lemna minor L.) but had little effect on the growth of cyanobacteria (Microcystis aeruginosa). In addition, the accumulation of positively and negatively charged NPs in cyanobacteria occurred in a concentration-dependent manner, with positively charged NPs more easily taken up by cyanobacteria. In contrast, negatively charged NPs were more readily internalized in duckweed. This study developed a model using a core-shell Au@NP tracer to study the environmental fate and behavior of NPs in various complex environmental systems.

Combined disposal of methyl orange and corn straw via stepwise adsorption-biomethanation-composting.

Agriculture wastes have been proved to be the potential adsorbents to remove azo dye from textile wastewater, but the post-treatment of azo dye loaded agriculture waste is generally ignored. A three-step strategy including sequential adsorption-biomethanation-composting was developed to realize the co-processing of azo dye and corn straw (CS). Results showed that CS represented a potential adsorbent to remove methyl orange (MO) from textile wastewater, with the maximum MO adsorption capacity of 10.00 ± 0.46 mg/g, deriving from the Langmuir model. During the biomethanation, CS could serve as electron donor for MO decolorization and substrate for biogas production simultaneously. Though the cumulative methane yield of CS loaded with MO was 11.7 ± 2.28% lower than that of blank CS, almost complete de-colorization of MO could be achieved within 72 h. Composting could achieve the further degradation of aromatic amines (intermediates during the degradation of MO) and decomposition of digestate. After 5 days' composting, 4-aminobenzenesulfonic acid (4-ABA) was not detectable. The germination index (GI) also indicated that the toxicity of aromatic amine was eliminated. The overall utilization strategy gives novel light on the management of agriculture waste and textile wastewater.

Use of magnetic powder to effectively improve the denitrification employing the activated sludge fermentation liquid as carbon source.

Nitrogen removal is often limited in municipal wastewater treatment due to the lack of sufficient carbon source. Utilizing volatile fatty acids (VFAs) from waste activated sludge (WAS) fermentation broth as a carbon source is an ideal alternative to reduce the cost for wastewater treatment plants (WWTPs) and improve denitrification efficiency simultaneously. In this study, an anaerobic system was applied for simultaneous denitrification and WAS fermentation and the addition of magnetic microparticles (MMP) were confirmed to enhance both denitrification and WAS fermentation. Firstly, the addition of MMP increased the nitrate reduction rate by over 25.36% and improve the production of N2. Additionally, the equivalent chemical oxygen demand (COD) of the detected VFAs increased by 7.06%-14.53%, suggesting that MMP promoted the WAS fermentation. The electron transfer efficiency of denitrifies was accelerated by MMP via electron-transporting system (ETS) activity and cyclic voltammetry (CV) experiments, which might result in the promotional denitrification and WAS fermentation performance. Furthermore, the high-throughput sequencing displayed that, MMP enriched key microbes capable of degrading the complex organics (Chloroflexi, Synergistota and Spirochaetota) as well as the typical denitrifies (Bacteroidetes_vadinHA17 and Denitratisoma). Therefore, this study provides a novel strategy to realize simultaneous WAS utilization and denitrification for WWTPs.

Effects of salvaged cyanobacteria content on larval development and feedstock humification during black soldier fly larvae (Hermetia illucens) composting.

Cyanobacteria salvage is widely used to deal with massive cyanobacterial blooms. Improper disposal of salvaged cyanobacteria would cause secondary pollution. Black soldier fly (Hermetia illucens) larvae (BSFL) can bio-convert organic wastes into larval biomass, which is rich in protein and lipid. This study evaluated the possibility of using BSFL composting for salvaged cyanobacteria treatment. Results showed that increasing salvaged cyanobacteria waste (CW) content (from 0 to 50%, dry weight basis) extended BSFL development time, e.g., BSFL fed with 50% CW needed 14 days more to finish development than Control (0% CW). The CW content (0-20%) in feeding substrates had no significant effect on BSFL body length and weight. Whereas further increase of CW content (from 20 to 50%) led to significant reductions in substrate-to-BSFL biomass conversion ratio, body size, body weight, and crude protein content of BSFL. Meanwhile, the presence of salvaged cyanobacteria in the feeding substrate reduced the degradation efficiency of feeding substrate. The dissolved organic matter (DOM) results demonstrated that the increased salvaged cyanobacteria content made it more difficult for BSFL to degrade the feeding substrate into simple organic matter and further into humic-like substances. Furthermore, salvaged cyanobacteria in feeding substrates affected the intestinal microbial community significantly. With 20% CW content in the feeding substrate, the relative abundance of Firmicutes decreased from 92.43 to 81.24%, while the relative abundance of Proteobacteria and Bacteroidetes increased from 4.10 to 2.93-8.75% and 7.51%, respectively. BSFL composting is feasible to convert salvaged cyanobacteria into insect biomass. However, the salvaged cyanobacteria content in the feeding substrate should be carefully controlled (e.g., less than 30%).

Life cycle assessment of hydrogenotrophic denitrification in membrane aerated biofilm reactors for sustainable wastewater treatment.

The conventional anaerobic-anoxic-oxic (AAO) process for wastewater treatment is associated with high energy consumption and pollutant emissions due to its reliance on heterotrophic denitrification. In contrast, membrane aerated biofilm reactors (MABR) coupled with hydrogenotrophic denitrification (H2-MABR) offers a more promising alternative. This study conducts a life cycle assessment (LCA) to evaluate the environmental and economic benefits of H2-MABR compared to traditional AAO processes. Results indicate that even with a limited reactor life, the application of MABR in actual wastewater treatment plants can yield over 30 % reduction in environmental and economic impacts. Using CO2 from biogas as a carbon source significantly reduces carbon emissions during the anaerobic stage, while the efficient nitrogen removal minimizes the need for wastewater recirculation and electricity consumption. The H2-driven denitrification process also avoids emissions and secondary pollution risks associated with organic electron donors. Furthermore, coupling H2-MABR with renewable energy source and Power-to-Gas technology further enhances sustainability by ensuring a stable hydrogen supply. Given the significant potential of H2-MABR for improving wastewater treatment, further research and large-scale implementation are highly encouraged.

Enhancing CH4 production in microbial electrolysis cells: Optimizing electric field via carbon cathode resistivity.

Microbial electrolysis cells (MECs) are increasingly recognized as a promising technology for converting CO2 to CH4, offering the dual benefits of energy recovery from organic wastewater and CO2 emission reduction. A critical aspect of this technology is the enhancement of the electron-accepting capacity of the methanogenic biocathode to improve CH4 production efficiency. This study demonstrates that adjusting the cathode resistivity is an effective way to control the electric field intensity, thereby enhancing the electron accepting capacity and CH4 production. By maintaining the electric field intensity within approximately 8.50-10.83 mV·cm-1, the CH4 yield was observed to increase by up to two-fold. The improvement in CH4 production under optimized electric field conditions was attributed to the enhancement of the direct accepting capacity of the biocathode. This enhancement was primarily due to an increase in the relative abundance of Methanosaeta by approximately 10 % and an up to 83.78 % rise in the electron-accepting capacity of the extracellular polymeric substance. These insights offer a new perspective on the operation of methanogenic biocathodes and propose a novel biocathode construction methodology based on these findings, thus contributing to the enhancement of MEC efficiency.

Micro-aeration: an attractive strategy to facilitate anaerobic digestion.

Micro-aeration can facilitate anaerobic digestion (AD) by regulating microbial communities and promoting the growth of facultative taxa, thereby increasing methane yield and stabilizing the AD process. Additionally, micro-aeration contributes to hydrogen sulfide stripping by oxidization to produce molecular sulfur or sulfuric acid. Although micro-aeration can positively affect AD, it must be strictly regulated to maintain an overall anaerobic environment that permits anaerobic microorganisms to thrive. Even so, obligate anaerobes, especially methanogens, could suffer from oxidative stress during micro-aeration. This review describes the applications of micro-aeration in AD and examines the cutting-edge advances in how methanogens survive under oxygen stress. Moreover, barriers and corresponding solutions are proposed to move micro-aeration technology closer to application at scale.

Effects of size and surface charge on the sedimentation of nanoplastics in freshwater.

The environmental issues caused by nanoplastics (NPs) are increasingly noticeable. Environmental behavior study of the NPs could provide vital information for their environmental impact assessment. However, associations between NPs' inherent properties and their sedimentation behaviors were seldom investigated. In this study, six types of PSNPs (polystyrene nanoplastics) with different charges (positive and negative) and particle sizes (20-50 nm, 150-190 nm and 220-250 nm) were synthesized, and their sedimentations under different environmental factors, (e.g., pH value, ionic strength (IS), electrolyte type and natural organic matter) were investigated. Results displayed that both particle size and surface charge would affect the sedimentation of PSNPs. The maximum sedimentation ratio of 26.48% was obtained in positive charged PSNPs with size of 20-50 nm, while the minimum sedimentation ratio of 1.02% was obtained in negative charged PSNPs with size of 220-250 nm at pH 7.6. The pH value shift (range of 5-10) triggered negligible changes of sedimentation ratio, the average particle size and the Zeta potential. Small size PSNPs (20-50 nm) showed higher sensitivity to IS, electrolyte type and HA condition than large size PSNPs. At high IS value ( [Formula: see text]  = 30 mM or ISNaCl = 100 mM), the sedimentation ratios of the PSNPs all increased differently according to their properties, and the sedimentation promoting effect of CaCl2 was more significant on negative charged PSNPs than positive charged PSNPs. When [Formula: see text] increased from 0.9 to 9 mM, the sedimentation ratios of negative charged PSNPs increased by 0.53%-23.49%, while that of positive charged PSNPs increased by less than 10%. Besides, humic acid (HA) addition (1-10 mg/L) would lead to a stable suspension status for PSNPs in water with different degree and perhaps different mechanism due to their charge characteristics. These results showed new light on influence factor studies of NPs' sedimentation and would be helpful for further knowledge of NPs' environmental behaviors.

From anaerobic digestion to single cell protein synthesis: A promising route beyond biogas utilization.

The accumulation of a large amount of organic solid waste and the lack of sufficient protein supply worldwide are two major challenges caused by rapid population growth. Anaerobic digestion is the main force of organic waste treatment, and the high-value utilization of its products (biogas and digestate) has been widely concerned. These products can be used as nutrients and energy sources for microorganisms such as microalgae, yeast, methane-oxidizing bacteria(MOB), and hydrogen-oxidizing bacteria(HOB) to produce single cell protein(SCP), which contributes to the achievement of sustainable development goals. This new model of energy conversion can construct a bioeconomic cycle from waste to nutritional products, which treats waste without additional carbon emissions and can harvest high-value biomass. Techno-economic analysis shows that the SCP from biogas and digestate has higher profit than biogas electricity generation, and its production cost is lower than the SCP using special raw materials as the substrate. In this review, the case of SCP-rich microorganisms using anaerobic digestion products for growth was investigated. Some of the challenges faced by the process and the latest developments were analyzed, and their potential economic and environmental value was verified.

Insights into the roles of humic acids in facilitating the anaerobic digestion process.

Humic acids (HAs) are important byproducts of anaerobic digestion (AD), which have complex structures and dynamic electrochemical activities. However, the effects of HAs on AD process were usually misestimated due to the neglect of the in situ generated HAs and the interaction between HAs and metal ions. This study explored the effects of HAs on AD performance using corn straw as typical "clean" substrate (rare in metals content) via commercial HAs (C-HAs) addition and in-situ-generated HAs (In-HAs) removal. Results showed that C-HAs (1 g/L) addition promoted the maximum methane production rate (Rm) by 20.6%, while In-HAs removal decreased the Rm by 42.7%. Meanwhile, C-HAs showed little effect on the acidification of corn straw but increased the Rm during the methanation of ethanol by 41.6%. Both the C-HAs and In-HAs were rich in surface oxygen-containing functional groups, which enabled them to act as electron shuttles and facilitate the syntrophic methanogenesis. HAs also acted in regulation of syntrophic microorganisms. For instance, C-HAs addition enriched the relative abundances of Cloacimonadia, Spirochaetia, Synergistia and Methanosarcina, while the removal of In-HAs reduced the relative abundances of Spirochaetia and Synergistia. In conclusion, HAs addition to the AD process could be a feasible approach to improve methane production by enhancing direct interspecies electron transfer during AD of lignocellulosic biomass.

Integrated Passive Sensing Chip for Highly Sensitive and Reusable Detection of Differential-Charged Nanoplastics Concentration.

In this work, a new type, highly sensitive, and reusable nanoplastics (NPs) microwave detection method is proposed, which can be used to rapidly analyze NPs with different surface charges and sizes. The effective dielectric constant of NPs varies according to the different concentrations, particle sizes, and surface charges of NPs in aqueous solution. The feasibility of the microwave method for differential-charged NPs detection is verified using a complementary split ring resonator sensor manufactured on a cost-effective printed circuit board, which shows a high sensitivity only for positively charged NPs (PS-NH2) detection. To achieve microwave detection of both positively and negatively charged NPs (PS-SO3H), a microscale spiral-coupled resonator sensing chip is manufactured through integrated passive technology, which demonstrates extremely low detection limits and high sensitivity for both PS-NH2 and PS-SO3H, with different concentrations, particle sizes, and charges. In addition, for NPs solution doped with methyl orange, the device can still perform stable measurements, overcoming the inability of traditional NPs molecular element determination and optical detection methods to detect NPs aqueous solution with organic matter doping and color presence. The proposed microwave detection method could also be extended to sensing detection for detecting other hazardous environmental substances.

Improving anaerobic digestion of corn straw by using solid-state urea pretreatment.

The resistant structure and high carbon/nitrogen ratio (C/N) of cellulosic substrate are the barriers during their anaerobic digestion (AD). Solid-state urea pretreatment was developed in this study to pretreat corn straw and adjust C/N ratio simultaneously for the downstream AD of corn straw. Results showed solid-state urea pretreatment was efficient in lignin removal and achieved the highest lignin reduction of 7.06% with C/N ratio = 15 during pretreatment. Scanning electron microscopy demonstrated the destruction of the dense structure by pretreatment, which benefited to the hydrolysis of corn straw. The cumulative methane yields of the pretreated corn straw ranged from 234.07 to 250.03 mL/g VS, which were obviously higher than that of the untreated corn straw. The maximum methane yield of 250.03 mL/g VS was achieved with C/N = 15 during pretreatment, which was 23.91% higher than that of the untreated group. In addition, AD digestates from the pretreated groups had 9.62% higher nutrients than that from the untreated group. The solid-state urea pretreatment can destroy the dense structure of corn straw and regulate the C/N ratio during AD, thus benefit the methane production and fertilizer use of the digestate, which is a potential choice during the AD of cellulosic substrate.

Understanding the mechanisms behind enhanced anaerobic digestion of corn straw by humic acids.

Humic acids (HAs) are abundant on earth, yet their effects on anaerobic digestion (AD) of cellulosic substrate are not fully uncovered. The effects of HAs on AD of corn straw and the mechanisms behind were analyzed in this study. Results showed that the effects of HAs on methane yield were closely related to the total solids (TS) content. At relative high TS content of 5.0%, HAs benefited AD process by increasing 13.8% of methane yield, accelerating methane production rate by 43% and shortening lag phase time by 37.5%. Microbial community analysis indicated that HAs increased the relative abundance of syntrophic bacteria (Syntrophomonadaceae and Synergistaceae), facilitating the degradation of volatile fatty acids. HAs might act as electron shuttles to directly transfer electrons to hydrogenotrophic methanogens for CO2 reduction to CH4. This study provides a simple and efficient strategy to facilitate the AD of cellulosic substrate by HAs addition.

Producing insect protein from food waste digestate via black soldier fly larvae cultivation: A promising choice for digestate disposal.

The treatment of food waste digestate with high salinity is a big challenge. This paper evaluated the possibility of using black soldier fly larvae for food waste digestate disposal and insect protein production. Results showed that both digestates from hydrogen and methane fermentations were rich in protein and lipid contents, which benefited the BSFL cultivation. The BSFL reared on digestates from hydrogen and methane fermentations of food waste performed better in pre-pupal weight (19.12% and 41.13% higher, respectively), body length (3.62% and 18.21% higher, respectively) and crude protein contents (7.85% and 39.05% higher, respectively) than that reared on raw food waste. In addition, the maximum body weight growth rate (Rm) of BSFL cultivated on both digestates were 28.28% and 47.10% higher than that of BSFL cultivated on raw food waste, respectively. During BSFL cultivation, organic matter reduction between 40.97% and 46.07% were achieved. Digestates from hydrogen and methane fermentations represent favorable feeding substrates for BSFL cultivation. Using BSFL to treat AD digestate not only provides a digestate disposal approach, but also produces insect biomass and organic fertilizer as value-added byproducts, which shows tremendous potential in digestate disposal.

Enhancement of biological nitrogen removal performance from low C/N municipal wastewater using novel carriers based on the nano-Fe3O4.

The aim of this work was to study the effects of the magnetic microparticles (MMP) on nitrogen removal under low C/N conditions. A 30-day anaerobic/oxic progress illustrated that nitrification and denitrification were promoted in the presence of MMP. MMP could facilitate the production of extracellular polymeric substances (EPS) and act as pH buffering in aerobic conditions. The high-throughput sequencing displayed that, compared with the sludge without MMP, the relative abundance of Dokdonella and Comamonas which are capable of both nitrifying and denitrifying were 8.7% and 1.29% higher in anaerobic sludge and 7.11% and 0.97% higher in aerobic sludge with MMP, respectively. The relative abundance of Pseudomonas with the excellent capability of EPS secretion was also observed 4.33 times higher than that without MMP in the aerobic sludge. Based on the superior performance above, MMP is a promising additive to enhance nitrogen removal efficiency for low C/N wastewater.

In situ Biogas Upgrading by CO2-to-CH4 Bioconversion.

Biogas produced by anaerobic digestion is an important renewable energy carrier. Nevertheless, the high CO2 content in biogas limits its utilization to mainly heat and electricity generation. Upgrading biogas into biomethane broadens its potential as a vehicle fuel or substitute for natural gas. CO2-to-CH4 bioconversion represents one cutting-edge solution for biogas upgrading. In situ bioconversion can capture endogenous CO2 directly from the biogas reactor, is easy to operate, and provides an infrastructure for renewable electricity storage. Despite these advantages, several challenges need to be addressed to move in situ upgrading technologies closer to applications at scale. This opinion article reviews the state of the art of this technology and identifies some obstacles and opportunities of biological in-situ upgrading technologies for future development.

Effects of nanoplastics on microalgae and their trophic transfer along the food chain: recent advances and perspectives.

Nanoplastics (NPs) have drawn increasing attention in recent years due to their potential threats to aquatic ecosystems. Microalgae are primary producers, which play important roles in the normal functioning of ecosystems. According to the source of production and laboratory experiments, both NPs and microalgae are likely to be widely found in various water environments, so they have a great chance of interacting with each other. Although tremendous efforts have been made to explore these potential interactions, a timely and critical review is still missing. In this paper, the effects of NPs on microalgae and their trophic transfer along the food chain are summarized. The toxic impact of NPs on microalgae is tightly associated with the concentrations, sizes and surface charge of NPs, as well as the microalgal species. In addition, NPs could also interact with many other contaminants, thus leading to combined effects on microalgae. NP exposure might block substance and energy exchange between microalgae and their surrounding environment, lead to a shading effect on microalgae, promote the production of reactive oxygen species (ROS) or induce direct physical damage on microalgae, thereby inhibiting the growth of microalgae. Moreover, NPs could also be trophically transferred along the food chain through microalgae and subsequently affect the species at a higher trophic level. Yet importantly, current understanding of the interactions between NPs and microalgae is still quite limited, and needs to be further studied.