Biomanufacture of nano-Pd(0) by Escherichia coli and electrochemical activity of bio-Pd(0) made at the expense of H2 and formate as electron donors.

OBJECTIVE: Palladised cells of Desulfovibrio desulfuricans and Shewanella oneidensis have been reported as fuel cell electrocatalysts but growth at scale may be unattractive/costly; we have evaluated the potential of using E. coli, using H2/formate for Pd-nanoparticle manufacture. RESULTS: Using 'bio-Pd' made under H2 (20 wt%) cyclic voltammograms suggested electrochemical activity of bio-NPs in a native state, attributed to proton adsorption/desorption. Bio-Pd prepared using formate as the electron donor gave smaller, well separated NPs; this material showed no electrochemical properties, and hence little potential for fuel cell use using a simple preparation technique. Bio-Pd on S. oneidensis gave similar results to those obtained using E. coli. CONCLUSION: Bio-Pd is sufficiently conductive to make an E. coli-derived electrochemically active material on intact, unprocessed bacterial cells if prepared at the expense of H2, showing potential for fuel cell applications using a simple one-step preparation method.

One step bioconversion of waste precious metals into Serratia biofilm-immobilized catalyst for Cr(VI) reduction.

OBJECTIVES: For reduction of Cr(VI) the Pd-catalyst is excellent but costly. The objectives were to prove the robustness of a Serratia biofilm as a support for biogenic Pd-nanoparticles and to fabricate effective catalyst from precious metal waste. RESULTS: Nanoparticles (NPs) of palladium were immobilized on polyurethane reticulated foam and polypropylene supports via adhesive biofilm of a Serratia sp. The biofilm adhesion and cohesion strength were unaffected by palladization and catalytic biofilm integrity was also shown by magnetic resonance imaging. Biofilm-Pd and mixed precious metals on biofilm (biofilm-PM) reduced 5 mM Cr(VI) to Cr(III) when immobilized in a flow-through column reactor, at respective flow rates of 9 and 6 ml/h. The lower activity of the latter was attributed to fewer, larger, metal deposits on the bacteria. Activity was lost in each case at pH 7 but was restored by washing with 5 mM citrate solution or by exposure of columns to solution at pH 2, suggesting fouling by Cr(III) hydroxide product at neutral pH. CONCLUSION: A 'one pot' conversion of precious metal waste into new catalyst for waste decontamination was shown in a continuous flow system based on the use of Serratia biofilm to manufacture and support catalytic Pd-nanoparticles.

Bacterially produced calcium phosphate nanobiominerals: sorption capacity, site preferences, and stability of captured radionuclides.

A Serratia sp. bacterium manufactures amorphous calcium phosphate nanominerals (BHAP); this material has shown increased sorption capacity for divalent radionuclide capture. When heat-treated (≥450 °C) the cell biomass is removed and the biominerals are transformed to hydroxyapatite (HAP). Using a multimethod approach, we have elucidated both the site preferences and stability of analogue radionuclide incorporation for Sr, Co, Eu, and U. Strontium incorporates within the bulk amorphous inorganic phase of BHAP; however, once temperature modified to crystalline HAP, bonding was consistent with Sr substitution at the Ca(1) and/or Ca(2) sites. Cobalt incorporation occurs within the bulk inorganic amorphous phase of BHAP and within the amorphous grain boundaries of HAP. Europium (an analogue for trivalent actinides) substituted at the Ca(2) and/or the Ca(3) position of tricalcium phosphate, a known component of HAP grain boundaries. Uranium was surface complexed with no secondary minerals detected. With multiple sites for targeted radionuclide incorporation, high loadings, and good stability against remobilization, BHAP is shown to be a potential material for the remediation of aqueous radionuclide in groundwater.

Radiotolerance of phosphatases of a Serratia sp.: potential for the use of this organism in the biomineralization of wastes containing radionuclides.

Aqueous wastes from nuclear fuel reprocessing present special problems of radiotoxicity of the active species. Cells of Serratia sp. were found previously to accumulate high levels of hydrogen uranyl phosphate (HUP) via the activity of a phosphatase enzyme. Uranium is of relatively low radiotoxicity whereas radionuclide fission products such as (90)Sr and (137)Cs are highly radiotoxic. These radionuclides can be co-crystallized, held within the bio-HUP "host" lattice on the bacterial cells and thereby removed from contaminated solution, depending on continued phosphatase activity. Radiostability tests using a commercial (60)Co γ-source showed that while cell viability and activity of purified phosphatase were lost within a few hours on irradiation, whole-cell phosphatase retained 80% of the initial activity, even after loss of cell culturability, which was increased to 100% by the incorporation of mercaptoethanol as an example radioprotectant, beyond an accumulated dose of >1.3 MGy. Using this co-crystallization approach (without mercaptoethanol) (137)Cs(+) and (85)Sr(2+) were removed from a simulated waste selectively against a 33-fold excess of Na(+).

Configuration of microbially synthesized Pd-Au nanoparticles studied by STEM-based techniques.

Bimetallic Pd-Au particles synthesized using Desulfovibrio desulfuricans bacteria are characterized using scanning transmission electron microscopy (STEM) with a high-angle annular dark field (HAADF) detector combined with energy dispersive x-ray (EDX) silicon drift detector (SDD) elemental mapping and plasmon electron energy-loss spectroscopy (EELS). When combined with EDX, theoretical considerations or EELS, the atomic-number contrast (Z-contrast) provided by HAADF-STEM is effective in characterizing the compositional configuration of the bimetallic nanoparticles. Homogeneous mixing and complex segregations have been found for different particles in this work. The EELS study has also found different behaviours corresponding to surface plasmon resonances in different regions of a single particle due to its heterogeneity and anisotropy. HAADF-STEM tomography has been performed to obtain three-dimensional (3D) visualization of the nanoparticles.

Uptake of Sr2+ and Co2+ into biogenic hydroxyapatite: implications for biomineral ion exchange synthesis.

Biomineral hydroxyapatite (Bio-HAp) produced by Serratia sp. has the potential to be a suitable material for the remediation of metal contaminated waters and as a radionuclide waste storage material. Varying the Bio-HAp manufacturing method was found to influence hydroxyapatite (HAp) properties and consequently the uptake of Sr(2+) and Co(2+). All the Bio-HAp tested in this study were more efficient than the commercially available hydroxyapatite (Com-HAp) for Sr(2+) and Co(2+) uptake. For Bio-HAp the uptake for Sr(2+) and Co(2+) ranged from 24 to 39 and 29 to 78 mmol per 100 g, respectively. Whereas, the uptake of Sr(2+) and Co(2+) by Com-HAp ranged from 3 to 11 and 4 to 18 mmol per 100 g, respectively. Properties that increased metal uptake were smaller crystallite size (<40 nm) and higher surface area (>70 m(2) g(-1)). Organic content which influences the structure (e.g., crystallite arrangement, size and surface area) and composition of Bio-HAp was also found to be important in Sr(2+) and Co(2+) uptake. Overall, Bio-HAp shows promise for the remediation of aqueous metal waste especially since Bio-HAp can be synthesized for optimal metal uptake properties.

Using non-invasive magnetic resonance imaging (MRI) to assess the reduction of Cr(VI) using a biofilm-palladium catalyst.

Industrial waste streams may contain contaminants that are valuable like Pd(II) and/or toxic and mutagenic like Cr(VI). Using Serratia sp. biofilm the former was biomineralized to produce a supported nanocrystalline Pd(0) catalyst, and this biofilm-Pd heterogeneous catalyst was then used to reduce Cr(VI) to less dangerous Cr(III) at room temperature, with formate as the electron donor. Cr(VI)((aq)) is non-paramagnetic while Cr(III)((aq)) is paramagnetic, which enabled spatial mapping of Cr species concentrations within the reactor cell using non-invasive magnetic resonance (MR) imaging experiments. Spatial reactivity heterogeneities were thus examined. In batch reactions, these could be attributed primarily to heterogeneity of Pd(0) distribution and to the development of gas bubbles within the reactor. In continuous flow reactions, spatial reactivity heterogeneities resulted primarily from heterogeneity of Cr(VI) delivery.

Towards an integrated system for bio-energy: hydrogen production by Escherichia coli and use of palladium-coated waste cells for electricity generation in a fuel cell.

Escherichia coli strains MC4100 (parent) and a mutant strain derived from this (IC007) were evaluated for their ability to produce H(2) and organic acids (OAs) via fermentation. Following growth, each strain was coated with Pd(0) via bioreduction of Pd(II). Dried, sintered Pd-biomaterials ('Bio-Pd') were tested as anodes in a proton exchange membrane (PEM) fuel cell for their ability to generate electricity from H(2). Both strains produced hydrogen and OAs but 'palladised' cells of strain IC007 (Bio-Pd(IC007)) produced ~threefold more power as compared to Bio-Pd(MC4100) (56 and 18 mW respectively). The power output used, for comparison, commercial Pd(0) powder and Bio-Pd made from Desulfovibrio desulfuricans, was ~100 mW. The implications of these findings for an integrated energy generating process are discussed.

Uranium bioaccumulation by a Citrobacter sp. as a result of enzymically mediated growth of polycrystalline HUO2PO4.

A Citrobacter sp. accumulates heavy deposits of metal phosphate, derived from an enzymically liberated phosphate ligand. The cells are not subject to saturation constraints and can accumulate several times their own weight of precipitated metal. This high capacity is attributable to biomineralization; uranyl phosphate accumulates as polycrystalline HUO2PO4 at the cell surface. The precipitated metal is indistinguishable from crystalline HUO2PO4.4H2O grown by chemical methods.

Versatility of a new bioinorganic catalyst: palladized cells of Desulfovibrio desulfuricans and application to dehalogenation of flame retardant materials.

The versatility and reaction specificity of a novel bioinorganic catalyst is demonstrated in various reactions. Palladized cells (bioPd) of the sulphate-reducing bacterium Desulfovibrio desulfuricans showed an increased product selectivity and a catalytic activity comparable to a commercial Pd catalyst in several industrially relevant hydrogenations and hydrogenolyses (reductive dehalogenations). The ability of palladized cells to promote the reductive debromination of a polybrominated diphenyl ether (PBDE #47) is demonstrated, although chemically reduced Pd(II) and commercial Pd(0) were more effective debromination agents. Polybrominated diphenyl ethers are being supplanted as flame retardants by other compounds, e.g. tris(chloroisopropyl)phosphate (TCPP), the concentration of which was seen to increase approximately 10-fold in groundwater samples between 2000 and 2004. BioPd dechlorinated TCPP in groundwater samples with >90% recovery of free chloride ion, and was five times more effective than using commercial Pd(0) catalyst. Examination of the spent groundwater using 31P NMR showed a phosphorus species novel to the bioPd-treated solution, which was not evident in a commercial reference sample of TCPP.

Bioaccumulation of palladium by Desulfovibrio fructosivorans wild-type and hydrogenase-deficient strains.

Wild-type Desulfovibrio fructosivorans and three hydrogenase-negative mutants reduced Pd(II) to Pd(0). The location of Pd(0) nanoparticles on the cytoplasmic membrane of the mutant retaining only cytoplasmic membrane-bound hydrogenase was strong evidence for the role of hydrogenases in Pd(0) deposition. Hydrogenase activity was retained at acidic pH, shown previously to favor Pd(0) deposition.

Biorecovery of gold by Escherichia coli and Desulfovibrio desulfuricans.

Microbial precipitation of gold was achieved using Escherichia coli and Desulfovibrio desulfuricans provided with H2 as the electron donor. No precipitation was observed using H2 alone or with heat-killed cells. Reduction of aqueous AuIII ions by both strains was demonstrated at pH 7 using 2 mM HAuCl4 solution and the concept was successfully applied to recover 100% of the gold from acidic leachate (115 ppm of AuIII) obtained from jewelry waste. Bioreductive recovery of gold from aqueous solution was achieved within 2 h, giving crystalline Au0 particles (20-50 nm), in the periplasmic space and on the cell surface, and small intracellular nanoparticles. The nanoparticle size was smaller (red suspension) at acidic pH (2.0) as compared to that obtained at pH 6.0 and 7.0 (purple) and 9.0 (dark blue). Comparable nanoparticles were obtained from AuIII test solutions and jewelry leachate.

Spatially resolved quantification of metal ion concentration in a biofilm-mediated ion exchanger.

A bioremediation process to remove Co(2+) from aqueous solution is investigated in this study using a magnetic resonance imaging (MRI) protocol to rapidly obtain multiple 2D spatially resolved Co(2+) ion concentration maps. The MRI technique is described in detail and its ability to determine the evolution in both axial and radial concentration profiles demonstrated, from which total column capacity can be determined. The final ion exchange column design allows operation in the 'plug flow' regime, hence making use of its full capacity before breakthrough. Conventional techniques for such process optimization are either restricted to the analysis of the exchanger outlet, which provides no information on the spatial heterogeneity of the system, or are invasive and need a variety of sample points to obtain 1D concentration information. To the best of our knowledge, our results represent the first concentration maps describing the bioremediation of metal ion contaminated water.

Bioaccumulation of nickel by intercalation into polycrystalline hydrogen uranyl phosphate deposited via an enzymatic mechanism.

A Citrobacter sp. accumulates uranyl ion (UO2(2+)) as crystalline HUO2PO4.4H2O (HUP), using enzymatically generated inorganic phosphate. Ni was not removed by this mechanism, but cells already loaded with HUP removed Ni2+ by intercalative ion-exchange, forming Ni(UO2PO4)2.7H2O, as concluded by x-ray diffraction (XRD) and proton induced x-ray emission (PIXE) analyses. The loaded biomass became saturated with Ni rapidly, with a molar ratio of Ni:U in the cellbound deposit of approx. 1:6; Ni penetration was probably surface-localized. Cochallenge of the cells with Ni2+ and UO2(2+), and glycerol 2-phosphate (phosphate donor for phosphate release and metal bioprecipitation) gave sustained removal of both metals in a flow through bioreactor, with more extensively accumulated Ni. We propose 'Microbially Enhanced Chemisorption of Heavy Metals' (MECHM) to describe this hybrid mechanism of metal bioaccumulation via intercalation into preformed, biogenic crystals, and note also that MECHM can promote the removal of the transuranic radionuclide neptunium, which is difficult to achieve by conventional methods.

From bio-mineralisation to fuel cells: biomanufacture of Pt and Pd nanocrystals for fuel cell electrode catalyst.

Biosynthesis of nano-scale platinum and palladium was achieved via enzymatically-mediated deposition of metal ions from solution. The bio-accumulated Pt(0) and Pd(0) crystals were dried, applied onto carbon paper and tested as anodes in a polymer electrolyte membrane (PEM) fuel cell for power production. Up to 100% and 81% of the maximum power generation was achieved by the bio-Pt and bio-Pd catalysts, respectively, compared to commercial fuel cell grade Pt catalyst. Hence, biomineralisation could pave the way for economical production of fuel cell catalysts since previous studies have shown that precious metals can be biorecovered from wastes into catalytically active bionanomaterials.

Enzymically accelerated biomineralization of heavy metals: application to the removal of americium and plutonium from aqueous flows.

A biological process for the removal of heavy metals from the aqueous flows is described. Metals are precipitated on the surface of immobilized cells of a Citrobacter sp. as cell-bound metal phosphates. This uses phosphate liberated by the activity of a cell-bound phosphatase. Some radionuclides (e.g. 241americium) form metal phosphates readily; efficient removal of 241Am on a continuous basis is demonstrated. At low phosphatase activities, the efficiency of uranium removal correlates with enzyme activity. High phosphatase activities are not realised as an increase in metal removal, suggesting that chemical events become rate-limiting. Studies have suggested that maximal metal uptake occurs only after nucleation and the formation of precipitation foci. A model is presented to illustrate how nucleation and crystallization processes could enhance the removal of plutonium and neptunium from dilute solutions.

Phosphatase production by a Citrobacter sp. growing in batch cultures retarded by anaerobic or osmotic stress, and the effect of the osmoprotectant glycine betaine.

The effect of 500 mM NaCl on the growth, and phosphatase production of a Citrobacter sp. was investigated. Although growth was retarded, phosphatase production was enhanced by 50%. Relief from osmotic stress using the osmoprotectant glycine betaine gave normal growth, but phosphatase activity was reduced. The Citrobacter sp. ceased to grow following a shift to anaerobic conditions, but anaerobically-incubated cells continued to produce phosphatase after a transient lag.

Phosphatase-mediated heavy metal accumulation by a Citrobacter sp. and related enterobacteria.

A Citrobacter sp. was reported previously to accumulate heavy metals as cell-bound heavy metal phosphates. Metal uptake is mediated by the activity of a periplasmic acid-type phosphatase that liberates inorganic phosphate to provide the precipitant ligand for heavy metals presented to the cells. Amino acid sequencing of peptide fragments of the purified enzyme revealed significant homology to the phoN product (acid phosphatase) of some other enterobacteria. These organisms, together with Klebsiella pneumoniae, previously reported to produce acid phosphatase, were tested for their ability to remove uranium and lanthanum from challenge solutions supplemented with phosphatase substrate. The coupling of phosphate liberation to metal bioaccumulation was limited to the metal accumulating Citrobacter sp.; therefore the participation of species-specific additional factors in metal bioaccumulation was suggested.

Fungal volatilization of arsenic and antimony and the sudden infant death syndrome.

Fungal volatilization of antimony and other group Vb elements has been proposed to have a causal role in the sudden infant death syndrome (SIDS; cot death). The ability of fungi to produce volatile arsenic and antimony compounds in pure culture was examined using Scopulariopsis brevicaulis, reported as an inhabitant of PVC cot mattress covers, and Phaeolus schweinitzii, a wood decay fungus known to be a good volatilizer of arsenic. Volatile arsenic compounds were detected from all cultures grown on arsenic-supplemented media, but antimony volatilization was not reliably detected. Although antimony levels above the baseline sensitivity of the analytical technique were detected in four (out of 24) of the samples analyzed, the concentrations recorded were too low to be reliably interpreted as evidence for volatilization. Our results are discussed in relation to hypotheses regarding the causes of SIDS.

The biodegradation of tributyl phosphate by naturally occurring microbial isolates.

The biodegradation of tributyl phosphate by a mixed culture of Pseudomonads was demonstrated. Growth and the rate of tributyl phosphate consumption were variable and divisible into rapid and slow rates. Rapidly growing, rapidly tributyl phosphate-utilising cultures contained a 22-24 kb DNA fragment isolated by two methods, which was not visible in the cultures growing slowly. The mixed culture gave five periods of rapid growth interspersed with periods of poor growth during 7 months of weekly subculture, with the 22-24 kb DNA fragment detectable during the rapidly growing periods only. Seven Pseudomonads isolated from the culture grew at the expense of tributyl phosphate as the sole phosphorus source but spontaneously and irreversibly lost this ability after eight serial subcultures.