Impact of water activity and temperature on growth and alternariol and alternariol monomethyl ether production of Alternaria alternata isolated from soybean.

The objective of this study was to determine the effect of water activity (a(w); 0.995, 0.98, 0.96, 0.94, 0.92, and 0.90), temperature (5, 18, 25, and 30 degrees C), incubation time (7 to 35 days), and their interactions on mycelial growth and alternariol (AOH) and alternariol monomethyl ether (AME) production. Two Alternaria alternata strains isolated from soybeans in Argentina were grown on 2% soybean extract agar. Maximum growth rates were obtained at the highest a(w) (0.995) and 25 degrees C, with growth decreasing as the water availability of the medium was reduced. Maximum amount of AOH was produced at 0.98 a(w) and 25 degrees C for both strains. Maximum AME production was obtained for both strains at 30 degrees C but different a(w) values, 0.92 and 0.94, for the strains RC 21 and RC 39, respectively. The concentrations of both toxins varied considerably depending on the a(w) and temperature interactions assayed. The two metabolites were produced from 5 to 30 degrees C and at a(w) values of 0.92 to 0.995. Although at 5 and 18 degrees C little mycotoxin was produced at a(w) lower than 0.94. Two-dimensional profiles of a(w) by temperature interactions were developed from these data to identify areas where conditions indicate a significant risk from AOH and AME accumulation on soybeans. All the conditions of a(w) and temperature that resulted in maximum production of both toxins are those found during soybean development in the field. Thus, field conditions are likely to be conducive to optimum A. alternata growth and toxin production.

Effect of environmental factors on tenuazonic acid production by Alternaria alternata on soybean-based media.

AIMS: To determine the effects of water activity (a(W); 0.995-0.90), temperature (5, 18, 25 and 30 degrees C), time of incubation (7-35 days) and their interactions on tenuazonic acid (TA) production on 2% soybean-based agar by two Alternaria alternata strains isolated from soybean in Argentina. METHODS AND RESULTS: TA production by two isolates of A. alternata was examined under interacting conditions of a(W), temperature and time of incubation on 2% soybean-based agar. Maximum TA production was obtained for both strains at 0.98 a(W), but at 30 and 25 degrees C for the strains for RC 21 and RC 39, respectively. The toxin concentration varied considerably depending on a(W), temperature, incubation time and strain interactions. TA was produced over the temperature range from 5 to 30 degrees C and a(W) range from 0.92 to 0.995, however at 5 and 18 degrees C little TA was produced at a(W) below 0.94. Contour maps were developed from these data to identify areas where conditions indicate a significant risk for TA accumulation. CONCLUSIONS: The optimum and marginal conditions for TA production by A. alternata on soybean-based agar were identified. The results indicated that TA production by A. alternata is favoured by different temperatures in different strains. SIGNIFICANCE AND IMPACT OF THE STUDY: Data obtained provide very useful information for predicting the possible risk factors for TA contamination of soybean as the a(W) and temperature range used in this study simulate those occurring during grain ripening. The knowledge of TA production under marginal or sub-optimal temperature and a(W) conditions for growth are relevant as improper storage conditions accompanied by elevated temperature and moisture content in the grain can favour further mycotoxin production and lead to reduction in grain quality.

Natural occurrence of alternariol and alternariol monomethyl ether in soya beans.

The natural occurrence of alternariol (AOH) and alternariol monomethyl ether (AME) in soya beans harvested in Argentina was evaluated. Both toxins were simultaneously detected by using HPLC analysis coupled with a solid phase extraction column clean-up. Characteristics of this in-house method such as accuracy, precision and detection and quantification limits were defined by means of recovery test with spiked soya bean samples. Out of 50 soya bean samples, 60% showed contamination with the mycotoxins analyzed; among them, 16% were only contaminated with AOH and 14% just with AME. Fifteen of the positive samples showed co-occurrence of both mycotoxins analyzed. AOH was detected in concentrations ranging from 25 to 211 ng/g, whereas AME was found in concentrations ranging from 62 to 1,153 ng/g. Although a limited number of samples were evaluated, this is the first report on the natural occurrence of Alternaria toxins in soya beans and is relevant from the point of view of animal public health.

Natural deoxynivalenol occurrence and genotype and chemotype determination of a field population of the Fusarium graminearum complex associated with soybean in Argentina.

Soybean (Glycine max L.), the main source of protein throughout the world, is used both as a food and a feedstuff. Currently, limited information about the occurrence of Fusarium species and mycotoxins in soybean grain and by-products is available. The aims of the present study were: (1) to identify toxigenic Fusarium species associated with soybean during crop reproductive stages; (2) to determine the occurrence of deoxynivalenol (DON) and nivalenol (NIV) in soybean seeds; (3) to determine the genotype and chemotype of selected Fg complex strains using molecular and chemical analysis, respectively; and (4) to characterize the strains using AFLP(s) markers. One soybean field located at Córdoba Province, Argentina, was monitored and samples of soybean tissue were harvested at three reproductive stages: flowering (R2), full seed (R6) and full maturity (R8). A total of 389 Fusarium strains F. equiseti (40%) was the most frequently species recovered followed by F. semitectum (27%) and F. graminearum (Fg) (11%). From the 40 soybean samples analysed, only two presented detectable DON levels. Based on DON occurrence on soybean seeds at ripening stages, the toxigenic ability of Fg complex strains isolated from soybean seeds, pods and flowers were analysed. The trichothecene genotype was determined by a multiplex PCR using primers based on Tri3, Tri5 and Tri7 toxin genes and then the chemotype was verified by chemical analysis. Most Fg complex strains showed 15-ADON genotype and five strains presented a DON/NIV; these also produced both toxins under in vitro culture. Neither the NIV nor the 3-ADON genotypes were detected among the members of the population evaluated. All the 15-ADON genotype strains were characterized as F. graminearum sensu stricto (lineage 7), while the strains presented a DON/NIV genotype were characterized as F. meridionale (lineage 2). The present study contributes new information on the occurrence of Fusarium species and trichothecenes toxins on soybean at the pre-harvest stages. Also, this is the first report on the chemotype, genotype and lineages among Fg complex isolated from soybean.