Medium composition and aeration to high (R,R)-2,3-butanediol and acetoin production by Paenibacillus polymyxa in fed-batch mode.

Concerning the potential application of the optically active isomer (R,R)-2,3-butanediol, and its production by a non-pathogenic bacterium Paenibacillus polymyxa ATCC 842, the present study evaluated the use of a commercial crude yeast extract Nucel®, as an organic nitrogen and vitamin source, at different medium composition and two airflows (0.2 or 0.5 vvm). The medium formulated (M4) with crude yeast extract carried out with the airflow of 0.2 vvm (experiment R6) allowed for a reduction in the cultivation time and kept the dissolved oxygen values at low levels until the total glucose consumption. Thus, the experiment R6 led to a fermentation yield of 41% superior when compared to the standard medium (experiment R1), which was conducted at airflow of 0.5 vvm. The maximum specific growth rate at R6 (0.42 h-1) was lower than R1 (0.60 h-1), however, the final cell concentration was not affected. Moreover, this condition (medium formulated-M4 and low airflow-0.2 vvm) was a great alternative to produce (R,R)-2,3-BD at fed-batch mode, resulting in 30 g.L-1 of the isomer at 24 h of cultivation, representing the main product in the broth (77%) and with a fermentation yield of 80%. These results showed that both medium composition and oxygen supply have an important role to produce 2,3-BD by P. polymyxa.

Correction to: High lactobionic acid production by immobilized Zymomonas mobilis cells: a great step for large-scale process.

In the original publication, table captions were incorrectly published. The correct captions are given here.

High lactobionic acid production by immobilized Zymomonas mobilis cells: a great step for large-scale process.

Lactobionic acid and sorbitol are produced from lactose and fructose in reactions catalyzed by glucose-fructose oxidoreductase and glucono-δ-lactonase, periplasmic enzymes present in Zymomonas mobilis cells. Considering the previously established laboratory-scale process parameters, the bioproduction of lactobionic acid was explored to enable the transfer of this technology to the productive sector. Aspects such as pH, temperature, reuse and storage conditions of Ca-alginate immobilized Z. mobilis cells, and large-scale bioconversion were assessed. Greatest catalyst performance was observed between pH range of 6.4 and 6.8 and from 39 to 43 °C. The immobilized biocatalyst was reused for twenty three 24-h batches preserving the enzymatic activity. The activity was maintained during biocatalyst storage for up to 120 days. Statistically similar results, approximately 510 mmol/L of lactobionic acid, were attained in bioconversion of 0.2 and 3.0 L, indicating the potential of this technique of lactobionic acid production to be scaled up to the industrial level.

Assessment of different systems for the production of aldonic acids and sorbitol by calcium alginate-immobilized Zymomonas mobilis cells.

Equimolar amounts of lactobionic acid and sorbitol may be obtained in a reaction catalyzed by the enzymes glucose-fructose oxidoreductase and glucono-δ-lactonase, which are found in the periplasm of Zymomonas mobilis. These reactions are generally conducted using immobilized bacterial cells, and the cell treatment and immobilization steps are costly and time-consuming. This study evaluated alternatives to simplify the preparation of calcium alginate-immobilized biocatalyst and its application in different operation modes and types of reactors. It was possible to eliminate cell permeabilization with cetyltrimethylammonium bromide, and the reticulation of Z. mobilis cells with glutaraldehyde sufficed to inhibit the fermentative metabolism of carbohydrates by the bacterium, with accumulation of bioconversion products. When the process was carried out in a mechanically stirred reactor in batch mode, 530 mmol L- 1 of products were obtained in 24 h. The process was also tested in fed-batch mode so as to use of a larger amount of lactose, since it could not be used in the batch because of its low solubility in water. Under this condition, final products concentration reached 745 mmol L- 1 within 42 h. Similar results were obtained for reactions conducted in a pneumatically stirred reactor in batch and fed-batch modes, proving the potential use of this process in several industrial settings.

Production of organic acids by periplasmic enzymes present in free and immobilized cells of Zymomonas mobilis.

In this work the periplasmic enzymatic complex glucose-fructose oxidoreductase (GFOR)/glucono-δ-lactonase (GL) of permeabilized free or immobilized cells of Zymomonas mobilis was evaluated for the bioconversion of mixtures of fructose and different aldoses into organic acids. For all tested pairs of substrates with permeabilized free-cells, the best enzymatic activities were obtained in reactions with pH around 6.4 and temperatures ranging from 39 to 45 °C. Decreasing enzyme/substrate affinities were observed when fructose was in the mixture with glucose, maltose, galactose, and lactose, in this order. In bioconversion runs with 0.7 mol l(-1) of fructose and with aldose, with permeabilized free-cells of Z. mobilis, maximal concentrations of the respective aldonic acids of 0.64, 0.57, 0.51, and 0.51 mol l(-1) were achieved, with conversion yields of 95, 88, 78, and 78 %, respectively. Due to the important applications of lactobionic acid, the formation of this substance by the enzymatic GFOR/GL complex in Ca-alginate-immobilized cells was assessed. The highest GFOR/GL activities were found at pH 7.0-8.0 and temperatures of 47-50 °C. However, when a 24 h bioconversion run was carried out, it was observed that a combination of pH 6.4 and temperature of 47 °C led to the best results. In this case, despite the fact that Ca-alginate acts as a barrier for the diffusion of substrates and products, maximal lactobionic acid concentration, conversion yields and specific productivity similar to those obtained with permeabilized free-cells were achieved.

Oxygen supply in Bacillus thuringiensis fermentations: bringing new insights on their impact on sporulation and δ-endotoxin production.

The growth kinetics, sporulation, and toxicity of Bacillus thuringiensis var. israelensis were evaluated through the analysis of batch cultures with different dissolved oxygen (DO) profiles. Firstly, DO was maintained constant at 5%, 20%, or 50% throughout fermentation in order to identify the most suitable one to improve the main process parameters. Higher biomass concentration, cell productivity, and cell yield based on glucose were obtained with 50% DO. The higher aeration level also resulted in higher spore counts and markedly improved the toxic activity of the fermentation broth, which was 9-fold greater than that obtained with 5% DO (LC(50) of 39 and 329 mg/L, respectively). Subsequently, using a two-stage oxygen supply strategy, DO was kept at 50% during the vegetative and transition phases until the maximum cell concentration was achieved. Then, DO was changed to 0%, 5%, 20%, or 100% throughout sporulation and cell lysis phases. The interruption of oxygen supply strongly reduced the spore production and thoroughly repressed the toxin synthesis. On the contrary, when DO was raised to 100% of saturation, toxic activity increased approximately four times (LC(50) of 8.2 mg/L) in comparison with the mean values reached with lower DO levels, even though spore counts were lower than that from the 50% DO assay. When pure oxygen was used instead of normal air, it was possible to obtain 70% of the total biomass concentration achieved in the air assays; however, cultures did not sporulate and the toxin synthesis was consequently suppressed.

Glycine betaine enhances growth of nitrogen-fixing bacteria Gluconacetobacter diazotrophicus PAL5 under saline stress conditions.

In this study, the effect of glycine betaine as osmoprotectant compound for Gluconacetobacter diazotrophicus PAL5 was evaluated by kinetic growth parameters. Batch fermentation assays were performed employing media supplemented with different sodium chloride concentrations to simulate saline stress conditions. Salt concentrations of 50-300 mM led to decreased cell concentrations, while the maximum specific growth rates and cell productivities were reduced at concentrations above 100-mM NaCl. Salt inhibition was mainly observed in media with 200- and 300-mM NaCl, in which drastic changes in cell morphology were also noted. The addition of glycine betaine to the media showed to be efficient to counteract the salt inhibitory effect by increasing some fermentation parameters. However, the osmoprotectant was not able to revert the polymorphism promoted by higher salt concentrations.

Sodium, potassium, calcium lactobionates, and lactobionic acid from Zymomonas mobilis: A novel approach about stability and stress tests.

The bioproduction of lactobionic acid and its salts can be performed by enzymatic complex glucose-fructose oxidoreductase (GFOR) and glucono-δ-lactonase (GL) of Zymomonas mobilis. Considering the applicability of these compounds in pharmaceutical area, the aim of this study was to assess the accelerated and long-term stability studies of sodium, potassium, calcium lactobionate, and lactobionic acid. Furthermore, stress tests were performed to evaluate the stability against pH, temperature and oxidation. The samples submitted to degradation tests were analyzed by high-performance liquid chromatography (HPLC) and high-resolution mass spectrometry analysis (HRMS-ESI-QTOF). Sodium, potassium, and calcium lactobionate were stable for six months of analyses considering the accelerated (40 °C and 75% RH) and long-term (30 °C and 75% RH) stability studies. The presence of lactobiono-δ-lactone and a significant increase in moisture were observed for both biosynthesized and commercially available lactobionic acid samples. Against the forced degradation tests, all the lactobionate salts and lactobionic acid showed to be stable upon alkaline and acid pH conditions, at 60 and 80 °C, and also against UV light exposition. Furthermore, the presence of lactobiono-δ-lactone form was observed in lactobionic acid samples. However, the degradation of both lactobionic acid and lactobionate salts was evident in the presence of hydrogen peroxide. This degradation kinetic profile suggests, that lactobionate salts follows a zero-order reaction model and lactobionic acid follows a second-order kinetic. The MS analysis of the main degradation product suggests a molecular formula C11H20O10 resulting from the oxidative decarboxylation. This report brings an amount of results as contribution to the scarce information regarding the chemical and physical-chemical stability of sodium, potassium, calcium lactobionate, and lactobionic acid. These data may be useful and serve as reference, in view of the multipurpose applications of the cited compounds.

The influence of sorbitol on the production of cellulases and xylanases in an airlift bioreactor.

The production of cellulases and xylanases by Penicillium echinulatum in an airlift bioreactor was evaluated. In batch production, we tested media with isolated or associated cellulose and sorbitol. In fed-batch production, we tested cellulose addition at two different times, 30 h and 48 h. Higher liquid circulation velocities in the downcomer were observed in sorbitol 10 g L(-1) medium. In batch production, higher FPA (filter paper activity) and endoglucanase activities were obtained with cellulose (7.5 g L(-1)) and sorbitol (2.5 g L(-1)), 1.0 U mL(-1) (120 h) and 6.4 U m L(-1) (100 h), respectively. For xylanases, the best production condition was cellulose 10 g L(-1), which achieved 5.5 U mL(-1) in 64 h. The fed-batch process was favorable for obtaining xylanases, but not for FPA and endoglucanases, suggesting that in the case of cellulases, the inducer must be added early in the process.

Production of polygalacturonases by Aspergillus oryzae in stirred tank and internal- and external-loop airlift reactors.

The production of endo- and exo-polygalacturonase (PG) by Aspergillus oryzae was assessed in stirred tank reactors (STRs), internal-loop airlift reactors (ILARs) and external-loop airlift reactors (ELARs). For STR production, we compared culture media formulated with either pectin (WBE) or partially hydrolyzed pectin. The highest enzyme activities were obtained in medium that contained 50% pectin in hydrolyzed form (WBE5). PG production in the three reactor types was compared for WBE5 and low salt WBE medium, with additional salts added at 48, 60 and 72h (WBES). The ELARs performed better than the ILARs in WBES medium where the exo-PG was the same concentration as for STRs and the endo-PG was 20% lower. These results indicate that PG production is higher under experimental conditions that result in higher cell growth with minimum pH values less than 3.0.

Comparison of stirred tank and airlift bioreactors in the production of polygalacturonases by Aspergillus oryzae.

The production of endo and exo-polygalacturonase (PG) by Aspergillus oryzae IPT 301 was studied in a stirred tank bioreactor (STR) and an internal circulation airlift bioreactor. Using a factorial experimental design, a soluble culture medium was defined which allowed the production of exo- and endo-PG comparable to that obtained in a medium containing suspended wheat bran. The soluble medium was used in tests to compare the production of these enzymes in the STR and airlift bioreactor. In these tests, after 96 h, maximum enzymatic activity values achieved for exo- and endo-PG were 65.2 units (U) per mL and 91.3 U mL(-1), in the STR, with similar activity values of 60.6 U mL(-1) and 86.2 U mL(-1), respectively, being achieved in the airlift bioreactor. The airlift bioreactor also showed satisfactory results regarding the oxygen transfer rate in this process, indicating its potential to be used in an eventual larger scale production of exo- and endo-PG, with lower costs for both installation and operation.