Quantitative management of human faecal bulking response to combinations of functionally distinct dietary fibers, using functional equivalents and a validated rat model.

Functionally distinct dietary fibre sources may be combined in reformulated foods to restore a natural spectrum of health attributes. Effects of wheat bran (WB), psyllium husk, guar gum and Raftilose™ combinations on hydrated faecal mass (HFM), were determined. A valid rat model was fed diets supplemented with 10% WB, 10% WB with 1-6% psyllium in 1% steps, and 10% WB/5% psyllium with 1-7% guar gum or 1-6% Raftilose in 1% steps. Fully hydrated faecal pellets gave HFM values in the human range, increasing by 2.4 ± 0.29 g per gram of WB ingested, and by 15.6 ± 1.52 g per g of psyllium. Equations for incremental changes in HFM predicted intakes of fibre combinations required for adequate daily HFM, and it is shown how expressing relative effects of foods on HFM as functional equivalents would allow quantitative personalised management of HFM for reduced constipation and colorectal cancer in humans.

Hydrothermal Treatment of Wheat Bran under Mild Acidic or Alkaline Conditions for Enhanced Polyphenol Recovery and Antioxidant Activity.

This study was undertaken to investigate the effects of hydrothermal treatments under mild acid and alkaline conditions on polyphenol release and recovery from wheat bran (WB). After an initial screening of various food-grade substances, strong evidence was raised regarding the potency of citric acid and sodium carbonate to provide WB extracts exceptionally enriched in polyphenols. Thus, these two catalysts were tested under various time and temperature combinations, and the processes were described by linear models based on severity factor. The most effective treatments were those performed with 10% of either citric acid or sodium carbonate, at a constant temperature of 90 °C for 24 h, providing yields in total polyphenols of 23.76 and 23.60 mg g-1 dry mass of ferulic acid equivalents, respectively. Liquid chromatography-mass spectrometry analyses revealed that, while the sodium carbonate treatment afforded extracts enriched in ferulic acid, treatments with citric acid gave extracts enriched in a ferulate pentose ester. The extracts produced from those treatments also exhibited diversified antioxidant characteristics, a fact ascribed to the different polyphenolic composition. To the best of the authors' knowledge, this is the first report demonstrating the effective release of ferulic acid and a ferulate pentose ester from WB, using benign acid and alkali catalysts, such as citric acid and sodium carbonate.

Structure Characterization and Dye Adsorption Properties of Modified Fiber from Wheat Bran.

The fibers from four wheat varieties (FT, XW 26, XW 45, and KW 1701) were selected and chemically modified with NaOH, epichlorohydrin, and dimethylamine to improve the adsorption capacity for anionic dye. The structure of the fibers with or without modification was characterized by scanning electron microscope (SEM), X-ray diffraction (XRD), and Fourier-transform infrared (FTIR) spectrometry. The modified products were studied from the aspects of adsorption capacities, adsorption kinetics, and thermodynamics to provide a reference for the utilization of wheat bran. By SEM, more porous and irregular structures were found on the modified fibers. The XRD results showed that the crystals from the original fibers were destroyed in the modification process. The changes in fibers' infrared spectra before and after modification suggested that quaternary ammonium salts were probably formed in the modification process. The maximum adsorption capacity of wheat bran fibers for Congo red within 120 min was 20 mg/g for the unmodified fiber (XW 26) and 93.46 mg/g for the modified one (XW 45). The adsorption kinetics of Congo red by modified wheat bran fiber was in accord with the pseudo-second-order kinetic model at 40 °C, 50 °C, and 60 °C, indicating that the adsorption process might be mainly dominated by chemisorption. The adsorption was more consistent with the Langmuir isothermal adsorption model, implying that this process was monolayer adsorption. The thermodynamic parameters suggested that the adsorption occurred spontaneously, and the temperature increase was favorable to the adsorption. As mentioned above, this study proved that the wheat bran fiber could possess good adsorption capacities for anion dye after chemical modification.

Optimization of phytase production by Penicillium oxalicum in solid-state fermentation for potential as a feed additive.

The study aims to statistically optimize the phytase production by Penicillium oxalicum PBG30 in solid-state fermentation using wheat bran as substrate. Variables viz. pH, incubation days, MgSO4, and Tween-80 were the significant parameters identified through the Plackett-Burman design (PBD) that majorly influenced the phytase production. Further, central composite design (CCD) method of response surface methodology (RSM) defined the optimum values for these factors i.e., pH 7.0, 5 days of incubation, 0.75% of MgSO4, and 3.5% of Tween-80 that leads to maximum phytase production of 475.42 U/g DMR. Phytase production was also sustainable in flasks and trays of different sizes with phytase levels ranging from 394.95 to 475.42 U/g DMR. Enhancement in phytase production is 5.6-fold as compared to unoptimized conditions. The in-vitro dephytinization of feed showed an amelioration in the nutritive value by releasing inorganic phosphate and other nutrients in a time-dependent manner. The highest amount of inorganic phosphate (33.986 mg/g feed), reducing sugar (134.4 mg/g feed), and soluble protein (115.52 mg/g feed) was achieved at 37 °C with 200 U of phytase in 0.5 g feed for 48 h. This study reports the economical and large-scale production of phytase with applicability in enhancing feed nutrition.

Purification and biochemical characterization of novel α-amylase and cellulase from Bacillus sp. PM06.

Bacillus sp. PM06, previously isolated from sugarcane waste pressmud, could produce dual enzymes α-amylase and cellulase. The isolate's crude enzymes were purified homogeneously using ammonium sulfate precipitation followed by High Quaternary amine anion exchange chromatography. Purified enzymes revealed the molecular weights of α-amylase and cellulase as 55 and 52 kDa, with a purification fold of 15.4 and 11.5, respectively. The specific activity of purified α-amylase and cellulase were 740.7 and 555.6 U/mg, respectively. It demonstrated a wide range of activity from pH 5.0 to 8.5, with an optimum pH of 5.5 and 6.4 for α-amylase and cellulase. The optimum temperature was 50 °C for α-amylase and 60 °C for cellulase. The kinetic parameters of purified α-amylase were 741.5 ± 3.75 µmol/min/mg, 1.154 ± 0.1 mM, and 589 ± 3.5/(s mM), using starch as a substrate. Whereas cellulase showed 556.3 ± 1.3 µmol/min/mg, 1.78 ± 0.1 mM, and 270.9 ± 3.8/(s mM) of Vmax, Km, Kcat/Km, respectively, using carboxymethyl cellulose (CMC) as substrate. Among the various substrates tested, α-amylase had a higher specificity for amylose and CMC for cellulase. Different inhibitors and activators were also examined. Ca2+ Mg2+, Co2+, and Mn2+ boosted α-amylase and cellulase activities. Cu2+ and Ni2+ both inhibited the enzyme activities. Enzymatic saccharification of wheat bran yielded 253.61 ± 1.7 and 147.5 ± 1.0 mg/g of reducing sugar within 12 and 24 h of incubation when treated with purified α-amylase and cellulase. A more significant amount of 397.7 ± 1.9 mg/g reducing sugars was released from wheat bran due to the synergetic effect of two enzymes. According to scanning electron micrograph analysis, wheat bran was effectively broken down by both enzymes.

Effects of airflow superfine pulverization on the structure, functional properties, and flavor quality of wheat bran.

BACKGROUND: Wheat bran (WB) is a byproduct of refined wheat flour production with poor edible taste and low economic value. Herein, the WB was micronized via airflow superfine pulverization (ASP), and the effects of the ASP conditions on its particle size, nutritive compositions, whiteness, hydration characteristics, moisture distribution, microstructure, cation exchange capacity, volatile flavor components, and other characteristics were investigated. RESULTS: Reducing the rotational speed of the ASP screw and increasing the number of pulverizations significantly decreased the median particle size Dx(50) of WB to a minimum of 12.97 ± 0.19 µm (P < 0.05), increased the soluble dietary fiber content from 55.05 ± 2.94 to 106.86 ± 1.60 mg g-1, and improved the whiteness and water solubility index. In addition, the water holding capacity and oil holding capacity were significantly reduced (P < 0.05), while the cation exchange and swelling capacities first increased and then decreased. Up to about 70% of water in WB exists as bound water. As the Dx(50) of WB decreased, the content of bound and immobile water increased, while the free water decreased from 14.37 ± 1.21% to 7.59 ± 1.03%. Furthermore, WB was micronized and the particles became smaller and more evenly distributed. Using gas chromatography-ion mobility spectrometry, a total of 37 volatile compounds in micronized WB (including 10 aldehydes, 9 esters, 7 alcohols, and several acids, furans, ethers, aldehydes, esters, and alcohols) were identified as the main volatile compounds of WB. CONCLUSION: Collectively, ASP improved the physicochemical properties of WB. This study provides theoretical references for the use of ASP to improve the utilization and edibility of WB. © 2024 Society of Chemical Industry.

Wheat bran arabinoxylans: Chemical structure, extraction, properties, health benefits, and uses in foods.

Wheat bran (WB) is a well-known and valuable source of dietary fiber. Arabinoxylan (AX) is the primary hemicellulose in WB and can be isolated and used as a functional component in various food products. Typically, AX is extracted from the whole WB using different processes after mechanical treatments. However, WB is composed of different layers, namely, the aleurone layer, pericarp, testa, and hyaline layer. The distribution, structure, and extractability of AX vary within these layers. Modern fractionation technologies, such as debranning and electrostatic separation, can separate the different layers of WB, making it possible to extract AX from each layer separately. Therefore, AX in WB shows potential for broader applications if it can be extracted from the different layers separately. In this review, the distribution and chemical structures of AX in WB layers are first discussed followed by extraction, physicochemical properties, and health benefits of isolated AX from WB. Additionally, the utilization of AX isolated from WB in foods, including cereal foods, packaging film, and the delivery of food ingredients, is reviewed. Future perspectives on challenges and opportunities in the research field of AX isolated from WB are highlighted.

Stimbiotic and wheat bran inclusion in maize or wheat-based diets for broiler chickens; effects on jejunal histomorphology, digesta oligosaccharides and caecal short-chain fatty-acids profiles.

1. A stimbiotic (STB) is any feed additive that stimulates caeca fibre fermentation, although the additive itself contributes little to the caeca short-chain fatty acid (SCFA) production. A 42 d experiment investigated the interactive effects of STB and wheat bran (WB) in broiler chickens receiving maize or wheat-based diets.2. The treatments were arranged in a 2 × 2 × 2 factorial (eight replicates each), the dietary factors being diet (maize-SBM or wheat-SBM), STB (with or without) and WB (0 or 50 g/kg). Jejunal tissue, gizzard, jejunal and ileal digesta and caecal contents were collected on d 18 and 42.3. Gizzard pH tended to decrease with STB (p = 0.06) supplementation and was lower in birds fed wheat- compared to maize-based diets on d 18 (p < 0.05). Birds receiving diets with WB had higher jejunum pH on d 18 (p < 0.05).4. Total short-chain fatty acids (SCFA) in the caeca on d 18 and isobutyrate on d 42 were higher (p < 0.05) for maize compared with wheat-based diets. However, on d 42, acetate, butyrate and total SCFA were higher (p < 0.05) for wheat-based compared with maize-based diets.5. On d 18, STB and WB inclusion increased villi height (VH; p < 0.05) and VH to crypt depth ratio (VH/CD), respectively (p < 0.05). On d 42, VH (p < 0.05) and VH/CD were higher in wheat-based diets (p < 0.05). The VH/CD ratio was lower with STB supplementation (p < 0.05). Marker-corrected pentose oligosaccharides (Pent)4 and (Pent)5 concentrations in the ileal digesta were reduced (p < 0.05) with STB supplementation. In addition, STB decreased (Pent)3 concentration in maize-, but not wheat-based diets (p < 0.05).6. In conclusion, both WB and STB influenced gastrointestinal pH and jejunum histomorphology of broilers without increasing oligosaccharide concentration in the ileum and SCFA in the caeca.

Wheat bran layers: composition, structure, fractionation, and potential uses in foods.

Wheat bran, the main by-product of dry milling of wheat, is currently mainly used in the animal feed industry, but has attracted attention as a food ingredient owing to its high dietary fiber and phytochemical contents, providing excellent physiological effects. The bran layers (aleurone layer, outer pericarp and intermediate layer) contain different compositions, structures, and nutrients, and have different properties. Each layer, when separated and isolated, potentially could find more extensive applications in foods. This triggered interest in isolating the bran layers using milling and wet- or dry-fractionation techniques based on their chemical or physical properties. The recent progress has allowed the production of commercial products from wheat bran layers, particularly aleurone-rich products, enhancing the value of wheat bran layers and their applications in food. The present review highlights the recent advances in studying the chemical composition including distribution of chemical components, physical structure, biopolymer matrix, and physicochemical properties of each wheat bran layer. Technologies to fractionate wheat bran layers and utilization of different bran layers in foods are discussed and reviewed, providing new strategies for improving the value of wheat bran and utilization of wheat bran in foods.

Aqueous phase extractable protein of wheat bran and germ for the production of liquid and semi-solid foods.

To achieve a more sustainable global food production, a shift from animal to plant protein based food is necessary. At the same time, these plant proteins are preferentially derived from side-streams of industrial processes. Wheat bran and germ represent two major side-streams of the wheat milling industry, and contain aqueous-phase soluble proteins with a well-balanced amino acid composition. To successfully use wheat bran and germ proteins in novel plant-based liquid and semi-solid foods, they need to (i) be rendered extractable and (ii) contribute functionally to stabilizing the food system. Prior heat treatment and the occurrence of intact cell walls are important barriers in this regard. Several strategies have been applied to overcome these issues, including physical processing and (bio)chemical modification. We here present a comprehensive, critical overview of the aqueous-phase extraction of protein from (modified) wheat bran and germ. Moreover, we discuss the functionality of the extracted protein, specifically in the context of liquid (foam- and emulsion-type) and semi-solid (gel-type) food applications. In each section, we identify important knowledge gaps and highlight several future prospects that could further increase the application potential of wheat bran and germ proteins in the food industry.

Dilute acid pretreatment for enhancing the enzymatic saccharification of agroresidues using a Botrytis ricini endoglucanase.

The enormous amount of agroindustrial residues generated in Brazil can be used as biomass to produce fermentable sugars. This study compared the pretreatments with different proportions of dilute acid. The method involved pretreatment with 0.5%, 1%, and 1.5% (v/v) sulfuric acid, followed by hydrolysis using the halotolerant and thermostable endoglucanase from Botrytis ricini URM 5627. The physicochemical characterization of plant biomass was performed using XRD, FTIR, and SEM. The pretreatment significantly increased the production of fermentable sugars following enzymatic saccharification from wheat bran, sugarcane bagasse, and rice husk: 153.67%, 91.98%, and 253.21% increment in sugar production; 36.39 mg⋅g-1 ± 1.23, 39.55 mg⋅g-1 ± 1.70, and 42.53 mg⋅g-1 ± 7.61 mg⋅L-1 of glucose; and 3.26 ± 0.35 mg⋅g-1 , 3.61mg⋅g-1 ± 0.74 and 3.59 mg⋅g-1 ± 0.80 of fructose were produced, respectively. In conclusion, biomass should preferably be pretreated before the enzymatic saccharification using B. ricini URM 5627 endoglucanase.

Optimization of culture conditions for enhanced production of extracellular α-amylase using solid-state and submerged fermentation from Aspergillus tamarii MTCC5152.

Amylases are one of the main enzymes used in various industries such as food, fermentation, textile, and pharmaceuticals. Microorganisms are the potent sources of amylase enzyme, apart from plant and animal sources. Fungal amylases are more stable than bacterial amylases. The production of extracellular α-amylase from Aspergillus tamarii MTCC5152 using solid-state and submerged fermentation (SSF and SmF) and the various nutritional factors influencing its production were studied. A higher activity of α-amylase (519.40 u/g) was attained in a medium having wheat bran (WB) alone as the substrate at an initial moisture content of 70% (v/w) with 2.5% (v/w) of inoculum level (containing 106 spores/ml) after 4 days of incubation at 28°C by SSF. Addition of 1% glucose to WB containing basal medium enhanced α-amylase production (6.49 u/ml) after 4 days of incubation by SmF method. Comparative evaluation of enzyme production by SSF and SmF methods produced better results in SSF method.

Antioxidant, Immunostimulatory, and Anticancer Properties of Hydrolyzed Wheat Bran Mediated through Macrophages Stimulation.

Previous studies demonstrated that enzymatic hydrolysis enhances wheat bran (WB) biological properties. This study evaluated the immunostimulatory effect of a WB hydrolysate (HYD) and a mousse enriched with HYD (MH) before and after in vitro digestion on murine and human macrophages. The antiproliferative activity of the harvested macrophage supernatant on colorectal cancer (CRC) cells was also analyzed. MH showed significantly higher content than control mousse (M) in soluble poly- and oligosaccharides (OLSC), as well as total soluble phenolic compounds (TSPC). Although in vitro gastrointestinal digestion slightly reduced the TSPC bioaccessibility of MH, ferulic acid (FA) levels remained stable. HYD showed the highest antioxidant activity followed by MH, which demonstrated a greater antioxidant activity before and after digestion as compared with M. RAW264.7 and THP-1 cells released the highest amounts of pro-inflammatory cytokines after being treated with 0.5 mg/mL of digested WB samples. Treatment with digested HYD-stimulated RAW264.7 supernatant for 96 h showed the most anticancer effect, and spent medium reduced cancer cell colonies more than direct WB sample treatments. Although a lack of inner mitochondrial membrane potential alteration was found, increased Bax:Bcl-2 ratio and caspase-3 expression suggested activation of the mitochondrial apoptotic pathway when CRC cells were treated with macrophage supernatants. Intracellular reactive oxygen species (ROS) were positively correlated with the cell viability in CRC cells exposed to RAW264.7 supernatants (r = 0.78, p < 0.05) but was not correlated in CRC cells treated with THP-1 conditioned media. Supernatant from WB-stimulated THP-1 cells may be able to stimulate ROS production in HT-29 cells, leading to a decrease of viable cells in a time-dependent manner. Therefore, our present study revealed a novel anti-tumour mechanism of HYD through the stimulation of cytokine production in macrophages and the indirect inhibition of cell proliferation, colony formation, and activation of pro-apoptotic proteins expression in CRC cells.

Low-Cost Pocket Fluorometer and Chemometric Tools for Green and Rapid Screening of Deoxynivalenol in Durum Wheat Bran.

Cereal crops are frequently contaminated by deoxynivalenol (DON), a harmful type of mycotoxin produced by several Fusarium species fungi. The early detection of mycotoxin contamination is crucial for ensuring safety and quality of food and feed products, for preventing health risks and for avoiding economic losses because of product rejection or costly mycotoxin removal. A LED-based pocket-size fluorometer is presented that allows a rapid and low-cost screening of DON-contaminated durum wheat bran samples, without using chemicals or product handling. Forty-two samples with DON contamination in the 40-1650 µg/kg range were considered. A chemometric processing of spectroscopic data allowed distinguishing of samples based on their DON content using a cut-off level set at 400 µg/kg DON. Although much lower than the EU limit of 750 µg/kg for wheat bran, this cut-off limit was considered useful whether accepting the sample as safe or implying further inspection by means of more accurate but also more expensive standard analytical techniques. Chemometric data processing using Principal Component Analysis and Quadratic Discriminant Analysis demonstrated a classification rate of 79% in cross-validation. To the best of our knowledge, this is the first time that a pocket-size fluorometer was used for DON screening of wheat bran.

Dephytinization of wheat and rice bran by cross-linked enzyme aggregates of Mucor indicus phytase: a viable prospect for food and feed industries.

BACKGROUND: Novel feeds for improved feed intake and for enhanced nutrient bioavailability have recently attracted attention. Insoluble dietary fibers, especially rice and wheat bran, have generated much interest due to their nutritional value. Incorporating insoluble dietary fiber into diets could be a viable way to maximize the feed conversion ratio. RESULTS: Cross-linked phytase aggregates (CLPA) were synthesized by precipitating enzymes followed by cross-linking with 5 mmol L-1 glutaraldehyde, yielding 88.24 (U g-1 ) of enzyme load without the assistance of a proteic feeder. The epitome of the study is the dephosphorylation of wheat bran and rice bran by varying pH, enzyme concentration, and temperature. The highest inorganic phosphorus liberation by 150 U L--1 of free phytase was 23.72 (wheat bran) and 48.08 mg g-1 (rice bran) after 12 h of incubation.  Furthermore, 150 U L-1 of CLPA liberated 28.72 (wheat bran) and 52.08 mg g-1 (rice bran) of inorganic phosphorus with an incubation time of 12 h. CONCLUSION: Thermostable free phytase was insolubilized to dephosphorylate the agro-residue, namely, wheat bran and rice bran, to reduce the anti-nutritional factor (the phytate content) of these insoluble dietary fibers. © 2022 Society of Chemical Industry.

Role of bran particles in the formation of dark spots on fresh wet noodle sheets: what are the dark spots?

BACKGROUND: Dark spots may affect the appearance of fresh noodles during storage, even when made from flour with low ash content. The effect of flour bran content on the degree of dark spot formation in fresh wet noodle sheets (FWNS) is investigated to explain this phenomenon. RESULTS: Confocal laser scanning microscopy (CLSM) observation revealed that the wheat bran particles were responsible for the formation of dark spots on FWNS, with each bran particle core generating a single dark spot. In wheat flours with low ash content, the number of wheat bran particles causing dark spot formation on FWNS was limited, and these particles were not visible to the naked eye until their size exceeded approximately 50 µm. Tropolone, a polyphenol oxidase inhibitor (PubChem CID: 24900578) and dry heating treatment, which inactivates polyphenol oxidase, was found to inhibit or reduce the formation of dark spots. CONCLUSION: Based on these findings, it can be concluded that bran particles, rich in polyphenol oxidase, play a key role in dark spot formation. © 2023 Society of Chemical Industry.

Three thermal treated methods improve physicochemical and functional properties of wheat bran-germ and the bran-germ containing products.

BACKGROUND: To fully investigate the effect of different stabilization methods on WBG in the same environment, we studied the effect of microwaving, baking, and extrusion on the nutritional, physicochemical, and processability properties of WBG and whole wheat bran-germ noodle (WBGN). Principal component analysis was used to comprehensively evaluate the qualities of WBG and WBGN. Machine learning-based research was conducted to predict the quality of WBGN based on the features of WBG. RESULTS: The results showed that three methods improved antioxidant ability, bound flavonoids, bound and total phenolics, and the processing properties in WBG (P < 0.05). Extruded-WBG showed a lower polyphenol oxidase activity, lipase activity (35.02 ± 2.02 U and 20.29 ± 0.47 mg g-1 ) and particle size (54.08 ± 0.38 µm), and higher water hold capacity (2.60 ± 0.68%) and bound phenolic levels. The enhanced quantity of bound polyphenols had a major role in the increased antioxidant potential of WBGN. Extruded-WBGN showed higher antioxidant ability for 2,2-diphenyl-1-picrylhydrazyl (171.28 ± 3.16 µmol Trolox eq kg-1 ). The extruded-WBGN had high concentrations of WBG aroma compounds, and low contents of bitterness and raw bran-germ flavor compounds. Next, the enzymatic activity, powder properties, color, and antioxidant capacity of WBG were further utilized to predict the polyphenolic, flavonoids, flavor compounds, and antioxidant capacities of WBGN, where the R2 value of the model exceeded 0.90. The best comprehensive quality modification method of the WBG and WBGN was extrusion, followed by baking and microwaving. CONCLUSION: The present study shows that extrusion is a promising way to improve WBG into a nutritious and flavorful cereal food ingredient. © 2023 Society of Chemical Industry.

[Variations of glucose content in Massa Medicata Fermentata during processing based on quantitative proton nuclear magnetic resonance].

A quantitative proton nuclear magnetic resonance(qHNMR) method was established to determine the glucose content in commercially available Massa Medicata Fermentata(MMF) products and explore the variations of glucose content in MMF products during processing. The qHNMR spectrum of MMF in deuterium oxide was obtained with 2,2,3,3-d_4-3-(trimethylsilyl) propionate sodium salt as the internal standard substance. With the doublet peaks of terminal hydrogen of glucose with chemical shift at δ 4.65 and δ 5.24 as quantitative peaks, the content of glucose in MMF samples was determined. The glucose content showed a good linear relationship within the range of 0.10-6.44 mg·mL~(-1). The relative standard deviations(RSDs) of precision, stability, repeatability, and recovery for determination were all less than 2.3%. The glucose content varied in different commercially available MMF samples, which were associated with the different fermentation days, wheat bran-to-flour ratios, and processing methods. The glucose content in MMF first increased and then decreased over the fermentation time. Compared with the MMF products fermented with wheat bran or flour alone, the products fermented with both wheat bran and flour had increased glucose. The glucose content of bran-fried MMF was slightly lower than that of raw MMF, while the glucose content in charred MMF was extremely low. In conclusion, the qHNMR method established in this study is simple, fast, and accurate, serving as a new method for determining the glucose content in MMF. Furthermore, this study clarifies the variations of glucose content in MMF during processing, which can not only indicate the processing degree but also provide a scientific basis for revealing the fermentation mechanism and improving the quality control of MMF.

Production, Characterization and Prebiotic Potential of Xylooligosaccharides Produced from Wheat Bran using Enterobacter hormaechei KS1 Xylanase.

In the present investigation, xylooligosaccharides were produced from wheat bran and wheat bran extracted xylan through enzymatic hydrolysis using xylanase from novel Enterobacter hormaechei KS1. Xylooligosaccharides/reducing sugars production from wheat bran was found maximum (374 mg/g) when 4.0% of wheat bran was treated with 375 units (IU/mL) of Enterobacter hormaechei KS1 xylanase at pH 6.0 and incubated at 50 °C for 24 h of incubation. In case of wheat bran extracted xylan 419 mg/g of xylooligosaccharides were produced when 3% of extracted xylan was incubate for 8 h. Analysis of the enzymatic hydrolysate through high performance liquid chromatography equipped with refractive index detector showed the presence of xylose, xylopentose and xylohexose. The decrease in pH with 1.0% dose of xylooligosacchaides produced from extracted xylan hydrolysis using E. hormaechei KS1 xylanase showed more decrease with L. rhamnosus (6.72 to 5.94) followed by L. brevis (6.71 to 6.15) and L. plantarum (6.71 to 6.41). In case of increase in optical density both wheat bran and wheat bran extracted xylan generated xylooligosaccharides exhibited similar pattern i.e., L. rhamnosus > L. plantarum > L. brevis.

Isolation, characterization, and utilization of wheat bran protein fraction for food application.

Wheat bran (WB), a low-cost industrial by-product, is a vital source of high-quality proteins, minerals, vitamins, and several bioactive compounds. The present study encompasses the identification of appropriate bran streams of a commercial roller flour mill (CRFM) essentially based on hector liter weight, (HLW), optimization of WB protein isolation process, amino acid characterization, rendering more emphasis on simple water-soluble albumins, having higher commercial viability, and its application in food formulation. Total WB protein was 16.18% protein, the sum of the extracted proteins viz. albumin (2.43%), a prolamin (2.47%), glutelin (5.25%), globulin (1.92%), and insoluble proteins (4.09%) was 12.08%. Following albumin extraction, residual WB was subjected to ultra-sonication which further increased albumin protein yield from 2.43 to 3.07%. The extracted WB albumin isolate (WBAI) was utilized to develop high protein bread having significantly high volume and protein content, compared to control bread. The structural and sensorial attributes of the developed bread were superior compared to control bread. Thus, WBAI has a tremendous scope as a natural, affordable potential inexpensive food improver/fortificant to address protein-energy malnutrition (PEM). The process has the great advantage of being eco-friendly, besides, residual bran can still be used as cattle feed, enhancing profitability and viability.