RESUMEN
Composting is widely adopted in livestock waste management, and the ventilation system control is essential for composting efficiency. For ventilation system, the airflow resistance is a major factor influencing the ventilation intensity and oxygen supply capacity. This study explored the variation law of airflow resistance, bulk density, specific gravity, particle size and total pressure throughout composting with cattle manure. The airflow resistance was calculated with Ergun equation, and contribution coefficients of different components were analyzed with principal component analysis (PCA). Results showed that the viscous airflow resistance was dominant throughout cattle manure composting. The average airflow resistance was 0.146 Pa/m, and resistance of pile at lower layer was higher than that at the upper layer by 18.1 %. For contribution coefficient affecting airflow resistance, the ranks were bulk density, average particle size and specific gravity. During composting process, the average airflow resistance decreased by 40.1 % and the total pressure reduced by 3.47 %. All parameters had the greatest variation at thermophilic phase, which accounted for more than 60 % of the total variation amplitude. Meanwhile, less than 10 % of the total pressure was used to overcome the airflow resistance. Therefore, reducing bulk density of pile should be considered preferentially to decrease the airflow resistance. During cattle manure composting process, the total pressure of ventilation system ought to be adjusted with the aerobic reaction to a lower level, especially at thermophilic phase with the most rapid descent rate. This study can provide support for reducing the energy consumption required for ventilation of composting.
Asunto(s)
Compostaje , Administración de Residuos , Bovinos , Animales , Estiércol/análisis , Administración de Residuos/métodos , Ganado , SueloRESUMEN
In this study, a novel iron 1,3,5-benzene tricarboxylate loaded on biochar (BC-FeBTC) was developed and applied to kitchen waste composting. The results demonstrated that the emissions of NH3 and N2O were significantly reduced by 57.2% and 37.8%, respectively, compared with those in control group (CK). Microbiological analysis indicated that BC-FeBTC addition altered the diversity and abundance of community structure as well as key functional genes. The nitrification genes of ammonia-oxidizing bacteria were enhanced, thereby promoting nitrification and reducing the emission of NH3. The typical denitrifying bacterium, Pseudomonas, and critical functional genes (nirS, nirK, and nosZ) were significantly inhibited, contributing to reduced N2O emissions. Network analysis further revealed the important influence of BC-FeBTC in nitrogen transformation driven by functional microbes. These findings offer crucial scientific foundation and guidance for the application of novel materials aimed at mitigating nitrogen loss and environmental pollution during composting.
Asunto(s)
Carbón Orgánico , Compostaje , Óxido Nitroso , Óxido Nitroso/análisis , Desnitrificación , Amoníaco , Benceno , Suelo/química , Nitrógeno , Microbiología del SueloRESUMEN
Composting is an effective technology to realize resource utilization of food waste in rural China. However, high oil content in food waste limits composting humification. This study investigated the effects of blended plant oil addition at different proportions (0, 10, 20, and 30%) on the humification of food waste composting. Oil addition at 10%-20% enhanced lignocellulose degradation by 16.6%-20.8% and promoted humus formation. In contrast, the high proportion of oil (30%) decreased the pH, increased the electrical conductivity, and reduced the seed germination index to 64.9%. High-throughput sequencing showed that high oil inhibited the growth and reproduction of bacteria (Bacillus, Fodinicurvataceae, and Methylococcaceae) and fungi (Aspergillus), attenuated their interaction, thus, reducing the conversion of organic matter, such as lignocellulose, fat, and total sugar, to humus, consequently leading to negative impacts on composting humification. The results can guide composting parameter optimization and improve effective management of rural food waste.
Asunto(s)
Compostaje , Microbiota , Eliminación de Residuos , Alimentos , Suelo/química , EstiércolRESUMEN
Composting is an effective way to treat agricultural waste, whereas inappropriate initial conditions could cause lower maturity and system instability. In this study, the dissolved organic matter dynamics and microbial community succession of cattle-manure composting were investigated under different initial moisture content (MC) and pH of raw material. The results indicated that the extended duration of thermophilic phase and the highest GI (germination index) value of final product were observed at matrix 60% MC and pH 8.5 (AT2 treatment). Microbial analysis showed that the succession of bacterial and fungal community was significantly influenced by total carbon (TN), pH and MC (P < 0.05). The relationship between microbial community and fluorescence regional integration (FRI) parameters demonstrated that Thermobifida (bacterial genus), Mycothermus and Thermomyces (fungal genera) were positively correlated with PV, n (the integral aera of Region V). This study could provide a potential strategy for large-scale industrial application of compost.
Asunto(s)
Compostaje , Animales , Bovinos , Materia Orgánica Disuelta , Concentración de Iones de Hidrógeno , Estiércol , SueloRESUMEN
Heavy metals in farmland soil are one of the most hazardous pollutants in the environment, owing to their universality and irreversibility. Modified biochar has been widely used in the adsorption and immobilization of heavy metals in soil, and its applicability is mainly determined by the types of heavy metals, pollution levels, and soil environmental conditions. Soil pollution is gradually becoming more complex and diversified, and heavy metal pollutants mostly occur in the form of compound pollution. However, most studies have focused on single heavy metal pollutant or the addition of heavy metal to soil. This study used rice straw as a raw material to prepare biochar, and modified it with K3PO4, KMnO4, and NaOH. The physicochemical and structural characteristics of the modified biochars were detected using a BET accelerated surface area and porosimetry system, scanning electron microscopy (SEM), Fourier transform infrared spectroscopy (FT-IR), and the biochars were then analyzed for the availability and forms of Cd and Cu in soils contaminated with heavy metals in the mining area. The results showed that the surface roughness of the modified biochar increased to different degrees with increases in specific surface area and pore volume, with the NaOH modified biochar showing the most significant increases from 4.96 m2·g-1 to 60.79 m2·g-1, and from 0.02 cm3·g-1 to 0.12 cm3·g-1, respectively. The pore diameter changed in the opposite direction. The absorption peaks of the functional groups of the modified biochar were all changed, with K3PO4 modified biochar exhibiting the greatest degree of change. The addition of biochar significantly improved the soil pH value (P<0.05), and the pH value of the soil treated with K3PO4 modified biochar exhibited the largest increase. With an application of 20.5% K3PO4 modified biochar, the availability of Cu and Cd in the soil was significantly reduced, by 75.44% and 67.70%, respectively. The immobilization efficiency of Cu was much higher than that of Cd. The best immobilization efficiency of Cu and Cd in soil was achieved with K3PO4 modified biochar. With an addition of 2% K3PO4 modified biochar, the immobilization efficiency of Cu and Cd was 61.06% and 4.12%, respectively. In summary, K3PO4 modified biochar had a better immobilization effect on both Cu and Cd in compound contaminated soil.