RESUMEN
Matured nitrosation granules were inoculated to an anoxic-aerobic continuous-flow reactor at room temperature (17-19â). The startup and stabilization of nitrosation with granules were studied. The results show that the nitrosation of the continuous-flow was successfully achieved with an average nitrite accumulation rate (NAR) above 95%. With the increase of the dissolved oxygen (DO) content from (3±0.2) to (4.5±0.2) mg·L-1 in the aerobic zone, the NAR remained above 95%. The effect of the hydraulic retention time (HRT) of the continuous-flow reactor was investigated. The short HRT (8.4 h) sped up the circulation of the sludge particles in the continuous-flow system such that the broken granular sludge could not be integrated in time, resulting in the deterioration of granular sludge settling and the loss of sludge granules. The performance of the system was restored with the increase of the HRT to 12.2 h and the continuous-flow system stabilized. The ammonia removal efficiency and NAR were 86.7% and 96.2% on day 166, respectively.
Asunto(s)
Amoníaco/aislamiento & purificación , Reactores Biológicos , Nitrosación , Aguas del Alcantarillado , Eliminación de Residuos Líquidos , Nitritos/análisisRESUMEN
Mature biological phosphorus removal granules were inoculated into a SBR. The effect of the ammonia concentration on biological phosphorus removal granules system was investigated by increasing the concentration of ammonia in the influent. The ability of the system to withstand ammonia loading was determined. The results showed that when the influent ammonia concentration was below 45 mg·L-1, the biological phosphorus removal granule system showed good performance. The TP removal efficiency was above 96%, the COD removal efficiency was over 89%. The effluent TP concentration and COD concentration were 0.4 mg·L-1 and 25 mg·L-1 respectively. The particle size was above 950 µm and the SVI was below 45 mL·g-1. When the influent ammonia concentration was 60 mg·L-1, the removal efficiency of TP was more than 95%. The effluent TP concentration was below 0.5 mg·L-1, the particle size was 760 µm, and the SVI was 56 mL·g-1. Furthermore, the biological phosphorus removal granules partially disintegrated and the metabolism and growth of PAOs began to be inhibited in the system. When the influent ammonia concentration reached 70 mg·L-1, the removal efficiency of TP was 70%, the effluent TP concentration was about 3 mg·L-1, the particle size was 570 µm, the SVI was 75 mL·g-1, and the value of PN/PS was about 7.50. The biological phosphorus granules severely disintegrated and the metabolism and growth of PAOs was severely inhibited in the system. Moreover, as the influent ammonia concentration increased, the protein increased and polysaccharide decreased from the microbial secretion of biological phosphorus removal granules. Moreover, the value of PN/PS increased, the biological phosphorus removal granules disintegrated, the particle size decreased, the SVI increased, and the structure and function of the biological phosphorus removal granules were destroyed.
Asunto(s)
Amoníaco/análisis , Reactores Biológicos , Fósforo/aislamiento & purificación , Eliminación de Residuos Líquidos , Aguas del AlcantarilladoRESUMEN
The effect of aeration densities (3, 6, 12) on the CANON process start-up were investigated in R1, R2, and R3 inoculated mature anaerobic ammonium oxide granule sludge under the same conditions of aeration and aeration/anaerobic time ratio (1:1) at 25â. The results showed that R1, R2, and R3 of the CANON process were initiated in 32, 29, and 23 d, respectively. A greater aeration density promoted the start-up of the CANON process. In the cycle test, the pH of R1, R2, and R3 decreased by 0.4, 0.55, and 1.06, respectively. R3 exhibited excellent denitrification performance due to its large aeration density and suitable time interval, which increased system efficiency in DO and better inhibited NOB activity. According to the denitrification route analysis, there were two denitrification pathways of ANA and SNA in the system. The proportion of SNA was 19.3%, 24.5%, and 33.6%, respectively. With the increase in aeration density, the contribution of SNA increased gradually.
Asunto(s)
Compuestos de Amonio , Reactores Biológicos , Desnitrificación , Aguas del Alcantarillado , NitrógenoRESUMEN
In this study, the effect of COD loading on a biological phosphorus removal granule system under different phosphorus concentrations was investigated by changing the concentration of total phosphorus (TP) and COD in the influent. The lowest concentration of COD for good performance of the biological phosphorus removal system under different phosphorus concentrations was obtained. The results show that when the concentration of TP was 10 mg·L-1 in the influent, the lowest concentration of COD for good performance of the biological phosphorus removal system was 175 mg·L-1. The concentration of TP in the effluent was below 0.5 mg·L-1; the particle size and SVI were 1020 µm and 36 mL·g-1, respectively; and the contents of PN and PS (by MLSS) were 78 mg·g-1 and 39 mg·g-1, respectively. Furthermore, the PN/PS was lower and the granules had good structure and performance. When the concentration of TP was 6 mg·L-1 in the influent, the lowest concentration of COD for good performance of the biological phosphorus removal system was 150 mg·L-1. The concentration of TP in the effluent was below 0.3 mg·L-1; the particle size and SVI were respectively 960 µm and 35 mL·g-1; and the contents of PN and PS were 75 mg·g-1 and 35 mg·g-1, respectively. Moreover, the PN/PS was lower and the granules had good structure and performance. The removal efficiency of COD was above 83% and the concentration of COD in the effluent was below 25 mg·L-1 throughout the operational process. Under different the influent phosphorus concentrations, the contents of PN and PS decreased, PN/PS increased, particle size decreased, SVI increased, and the structure and performance of the biological phosphorus removal granules deteriorated as the COD concentration decreased.
Asunto(s)
Reactores Biológicos , Fósforo/aislamiento & purificación , Eliminación de Residuos Líquidos , Análisis de la Demanda Biológica de Oxígeno , Tamaño de la Partícula , Aguas del AlcantarilladoRESUMEN
The different effects of additional aerobic granules (AGs) and phosphorus removal granules (PRGs) on the start-up and stable operation of partial nitrification granular sludge (PNGS) were compared at room temperature(22-28â). The results showed that in the first stage (days 0-22), partial nitrification was accomplished on day 19 for the three reactors (R1, R2, and R3). In the second stage (days 23-56), 20% AGs and 20% PRGs were added to R2 and R3 to induce PNGS. The start-up of the granules of the three reactors was successfully achieved. The mean particle sizes of R1, R2, and R3 reached 412 µm at day 76, 468 µm at day 42, and 400 µm at day 56. In the third stage (days 57-108), because the influent ammonia load increased from 0.4 kg·(m3·d)-1 to 0.5 kg·(m3·d)-1 and the COD load increased from 0.2 kg·(m3·d)-1 to 0.5 kg·(m3·d)-1, the mean particle sizes of R1 and R2 increased significantly. The average particle sizes of R1 and R2 reached 689 µm and 893 µm by the end of the operation (day 108), but sludge expansion occurred in R3. The inoculation of either AGs or PRGs could quickly achieve granulation, but the PNGS inoculated with the AGs could adapt to higher C/N and be more tolerable to shock loads and long-term stable operation.
Asunto(s)
Reactores Biológicos , Nitrificación , Fósforo/química , Aguas del Alcantarillado , Eliminación de Residuos Líquidos , AerobiosisRESUMEN
Flocculent sludge with good nitritation performance and MLSS and SVI values of 3500 mg ·L-1 and 162 mL ·g-1, respectively, was inoculated in the R1, R2, and R3 groups of the same SBR reactors at room temperature (22-28â). The effects of different anaerobic time and aeration time ratios (1:2, 1:1, and 2:1) on the formation of partial nitrification granular sludge were studied. The results showed that granules in three reactors were successfully formed at 103 d, 82 d, and 64 d. The nitrosation rate of R1, R2, and R3 were 86%, 98%, and 96%, respectively, and SVI decreased to 89, 75, and 58 mL ·g-1 and MLSS increased to 2314, 2781, and 2946 mg ·L-1, respectively, at the 85 d. The larger ratio of anaerobic time and aeration time was more conducive to sludge granulation, better settling, and nitritation performance. When the anaerobic time and aeration time ratio was 1:2, the nitritation performance of the sludge decreased since the NOB could not be suppressed, and the settling performance of the sludge became better and then worse. In addition, at the larger ratio of anaerobic time and aeration time, there was more PN and PS from microbial secretion. The PN of R1, R2, and R3 was smaller at the end of the anaerobic phase compared to that of the aerobic phase in the early stage of granular formation, but were reversed in the stabilization stage. The PS of the anaerobic phase was larger than that of the aerobic stage over the entire process.
Asunto(s)
Reactores Biológicos , Nitrificación , Aguas del Alcantarillado , Eliminación de Residuos Líquidos , AerobiosisRESUMEN
Anaerobic ammonium oxidizing bacteria were stored under NH4+-N and NO2--N conditions (addition ratio 1:1) at a substrate concentration of 0, 60, and 120 mg·L-1at 15â±1â for 15 days. The effect of different substrate concentrations on the short-term storage and recovery of anaerobic ammonia oxidation sludge was investigated. After a short period of storage, a recovery experiment was performed. The results show that the anaerobic ammonia oxidation activities in the reactors 1, 2, and 3 decrease by 41.8%, 17.4%, and 33.4%, respectively. Because of the excessive endogenous respiration and high substrate concentration, the activities of the bacteria in reactors 1 and 3 were inhibited, respectively. Therefore, the activities decreased greatly. Because the substrate concentration was relatively suitable in reactor No. 2, excessive endogenous respiration and high substrate concentration inhibition were avoided such that the activity of the bacteria species was maintained at the substrate concentration. Endogenous respiration occurred during the storage period. Subsequently, the organic matter in the three reactors was consumed. As a result, the EPS content decreased by 50.9%, 41.7%, and 23.7% and the particle size decreased by 31.6%, 16.7%, and 8.2%, respectively. This shows that endogenous respiration is maintained by the bacteria in the matrix-deficient period and the higher concentration of the substrate can to some extent delay the endogenous respiration. During the recovery period, the three reactors recover the denitrification performances after 15, 10, and 7 d respectively. This shows that the denitrification performance of the system has a faster recovery through enhanced strain activities compared with the proliferation of the strain.
Asunto(s)
Bacterias Anaerobias , Reactores Biológicos/microbiología , Desnitrificación , Nitrógeno/aislamiento & purificación , Amoníaco , Oxidación-Reducción , Aguas del AlcantarilladoRESUMEN
The experiment explored the effect of different seeding sludge on the rapid start-up of an anaerobic ammonium oxidation (ANAMMOX) reactor by seeding a single type of denitrified granular sludge and a mixed sludge composed of denitrified granular sludge and aerobic nitrification sludge (the volume ratio of the mixed sludge was 2:1) in two sequencing batch reactors (SBR), R0 and R1, respectively. The results indicated that R0 was started up successfully on day 64 with a nitrogen removal rate (NRR) of 0.26 kg·(m3·d)-1, while R1 was started up by day 47 with a NRR of 0.30 kg·(m3·d)-1, which was shorter than R0 by 17 d. In the enrichment stage, reddish sludge appeared in R1, and the characteristics of anaerobic ammonium oxidation of the system were more obvious than in R0. After the reactor was started up successfully, the stoichiometric ratio of R0 was 1.20 and 0.34, respectively, and the stoichiometric ratio of R1 was 1.26 and 0.21, which was closer to the theoretical values of 1.32 and 0.26. The mixed liquor suspended solids (MLSS) and mixed liquor volatile suspended solids (MLVSS) of R0 were restored to 51% (4.2 g·L-1) and 38% (2.3 g·L-1)of the initial seeding sludge, respectively, while the MLSS and MLVSS of R1 were restored to 54% (4.4 g·L-1) and 42% (2.6 g·L-1),which was higher than R0. It can be speculated that the proliferation rate of AnAOB in R1 was faster than in R0. Seeding mixed sludge can accelerate the start-up process of anaerobic ammonium oxidation with more stable N-removal performance.