Metabolic flux balance analysis during lactate and glucose concomitant consumption in HEK293 cell cultures.

At early stages of the exponential growth phase in HEK293 cell cultures, the tricarboxylic acid cycle is unable to process all the amount of NADH generated in the glycolysis pathway, being lactate the main by-product. However, HEK293 cells are also able to metabolize lactate depending on the environmental conditions. It has been recently observed that one of the most important modes of lactate metabolization is the cometabolism of lactate and glucose, observed even during the exponential growth phase. Extracellular lactate concentration and pH appear to be the key factors triggering the metabolic shift from glucose consumption and lactate production to lactate and glucose concomitant consumption. The hypothesis proposed for triggering this metabolic shift to lactate and glucose concomitant consumption is that HEK293 cells metabolize extracellular lactate as a response to both extracellular protons and lactate accumulation, by means of cotransporting them (extracellular protons and lactate) into the cytosol. At this point, there exists a considerable controversy about how lactate reaches the mitochondrial matrix: the first hypothesis proposes that lactate is converted into pyruvate in the cytosol, and afterward, pyruvate enters into the mitochondria; the second alternative considers that lactate enters first into the mitochondria, and then, is converted into pyruvate. In this study, lactate transport and metabolization into mitochondria is shown to be feasible, as evidenced by means of respirometry tests with isolated active mitochondria, including the depletion of lactate concentration of the respirometry assay. Although the capability of lactate metabolization by isolated mitochondria is demonstrated, the possibility of lactate being converted into pyruvate in the cytosol cannot be excluded from the discussion. For this reason, the calculation of the metabolic fluxes for an HEK293 cell line was performed for the different metabolic phases observed in batch cultures under pH controlled and noncontrolled conditions, considering both hypotheses. The main objective of this study is to evaluate the redistribution of cellular metabolism and compare the differences or similarities between the phases before and after the metabolic shift of HEK293 cells (shift observed when pH is not controlled). That is from a glucose consumption/lactate production phase to a glucose-lactate coconsumption phase. Interestingly, switching to a glucose and lactate cometabolization results in a better-balanced cell metabolism, with decreased glucose and amino acids uptake rates, affecting minimally cell growth. This behavior could be applied to further develop new approaches in terms of cell engineering and to develop improved cell culture strategies in the field of animal cell technology.

Lactate and glucose concomitant consumption as a self-regulated pH detoxification mechanism in HEK293 cell cultures.

One of the most important limitations of mammalian cell-based processes is the secretion and accumulation of lactate as a by-product of their metabolism. Among the cell lines commonly used in industrial bioprocesses, HEK293 has been gaining importance over the last years. Up recently, HEK293 cells were known to consume lactate in late stages of cell culture usually when glucose and/or glutamine were depleted from media. Remarkably, in both scenarios, no significant cell growth was reported. However, we have observed a different metabolic behavior regarding lactate production and consumption in HEK293 cultures. HEK293 cells were able to co-metabolize glucose and lactate simultaneously, even in exponentially growing cell cultures. Our deep study of the effects of environmental conditions on lactate metabolism revealed that pH was the key to trigger the metabolic shift from lactate production to lactate and glucose concomitant consumption. Remarkably, this shift could be triggered at will when pH was set at 6.8. Even more interesting was the fact that lowering pH to 6.6 and supplementing media with exogenous lactate resulted in co-consumption of glucose and lactate from the beginning of cell culture, without affecting cell growth or protein productivity. On the contrary, cell growth was clearly hampered at this low pH if extracellular lactate was lacking. From our results, we hypothesize that HEK293 cells metabolize extracellular lactate as a strategy for pH detoxification, by means of co-transporting extracellular protons together with lactate into the cytosol. This novel hypothesis for unraveling lactate metabolism in HEK293 cells could open a door to re-direct genetic engineering strategies in order to obtain more efficient cell lines and also to further develop animal cell technology applications.

HEK293 cell culture media study towards bioprocess optimization: Animal derived component free and animal derived component containing platforms.

The increasing demand for biopharmaceuticals produced in mammalian cells has lead industries to enhance bioprocess volumetric productivity through different strategies. Among those strategies, cell culture media development is of major interest. In the present work, several commercially available culture media for Human Embryonic Kidney cells (HEK293) were evaluated in terms of maximal specific growth rate and maximal viable cell concentration supported. The main objective was to provide different cell culture platforms which are suitable for a wide range of applications depending on the type and the final use of the product obtained. Performing simple media supplementations with and without animal derived components, an enhancement of cell concentration from 2 × 10(6) cell/mL to 17 × 10(6) cell/mL was achieved in batch mode operation. Additionally, the media were evaluated for adenovirus production as a specific application case of HEK293 cells. None of the supplements interfered significantly with the adenovirus infection although some differences were encountered in viral productivity. To the best of our knowledge, the high cell density achieved in the work presented has never been reported before in HEK293 batch cell cultures and thus, our results are greatly promising to further study cell culture strategies in bioreactor towards bioprocess optimization.