Evaluation in pig of an intestinal administration device for oral peptide delivery.

The bioavailability of peptides co-delivered with permeation enhancers following oral administration remains low and highly variable. Two factors that may contribute to this are the dilution of the permeation enhancer in the intestinal fluid, as well as spreading of the released permeation enhancer and peptide in the lumen by intestinal motility. In this work we evaluated an Intestinal Administration Device (IAD) designed to reduce the luminal dilution of drug and permeation enhancer, and to minimize movement of the dosage form in the intestinal lumen. To achieve this, the IAD utilizes an expanding design that holds immediate release mini tablets and places these in contact with the intestinal epithelium, where unidirectional drug release can occur. The expanding conformation limits movement of the IAD in the intestinal tract, thereby enabling drug release at a single focal point in the intestine. A pig model was selected to study the ability of the IAD to promote intestinal absorption of the peptide MEDI7219 formulated together with the permeation enhancer sodium caprate. We compared the IAD to intestinally administered enteric coated capsules and an intestinally administered solution. The IAD restricted movement of the immediate release tablets in the small intestine and histological evaluation of the mucosa indicated that high concentrations of sodium caprate were achieved. Despite significant effect of the permeation enhancer on the integrity of the intestinal epithelium, the bioavailability of MEDI7219 was of the same order of magnitude as that achieved with the solution and enteric coated capsule formulations (2.5-3.8%). The variability in plasma concentrations of MEDI7219 were however lower when delivered using the IAD as compared to the solution and enteric coated capsule formulations. This suggests that dosage forms that can limit intestinal dilution and control the position of drug release can be a way to reduce the absorptive variability of peptides delivered with permeation enhancers but do not offer significant benefits in terms of increasing bioavailability.

Effects of mineral oil administration on the pharmacokinetics, metabolism and pharmacodynamics of atorvastatin and pravastatin in mice and dogs.

We investigated the effects of mineral oil on statin pharmacokinetics and inflammatory markers in animal models. A new synthesis strategy produced regioisomers that facilitated the characterization of the main metabolite (M1) of atorvastatin, a lipophilic statin, in C57BL/6NCrl mice. The chemical structure of M1 in mice was confirmed as ortho-hydroxy ß-oxidized atorvastatin. Atorvastatin and M1 pharmacokinetics and inflammatory markers were assessed in C57BL6/J mice given atorvastatin 5 mg/kg/day or 10 mg/kg/day, as a single dose or for 21 days, with or without 10 µL or 30 µL mineral oil. No consistent differences in plasma exposure of atorvastatin or M1 were observed in mice after single or repeat dosing of atorvastatin with or without mineral oil. However, mice administered atorvastatin 10 mg/kg with 30 µL mineral oil for 21 days had significantly increased plasma levels of serum amyloid A (mean 9.6 µg/mL vs 7.9 µg/mL without mineral oil; p < 0.01) and significantly increased proportions of C62Lhigh B cells (mean 18% vs 12% without mineral oil; p = 0.04). There were no statistically significant differences for other inflammatory markers assessed. In dogs, pharmacokinetics of atorvastatin, its two hydroxy metabolites and pravastatin (a hydrophilic statin) were evaluated after single administration of atorvastatin 10 mg plus pravastatin 40 mg with or without 2 g mineral oil. Pharmacokinetics of atorvastatin, hydroxylated atorvastatin metabolites or pravastatin were not significantly different after single dosing with or without mineral oil in dogs. Collectively, the results in mice and dogs indicate that mineral oil does not affect atorvastatin or pravastatin pharmacokinetics, but could cause low-grade inflammation with chronic oral administration, which warrants further investigation.

Biowaiver Monograph for Immediate-Release Solid Oral Dosage Forms: Carbamazepine.

Literature relevant to assessing whether BCS-based biowaivers can be applied to immediate release (IR) solid oral dosage forms containing carbamazepine as the single active pharmaceutical ingredient are reviewed. Carbamazepine, which is used for the prophylactic therapy of epilepsy, is a non-ionizable drug that cannot be considered "highly soluble" across the range of pH values usually encountered in the upper gastrointestinal tract. Furthermore, evidence in the open literature suggests that carbamazepine is a BCS Class 2 drug. Nevertheless, the oral absolute bioavailability of carbamazepine lies between 70 and 78% and both in vivo and in vitro data support the classification of carbamazepine as a highly permeable drug. Since the therapeutic and toxic plasma level ranges overlap, carbamazepine is considered to have a narrow therapeutic index. For these reasons, a BCS based biowaiver for IR tablets of carbamazepine cannot be recommended. Interestingly, in nine out of ten studies, USP dissolution conditions (900 mL water with 1% SLS, paddle, 75 rpm) appropriately discriminated among bioinequivalent products and this may be a way forward to predicting whether a given formulation will be bioequivalent to the comparator product.

In Vitro and In Vivo Evaluation of 3D Printed Capsules with Pressure Triggered Release Mechanism for Oral Peptide Delivery.

In this study a 3D printed capsule designed to break from the physiological pressures in the antropyloric region was evaluated for its ability to deliver the synthetic octapeptide octreotide in beagle dogs when co-formulated with the permeation enhancer sodium caprate. The pressure sensitive capsules were compared to traditional enteric coated hard gelatin capsules and enteric coated tablets. Paracetamol, which is completely absorbed in dogs, was included in the formulations and used as an absorption marker to give information about the in vivo performance of the dosage forms. The pressure sensitive capsules released drug in 50% of the dogs. In the cases where drug was released, there was no difference in octreotide bioavailability or Cmax compared to the enteric coated dosage forms. When comparing all dosage forms, a correlation was seen between paracetamol Cmax and octreotide bioavailability, suggesting that a high drug release rate may be beneficial for peptide absorption when delivered together with sodium caprate.

Biowaiver Monograph for Immediate-Release Solid Oral Dosage Forms: Ondansetron.

Literature data pertaining to the physicochemical, pharmaceutical, and pharmacokinetic properties of ondansetron hydrochloride dihydrate are reviewed to arrive at a decision on whether a marketing authorization of an immediate release (IR) solid oral dosage form can be approved based on a Biopharmaceutics Classification System (BCS)-based biowaiver. Ondansetron, a 5HT3 receptor antagonist, is used at doses ranging from 4 mg to 24 mg in the management of nausea and vomiting associated with chemotherapy, radiotherapy, and postoperative treatment. It is a weak base and thus exhibits pH-dependent solubility. However, it is able to meet the criteria of "high solubility" as well as "high permeability" and can therefore be classified as a BCS class I drug. Furthermore, ondansetron hydrochloride 8 mg IR tablets (Zofran® 8 mg) and multiples thereof (16 mg = Zofran® 8 mg × 2 tablets and 24 mg = Zofran® 8 mg × 3 tablets) meet the criteria of "rapidly dissolving" in dissolution testing. Ondansetron hydrochloride has a wide therapeutic window and is well-tolerated after oral administration. Based on its favorable physicochemical properties, pharmacokinetic data and the minimal risks associated with an incorrect bioequivalence decision, the BCS-based biowaiver procedure can be recommended for ondansetron hydrochloride dihydrate IR tablets.

Biowaiver Monographs for Immediate-Release Solid Oral Dosage Forms: Folic Acid.

This work presents a review of literature and experimental data relevant to the possibility of waiving pharmacokinetic bioequivalence studies in human volunteers for approval of immediate-release solid oral pharmaceutical forms containing folic acid as the single active pharmaceutical ingredient. For dosage forms containing 5 mg folic acid, the highest dose strength on the World Health Organization Essential Medicines List, the dose/solubility ratio calculated from solubility studies was higher than 250 mL, corresponding to a classification as "not highly soluble." Small, physiological doses of folic acid (≤320 µg) seem to be absorbed completely via active transport, but permeability data for higher doses of 1-5 mg are inconclusive. Following a conservative approach, folic acid is classified as a Biopharmaceutics Classification System class IV compound until more reliable data become available. Commensurate with its solubility characteristics, the results of dissolution studies indicated that none of the folic acid products evaluated showed rapid dissolution in media at pH 1.2 or 4.5. Therefore, according to the current criteria of the Biopharmaceutics Classification System, the biowaiver approval procedure cannot be recommended for immediate-release solid oral dosage forms containing folic acid.

Amorphous is not always better-A dissolution study on solid state forms of carbamazepine.

Poor aqueous solubility is a major concern for many new drugs. One possibility to overcome this issue is to formulate the drug as a high energy form, i.e. a metastable polymorph, an amorphous neat drug or a glass solution with polymers. In this study the dissolution properties of different solid state forms of carbamazepine, crystalline or amorphous drug, with or without either polyvinylpyrrolidone (PVP) or hydroxypropylmethylcellulose (HPMC) and glass solutions of the drug with both polymers (2:1, 4:1 and 10:1 (w/w) drug-to-polymer ratio) were tested with respect to their dissolution behaviour in a biorelevant gastric medium (for 30min) and subsequently in intestinal conditions (for 2h). Carbamazepine form III in the absence of polymer dissolved to a drug concentration of 540µg/ml, but the concentration decreased after around 70min due to precipitation of the dihydrate form, and reached 436µg/ml after 2.5h dissolution testing. The presence of PVP led to a similar dissolution profile with a slightly earlier onset of decrease in drug concentration, while in the presence of HPMC no decline in dissolved drug concentration was observed. Surprisingly, amorphous carbamazepine did not result in any supersaturation and the drug concentration was lower than that measured for crystalline carbamazepine. The addition of polymers further decreased the concentration of dissolved drug (290-310µg/ml, depending on polymer type and concentration). Amorphous drug converted quickly into the dihydrate form and thus no supersaturation was achieved. Glass solutions of carbamazepine with PVP reached drug concentrations between 348 and 408µg/ml after 2.5h, i.e. lower than for the crystalline drug, whilst glass solutions with HPMC reached concentrations similar to the crystalline drug.

Characterization of the ascending colon fluids in ulcerative colitis.

PURPOSE: To characterize the fluid composition in ascending colon of fasted adults with ulcerative colitis in relapse and in remission with a view to predicting variations on dosage form performance in the lower inflamed gut. METHODS: Twelve patients participated in a two-phase, crossover study. Enrollment to the relapse phase (Phase A) and designation of the remission state for the second colonoscopy (Phase B) were based on Clinical Rachmilewicz Index values. Samples were analyzed for pH and buffer capacity immediately upon collection. After ultracentrifugation, osmolality, surface tension, soluble protein, soluble carbohydrates, and the levels of ten bile acids, seven short-chain fatty acids (SCFAs), three long-chain fatty acids, triglycerides, diglycerides, monoglycerides, phosphatidylcholine, and cholesterol were measured. RESULTS: Total SCFAs are significantly decreased in relapse, but pH remains unaffected. Regardless of remission/relapse status, pH and isobutyric acid levels are lower than in healthy adults. Buffer capacity, osmolality, and soluble protein are higher than in healthy adults. Treatment with prednisolone increases the volume of intracolonic contents. CONCLUSION: Variations in fluid composition of the ascending colon with activity and severity of ulcerative colitis may have an impact on the performance of orally administered products that are targeted to release the therapeutic agent in the colon.

Challenges and opportunities in establishing scientific and regulatory standards for assuring therapeutic equivalence of modified-release products: workshop summary report.

Modified-release products are complex dosage forms designed to release drug in a controlled manner to achieve desired efficacy and safety. Inappropriate control of drug release from such products may result in reduced efficacy or increased toxicity. This workshop provided an opportunity for pharmaceutical scientists from academia, industry and regulatory agencies to discuss current regulatory expectations and industry practices for demonstrating pharmaceutical equivalence and bioequivalence of MR products, further facilitating the establishment of regulatory standards for ensuring therapeutic equivalence of these products.

Characterization of the contents of ascending colon to which drugs are exposed after oral administration to healthy adults.

PURPOSE: To characterize the contents of the ascending colon in healthy adults under fasting and fed state conditions, with a view to designing in vitro studies to explain/predict dosage form performance in the lower gut. METHODS: Twelve healthy adults participated in a two-phase crossover study. In Phase A, subjects were fasted (water allowed) overnight plus 5 h in the morning prior to colonoscopy (fasted state). In Phase B, subjects were fasted overnight, consumed a standard breakfast (960 kcal) in the morning, and were offered a light lunch 4.5 h later. In this phase, colonoscopy was performed 1 h after lunch (fed state). Volume, pH, and buffer capacity of colonic contents were measured immediately upon collection. After ultracentrifugation, the supernatant was further characterized. RESULTS: Free water content, pH, surface tension, and isobutyrate levels were lower in fed than in fasted subjects. On the other hand, buffer capacity, osmolality, acetate, butyrate, cholate, and chenodeoxycholate levels were higher in fed subjects. Carbohydrate content; protein content; and levels of long chain fatty acids, phosphatidylcholine, and cholesterol were not affected significantly by prandial state. CONCLUSION: Composition of fluids in the ascending colon is affected by feeding. This may affect the performance of products designed to deliver drug to the colon.