Bicarbonate buffer dissolution test with gentle mechanistic stress for bioequivalence prediction of enteric-coated pellet formulations.

This study aimed to develop a dissolution test that can predict the bioequivalence (BE) of enteric-coated pellet formulations. The original duloxetine hydrochloride capsule (reference formulation (RF); Cymbalta® 30 mg capsule) and four generic test formulations (two capsules (CP) and two orally disintegrating tablets (OD)) were used as model formulations. Clinical BE studies were conducted on 24-47 healthy male subjects under fasting conditions. Dissolution tests were performed using a compendial paddle method (PD) (paddle speed: 50 rpm) and a flow-through cell method (FTC) (flow rate: 4 mL/min). For a further test, cotton balls were added to the vessel to apply gentle mechanistic stress to the formulations, and paddle speed was reduced to 10 rpm (paddle with cotton ball method (PDCB)).All the dissolution tests were conducted with 0.01 M HCl (pH 2.0) for 0.5 h followed by 10 mM bicarbonate buffer solutions (pH 6.5) for 4 h. One each of the two CP and two OD showed BE with RF. PDCB was able to discriminate between BE and non-BE formulations, while this was not possible with PD and FTC. In PDCB, the cotton balls intermittently moved the pellets near the vessel bottom. PDCB is useful for predicting BE during formulation development.

Pharmacokinetics and food impact assessment of ademetionine enteric-coated tablet as an endogenous substance drug in healthy Chinese volunteers.

WHAT IS KNOWN AND OBJECTIVES: Ademetionine 1,4-Butanedisulfonate (SAMe) enteric-coated tablets are widely used for treatment of pre-cirrhotic and cirrhotic intrahepatic cholestasis, as well as intrahepatic cholestasis of pregnancy (ICP), but incomplete clinical data and interference from endogenous substances pose numerous challenges for clinical trial of ademetionine. The objective of this study was to evaluate the pharmacokinetic profile of SAMe enteric-coated tablets and to assess its food impact and safety in healthy Chinese subjects. METHODS: A randomized, open-label, single-dose study was carried out to determine the pharmacokinetics of SAMe enteric-coated tablets administered in both fasted and postprandial conditions. Baseline collection and data adjustment were required to reduce the effect of endogenous substances. Relevant pharmacokinetic data from subjects administered the reference formulation will be disclosed and utilized in this thesis. RESULTS: Twenty-four subjects with a body mass index (BMI) of 19-24 kg/m2 were enrolled in the study and all completed the trial. The impact of food on the drug was noticeable, with faster absorption in the fasting group (Tmax , 4.50 ± 1.07 and 7.50 ± 1.58 for the fasting and postprandial groups, respectively) but higher exposure in the postprandial group (AUC0-inf , 4021.02 ± 3377.13 and 5087.28 ± 3539.26 for the fasting and postprandial groups, respectively). No serious adverse effects were observed in the fasted and postprandial conditions. WHAT IS NEW AND CONCLUSIONS: The pharmacokinetic profile of SAMe enteric-coated tablets in healthy Chinese subjects was partially complemented in this study. SAMe enteric-coated tablets showed promising safety in fasted and postprandial conditions. However, the impact of food on the drug was significant and might access to the absorption site and affect biochemical reactions.

Impact of co-administered stabilizers on the biopharmaceutical performance of regorafenib amorphous solid dispersions.

Poor solubility of drug candidates is a well-known and thoroughly studied challenge in the development of oral dosage forms. One important approach to tackle this challenge is the formulation as an amorphous solid dispersion (ASD). To reach the desired biopharmaceutical improvement a high supersaturation has to be reached quickly and then be conserved long enough for absorption to take place. In the presented study, various formulations of regorafenib have been produced and characterized in biorelevant in-vitro experiments. Povidone-based formulations, which are equivalent to the marketed product Stivarga®, showed a fast drug release but limited stability and robustness after that. In contrast, HPMCAS-based formulations exhibited excellent stability of the supersaturated solution, but unacceptably slow drug release. The attempt to combine the desired attributes of both formulations by producing a ternary ASD failed. Only co-administration of HPMCAS as an external stabilizer to the rapidly releasing Povidone-based ASDs led to the desired dissolution profile and high robustness. This optimized formulation was tested in a pharmacokinetic animal model using Wistar rats. Despite the promising in-vitro results, the new formulation did not perform better in the animal model. No differences in AUC could be detected when compared to the conventional (marketed) formulation. These data represent to first in-vivo study of the new concept of external stabilization of ASDs. Subsequent in-vitro studies revealed that temporary exposure of the ASD to gastric medium had a significant and long-lasting effect on the dissolution performance and externally administered stabilizer could not prevent this sufficiently. By applying the co-administered HPMCAS as an enteric coating onto Stivarga tablets, a new bi-functional approach was realized. This approach achieved the desired tailoring of the dissolution profile and high robustness against gastric medium as well as against seeding.

Development of an orally delivered GLP-1 receptor agonist through peptide engineering and drug delivery to treat chronic disease.

Peptide therapeutics are increasingly used in the treatment of disease, but their administration by injection reduces patient compliance and convenience, especially for chronic diseases. Thus, oral administration of a peptide therapeutic represents a significant advance in medicine, but is challenged by gastrointestinal instability and ineffective uptake into the circulation. Here, we have used glucagon-like peptide-1 (GLP-1) as a model peptide therapeutic for treating obesity-linked type 2 diabetes, a common chronic disease. We describe a comprehensive multidisciplinary approach leading to the development of MEDI7219, a GLP-1 receptor agonist (GLP-1RA) specifically engineered for oral delivery. Sites of protease/peptidase vulnerabilities in GLP-1 were removed by amino acid substitution and the peptide backbone was bis-lipidated to promote MEDI7219 reversible plasma protein binding without affecting potency. A combination of sodium chenodeoxycholate and propyl gallate was used to enhance bioavailability of MEDI7219 at the site of maximal gastrointestinal absorption, targeted by enteric-coated tablets. This synergistic approach resulted in MEDI7219 bioavailability of ~ 6% in dogs receiving oral tablets. In a dog model of obesity and insulin resistance, MEDI7219 oral tablets significantly decreased food intake, body weight and glucose excursions, validating the approach. This novel approach to the development of MEDI7219 provides a template for the development of other oral peptide therapeutics.

Alternatives to titanium dioxide in tablet coating.

Titanium dioxide (TiO2) is one of the most commonly used pharmaceutical excipients. It is widely used as a white pigment in tablet and pellet coatings. However, it has recently been under massive criticism as a number of studies suggest a cancerogenic potential. It can therefore no longer be taken for granted that TiO2 will continue to be universally available for drug products. Finding suitable alternatives is hence of special relevance. In this study, a number of different pigments were coated on tablets and their covering potential analyzed. None of the alternative pigments showed comparable effectiveness and efficiency to TiO2, though the CaCO3/CaHPO4-based coating showed the second-best results. Regarding the ability to protect photosensitive active ingredients, ZnO showed a comparable potential as TiO2, while all other pigments failed. Using the alternative pigments as markers for in-line Raman spectroscopy as a process analytical technology was challenging and led to increased prediction errors. Again, the CaCO3/CaHPO4-based coating was the only of the tested alternatives with satisfying results, while all other pigments led to unacceptably high prediction errors.

In Vitro and In Vivo Evaluation of 3D Printed Capsules with Pressure Triggered Release Mechanism for Oral Peptide Delivery.

In this study a 3D printed capsule designed to break from the physiological pressures in the antropyloric region was evaluated for its ability to deliver the synthetic octapeptide octreotide in beagle dogs when co-formulated with the permeation enhancer sodium caprate. The pressure sensitive capsules were compared to traditional enteric coated hard gelatin capsules and enteric coated tablets. Paracetamol, which is completely absorbed in dogs, was included in the formulations and used as an absorption marker to give information about the in vivo performance of the dosage forms. The pressure sensitive capsules released drug in 50% of the dogs. In the cases where drug was released, there was no difference in octreotide bioavailability or Cmax compared to the enteric coated dosage forms. When comparing all dosage forms, a correlation was seen between paracetamol Cmax and octreotide bioavailability, suggesting that a high drug release rate may be beneficial for peptide absorption when delivered together with sodium caprate.

Colon-specific tablets containing 5-fluorouracil microsponges for colon cancer targeting.

Most anticancer medications undergo major first-pass metabolism in the intestinal wall, the liver, or both. 5-fluorouracil (5-FU) is known to have erratic oral bioavailability due to first-pass metabolism. The present study aimed to develop 5-FU-loaded microsponges (MS) compressed in enteric-coated tablets as a new colon targeting to colorectal cancer. MS was prepared as a controlled release system for 5-FU and characterized for drug encapsulation efficiency, and surface morphology. Further, hydroxypropyl methylcellulose (HPMC) was mixed with pectin and characterized for their flow as a tablet coat enclosing the core tablets of 5-FU-MS. Moreover, in vitro drug release behavior was studied in different pH media, while the X-ray imaging was used to monitor the in vivo movement of prepared tablets containing 5-FU-MS throughout the GI system. The results showed that MS were spherical in shape and have several pores on their surfaces. The encapsulation efficiency was from 71.80 ± 1.62% - 101.3 ± 2.60%, while the particle size was from 53.11 ± 41.03 - 118.12 ± 48.21 nm. The formulated tablets were fulfilling all official and other specifications and exhibited sustained release of 5-FU only inside the colon. The in vivo human volunteer study of X-ray has shown that the tablets ultimately reached the colon without disturbing in the upper GI system. The obtained carrier formulation is considered as a novel system to deliver 5-FU to the colon tumor with 100% targeting without any drug release in the upper GIT or first-pass metabolism.

Enteric-Coated Strategies in Colorectal Cancer Nanoparticle Drug Delivery System.

Colorectal cancer is one of the most common cancer diseases with the increase of cases prevalence >5% every year. Multidrug resistance mechanisms and non-localized therapy become primary problems of chemotherapy drugs for curing colorectal cancer disease. Therefore, the enteric-coated nanoparticle system has been studied and proved to be able to resolve those problems with good performance for colorectal cancer. The highlight of our review aims to summarize and discuss the enteric-coated nanoparticle drug delivery system specific for colorectal cancer disease. The main and supporting literatures were collected from published research articles of journals indexed in Scopus and PubMed databases. In the oral route of administration, Eudragit pH-sensitive copolymer as a coating agent prevents the degradation of the nanoparticle system from the gastric fluid and releases drug to intestinal-colon track. Therefore, it provides a colon-specific targeting ability. Impressively, enteric-coated nanoparticles having a sustained release profile significantly increase the cytotoxic effect of chemotherapeutic drugs and achieve cell-specific target delivery. The enteric-coated nanoparticle drug delivery system represents an excellent modification to improve the effectiveness and performance of anticancer drugs for colorectal cancer disease in terms of the oral route of administration.

Patients with Essential Thrombocythemia may be Poor Responders to Enteric-Coated Aspirin, but not to Plain Aspirin.

Essential thrombocythemia (ET) patients are treated with aspirin (acetylsalicylic acid [ASA]) to prevent thrombosis. Previous studies showed that serum thromboxane (Tx) B2 was high 24 hours after enteric-coated (EC)-ASA in ET patients, due to increased number of noninhibited reticulated platelets (RPs), consequent to high platelet turnover, and that ASA should be given twice a day to ET patients. We studied ET patients (n = 17) and healthy subjects (n = 10) on 100 mg EC-ASA once daily; experiments were repeated after 14-day treatment with 100 mg plain-ASA once daily. Serum TxB2, plasma ASA, and salicylic acid (SA) were measured before the morning dose and up to 8 hours thereafter. Blood activity of ASA-deacethylating esterases, in vitro inhibition of collagen-induced TxB2 production by ASA (10-1,000 µM), and number of RP were measured. TxB2 inhibition by ASA in vitro and esterases activities were normal in all subjects. EC-ASA elicited highly variable responses; 6 ET patients were poor responders, as their serum TxB2 was high after EC-ASA; their plasma levels of ASA and SA were low/undetectable. In contrast to EC-ASA, plain ASA decreased serum TxB2 and increased plasma ASA and SA in all subjects. Serum TxB2 was high in ET patients at 24 hours and significantly correlated with RP count (but not RP percentage) and platelet count. Plain ASA should be used in ET patients to inhibit platelets efficiently. The identification of ET patients who might benefit from twice a day ASA could simply be based on their platelet count: since their platelet turnover is not increased, ET patients with normalized platelet count should not need twice a day ASA treatment.

Orthotopic Heart Transplant Recipient with Enteric-coated Mycophenolate Sodium (Myfortic) Induced Colitis.

BACKGROUND Mycophenolic acid is an immunosuppressive drug commonly used in solid organ transplantation to prevent acute and chronic allograft rejection. There are 2 common preparations of mycophenolic acid including mycophenolate mofetil (Cellcept), and enteric-coated mycophenolate sodium (Myfortic) which was developed to reduce the high rate of gastrointestinal side effects seen with Cellcept. Cases of mycophenolate mofetil induced colitis have been described in solid organ transplant patients and rarely in heart transplant patients, but enteric-coated mycophenolate sodium induced colitis is very rare and has not been reported in heart transplant patients. CASE REPORT A 66-year old male with an orthotopic heart transplant was admitted with diarrhea. The patient was on an immunosuppression regimen including mycophenolate mofetil for 10 weeks post-transplantation until complaining of soft stools and bloating. At this time, he was switched to enteric-coated mycophenolate sodium. At week 11 post-transplantation, the patient was admitted to the hospital with worsening diarrhea. Extensive workup was unrevealing. Colonoscopy with biopsy showed features of mycophenolic acid induced colitis. Enteric coated mycophenolate sodium was discontinued, and the patient's diarrhea markedly improved over the next 48 hours. The patient had no signs of colitis or solid organ rejection at 7-month follow up appointment. CONCLUSIONS Although a diagnosis of exclusion, enteric-coated mycophenolate sodium induced colitis should be considered in the differential of an orthotopic heart transplant patient with diarrhea as discontinuing the medication can improve symptoms and avoid costly workups, however, patients should be monitored closely for signs of rebound rejection.

Longitudinal Pharmacokinetics of Mycophenolic Acid in Elderly Renal Transplant Recipients Compared to a Younger Control Group: Data from the nEverOld Trial.

BACKGROUND AND OBJECTIVES: Elderly patients are increasingly likely to be recipients of transplants. However, the pharmacokinetics of mycophenolic acid (MPA) in this population are yet to be studied in detail. The objective of this study was to assess whether there were differences in MPA pharmacokinetic parameter values between elderly recipients and younger-adult recipients during the 6 months immediately following renal transplantation. METHODS: In this analysis, the longitudinal 12-h pharmacokinetics of MPA, administered as enteric-coated mycophenolate sodium (EC-MPS), were evaluated in 44 elderly renal transplant recipients and compared with the corresponding pharmacokinetics of MPA in 31 younger adult recipients. Measurements were performed at 7, 30, 60, 90, and 180 days post-transplantation. All patients received tacrolimus and prednisone. RESULTS: The elderly patients were 30 years older than the younger controls, with a predominance of males and Caucasians. Elderly patients had lower serum albumin than the younger controls during the first 6 months after transplantation. The mean estimated total body MPA clearance of the elderly recipients was not significantly different from that of the controls at any analyzed time point (the mean clearance across all time points was 0.31 ± 0.17 vs 0.30 ± 0.25 L/h/kg). MPA exposure, as evaluated from the area under the 12-h time versus measured MPA concentration (adjusted for dose/body weight) curve, did not differ between the groups at any time point (mean exposure across all time points was 4.68 ± 3.61 vs 5.95 ± 4.29 µg·h/mL per mg/kg for the elderly recipients and the controls). CONCLUSIONS: These data show that the pharmacokinetics of MPA in elderly renal transplant recipients were no different to those of younger-adult recipients in this study population. CLINICALTRIALS.GOV: NCT 01631058.

Oral delivery of the anti-tumor necrosis factor α domain antibody, V565, results in high intestinal and fecal concentrations with minimal systemic exposure in cynomolgus monkeys.

OBJECTIVE: V565 is a novel oral anti-tumor necrosis factor (TNF)-α domain antibody being developed for topical treatment of inflammatory bowel disease (IBD) patients. Protein engineering rendered the molecule resistant to intestinal proteases. Here we investigate the formulation of V565 required to provide gastro-protection and enable optimal delivery to the lower intestinal tract in monkeys. METHODS: Enteric-coated V565 mini-tablets were prepared and dissolution characteristics tested in vitro. Oral dosing of monkeys with enteric-coated mini-tablets containing V565 and methylene blue dye enabled in vivo localization of mini-tablet dissolution. V565 distribution in luminal contents and feces was measured by enzyme-linked immunosorbent assay (ELISA). To mimic transit across the damaged intestinal epithelium seen in IBD patients an intravenous (i.v.) bolus of V565 was given to monkeys and pharmacokinetic parameters of V565 measured in serum and urine by ELISA. RESULTS: Enteric-coated mini-tablets resisted dissolution in 0.1 M HCl, before dissolving in a sustained release fashion at neutral pH. In orally dosed monkeys methylene blue intestinal staining indicated the jejunum and ileum as sites for mini-tablet dissolution. Measurements of V565 in monkey feces confirmed V565 survival through the intestinal tract. Systemic exposure after oral dosing was very low consistent with limited V565 mucosal penetration in healthy monkeys. The rapid clearance of V565 after i.v. dosing was consistent with renal excretion as the primary route for elimination of any V565 reaching the circulation. CONCLUSIONS: These results suggest that mini-tablets with a 24% Eudragit enteric coating are suitable for targeted release of orally delivered V565 in the intestine for topical treatment of IBD.

Rabbit as an Animal Model for Pharmacokinetics Studies of Enteric Capsule Contains Recombinant Human Keratinocyte Growth Factor Loaded Chitosan Nanoparticles.

BACKGROUND: Recombinant human keratinocyte growth factor (rHuKGF) has gained considerable attention by researchers as epithelial cells proliferating agent. Moreover, intravenous truncated rHuKGF (palifermin) has been approved by Food and Drug Administration (FDA) to treat and prevent chemotherapy-induced oral mucositis and small intestine ulceration. The labile structure and short circulation time of rHuKGF in-vivo are the main obstacles that reduce the oral bioactivity and dosage of such proteins at the target site. OBJECTIVE: Formulation of methacrylic acid-methyl methacrylate copolymer-coated capsules filled with chitosan nanoparticles loaded with rHuKGF for oral delivery. METHODS: We report on chitosan nanoparticles (CNPs) with diameter < 200 nm, prepared by ionic gelation, loaded with rHuKGF and filled in methacrylic acid-methyl methacrylate copolymercoated capsules for oral delivery. The pharmacokinetic parameters were determined based on the serum levels of rHuKGF, following a single intravenous (IV) or oral dosages using a rabbit model. Furthermore, fluorescent microscope imaging was conducted to investigate the cellular uptake of the rhodamine-labelled rHuKGF-loaded nanoparticles. The proliferation effect of the formulation on FHs 74 Int cells was studied as well by MTT assay. RESULTS: The mucoadhesive and absorption enhancement properties of chitosan and the protective effect of methacrylic acid-methyl methacrylate copolymer against rHuKGF release at the stomach, low pH, were combined to promote and ensure rHuKGF intestinal delivery and increase serum levels of rHuKGF. In addition, in-vitro studies revealed the protein bioactivity since rHuKGFloaded CNPs significantly increased the proliferation of FHs 74 Int cells. CONCLUSION: The study revealed that oral administration of rHuKGF-loaded CNPs in methacrylic acid-methyl methacrylate copolymer-coated capsules is practically alternative to the IV administration since the absolute bioavailability of the orally administered rHuKGF-loaded CNPs, using the rabbit as animal model, was 69%. Fluorescent microscope imaging revealed that rhodaminelabelled rHuKGF-loaded CNPs were taken up by FHs 74 Int cells, after 6 hours' incubation time, followed by increase in the proliferation rate.

Comparative Bioavailability of Metformin Hydrochloride Oral Solution Versus Metformin Hydrochloride Tablets in Fasting Mexican Healthy Volunteers.

INTRODUCTION: Metformin tablets may be challenging to swallow not only for those patients with dysphagia but also for children and the elderly. A metformin solution was developed for easier administration and flexible dose adjustment mantained with the same bioavailability of tablets. The objective of this study was to assess the single-dose oral bioavailability of metformin hydrochloride administered as an oral solution (500 mg/5 mL) compared with metformin hydrochloride 500 mg tablets in fasting Mexican healthy volunteers. METHODS: A randomized, single dose, two-period, two-sequence, crossover study design with a 7-day washout interval was conducted. Subjects were randomly assigned to receive a single dose of 500 mg metformin hydrochloride, either as an oral solution (test drug) or as a tablet (reference drug), after 10 h of fasting. Plasma samples (16) were collected over a 16-h period after drug administration. Bioequivalence was declared when the ratio for the 90% confidence intervals (CI) of the difference in the means of the log-transformed area under the concentration-time curve from time 0 to the last observed concentration time (AUC0-t), the area under the concentration-time curve extrapolated to infinite time (AUC0-∞), and the maximum plasma concentration (Cmax) of the two products were within 0.80 and 1.25 interval. Plasma concentrations were analyzed using reverse phase chromatography by tandem mass spectrometry (LC-MS/MS). Safety and tolerability of metformin were also assessed in all subjects. RESULTS: 24 subjects were enrolled and completed the study (15 female and 9 male). Test and reference metformin hydrochloride were bioequivalent during the extent of exposure since AUC0-t and Cmax 90% CIs corresponded to 89.77-101.08% and 89.63-102.48%, respectively, both being within the pre-specified acceptance range criteria (80-125%). There were two adverse events (AE) with the reference formulation that were not related to the study drug. CONCLUSIONS: Bioequivalence in healthy volunteers in fasting conditions of the two metformin hydrochloride formulations (oral solution and tablets) was established, being the difference in means of AUC0-t, AUC0-∞ and Cmax within the acceptance range (80-125%). Oral solution formulation could offer the advantages of allowing adjusted doses and easier swallowing for every patient. Plain language summary is available for this article. TRIAL REGISTRATION: National Clinical Trials Registry (RNEC by its Spanish acronym), BD METF-Sil No. 86-15. Mexican Medicine Agency (COFEPRIS) Registry: 153300410B0368. FUNDING: Laboratorios Silanes, S.A. de C.V.

Short-Term Intensified Dosage Regimen of Mycophenolic Acid is Associated with Less Acute Rejection in Kidney Transplantation from Donation after Circulatory Death.

INTRODUCTION: Whether an early, short-term, adequate exposure to mycophenolic acid (MPA) under tacrolimus-based immunosuppression regimen in kidney transplantation from donation after circulatory death (DCD) was effective and safe is yet unknown. MATERIAL AND METHODS: The study was a single-center, retrospective, cohort study of DCD transplantation in China. Intensified and standard dosage regimens of enteric-coated mycophenolate sodium (EC-MPS) were week 1, 2,160 vs. 1,440 mg/day. The incidences of biopsy-proven acute rejection (BPAR), delayed graft function, infection, and patient and graft survival were compared between the 2 groups. RESULTS: A total of 209 patients (n = 82 in intensified group and n = 127 in standard group) were enrolled from August 2013 to December 2014. The incidence of BPAR at 12 months was significantly lower in the intensified group as compared to that of the standard group. (2.4 vs. 10.2%, p = 0.035). The mean MPA area under curve (AUC) levels at day 7 was significantly higher in the intensified group than that in the standard group (66.18 ± 35.48 vs. 45.30 ± 23.5 mg·h/L, p < 0.001). MPA AUC levels were significantly decreased in patients with BPAR as compared to those with NO-BPAR. CONCLUSION: An early, short-term regimen of intensified EC-MPS with tacrolimus increased early MPA exposure and achieved a low rate of BPAR in kidney transplantation from DCD.

Development of Colorectal-Targeted Dietary Supplement Tablets Containing Natural Purple Rice Bran Oil as a Colorectal Chemopreventive.

Colorectal cancer occurs due to various factors. The important risks are dietary lifestyle and inflammatory bowel diseases, such as Crohn’s disease and ulcerative colitis. It has been found that the inhibitory enzyme cyclooxygenase-2 (COX-2) in the colorectal region can potentially reduce the risk of colorectal cancer. The present study investigated rice bran oil from natural purple rice bran, which exhibits antioxidant and anti-inflammatory activity. This study aimed to evaluate the bioactive compound content of natural purple rice bran oil (NPRBO) derived from native Thai purple rice and the anti-inflammatory activity of NPRBO in colorectal cancer cells, and to develop a colorectal delivery platform in the form of film-coated tablets. NPRBO from the rice bran of five different Thai purple rice cultivars, namely Khao’ Gam Leum-Phua (KGLP), Khao’ Gam Boung (KGB), Khao’ Gam Thor (KGT), Khao’ Gam Pah E-Kaw (KGPEK), and Khao’ Niaw Dam (KND), were extracted using the supercritical carbon dioxide extraction technique. The amount of γ-oryzanol (ORY), tocotrienols, and tocopherols present in NPRBOs and the in vitro anti-inflammatory activity of NPRBO were investigated. The highest anti-inflammatory NPRBO was transformed into a dry and free-flowing powder by liquisolid techniques. Then, it was compressed into core tablets and coated with Eudragit®L100 and Eudragit® NE30D. The in vitro release study of the film-coated NPRBO tablets was performed in three-phase simulated gastrointestinal media. The cultivar KGLP was superior to the other samples in terms of the ORY, tocotrienol and tocopherol contents and anti-inflammatory activity. Aerosil® was the most suitable absorbent for transforming NPRBO into a free-flowing powder and was used to prepare the NPRBO core tablets. The in vitro KGLP-NPRBO film-coated tablet release profile showed that no ORY was released at gastric pH while 85% of ORY was released at pH 7.4 after 6 h; this would be expected to occur in the colorectal area. Therefore, this study demonstrates the potential of KGLP-NPRBO to prevent colorectal cancer via a specific colorectal dietary supplement delivery system.

Transitioning Patients With Iron Overload From Exjade to Jadenu.

Iron overload is a concern for patients who require chronic transfusions as a result of inherited or acquired anemias, including sickle cell disease, thalassemia, and myelodysplastic syndromes. Iron chelation therapy (ICT) is the primary treatment for iron overload in these patients. The ICT deferasirox, which has been available as an oral dispersible tablet for liquid suspension, is now also available as a once-daily, film-coated tablet (FCT). Deferasirox FCT allows greater convenience and may be associated with fewer gastrointestinal side effects versus the original formulation. Dose adjustment increments, determined by titration monitoring, are lower for the FCT because of greater bioavailability.

Guargum and Eudragit ® coated curcumin liquid solid tablets for colon specific drug delivery.

Colorectal cancer, also known as bowel cancer, is the uncontrolled cell growth in the colon or rectum (parts of the large intestine), or in the appendix. The colon specific drug delivery would alleviate the systemic side effects and would assure the safe therapy for colonic disorders with minimum dose and duration of therapy. The liquisolid technique refers to solubilisation of drug in a non-volatile solvent combined with inclusion of appropriate carrier and coating agent required for tableting. Colon specific degradation of natural polymer, guar gum and pH dependant degradative (pH-7) property of eudragit L100 restricts the delivery of curcumin in gastric and intestinal pH. Formulated curcumin liquisolid powder was evaluated for the micrometric properties, solubility and by differential thermal analysis, X ray powder diffraction and scanning electron microscopy. Curcumin loaded liquisolid tablet showed more anticancer activity against HCT-15 compared with free curcumin. Bioavailability study of the coated and uncoated liquisolid tablets were performed using Newzealand white rabbits. The present study concludes that liquisolid technique is a promising alternative for improving oral bioavailability and dissolution rate of water insoluble drug and coating liquisolid tablet with colon sensitive polymers showed site specific release of drug in the colon.

Liquid Nanosize Emulsion-Filled Enteric-Coated Capsules for Colon Delivery of Immunosuppressant Peptide.

Present study aims at solubilizing slightly water-soluble peptide into a nanosize emulsion which is filled into a hard gelatin capsule in the form of preconcentrate. Further, liquid-filled capsule was dip-coated with ethyl cellulose and Eudragit S100 for colon targeting. An in vitro release profile was studied for selected formulations, i.e., Formulation A (5 mg ethyl cellulose and 40 mg Eudragit S100), Formulation B (10 mg ethyl cellulose and 30 mg Eudragit S100), and Formulation C (10 mg ethyl cellulose and 20 mg Eudragit S100). Formulations B and A showed an immediate release after 5 and 6 h, respectively, which represents ileo-ceacal transit time. The nanosize of emulsion, i.e., below 100 nm, was confirmed by transmission electron microscopy. Also, a phase transition of nanosize emulsion from water in oil to oil in water on dilution with water was observed through TEM. This novel approach of filling poorly water-soluble protein in solubilized form of nanosize emulsion preconcentrate into coated hard gelatin capsules for colon targeting has been reported first time. This approach could be a breakthrough for the better management of local intestinal pathologies.

Application of statistical process control for spotting compliance to good pharmaceutical practice

ABSTRACT For the release of pharmaceutical products into the drug market; most of the pharmaceutical companies depend on acceptance criteria - that are set internally, regulatory and/or pharmacopeially. However, statistical process control monitoring is underestimated in most quality control in cases; although it is important not only for process stability and efficiency assessment but also for compliance with all appropriate pharmaceutical practices such as good manufacturing practice and good laboratory practice, known collectively as GXP. The current work aims to investigate two tablet inspection characteristics monitored during in-process control viz. tablet average weight and hardness. Both properties were assessed during the compression phase of the tablet and before the coating stage. Data gathering was performed by the Quality Assurance Team and processed by Commercial Statistical Software packages. Screening of collected results of 31 batches of an antibacterial tablet - based on Fluoroquinolone -showed that all the tested lots met the release specifications, although the process mean has been unstable which could be strongly evident in the variable control chart. Accordingly, the two inspected processes were not in the state of control and require strong actions to correct for the non-compliance to GXP. What is not controlled cannot be predicted in the future and thus the capability analysis would be of no value except to show the process capability retrospectively only. Setting the rules for the application of Statistical Process Control (SPC) should be mandated by Regulatory Agencies.