Feasibility assessment of a low-cost visible spectroscopy-based prototype for monitoring polyphenol extraction in fermenting musts.

BACKGROUND: Polyphenols have long been used to evaluate grape and wine quality and it is necessary to measure them throughout various winemaking stages. They are currently assessed predominantly through analytical methods, which are characterized by time-consuming procedures and environmentally harmful practices. Non-destructive spectroscopy-based devices offer an alternative but they tend to be costly and not readily accessible for smaller wineries. This study introduces the initial steps in employing a portable, user-friendly, and cost-effective visible (VIS) spectrophotometer prototype for direct polyphenol measurement during winemaking. RESULTS: Grapes (cv Syrah, Bobal, and Cabernet Sauvignon) at different maturation stages were fermented with or without stems. Throughout fermentation, parameters such as color intensity, total polyphenol index, total anthocyanins, and tannins were monitored. Concurrently, VIS spectra were acquired using both the prototype and a commercial instrument. Chemometric approaches were then applied to establish correlation models between spectra and destructive analyses. The prototype models demonstrated an acceptable level of confidence for only a few parameters, indicating their lack of complete reliability at this stage. CONCLUSIONS: Visible spectroscopy is already utilized for polyphenol analysis in winemaking but the aspiration to automate the process in wineries, particularly with low-cost devices, remains unrealized. This study investigates the feasibility of a low-cost and user-friendly spectrophotometer. The results indicate that, in the early stages of prototype utilization, the goal is attainable but requires further development and in-depth assessments. © 2024 The Authors. Journal of The Science of Food and Agriculture published by John Wiley & Sons Ltd on behalf of Society of Chemical Industry.

Optimizing the winemaking process: NIR spectroscopy and e-nose analysis for the online monitoring of fermentation.

BACKGROUND: In the winemaking process, the rapid determination of specific quality parameters such as sugar content, pH, acidity, concentrations of phenolic compounds, anthocyanins and volatile organic compounds is crucial for high-quality wine production. Traditional analytical methods allow for precise quantification of these parameters but are time-consuming and expensive. This article explores the potential application of non-destructive analytical technique (NDAT) (near infra-red [NIR] and e-nose), as efficient alternatives for online monitoring of fermentation working on two different winemaking tanks and applying chemometrics to develop predictive models to correlate non-destructive and analytical data. RESULTS: NIR measurements have been used to build principal components regression models, showing good prediction capability for polyphenols, anthocyanins, glucose and fructose. Both offline and online e-nose applications demonstrate good capability of discriminating different fermentation phases, in agreement with aromatic profile changes observed via gas chromatography-mass spectrometry analysis. Moreover, correlation analysis reveals the potential of quartz microbalances, Taguchi Gas Sensors and H2 S sensors in predicting the concentration of compounds of great interest for winemaking (e.g. C6 alcohols, ketones, terpenes and ethyl esters) highlighting the robust connection between sensor data and specific chemical classes. CONCLUSION: This research aims to showcase the potential employment of NDAT for online monitoring the evolution of must composition during fermentation. The proposed methods could potentially fulfil a longstanding requirement of winemakers, enabling them to closely monitor fermentation allowing the timely making of important technical decisions aimed at achieving oenological objectives in wine production. © 2024 Society of Chemical Industry.

Postharvest wine grape dehydration: ethanol dissipation from grape and biochemical changes.

BACKGROUND: During postharvest dehydration, grapes are subject to metabolic changes including ethanol anabolism and catabolism. These changes affect the quality of the final product and ethanol production is a key step. Ethanol dissipation has never been measured during postharvest wine grape dehydration. Thus, the present study aimed to: (i) monitor ethanol dissipation and (ii) investigate chemical-biochemical changes in berries during dehydration. RESULTS: Ethanol dissipation from Raboso grapes, under controlled postharvest dehydration, was found to comprise up to 36% of weight loss (w.l.). Moreover, the activity of enzymes involved in the anaerobic metabolism of grapes was investigated. Ethanol dissipation was highly correlated with grape weight loss (r2 = 0.989). Alcohol dehydrogenase activity, responsible for the reduction of ethanol to acetaldehyde, declined significantly with w.l. Similarly, pyruvate decarboxylase and lactate dehydrogenase reduced their activity. High lipoxygenase activity was measured at 27% w.l., whereas polyphenol oxidation was constant and declined in the last sampling. CONCLUSION: Ethanol dissipation during postharvest dehydration allows for reducing anaerobic metabolism and promotes oxidative metabolism. The sensor used can be a useful commercial tool for monitoring berry metabolism. © 2023 Society of Chemical Industry.

Novelty of Italian Grape Ale (IGA) beer: Influence of the addition of Gamay macerated grape must or dehydrated Aleatico grape pomace on the aromatic profile.

A new category of fruit style beer resulting from the addition of grape matrices is named Italian Grape Ale (IGA). In this paper, we report data on an experimental work to produce IGA beers, adding macerated (CO2 or N2) red Gamay grape must or Aleatico grape pomace resulting from a grape dehydration process. Our hypothesis, that these wine processes can produce volatile organic compounds (VOCs) to characterize these IGA beers which was confirmed by chemical, sensory and aromatic results. IGA beers especially the one with gas-macerated grape musts (IGA-C and IGA-N) showed higher alcohol content than ALE beer (Control) and a higher polyphenol content and antioxidant activity. As regards VOCS, IGA beers increased the concentration of some classes (i.e., alcohols, esters, norisoprenoids) and IGA-N was better characterized by specific compounds such as isobutyric acid, phenylacetate, tyrosol, ethyl hydrogen succinate. Finally, E-nose and sensory evaluation discriminated significantly all the IGA beers.

Nitrogen maceration of wine grape: An alternative and sustainable technique to carbonic maceration.

Carbonic maceration (CM) consists in placing intact grape bunches into a sealed tank to have a natural or artificially created carbon dioxide atmosphere. No articles have been published on the comparison between CM and nitrogen maceration (NM). Therefore, the present study aimed at testing the use of alternative maceration technique (NM) in alternative to CM, to create the conditions of anoxia on the Gamay variety. The results showed a higher concentration of polyphenols and anthocyanins in the macerated wines, especially in NM wine. Concerning VOCs (Volatile Organic Compounds), the CM wine showed the highest content in esters while the total alcohol content was slightly higher in the NM wines. The CM wine had the highest content in volatile medium chain fatty acids (MCFA). E-nose measurements revealed a clear separation among the samples, and the E-nose data, in PCA computation, were generally overlapped by the PCA of VOCs analysis. The NM showed a potential as environmentally sustainable technique useful to produce a new style of macerated and aromatic wines.

Ozone Gas for Low Cost and Environmentally Friendly Desulfurization of Mute Grape Must.

Ozone is widely used for storage and processing facilities and food sanitization. In this research, ozone was tested as an alternative to high temperature vacuum must desulfurization in order to make a more sustainable process. Bubbling ozone in highly sulfited red must (mute must) at two treatment temperatures, a significant reduction in total and free sulfites from around 1000 mg/L to 200 and 120 mg/L at 20 and 10 °C, respectively, was observed in 24 h, but already after 4 h the concentration was halved. Air flushing of the mute must did not reduce the SO2 content. To evaluate the potential ozone effect on polyphenol oxidation, we carried out the ozone treatment on a water solution with tannins, ascorbic acid, or potassium metabisulfite (MBK) as single and as mixture. In 1 h, 2/3 of sulfite disappeared with the treatment, but the reduction was greater with ascorbate and tannins; the same was observed for ascorbate, whereas tannins decreased to a lesser extent when combined with ascorbate and MBK. Taken together, the results indicate that ozone could be an environmentally friendly, low cost, treatment for desulfurization, especially for white must, and is also easy to use by small wineries.

Ozone and Bioactive Compounds in Grapes and Wine.

Ozone is widely used in the agri-food and food processing industries mainly as a sanitizing agent. However, it has recently become clear that ozone exposition leads to another important benefit: in living tissues, the induced-oxidative stress triggers the antioxidant response, and, therefore, it enhances the production of antioxidant and stress-related secondary metabolites. As such, ozone can be considered an abiotic elicitor. The goal of the present review was to critically summarize knowledge about the possibility of improving bioactive compounds and, consequently, the health-related properties of grapes and wine, by using ozone. The greatest interest has been given not only to the pre- and post-harvest treatment of table and wine grapes, but also to the explanation of the mechanisms involved in the ozone-related response and the main secondary metabolites biosynthetic pathways. From the literature available, it is clear that the effect of ozone treatment on health-related properties and secondary metabolites accumulation depends on many factors, such as the cultivar, but also the form (water or gaseous), doses, and application method of ozone. Most of the published papers report an increase in antioxidant compounds (e.g., polyphenols) and stress-related volatiles, confirming the hypothesis that ozone could be used to improve berry and wine compositional and sensory quality.

Postharvest Water Loss of Wine Grape: When, What and Why.

In postharvest science, water loss is always considered a negative factor threatening fruit and vegetable quality, but in the wine field, this physical process is employed to provide high-quality wine, such as Amarone and Passito wines. The main reason for this is the significant metabolic changes occurring during wine grape water loss, changes that are highly dependent on the specific water loss rate and level, as well as the ambient conditions under which grapes are kept to achieve dehydration. In this review, hints on the main techniques used to induce postharvest wine grape water loss and information on the most important metabolic changes occurring in grape berries during water loss are reported. The quality of wines produced from dried/dehydrated/withered grapes is also discussed, together with an update on the application of innovative non-destructive techniques in the wine sector. A wide survey of the scientific papers published all over the world on the topic has been carried out.

Use of water and ethanol extracts from wine grape seed pomace to prepare an antioxidant toothpaste.

BACKGROUND: Extracts of fresh wine grape seeds/skin or of grape pomace seeds were used to prepare antioxidant natural toothpastes. RESULTS: Ethanol extracted twice more polyphenols than water; ultrasound did not provide any improvement in the extraction. The addition of freeze-dried ethanol extracts of seeds or skin, at 2% and 10%, to the commercial toothpaste significantly increased the polyphenol content, both from white grape seeds and skin and from red grape seed pomace. The evaluation of time stability (shelf life) revealed a decrease, after 4 months, of 3.9% and 9.4% in total polyphenol content, in 5% and 10% water extracts, but not for ethanol extracts. 1,1-Diphenyl-2-picrilhydrazil1 antiradical activity was the highest in 10% of seed water extract toothpaste and, after 4 months, the activity was stable. CONCLUSION: Ethanol and water are efficient and safe solvents to create natural toothpaste with grape or pomace seed extract with antioxidant activity. © 2021 The Authors. Journal of The Science of Food and Agriculture published by John Wiley & Sons Ltd on behalf of Society of Chemical Industry.

Time of Postharvest Ethylene Treatments Affects Phenols, Anthocyanins, and Volatile Compounds of Cesanese Red Wine Grape.

Red Cesanese wine grapes, picked at around 22-23 °Brix, were treated with gas ethylene (500 mg L-1) for 15, 24, and 36 h, or air at 20 °C and 95-100% relative humidity (R.H.), then analysed for titratable acidity, sugar content, pH, total phenols, total and specific anthocyanins, and volatile compounds. Ethylene treatments increased the polyphenol content from 412 to 505 and 488 mg L-1 (about +23 and +19%) for 15 and 24 h samples, respectively. Anthocyanins were increased by ethylene, mainly for 15 h treatment (about +17%). The 36 h ethylene treatment induced a loss anthocyanins (-14%), while phenols practically returned to the initial content. A high content of ethanol, acetic acid, and ethyl acetate were detected in 36 h ethylene-treated grapes, together with higher isoamyl acetate content, compared to air and other ethylene treatments. C6 compounds, markers of lipids peroxidation, were slightly higher in 36 h ethylene-treated samples than in control. Shorter ethylene treatments did not significantly modify the aroma profile compared to air treatment.

Effect of flotation and vegetal fining agents on the aromatic characteristics of Malvasia del Lazio (Vitis vinifera L.) wine.

BACKGROUND: Flotation is a process to reduce the must turbidity after grape pressing. The use of fining agents to reduce the polyphenol content is essential for white wine, but their impact on volatile compounds must be considered. Malvasia del Lazio juice (Vitis vinifera L.) was treated before flotation with animal gelatin (GEL), legume protein plus chitin (LEGCHIT), and legume protein plus yeast extract (LEGYEAST). The clarification efficiency, total polyphenols, and total proteins were determined in the grape must before and after flotation, as well as the volatile composition and sensory characteristics of the resulting wines. RESULTS: The LEGCHIT trial was the most efficient, it being the fastest and achieving the lowest turbidity values. The GEL trial was the slowest, showing grape must turbidity values similar to LEGYEAST but also the highest total protein content. The vegetal protein treatments caused a decrease in the concentration of volatile organic compounds (VOCs) with respect to gelatin, which resulted in a reduction of aroma intensity, particularly for fruity and floral notes, but also for green notes. Furthermore, LEGCHIT wines were appreciated by panelists for their greater body and reduced astringency perception. CONCLUSION: The use of legume protein combined with chitin as a fining agent for flotation is advantageous in terms of clarification efficiency for grape must. Furthermore, the wines obtained showed high perceived global quality, even though a higher loss (38% and 27% respectively for LEGYEAST and LEGCHIT) of VOCs occurred when compared with gelatin. © 2020 Society of Chemical Industry.

Alternating temperature in postharvest cooling treatment of 'Fiano' and 'Falanghina' grapes affects cell wall enzyme rate, berry softening and polyphenols.

BACKGROUND: In wine production, temperature control is important and cooling techniques are frequently used to cool down grape must. Grape compound extraction is facilitated by enzymatic cell wall disassembly. Accordingly, our hypothesis is that the use of an alternating temperature could favor enzyme activity and thus berry compound extraction. RESULTS: White wine grapes (cvs 'Falanghina' and 'Fiano') were kept at 4 °C or at an alternating temperature (4 and 20 °C with a 6-h interval) for 24 h. During the cooling treatment, berry skin resistance, berry firmness and native enzymes from the cell wall were analyzed; sugars, total acidity, malic acid and polyphenols were also measured. In 'Falanghina', α-d-glucosidase, ß-d-galactosidase and pectinmethylesterase increased in grape berry kept at an alternating temperature, and the berry firmness decreased and the polyphenol content was greater than in the other sample. In 'Fiano', polygalacturonase and pectinmethylesterase were responsable for berry softening and, overall, with an alternating temperature, the activity was higher and, consequently, sugars and polyphenol contents were higher. CONCLUSION: Instead of just cooling wine grape, a 24-h cycle of low and high temperature on wine grape after harvest could be used to increase cell wall enzyme activity and, consequently, decrease the berry firmness, favouring an increase in sugars and polyphenol contents. © 2018 Society of Chemical Industry.

Nebulized water cooling of the canopy affects leaf temperature, berry composition and wine quality of Sauvignon blanc.

BACKGROUND: The present paper details a new technique based on spraying nebulized water on vine canopy to counteract the negative impact of the current wave of hot summers with temperatures above 30 °C, which usually determine negative effects on vine yield, grape composition and wine quality. RESULTS: The automatized spraying system was able to maintain air temperature at below 30 °C (the threshold temperature to start spraying) for all of August 2013, when in the canopy of uncooled vines the temperature was as high as 36 °C. The maintenance of temperature below 30 °C reduced leaf stress linked to high temperature and irradiance regimes as highlighted by the decrease of H2 O2 content and catalase activity in the leaves. A higher amount of total polyphenols and organic acids and lower sugars characterized the grapes of cooled vines. Wine from these grapes had a higher content of some volatile thiols like 3-sulfanylhexanol (3SH) and 3-sulfanylhexylacetate (3SHA), and lower content of 4-methyl-4-sulfanylpentan-2-one (4MSP). CONCLUSION: Under conditions of high temperature and irradiance regimes, water nebulization on the vine canopy can represent a valid solution to reduce and/or avoid oxidative stress and associated effects in the leaves, ensure a regular berry ripening and maintain high wine quality. The consumption of water during nebulization was acceptable, being 180 L ha-1 min-1 , which lasted an average of about 1 min to reduce the temperature below the threshold value of 30 °C. A total of 85-90 hL (from 0.8 to 0.9 mm) of water per hectare per day was required. © 2016 Society of Chemical Industry.

Oil accumulation in intact olive fruits measured by near infrared spectroscopy-acousto-optically tunable filter.

BACKGROUND: A field experiment was conducted to test the reliability of the near infrared spectroscopy (NIR)-acousto-optically tunable filter (AOTF) method to measure mesocarp oil content in vivo against nuclear magnetic resonance (NMR) determinations using three different olive cultivars at different stages of ripening. RESULTS: In the partial least squares model carried out for the cultivar 'Arbequina', the coefficient of determination in calibration (R(2)c) was 0.991, while the coefficient of determination in cross-validation (R(2)cv) was 0.979. For the cultivar 'Frantoio' the indexes were 0.982 and 0.971, respectively; while for the cultivar 'Leccino' R(2)c was 0.977 and R(2)cv was 0.965. Finally, for the combined model (sum of the three varieties) these indexes were 0.921 and 0.903, respectively. The residual predictive deviation (RPD) ratio was insufficient for the predictive model of cultivar 'Leccino' only (1.98), whereas in the other cases the RPD ratios were completely sufficient, within the estimation range over 2.5-3 (2.61 in the global model, and 4.23 in the cultivar 'Frantoio'), or in describing a large capacity with values greater than 5, as in the cultivar 'Arbequina' (9.58). CONCLUSION: NIR-AOTF spectroscopy proved to be a novel, rapid and reliable method to monitor the oil accumulation process in intact olive fruits in the field. The innovative approach of coupling NIR and NMR technologies opens up new scenarios for determining the optimal time for harvesting olive trees to obtain maximum oil production.

Feasible application of a portable NIR-AOTF tool for on-field prediction of phenolic compounds during the ripening of olives for oil production.

Olive fruits of three different cultivars (Moraiolo, Dolce di Andria, and Nocellara Etnea) were monitored during ripening up to harvest, and specific and total phenols were measured by HPLC (High Pressure Liquid Chromatography). On the same olive samples (n = 450), spectral detections were performed using a portable NIR (Near Infrared)-AOTF (Acousto Optically Tunable Filter) device in diffuse reflectance mode (1100-2300 nm). Prediction models were developed for the main phenolic compounds (e.g., oleuropein, verbascoside, and 3,4-DHPEA-EDA) and total phenols using Partial Least Squares (PLS). Internal cross-validation (leave-one-out method) was applied for calibration and prediction models developed on the data sets relative to each single cultivar. Validation of the models obtained as the sum of the three sample sets (total phenols, n = 162; verbascoside, n = 162; oleuropein, n = 148; 3,4-DHPEA-EDA, n = 162) were performed by external sets of data. Obtained results in term of R(2) (in calibration, prediction and cross-validation) ranged between 0.930 and 0.998, 0.874-0.942, and 0.837-0.992, respectively. Standard errors in calibration (RMSEC), cross-validation (RMSECV), and prediction (RMSEP) were calculated obtaining minimum error in prediction of 0.68 and maximum of 6.33 mg/g. RPD ratios (SD/SECV) were also calculated as references of the model effectiveness. This work shows how NIR-AOTF can be considered a feasible tool for the on-field and nondestructive measurement of specific and total phenols in olives for oil production.

Discrimination of sweet wines partially fermented by two osmo-ethanol-tolerant yeasts by gas chromatographic analysis and electronic nose.

Some special sweet wines are obtained by partial fermentation of musts from off-vine dried grapes containing large amounts of sugars. This process is very slow and subject to serious stop problems that can be avoided by using osmo-ethanol-tolerant yeasts. Musts containing 371g/l of sugars were partially fermented with selected Saccharomyces cerevisiae strains, X4 and X5, to 12% (v/v) and the wines obtained with X5 exhibited a higher volatile acidity but lower concentrations of higher alcohols, carbonyl compounds and polyols than those obtained with X4. A principal component analysis (PCA) of the data provided by an electronic nose (E-nose) afforded discrimination between fermented and unfermented musts, but not between wines obtained with X4 or X5. The PCA applied to the major volatile compounds and polyols shows similar results, but a clear discrimination between wines is obtained by removing the polyols glycerol and 2,3-butanediol from the PCA.

Chemical and biochemical change of healthy phenolic fractions in winegrape by means of postharvest dehydration.

Clusters of Aleatico winegrape were picked at 18 degrees Brix and placed at 10, 20, or 30 degrees C, 45% relative humidity (RH) and 1.5 m/s of air flow to dehydrate the berries up to 40% of loss of initial fresh weight. Sampling was done at 0, 10, 20, 30, and 40% weight loss (wl). Selected polyphenols and sugar content (expressed as SSC = soluble solids content) both measured on dry weight basis, polyphenol oxidase (PPO), and phenylpropanoid pathway gene expression were analyzed. Phenolic acids increased significantly at 20% wl at 20 degrees C, while at 10 degrees C the increase was lower. Stilbenes (trans-resveratrol and trans-piceid) and catechins rose more than double to 100 mg/kg and more than 3-fold to 135 mg/kg at 20 degrees C and 10% wl. At 10 degrees C the increase of these compounds was less, but higher than initial values. At 30 degrees C, except for a significant rise at 10% wl for catechins and stilbenes, all the rest of the compounds diminished. Anthocyanins increased at 10 and 20 degrees C, but decreased at 30 degrees C. PPO rapidly increased at 20 and 30 degrees C at 10% wl and then declined, while at 10 degrees C the activity lasted longer. Relative gene expression of phenylalanine ammonia lyase (PAL), stilbene synthase (STS), chalcone isomerase (CHI), dihydroflavonol reductase (DFR) were upregulated at 10 degrees C more than at 20 degrees C, at 20% wl, while at 30 degrees C the gene expression was downregulated.

Influence of ethylene inhibition by 1-methylcyclopropene on apricot quality, volatile production, and glycosidase activity of low- and high-aroma varieties of apricots.

Apricots of two varieties, Ceccona with strong aroma and San Castrese with low aroma but good firmness, were treated with 1 microL L(-)(1) 1-methylcyclopropene (1-MCP) for 12 h at 20 degrees C and then kept for shelf life at 20 degrees C and 85% relative humidity. 1-MCP treatment strongly inhibited ethylene production in apricots of both varieties, and softening was delayed. Fruit softening started before the rise of ethylene in air-treated apricots, which softened even when the rise of ethylene production was inhibited by 1-MCP. The softening reduction was more significant in Ceccona apricots than in San Castrese. Pectinmethylesterase (PME) activity declined in Ceccona fruit regardless of the treatment; in San Castrese, PME of air-treated fruit slightly increased, whereas in 1-MCP-treated apricots the activity declined. alpha-d-Galactosidase (alpha-gal) and beta-d-galactosidase (beta-gal) activities in Ceccona apricot were significantly reduced by 1-MCP treatment, whereas in San Castrese apricot no difference in activities was observed between air- and 1-MCP-treated fruit. The pattern of beta-d-xylosidase (xyl) activity in San Castrese apricot was similar to that of beta-gal, showing a peak on day 4 without difference between treatments. alpha-d-Mannosidase (alpha-man) activity of air-treated apricots of both varieties rose slightly, and 1-MCP treatment decreased the enzyme activity in both varieties. alpha-d-Glucosidase (alpha-glu) decreased in air-treated apricots in both varieties, and 1-MCP maintained higher activity in Ceccona fruit but not in San Castrese. Acidity decreased during postharvest ripening regardless of the treatment, whereas soluble solids content (SSC) increased in Ceccona apricot and slightly diminished in San Castrese ones without any effect by 1-MCP treatment. 1-MCP did not show any effect on apricot color; in contrast, it affected the volatiles profile, especially in Ceccona apricot, reducing the synthesis of lactones and promoting the rise of terpenols.