A New Approach for Bioremediation of Olive Mill Wastewaters: Combination of Straw Filtration and Nanofiltration.

A combination of straw filtration and nanofiltration was investigated for the first time as a sustainable approach aimed at valorizing olive mill wastewaters (OMWs) within a circular economy strategy. Ground straw filters with different granulometry (120, 250 and 500 µm) were tested in the first step to clarify the raw wastewater. The 500 µm filter offered the best performance due to a lower exposed surface of the filtering fibers and a shorter filtering time, allowing us to reduce about 70% of the chemical oxygen demand (COD) of the raw wastewater. Three different commercial membranes in a flat-sheet configuration with a molecular weight cut-off (MWCO) in the range 150-500 Da were tested to fractionate the clarified wastewater according to a dead-end configuration. Among the investigated membranes, a polymeric membrane of 500 Da (NFA-12A) exhibited the highest productivity in selected operating conditions (steady-state values of 11.4 L/m2 h at 20 bar and 24 ± 2 °C). In addition, flux decays for this membrane were lower than the other two tested membranes, indicating a lower propensity to fouling phenomena. Higher rejections towards total polyphenols and total antioxidant activity (TAA) (76.6% and 73.2%, respectively) were also observed for this membrane. Flavanols and hydroxycinnamic acids were retained by more than 99%. The combination of straw filtration and NF with the NFA-12A membrane allowed us to reduce the COD of raw OMWs up to 97.6%. The retentate fraction of this membrane exhibited a TAA of 18.9 ± 0.7 mM Trolox, supporting its propensity for the development of innovative formulations of interest in food and nutraceutical applications.

NMR-Based Characterization of Citrus Tacle Juice and Low-Level NMR and UV-Vis Data Fusion for Monitoring Its Fractions from Membrane-Based Operations.

Tacle is a citrus variety which recently gained further interest due to its antioxidant and biological properties. This study suggests using Nuclear Magnetic Resonance (NMR) imaging to characterize Tacle juice's metabolic composition as it is intimately linked to its quality. First, polar and apolar solvent systems were used to identify a significant fraction of the Tacle metabolome. Furthermore, the antioxidant capacity and the total content of flavonoids, polyphenols and ß-carotene in the juice were investigated with UV-Visible spectroscopy. Tacle juice was clarified and fractionated by ultrafiltration (UF) and nanofiltration (NF) membranes in order to recover and purify its bioactive principles. Finally, the second part of this work sheds light on the spectrophotometric assays and 1H-NMR spectra of fractions coming from membrane operations coupled with a multivariate data analysis technique, PCA, to explore the impact of UF and NF processes on the metabolic profile of the juice.

Concentration of Bioactive Phenolic Compounds in Olive Mill Wastewater by Direct Contact Membrane Distillation.

Olive mill wastewater (OMW), generated as a by-product of olive oil production, is considered one of the most polluting effluents produced by the agro-food industry, due to its high concentration of organic matter and nutrients. However, OMW is rich in several polyphenols, representing compounds with remarkable biological properties. This study aimed to analyze the chemical profile as well as the antioxidant and anti-obesity properties of concentrated fractions obtained from microfiltered OMW treated by direct contact membrane distillation (DCMD). Ultra-high performance liquid chromatography (UHPLC) analyses were applied to quantify some phenols selected as phytochemical markers. Moreover, α-Amylase, α-glucosidase, and lipase inhibitory activity were investigated together with the antioxidant activity by means of assays, namely ß-carotene bleaching, 2,2'-azino-bis(3-ethylbenzothiazoline-6-sulphonic) acid (ABTS) diammonium salts, 2,2-diphenyl-1-picrylhydrazyl (DPPH) assay, and Ferric Reducing Activity Power (FRAP) tests. MD retentate-which has content of about five times greater of hydroxytyrosol and verbascoside and about 7 times greater of oleuropein than the feed-was more active as an antioxidant in all applied assays. Of interest is the result obtained in the DPPH test (an inhibitory concentration 50% (IC50) of 9.8 µg/mL in comparison to the feed (IC50 of 97.2 µg/mL)) and in the ABTS assay (an IC50 of 0.4 µg/mL in comparison to the feed (IC50 of 1.2 µg/mL)).

Olive Mill Wastewater Polyphenol-Enriched Fractions by Integrated Membrane Process: A Promising Source of Antioxidant, Hypolipidemic and Hypoglycaemic Compounds.

The valorisation of food wastes is a challenging opportunity for the green, sustainable, and competitive development of industry. The recovery of phenols contributes to the sustainability of olive waste sector, reducing its environmental impact and promoting the development of innovative formulations of interest for pharmaceutical, nutraceutical, and cosmeceutical applications. In this work, olive mill wastewater was treated through a combination of microfiltration (MF), nanofiltration (NF), and reverse osmosis (RO) in a sequential design to produce polyphenol-enriched fractions that have been investigated for their chemical profile using ultra-high-performance liquid chromatography (UHPLC), and their potential antioxidant, hypolipidemic, and hypoglycaemic activities. RO retentate exhibited the highest content of hydroxytyrosol, tyrosol, oleuropein, verbascoside, vanillic acid, and luteolin. In particular, a content of hydroxytyrosol of 1522.2 mg/L, about five times higher than the MF feed, was found. RO retentate was the most active extract in all in vitro tests. Interestingly, this fraction showed a 2,2'-azino-bis(3-ethylbenzothiazoline-6-sulfonic) acid (ABTS) radicals scavenging activity with an IC50 value of 6.9 µg/mL and a potential inhibition of lipid peroxidation evaluated by the ß-carotene bleaching test with IC50 values of 25.1 µg/mL after 30 min of incubation. Moreover, RO retentate inhibited α-amylase and α-glucosidase with IC50 values of 65.3 and 66.2 µg/mL, respectively.

Biologically Active Compounds from Goji (Lycium Barbarum L.) Leaves Aqueous Extracts: Purification and Concentration by Membrane Processes.

Goji (Lycium barbarum L.) leaves and fruits have been described as a valuable source of bioactive compounds with a great potential for the development of health-promoting formulations. The present study aimed to evaluate the potential of a sustainable process for the recovery of phenolic compounds from Goji leaves through a combination of aqueous extraction and membrane-based operations. Water was used as a safe, cheap, and non-hazardous extraction solvent, and parameters of extraction of dried Goji leaves were optimized in order to maximize the yield of polyphenols, total soluble solids (TSS), and total antioxidants simultaneously. The aqueous extract was clarified by ultrafiltration and then processed with three flat-sheet polyethersulphone (PES) membranes with molecular weight cut-off (MWCO) values in the range of 0.3-4.0 kDa, in order to remove sugar compounds from polyphenols and improve the antioxidant activity of the produced fractions. Among the selected membranes, a 1 kDa membrane exhibited the best performance in terms of purification of polyphenols from the clarified aqueous extract. The rejection by this membrane of TSS and total carbohydrates was in the range of 15.8-25.3%, and was decreased by increasing the volume reduction factor (VRF). On the other hand, the retention values for total polyphenols and total antioxidant activity (TAA) were in the range of 73-80%, and were increased by increasing the VRF.

A Combination of Aqueous Extraction and Polymeric Membranes as a Sustainable Process for the Recovery of Polyphenols from Olive Mill Solid Wastes.

Polyamide commercial membranes in flat-sheet configuration and with molecular weight cut-off (MWCO) in the range of ultrafiltration (UF) to nanofiltration (NF) were tested for the recovery of phenolic compounds from clarified olive mill solid waste (OMSW) aqueous extracts. The performance of selected membranes was evaluated in terms of productivity (permeate flux) and selectivity towards biologically active compounds (such as phenolic compounds, flavanols, and hydroxycinnamic acids derivatives) and total antioxidant activity (TAA) as a function of transmembrane pressure (TMP). NF membranes produced higher permeate fluxes and a lower fouling index in comparison with UF membranes. Retention of bioactive compounds was also significantly higher for NF membranes than for UF membranes. In particular, membranes with MWCO in the range 150-500 Da showed rejection towards flavanols and hydroxycinnamic acid derivatives of about 100%. On the other hand, the rejection towards TAA and total polyphenols was of about 90% and 72%, respectively. Therefore, NF retentate fractions appear of practical interest for the production of food additives and food supplements due to their high antioxidant activity.

Membrane-Based Clarification and Fractionation of Red Wine Lees Aqueous Extracts.

Polyvinylidenefluoride (PVDF) hollow fiber membranes prepared in laboratory through the inversion phase method were characterized and used to clarify an aqueous extract from red wine lees. Steady-state permeate fluxes of 53 kg/m2h were obtained in the treatment of the aqueous extract in selected operating conditions. Suspended solids were completely retained by the hollow fiber membranes while bioactive compounds, including polyphenols, anthocyanins, and resveratrol were recovered in the permeate stream. The clarified stream was then fractionated by nanofiltration (NF). Three different commercial membranes, in flat-sheet configuration (NP010 and NP030 from Microdyn-Nadir, MPF36 from Koch Membrane Systems), were selected and tested for their productivity and selectivity towards sugars and bioactive compounds, including phenolic compounds, anthocyanins, and resveratrol. All selected membranes showed high retention towards anthocyanins (higher than 93%). Therefore, they were considered suitable to concentrate anthocyanins from clarified wine lees extracts at low temperature. On the other hand, NF permeate streams resulted enriched in phenolic compounds and resveratrol. Among the selected membranes, the MPF36 exhibited the lowest retention towards resveratrol (10%) and polyphenols (26.3%) and the best separation factor between these compounds and anthocyanins.

A Membrane-Based Process for the Recovery of Glycyrrhizin and Phenolic Compounds from Licorice Wastewaters.

In this work, the use of polymeric ultrafiltration and nanofiltration membranes was investigated in order to recover glycyrrhizin and phenolic compounds from licorice wastewaters. Filtration experiments were performed on a laboratory scale using four polyamide thin-film composite membranes (GK, GH, GE, and DK, from GE Osmonics) with different molecular weight cut-offs (from 150 to 3500 Da). The permeate flux and retention values of glycyrrhizin, the total polyphenols, the caffeic acid, the total carbohydrate, and the total antioxidant activity as a function of the transmembrane pressure (TMP) and weight reduction factor (WRF) were evaluated. In selected operating conditions, the membrane productivity decreased in the order of GK > DK > GH > GE, with a similar trend to that of water permeability. Glycyrrhizin was totally rejected by selected membranes, independently of TMP and WRF. For the other antioxidant compounds, the retention values increased by increasing both of the parameters. According to the experimental results, a combination of membranes in a sequential design was proposed as a viable approach to produce concentrated fractions enriched in bioactive compounds and purified water from licorice wastewater.

Treatment of Flue Gas Desulfurization Wastewater by an Integrated Membrane-Based Process for Approaching Zero Liquid Discharge.

An integrated membrane process for the treatment of wastewaters from a flue gas desulfurization (FGD) plant was implemented on a laboratory scale to reduce their salt content and to produce a water stream to be recycled in the power industry. The process is based on a preliminary pretreatment of FGD wastewaters, which includes chemical softening and ultrafiltration (UF) to remove Ca2+ and Mg2+ ions as well as organic compounds. The pretreated wastewaters were submitted to a reverse osmosis (RO) step to separate salts from water. The RO retentate was finally submitted to a membrane distillation (MD) step to extract more water, thus increasing the total water recovery factor while producing a high-purity permeate stream. The performance of RO and MD membranes was evaluated by calculating salts rejection, permeate flux, fouling index, and water recovery. The investigated integrated system allowed a total recovery factor of about 94% to be reached, with a consequent reduction of the volume of FGD wastewater to be disposed, and an MD permeate stream with an electrical conductivity of 80 µS/cm, able to be reused in the power plant, with a saving in fresh water demand.

Nanofiltration and Tight Ultrafiltration Membranes for the Recovery of Polyphenols from Agro-Food By-Products.

Pressure-driven membrane-based technologies represent a valid approach to reduce the environmental pollution of several agro-food by-products. Recently, in relation to the major interest for natural compounds with biological activities, their use has been also addressed to the recovery, separation and fractionation of phenolic compounds from such by-products. In particular, tight ultrafiltration (UF) and nanolfiltration (NF) membranes have been recognized for their capability to recover phenolic compounds from several types of agro-food by-products. The separation capability of these membranes, as well as their productivity, depends on multiple factors such as membrane material, molecular weight cut-off (MWCO) and operating conditions (e.g., pressure, temperature, feed flow rate, volume reduction factor, etc.). This paper aims at providing a critical overview of the influence of these parameters on the recovery of phenolic compounds from agro-food by-products by using tight UF and NF membranes. The literature data are analyzed and discussed in relation to separation processes, molecule properties, membrane characteristics and other phenomena occurring in the process. Current extraction methodologies of phenolic compounds from raw materials are also introduced in order to drive the implementation of integrated systems for the production of actractive phenolic formulations of potential interest as food antioxidants.

Clarification of Orange Press Liquors by PVDF Hollow Fiber Membranes.

Press liquors are typical by-products of the citrus juice processing characterized by a high content of organic compounds and associated problems of environmental impact, which imply high treatment costs. However, these wastes contain a great number of health promoting substances, including fibers, carotenoids and phenolic compounds (mainly flavonoids), whose recovery against waste-destruction technologies is very attractive for new business opportunities. In this work, the clarification of orange press liquor by using microfiltration (MF) membranes is studied as a preliminary step to obtain a permeate stream enriched in antioxidant compounds which can be further processed to produce extracts of nutraceutical and/or pharmaceutical interest. MF poly(vinylidene fluoride) (PVDF) hollow fibers were prepared by the dry/wet spinning technique. A series of fibers was produced from the same polymeric dope, in order to investigate the effect of selected spinning parameters, i.e., bore fluid composition and flowrate, on their properties. The morphology of the produced fibers was analyzed by Scanning Electron Microscopy (SEM). Fibers were further characterized for their mechanical properties, porosity, bubble point, pore size distribution and pure water permeability (PWP). Some of the produced fibers exhibited high permeability (pure water permeability ~530 L/m²·h·bar), coupled to good mechanical resistance and pore size in the range of MF membranes. These fibers were selected and used for the clarification of press liquor from orange peel processing. In optimized operating conditions, the selected fibers produced steady-state fluxes of about 41 L/m²·h with rejections towards polyphenols and total antioxidant activity of 4.1% and 1.4%, respectively.

Recovery of flavonoids from orange press liquor by an integrated membrane process.

Orange press liquor is a by-product generated by the citrus processing industry containing huge amounts of natural phenolic compounds with recognized antioxidant activity. In this work, an integrated membrane process for the recovery of flavonoids from orange press liquors was investigated on a laboratory scale. The liquor was previously clarified by ultrafiltration (UF) in selected operating conditions by using hollow fiber polysulfone membranes. Then, the clarified liquor with a total soluble solids (TSS) content of 10 g·100 g-1 was pre-concentrated by nanofiltration (NF) up to 32 g TSS 100 g-1 by using a polyethersulfone spiral-wound membrane. A final concentration step, up to 47 g TSS 100 g-1, was performed by using an osmotic distillation (OD) apparatus equipped with polypropylene hollow fiber membranes. Suspended solids were completely removed in the UF step producing a clarified liquor containing most part of the flavonoids of the original press liquor due to the low rejection of the UF membrane towards these compounds. Flavanones and anthocyanins were highly rejected by the NF membrane, producing a permeate stream with a TSS content of 4.5 g·100 g-1. An increasing of both the flavanones and anthocyanins concentration was observed in the NF retentate by increasing the volume reduction factor (VRF). The final concentration of flavonoids by OD produced a concentrated solution of interest for nutraceutical and pharmaceutical applications.

Fractionation of olive mill wastewaters by membrane separation techniques.

This study aims to evaluate the potential of an integrated membrane system in the treatment of olive mill wastewaters (OMWs) to produce a purified fraction enriched in low molecular weight polyphenols, a concentrated fraction of organic substances and a water stream which can be reused in the extractive process of olive oil. In particular, a sequence of two ultrafiltration (UF) processes followed by a final nanofiltration (NF) step was investigated on laboratory scale operating in selected process parameters. The produced fractions were analyzed for their total content of polyphenols, total antioxidant activity (TAA), free low molecular weight polyphenols and total organic carbon (TOC). The performance of selected membranes in terms of productivity, fouling index and selectivity toward compounds of interest was also evaluated and discussed. An integrated membrane process was proposed to achieve high levels of purification of OMWs and a water fraction which can be discharged in aquatic systems or to be reused in the olive oil extraction process.