Immobilised native plant cysteine proteases: packed-bed reactor for white wine protein stabilisation.

This research presents a feasibility study of using a continuous packed-bed reactor (PBR), containing immobilised native plant cysteine proteases, as a specific and mild alternative technique relative to the usual bentonite fining for white wine protein stabilisation. The operational parameters for a PBR containing immobilised bromelain (PBR-br) or immobilised papain (PBR-pa) were optimised using model wine fortified with synthetic substrate (Bz-Phe-Val-Arg-pNA). The effectiveness of PBR-br, both in terms of hazing potential and total protein decrease, was significantly higher than PBR-pa, in all the seven unfined, white wines used. Among the wines tested, Sauvignon Blanc, given its total protein content as well as its very high intrinsic instability, was selected as a control wine to evaluate the effect of the treatment on wine as to its soluble protein profile, phenolic composition, mineral component, and sensory properties. The treatment in a PBR containing immobilised bromelain appeared effective in decreasing both wine hazing potential and total protein amount, while it did not significantly affect the phenol compounds, the mineral component nor the sensory quality of wine. The enzymatic treatment in PBR was shown to be a specific and mild technique for use as an alternative to bentonite fining for white wine protein stabilisation.

Assessing the Potential Content of Ethyl Carbamate in White, Red, and Rosé Wines as a Key Factor for Pursuing Urea Degradation by Purified Acid Urease.

The ethyl carbamate (EC) content of a wine after a given temperature-time storage was theoretically predicted from the potential concentration of ethyl carbamate (PEC), as determined via an accelerated EC formation test. Such information was used to decide whether an enzymatic treatment was needed to reduce the wine urea level before bottling/aging. To this end, 6 white, red, and rosé wines, manufactured in Italy as such or enriched with urea, were tested for their PEC content either before or after enzymatic treatment using a purified acid urease preparation derived from Lactobacillus fermentum. The treatment was severely affected by the total phenolic content (TP) of the wine, the estimated pseudo-first-order kinetic rate constant for NH3 formation reducing by a factor of approximately 2000 as the TP increased from 0 to 1.64 g L(-1) . Such a sensitivity to TP was by far greater than that pertaining to a killed cell-based enzyme preparation used previously. Urea hydrolysis was successful at reducing EC concentration in wines with low levels of TP and other EC precursors.