The effect of priming techniques of ultrafiltrators on blood rheology: an in vitro evaluation.

The increased interest of using ultrafiltration during cardiopulmonary bypass ICPB) has mandated a re-evaluation of the hematological effects of this blood conservation process. 'Rinse-free' ultrafiltrators can be primed using either crystalloid or blood prior to use. It is unknown whether one priming technique results in superior results in ultrafiltration quality. An in vitro circuit was designed to evaluate the Sorin/COBE HC1400 (n=6), the Lifestream HC70 (n=6), and the Terumo/Sarns HC11 (n=6). All test conditions were conducted at a blood flow rate of 250 ml/min and a transmembrane pressure of 250 mmHg. Samples were drawn and analyzed at four distinct time points for hematocrit, total protein, plasma free hemoglobin, interleukin-6 (IL-6), interleukin-8 (IL-8), and tumor necrosis factor-alpha (TNFalpha). The HC11 had significantly greater percent increases in hematocrit under the blood priming protocol (29.2+/-7.9) than either the HC1400 (11.0+/-7.8, p<0.03) or the HC70 (11.9+/-7.8, p<0.04). When crystalloid priming was compared to blood priming, the HC1400 and HC70 produced significant percent increases in hematocrit and total protein levels. The HC1400 devices produced significantly less plasma free hemoglobin when primed with crystalloid rather than blood (43.6+/-38.3 vs 21.3+/-5.6, p<0.01). There were no significant differences between devices or priming techniques for IL-6, IL-8 or TNFalpha levels. In conclusion, the efficiency of the ultrafiltrators was elevated when primed with crystalloid before use. Cytokine levels were relatively unchanged with priming techniques, while plasma free hemoglobin levels were reduced with those devices previously primed with crystalloid.

An experimental evaluation of continuous cardiotomy reservoir ultrafiltration.

Ultrafiltration has been suggested as a means to reduce the morbidity associated with blood activation. However, the application of ultrafiltration to the highly activated blood of the cardiotomy suction subcircuit has not been investigated. The purpose of this study was to determine whether cardiotomy reservoir ultrafiltration (CRUF) would be effective in altering cytokine levels. Six swine, undergoing 90 min of cardiopulmonary bypass (CPB), were divided into two groups; one group was assigned to receive CRUF (N = 3), the other was to serve as controls and did not receive ultrafiltration (N = 3). Blood samples were analyzed for hematocrit, plasma-free hemoglobin, total protein, interleukin-8 (IL-8), and tumor necrosis factor alpha (TNF-alpha). Samples were taken pre-bypass, postheparinization, every 30 min during CPB, post-CPB and postprotamine. All data were analyzed using a one-way analysis of variance (ANOVA), with significance accepted at p < .05. There were no significant differences found between treatment and control groups for plasma-free hemoglobin levels (22.4 +/- 22.2 vs. 14.6 +/- 14.4; 40.1 +/- 26.1 vs. 40.0 +/- 19.3). After 90 min of ultrafiltration, there was a significant decrease in TNF-alpha (261.6 +/- 119.6 vs. 71.8 +/- 11.4; p = .02). Although IL-8 levels decreased from throughout the experiment, concentrations did not reach statistical significance. In conclusion, CRUF can be used without increasing cellular destruction, and can decrease certain cytokine levels. Our results suggest that further clinical studies should be undertaken utilizing this technique with a larger sample size.