The Impact of Inadequate Temperature Storage Conditions on Aggregate and Particle Formation in Drugs Containing Tumor Necrosis Factor-Alpha Inhibitors.

PURPOSE: To measure aggregate and particle formation in tumor necrosis factor-alpha (TNF-α) inhibitors etanercept, adalimumab and certolizumab pegol product samples after exposure to freezing temperature conditions similar to storage conditions previously observed in patients' homes. METHODS: TNF-α inhibitors in their original primary and secondary packaging were exposed to 32 freeze-thaw cycles (-10°C for 120min/5°C for 60 min) or continuous low storage temperature (-20°C for 96 h) before thawing at 2-8°C. Non-stressed products were used as controls. The products were analyzed by high pressure size exclusion chromatography (HP-SEC), dynamic light scattering (DLS), nanoparticle tracking analysis (NTA), micro-flow imaging (MFI) and second derivative ultraviolet (UV) spectroscopy. RESULTS: Ten out of twenty-one stressed product samples (47.6%) showed increased particle numbers in the submicron and micron size range when compared to controls. For each product, DLS, MFI and NTA detected an increase in particle level in at least one stressed syringe (both continuous freezing and freeze-thaw), whereas HP-SEC and UV spectroscopy showed no differences between stressed and non-stressed products. CONCLUSION: TNF-α inhibitors are relatively resistant to freezing temperatures similar to storage conditions previously observed in patients' homes. However, almost half of the stressed product samples showed formation of particles in the submicron and micron size range.

Effects of absorption enhancers on rat nasal epithelium in vivo: release of marker compounds in the nasal cavity.

PURPOSE: The assessment of the effects of nasal absorption enhancers on the rat nasal epithelium and membrane permeability in vivo after a single nasal dose of the enhancers. METHODS: The release of marker compounds (protein, cholesterol and acid phosphatase) from the nasal epithelium was measured using a lavage technique. The nasal membrane permeability was determined after intravenous administration of a systemic tracer (FITC-albumin). RESULTS: The effects of the absorption enhancers could be classified into four categories. The first consisted of HP beta CD (5%), DM beta CD (2%) and RAMEB (2%) and was not different from the control (physiological saline). For the second category, DM beta CD (5%), effects were significantly higher than for the control. The third category, SGC (1%), was more active than DM beta CD (5%) but less active than the last group. The fourth, most membrane damaging, category consisted of STDHF (1%), laureth-9 (1%) and LPC (1%). Administration of these three enhancers also resulted in release of acid phosphatase, indicating that severe membrane damage occurred. The release of cholesterol from nasal epithelium was largely dependent on the cholesterol solubilisation of the absorption enhancers. The amount of cholesterol released by laureth-9 and LPC was the largest. CONCLUSIONS: The results of this in vivo study are in agreement (i.e. similarity in rank order) with morphological and ciliotoxicity studies of nasal absorption enhancers, demonstrating that this in vivo model is a valuable tool to classify nasal absorption enhancers according to their effects on the rat nasal epithelium.

Hypocalcemic effect of salmon calcitonin following single and repeated nasal and intravenous administration in young rabbits.

The effect of the polypeptide salmon calcitonin (sCT) on serum calcium concentrations following intranasal and intravenous administration was studied in young rabbits. A small, hypocalcemic effect was observed after nasal administration of sCT without additives, indicating that the nasal sCT absorption was low. The absorption could be improved by addition of an absorption-enhancing adjuvant to the nasal preparation. The absorption, however, was still far from complete as was apparent from the much stronger effect of intravenously injected sCT. When a number of sCT doses were given during a 10-week period, the hypocalcemic effect per sCT dose in the young rabbits decreased after intravenous and, although less pronounced, after nasal administration. The decreased response to sCT is probably not related to the induction of neutralizing antibodies or desensitization of sCT receptors, but is more likely associated with the age-dependent level of bone activity.