Study on the Effect of Threshold Pressure Gradient on Remaining Oil Distribution in Heavy Oil Reservoirs.

Due to the spatial network structure, heavy oil has a high threshold pressure gradient when it flows through porous media, and the threshold pressure gradient plays a crucial role in the distribution of remaining oil. In previous study, the common methods to measure the threshold pressure gradient include the microflow-established differential pressure (MFEDP) method, capillary equilibrium method, and the percolation curve fitting method. In this study, a sample from the SZ36-1 oilfield was analyzed for the basic physical properties based on the comparison of the previous measurement to study the influence of mobility on the threshold pressure gradient and then an independently developed numerical simulator was established to study the effect of the threshold pressure gradient on the remaining oil distribution considering the permeability range, crude oil viscosity, well network deployment, well spacing, and fluid recovery rate. The results show that the SZ36-1 oilfield fluid belongs to Bingham fluids with yield stress and the mobility having an exponent relation to the threshold pressure gradient based on the measurement of the MFEDP method. Considering the threshold pressure gradient of heavy oil, the uneven distribution of remaining oil is intensified and the remaining oil is enriched. This study provides a reference for efficient development of heavy oil reservoirs.

Polymer Flooding in Heterogeneous Heavy Oil Reservoirs: Experimental and Simulation Studies.

Polymer flooding (PF) in heterogeneous heavy oil reservoirs is not only closely related to polymer degradation, but also to non-Newtonian flow. In this paper, both experimental and simulation methods are combined to investigate this type of flooding. Through experiments, the degradation of polymer, rheological properties of fluids, and flow of fluids in porous media were determined. Based on the experimental results, a novel mathematical model was established, and a new PF simulator was designed, validated, and further applied to study the effects of polymer degradation, polymer solution shear thinning, and non-Newtonian flow on PF in heterogeneous heavy oil reservoirs. These experimental results demonstrated that the polymer first-order static degradation rate constant was lower than the polymer first-order dynamic degradation rate constant; the polymer solution and heavy oil were non-Newtonian fluids, with shear thinning and Bingham fluid properties, respectively; and the heavy oil threshold pressure gradient (TPG) in low-permeability porous media was higher than that in high-permeability porous media. All comparison results showed that the designed simulator was highly accurate and reliable, and could well describe both polymer degradation and non-Newtonian flow, with special emphasis on the distinction between polymer static and dynamic degradation and heavy oil TPG. Furthermore, the simulation results verified that polymer degradation, polymer solution shear thinning, and heavy oil TPG all had negative effects on the efficiency of PF in heterogeneous heavy oil reservoirs.

Tracking alterations of alkyl side chains of N1 species in heavy crude oil after anaerobic biodegradation with negative-ion electrospray ionization coupled with high-field Fourier transform ion cyclotron resonance mass spectrometry.

RATIONALE: Heteroatomic compounds are relatively abundant and believed to be bio-resistant in heavy crude oils. However, few studies have focused on the biodegradation of these heteroatomic compounds. METHODS: Heteroatoms, especially N1 species, in a blank crude oil and in three treated oils co-incubated with anaerobic sulfate-reducing bacteria, nitrate-reducing bacteria and fermentative consortia cultures were detected using negative-ion electrospray ionization coupled with high-field Fourier transform ion cyclotron resonance mass spectrometry. RESULTS: The relative abundance of N1 species in the three treated oils decreased, while the relative abundance of O2 species increased. Remarkably, the relative abundances of N1 species with low carbon number increased and those with higher carbon number decreased. CONCLUSIONS: These results revealed that the anaerobic biodegradations of heavy crude oil occurred. With direct evidences, the degradations of alkyl side chains of N1 species by the anaerobic microbes could be deduced.

Effect of Non-Newtonian Flow on Polymer Flooding in Heavy Oil Reservoirs.

The flow of polymer solution and heavy oil in porous media is critical for polymer flooding in heavy oil reservoirs because it significantly determines the polymer enhanced oil recovery (EOR) and polymer flooding efficiency in heavy oil reservoirs. In this paper, physical experiments and numerical simulations were both applied to investigate the flow of partially hydrolyzed polyacrylamide (HPAM) solution and heavy oil, and their effects on polymer flooding in heavy oil reservoirs. First, physical experiments determined the rheology of the polymer solution and heavy oil and their flow in porous media. Then, a new mathematical model was proposed, and an in-house three-dimensional (3D) two-phase polymer flooding simulator was designed considering the non-Newtonian flow. The designed simulator was validated by comparing its results with those obtained from commercial software and typical polymer flooding experiments. The developed simulator was further applied to investigate the non-Newtonian flow in polymer flooding. The experimental results demonstrated that the flow behavior index of the polymer solution is 0.3655, showing a shear thinning; and heavy oil is a type of Bingham fluid that overcomes a threshold pressure gradient (TPG) to flow in porous media. Furthermore, the validation of the designed simulator was confirmed to possess high accuracy and reliability. According to its simulation results, the decreases of 1.66% and 2.49% in oil recovery are caused by the difference between 0.18 and 1 in the polymer solution flow behavior indexes of the pure polymer flooding (PPF) and typical polymer flooding (TPF), respectively. Moreover, for heavy oil, considering a TPG of 20 times greater than its original value, the oil recoveries of PPF and TPF are reduced by 0.01% and 5.77%, respectively. Furthermore, the combined effect of shear thinning and a threshold pressure gradient results in a greater decrease in oil recovery, with 1.74% and 8.35% for PPF and TPF, respectively. Thus, the non-Newtonian flow has a hugely adverse impact on the performance of polymer flooding in heavy oil reservoirs.

High quality genome sequence and description of Enterobacter mori strain 5-4, isolated from a mixture of formation water and crude-oil.

Enterobacter mori strain 5-4 is a Gram-negative, motile, rod shaped, and facultatively anaerobic bacterium, which was isolated from a mixture of formation water (also known as oil-reservior water) and crude-oil in Karamay oilfield, China. To date, there is only one E. mori genome has been sequenced and very little knowledge about the mechanism of E. mori adapted to the petroleum reservoir. Here, we report the second E. mori genome sequence and annotation, together with the description of features for this organism. The 4,621,281 bp assembly genome exhibits a G + C content of 56.24% and contains 4,317 protein-coding and 65 RNA genes, including 5 rRNA genes.

Permanent draft genome sequence of Bacillus flexus strain T6186-2, a multidrug-resistant bacterium isolated from a deep-subsurface oil reservoir.

Previous studies suggest that antibiotic resistance genes have an ancient origin, which is not always linked to the use of antibiotics but can be enhanced by human activities. Bacillus flexus strain T6186-2 was isolated from the formation water sample of a deep-subsurface oil reservoir. Interestingly, antimicrobial susceptibility testing showed that this strain is susceptible to kanamycin, however, resistant to ampicillin, erythromycin, gentamicin, vancomycin, fosfomycin, fosmidomycin, tetracycline and teicoplanin. To explore our knowledge about the origins of antibiotic resistance genes (ARGs) in the relatively pristine environment, we sequenced the genome of B. flexus strain T6186-2 as a permanent draft. It represents the evidence for the existence of a reservoir of ARGs in nature among microbial populations from deep-subsurface oil reservoirs.