Production of the natural iron chelator deferriferrichrysin from Aspergillus oryzae and evaluation as a novel food-grade antioxidant.

BACKGROUND: Deferriferrichrysin (Dfcy) is a siderophore found in foods fermented by Aspergillus oryzae and is a promising candidate for an antioxidant food additive because of its high binding constant toward iron. However, the Dfcy concentration is typically low in foods and cultures. RESULTS: We optimised culture conditions to improve Dfcy production to 2800 mg L(-1) from 22.5 mg L(-1) under typical conditions. Then, we evaluated the potential of Dfcy as a food additive by measuring its safety, stability, and antioxidant activity. Dfcy was sufficiently stable that over 90% remained after pasteurisation at 63 °C for 30 min at pH 3-11, or after sterilisation at 120 °C for 4 min at pH 4-6. Dfcy showed high antioxidant activity in an oil-in-water model, where inhibition of lipid oxidation was measured by peroxide value (PV) and thiobarbituric acid reactive substances (TBARS) assays. Dfcy decreased PV and TBARS by 83% and 75%, respectively. Antioxidant activity of Dfcy was equal to or higher than that of the synthetic chelator EDTA. CONCLUSION: Our study provides the first practical method for production of Dfcy. Dfcy can be a novel food-grade antioxidant and the first natural alternative to the synthesised iron chelator EDTA. © 2015 Society of Chemical Industry.

Biosynthesis of L-DOPA by Aspergillus oryzae.

The present investigation deals with the biosynthesis of L-DOPA by parental (GCB-6) and mutant (UV-7) strains of Aspergillus oryzae. There was a marked difference between the mycelial morphology and pellet type of parental and UV-irradiated mutant culture. The mutant strain of A. oryzae UV-6 exhibited pellet-like mycelial morphology and improved tyrosinase activity. Mould mycelium was used for biochemical conversion of L-tyrosine to L-DOPA because tyrosinase is an intracellular enzyme. The mutant was found to yield 3.72 fold higher production of L-DOPA than the parental strain. The mutant strain is stable and D-glc-resistant. The comparison of kinetic parameters was also done which showed the greater ability of the mutant to yield L-DOPA (i.e., Yp/x 40.00+/-0.01 d mg/mg with parent and 182.86+/-0.02a mg/mg in case of mutant). When cultures grown for various incubation periods, were monitored for Qp, Qs and q(p), there was significant enhancement (p < 0.0025-0.005) in these variables by the mutant strain of A. oryzae UV-7 over GCB-6 on all the rates. L-DOPA (3,4-dihydroxy phenyl L-alanine) is a drug of choice in the treatment of Parkinson's disease and myocardium following neurogenic injury.

On-line study of growth kinetics of single hyphae of Aspergillus oryzae in a flow-through cell.

Using image analysis the growth kinetics of the single hyphae of the filamentous fungus Aspergillus oryzae has been determined on-line in a flow-through cell at different glucose concentrations in the range from 26 mg L-1 to 20 g L-1. The tip extension rate of the individual hyphae can be described with saturation type kinetics with respect to the length of the hyphae. The maximum tip extension rate is constant for all hyphae measured at the same glucose concentration, whereas the saturation constant for the hyphae varies significantly between the hyphae even within the same hyphal element. When apical branching occurs, it is observed that the tip extension rate decreases temporarily. The number of branches formed on a hypha is proportional to the length of the hypha that exceeds a certain minimum length required to support the growth of a new branch. The observed kinetics has been used to simulate the outgrowth of a hyphal element from a single spore using a Monte Carlo simulation technique. The simulations shows that the observed kinetics for the individual hyphae result in an experimentally verified growth pattern with exponential growth in both total hyphal length and number of tips.