Comprehensive identification and risk assessment of regulated and emerging mycotoxins in infant foods and related raw materials and risk management advice: A case study of an infant food company in China.

This study evaluated muti-mycotoxins in 199 samples including processed infant foods and raw materials collected randomly from an infant food company and assessed their role in dietary exposure in infants and young children via probabilistic risk assessment. Approximately 79.6 % (74/93) of the processed infant foods and 65.1 % (69/106) of the raw materials were contaminated by mycotoxins, with a mean occurrence level of 3.66-321.8 µg/kg. Deoxynivalenol (DON) and tenuazonic acid (TeA) were the more prevalent mycotoxins detected, based on their higher frequencies and levels across samples. Co-occurrence of more than two mycotoxins was detected in 61.3 % (57/93) of the processed infant foods and 53.8 % (57/106) of the raw materials. Wheat flour and derived products (e.g., infant noodles and infant biscuits) were contaminated with higher contamination levels and a greater variety of mycotoxins than other samples (e.g., infant cereal and rice grains). The estimated daily exposure to OTA, DON, ZEN, and TEN was lower than the corresponding reference health-based guidance values, indicating acceptable health risks. However, the estimated dietary exposure to alternariol monomethyl ether (AME), alternariol (AOH), and tenuazonic acid (TeA) exceeded the corresponding thresholds of toxicological concern values, indicating potential dietary intake risks. Among the various samples, cereals and cereal-based infant foods emerged as the primary contributors to mycotoxin exposure. Further research is advised to address the uncertainties surrounding the toxicity associated with emerging Alternaria mycotoxins and to conduct cumulative risk assessments concerning multiple mycotoxin exposure in infants and young children.

Pitahaya (Hylocereus ocamponis)-Peel and -Flesh Flour Obtained from Fruit Co-Products-Assessment of Chemical, Techno-Functional and In Vitro Antioxidant Properties.

The aim of this work was to assess the chemical composition and physico-chemical, techno-functional, and in vitro antioxidant properties of flours obtained from the peel and flesh of pitahaya (Hylocereus ocamponis) to determine their potential for use as ingredients for food enrichment. The chemical composition, including total betalains, mineral content, and polyphenolic profile, was determined. The techno-functional properties (water holding, oil holding, and swelling capacities) were also evaluated. For the antioxidant capacity, four different methodologies, namely ferrous ion-chelating ability assay, ferric-reducing antioxidant power assay; 1,1-Diphenyl-2-picrylhydrazyl radical scavenging ability assay, and 2,2'-azino-bis(3-ethylbenzothiazoline-6-sulfonic acid) radical assay, were used. Pitahaya-peel flour had higher values for protein (6.72 g/100 g), ash (11.63 g/100 g), and dietary fiber 56.56 g/100 g) than pitahaya-flesh flour, with values of 6.06, 3.63, and 8.22 g/100 g for protein, ash, and dietary fiber, respectively. In the same way, pitahaya peel showed a higher content of minerals, betalains, and polyphenolic compounds than pitahaya-flesh flour, with potassium (4.43 g/100 g), catechin (25.85 mg/g), quercetin-3-rhamnoside (11.66 mg/g) and myricetrin (12.10 mg/g) as principal compounds found in the peel. Again, pitahaya-peel flour showed better techno-functional and antioxidant properties than pitahaya-flesh flour. The results obtained suggest that the flours obtained from the peel and pulp of pitahaya (H. ocamponis) constitute a potential material to be utilized as an ingredient in the food industry due to the high content of bioactive compounds such as betalains, phenolic acids, and flavonoids, with notable antioxidant capacity.

Early nutritional programming in sterlet sturgeon (Acipenser ruthenus) with dietary soybean meal: Assessment of growth performance, body composition, and expression of GH, IGF-I, and Ghrelin genes.

This study was performed to assess the impacts of introducing diets containing different levels of soybean meal (SBM) to sterlet sturgeon (Acipenser ruthenus) larvae on growth performance, body composition, and molecular responses in the juvenile stage. The sterlet larvae (57.68 ± 0.66 mg) were weaned onto the formulated diets as follows: a control diet containing 60% fishmeal (FM), and three experimental diets with replacement levels of 15% (SBM15), 30% (SBM30), and 45% (SBM45) of FM with SBM. Then, a total of 260 fish (initial weight: 323.33 ± 11.76 mg) were fed the four different diets for 28 days in triplicates (phase 1, nutritional programming, NP). All treatments were then fed with the FM diet in phase 2 (common phase), and in phase 3 (challenge phase), all experimental groups (6.14 ± 0.08 g) were transitioned to SBM45 for 28 days. At the end of phases 1 and 2, growth performance showed no significant differences among the groups (P > 0.05), while significantly improved in SBM45 than the control at the end of phase 3 (P < 0.05). No significant differences were found among the groups in any phases for whole body composition (P > 0.05). Additionally, the total saturated fatty acids were significantly higher in SBM-based diets than FM at the end of phase 3 (P < 0.05). The mRNA of GH, IGF-I was significantly affected by variation of FM replacement level (P < 0.05). The expression level of Ghrelin was up-regulated in fish fed SBM at the end of phase 3 (P < 0.05). Our findings revealed that NP can positively enhance the adaptation of juvenile sterlet sturgeon to 45% SBM when exposed to the same diets at the larval stage. Further research is being carried out to provide valuable insights into the underlying mechanisms of digestive performance for this species.

Aflatoxins in maize flour produced in Mozambique and its risk assessment.

This study investigated the occurrence of aflatoxins (B1, B2, G1, and G2) in maize flour produced in Mozambique and to assess the associated carcinogenic risk. At different opportunities, 30 samples of maize flour were collected in five flour processing factories. These were determined by high-performance liquid chromatography (HPLC) with fluorescence detection. AFB1 concentrations ranged from 0.25 to 0.33 µg kg-1. The levels of total aflatoxins ranged from 0.55 to 1.05 µg kg-1, with a mean of 0.89 µg kg-1, for which maximum limits (MLs) are 10 and 4 µg kg-1 for Mozambique and the European Union, respectively. The calculated Margin of Exposure (MOE) for men and women was 243 and 231, respectively, so several folds below the risk cut-off level, indicating that consumption of such maize flour poses a potential risk of hepatocarcinoma related to aflatoxin exposure due to high intake of this food, a staple diet in most African countries.

Firm-Level and Public-Sector Costs Make Small-Scale Maize Flour Fortification Challenging in Uganda.

BACKGROUND: Maize flour in Uganda is milled by hundreds of enterprises, mostly small- (5-20 metric tons [MT]/day) and micro-scale (<5 MT/day) mills or firms. A mandatory maize flour fortification program exists for medium-scale mills (>20 MT/day) and policymakers are considering including smaller-scale millers. OBJECTIVE: We estimated the private and public costs of maize flour fortification at different scales and explored their implications for extending the mandatory fortification to include smaller-scale mills. METHODS: We used secondary data on the structure of the maize flour market and primary data on milling and fortification costs to estimate mill and regulatory costs at 3 scales of flour production: micro, small, and medium. RESULTS: For micro-, small-, and medium-size operations, respectively, operational costs of fortification were US$13, US$9, and US$7 per metric ton (MT) of maize flour, which represented 20%, 16%, and 16% of annual operating costs, and the ratio of fortification equipment cost to mill equipment costs was higher for micro-scale mills (2.7) than for small- (0.38) and medium-scale (0.54) maize mills. Governmental regulatory costs rise if smaller-scale mills are included due to the increased number of facility inspections. CONCLUSIONS: Fortification and regulatory costs increase as production scale decreases. Up-front capital costs of fortification would be daunting for micro- and small-scale mills. Medium-scale mills, which supply social protection programs, might be able to manage fortification costs and other challenges. Decision-makers should consider all costs and cost burdens, and the realities of enforcement capabilities before expanding fortification programs to include smaller-scale operations.

Plain language titleCosts of Small-scale Maize Flour Fortification in UgandaPlain language summaryA study of the costs of adding vitamins and minerals by small-scale maize flour millers in Uganda was undertaken to understand if it would be commercially beneficial from a business and operations perspective for them to do so, and if requiring them to do so would impose additional cost burdens on government to ensure that fortification standards were met.Why was the study done?Maize flour is consumed by the majority of Uganda's population, especially the rural poor. If the flour were fortified, it would reduce vitamin and mineral deficiencies among those at risk. The most important constraint to market-wide fortification is the presence of many small-scale mills or firms that neither have the resources nor the technology to adopt and sustain the fortification process. To date, no study has been done to calculate the costs that small-scale mills would have to face to fortify flour, or what the cost implications for government would be for including smaller-scale mills in a national fortification program, including the costs of enforcing regulations.What did the researchers do?The researchers interviewed millers of several scales of operation to collect cost information on their operations and interviewed representatives of government regulatory bodies to estimate the costs of testing maize flour to ensure compliance with regulations. Researchers estimated the cost to the mills of adding fortification to their business models, and the impacts on the government costs (eg, testing additional samples, etc.) of including smaller-scale mills in the fortification program.What did the researchers find?The researchers looked at 3 different types of mills based on their capacity to mill maize flour­micro-scale firms milled less than 5 metric tons (MT) a day, small-scale firms milled 5 to 20 MT per day, and medium-scale firms milled over 20 MT a day. For micro-, small-, and medium-size firms, respectively, fortification increased operational costs by US$13, US$9, and US$7 per MT of maize flour, which represented 20%, 16%, and 16% of annual operating costs. Similarly, governmental regulatory costs rose if smaller-scale mills were included because of the increased number of facility inspections required since the current legislation requires mandatory annual inspections.What do the findings mean?Fortification and regulatory costs increase as the scale of production by the millers decreases. If fortification by small- and micro-scale mills were made mandatory, up-front costs of fortification equipment and materials would be daunting for micro- and small-scale millers. Ugandan medium-scale millers might manage fortification costs and other challenges, but only if the social protection programs they supplied were of sufficient volume and regularity.

Assessment of tropane alkaloid levels in Brazilian buckwheat flour products: A novel LC-UHPLC-MS/MS approach using solid-liquid extraction at low temperature.

In recent years, the monitoring of tropane alkaloids, specifically hyoscyamine and scopolamine, in food has become a pressing concern. This is due to increasing reports of food contamination with these compounds worldwide, raising awareness about the potential risks associated with their consumption. A novel method is proposed here for the determination of the sum of (+)-hyoscyamine, (-)-hyoscyamine, and (-)-scopolamine in buckwheat-based matrices, using solid-liquid extraction at low temperature and quantification by bidimensional chromatography coupled to tandem mass spectrometry. The validated method presented a linear response in the concentration range of 2.5-15 µg kg-1 (r > 0.99). The precision and accuracy were in the ranges from 0.8 to 11.0 % and from 96 to 103 %, respectively. The limit of quantification (LOQ) was 2.5 µg kg-1. No contamination was found at levels above the LOQ in any of the 18 samples analyzed (buckwheat flour, grains, and gluten-free mix).

Multi-residue monitoring and dietary risk assessment of 17 pesticides and 3 related metabolites in rice and rice flour from markets in China.

Pesticide residues in rice have attracted widespread public attention in recent years. This research aimed to monitor the residues of 17 pesticides and their 3 metabolites in 120 samples of rice and rice flour collected from markets in China using the QuEChERS (Quick, Easy, Cheap, Effective, Rugged, Safe) pretreatment method combined with high-performance liquid chromatography-tandem mass spectrometry (HPLC-MS/MS). The monitoring results showed that isoprothiolane, tricyclazole, fenoxanil, and tebuconazole were detected in the rice samples, with detection frequencies of 33.3%, 17.5%, 8.3%, and 2.5%, and concentrations ranging from 0.02 to 0.1 mg/kg (median = 0.04), 0.01 to 0.17 mg/kg (median = 0.14), 0.04 to 0.06 mg/kg (median = 0.05), and 0.01 to 0.02 mg/kg (median = 0.01), respectively. The residues of these four pesticides were all below their corresponding maximum residue levels (MRLs) set by China. Additionally, isoprothiolane, tricyclazole, fenoxanil, and tebuconazole were detected in rice flour samples, with detection frequencies of 74.2%, 55.0%, 5.0%, and 2.5%, and concentrations ranging from 0.01 to 0.1 mg/kg (median = 0.04), 0.01 to 0.04 mg/kg (median = 0.02), 0.01 to 0.06 mg/kg (median = 0.03), and 0.02 to 0.04 mg/kg (median = 0.03), respectively. Furthermore, the chronic dietary intake risk (HQc), the acute dietary intake risk (HQa), and cumulative dietary risk (HI) for all the detected pesticides were evaluated and found well below 100%, indicating that the dietary intake risks would not pose potential health risks.

Exposure Assessment to Deoxynivalenol of Children over 3 Years Deriving from the Consumption of Processed Wheat-Based Products Produced from a Dedicated Flour.

Wheat-based products are largely consumed by children worldwide. Deoxynivalenol (DON) is known for its acute and chronic toxicity and is the most common contaminant of cereal grains. Since no legal limits are set for DON in wheat-based products and specific foods intended for children over 3 years on the market, a high risk of overexposure to this contaminant may emerge. The main objective of the study, conducted in 2018-2019, was to produce a wheat flour intended for children over three years, characterized by a high level of safety in terms of DON content, to be used to produce wheat-derived products. The dedicated flour was produced by adopting tailored procedures like the selection of wheat suppliers, the predetermination of the safe contamination of DON in the final products, and the evaluation of the transfer rate from the wheat flour to derived products (bread, breadsticks, biscuits, plumcake, and focaccia). The results showed that the daily exposure of children was considered to be safe, in a range between 7% (biscuits) and 67% (bread) of DON tolerable daily intake (TDI) and that only by producing a flour characterized by DON levels much lower than those in force, can "safe" products be marketed.

Investigation on the Integration of Low-Cost NIR Spectrometers in Mill Flour Industries for Protein, Moisture and Ash Content Estimation.

The flour milling industry-a vital component of global food production-is undergoing a transformative phase driven by the integration of smart devices and advanced technologies. This transition promises improved efficiency, quality and sustainability in flour production. The accurate estimation of protein, moisture and ash content in wheat grains and flour is of paramount importance due to their direct impact on product quality and compliance with industry standards. This paper explores the application of Near-Infrared (NIR) spectroscopy as a non-destructive, efficient and cost-effective method for measuring the aforementioned essential parameters in wheat and flour by investigating the effectiveness of a low-cost handle NIR spectrometer. Furthermore, a novel approach using Fuzzy Cognitive Maps (FCMs) is proposed to estimate the protein, moisture and ash content in grain seeds and flour, marking the first known application of FCMs in this context. Our study includes an experimental setup that assesses different types of wheat seeds and flour samples and evaluates three NIR pre-processing techniques to enhance the parameter estimation accuracy. The results indicate that low-cost NIR equipment can contribute to the estimation of the studied parameters.

Quantification and economic assessment of surplus bread in Italian small-scale bakeries: An explorative study.

The generation of bread waste at suppliers and retailers is often linked to the production of surplus bread. This study reports the results of the first direct quantification and economic assessment of surplus bread conducted in Italy, involving a panel of 12 bakeries and their branches located in the Lazio region, which compiled a daily diary for 5 months. They are small-scale bakeries which reflect the typical structure of the Italian businesses in the bakery sector, producing fresh bread and selling it directly to consumers. The surplus bread measured during the study consists of 6,694 kg in total, with an average quantity of 4.83 kg/day per bakery. Studying the three main products (common bread, focaccia bread and bread rolls), the average rate of surplus is respectively 5.88 %, 3.99 % and 5.28 % of the production. The corresponding economic loss represents, on average, 5.44 % of the daily turnover. A set of factors seems to exert highest influence on the generation of surplus, as the range of production, location and number of customers. When surplus bread occurs, in 63 % of the cases it is managed on alternative routes to avoid disposal. Even if detected surplus bread does not necessarily become waste, it indeed represents a big loss for bakeries.

Food aflatoxin exposure assessment in Sichuan Province, China.

Aflatoxins (AFs) are frequent contaminants in crops worldwide and can cause adverse health effects in exposed humans. Since foods AFs (AFB1, AFB2, AFG1, AFG2) contamination in Sichuan Province are unexplored, we conducted a study to assess AFs exposure in the population. In total, 318 samples, including grains, red chilli, red chilli powder, and vegetable protein beverages, were collected from 13 cities of Sichuan Province, China, in 2022. AFs were detected in all types of foods except for wheat flour, the highest incidence was found in red chilli powder (75.0%). The concentrations of AFtot (the total aflatoxins) ranged between ND (not detected) and 54.20 µg kg-1. It was observed that the AFs profile was dominated by AFB1. The AFB1 content ranged from ND to 52.60 µg kg-1 across food types. According to EU maximum limits (ML) of AFs, 2.8% of samples exceeded the AFtot limits. For AFB1, 0.4% and 4.3% of samples exceeded the China and EU limits, respectively. In this study, packaging types and sampling sites were selected as parameters influence food aflatoxin contamination. Nevertheless, there was no significant difference between different samples. According to exposure assessment and risk characterization, AFtot daily exposure was shown to be 0.263 and 283.936 ng kg-1 bw for the lower and upper exposure. The MOE value derived from consumption grains and red chilli pepper products were generally bellow 10 000, and liver cancer cases based on these two foods consumption could range from < 0.001 to 0.16 cases per year/10 000 persons.

[Health Risk Assessment of Heavy Metals in Soil and Wheat Grain in the Typical Sewage Irrigated Area of Shandong Province].

Sewage irrigation is a common alternative to make up for the shortage of agricultural irrigation in intensive agricultural areas. Abundant organic matter and nutrients in sewage can improve soil fertility and crop yield, but hazardous materials, such as heavy metals, will damage the soil environmental quality and threaten human health. To better understand the characteristics of heavy metal enrichment and potential health risk in a sewage irrigated soil-wheat system, a total of sixty-three pairs of topsoil and wheat grain samples were collected from the sewage irrigated area of Longkou City in Shandong Province. The contents of Cr, Cu, Ni, Pb, Zn, As, Cd, and Hg were determined to analyze heavy metal contamination and calculate bio-accumulation factor (BAF), estimated daily absorption (EDA), as well as hazard quotient (HQ). The results showed that the average contents of the eight heavy metals were 61.647, 30.439, 29.769, 36.538, 63.716, 8.058, 0.328, and 0.028 mg·kg-1, respectively, which all exceeded the background values of corresponding heavy metals in the eastern Shandong Province. Especially, the average content of Cd was higher than the current standard value of soil environmental quality of agricultural land soil pollution risk control, indicating the apparent soil contamination. However, the correlations between the heavy metal contents in soil and wheat grains were not significant, suggesting that it is difficult to conclude the enrichment degree of heavy metals in wheat grains merely by the heavy metal contents in soil. The results of BAF showed that the high enrichment capacity of wheat grain was primarily obtained with Zn, Hg, Cd, and Cu. According to the national food safety limit standard, the over-limit ratios of Ni (100%) and Pb (96.8%) in wheat grains were the most serious. As a result, under the current consumption of local wheat flour, the EDAs of Ni and Pb were high, accounting for 28.278% and 1.955% of the acceptable daily intakes (ADI) for adults and 131.980% and 9.124% of the ADIs for children. The results of the health risk assessment exhibited that As and Pb were the main sources causing health risks, accounting for approximately 80% of the total risk. Although the sums of the HQ of the eight heavy metals for adults and children were below 10, the total HQ of children was 1.245 times higher than that of adults. The food safety of children should receive more attention. When considering spatial characteristics, the health risk in the southern study area was higher than that in the northern part of the study area. The prevention and control of heavy metal contamination in the southern area should be strengthened in the future.

Influence of substituting soybean meal with moringa seed cake on feed intake, growth performance, digestibility, blood parameters and economics of fattening crossbred calves.

The aim of this study was to investigate the effects of substitution moringa seed cake (MSC) for soybean meal (SBM) in calves' rations on blood parameters and growth performance. Thirty-two crossbred calves (232 ± 6.75 kg) were divided into 4 groups (8 animals each). All animals were fed a ration of 30% Egyptian clover + 10% corn silage and 60% concentrate mix (CM). The first group (MSC0%) was fed the CM without any MSC (control), while the second (MSC25%), the third (MSC50%), and the fourth (MSC100%) groups were fed on 25%, 50% and 100% MSC by replacing SBM in CM respectively. Results revealed that MSC50% increased (P ≤0.05) most of nutritive values and digestibility compared with the tested groups. Also, MSC50% reduced (P ≤0.05) feed conversion of dry matter (DM), total digestible nutrient (TDN) and digestible energy (DE) compared to the tested groups. Also, MSC50% increased the total weight gain and net revenue by 13.50% and 22.75%, respectively, compared to control. While MSC100% lowered the total weight gain and net revenue by -7.67% and -4.20%, respectively, compared to control. Total protein and glucose were increased (P ≤0.05) by rations with 25% and 50% MSC compared with MSC (0% and100%). Moreover, adding MSC to animals' rations at different levels improved most of blood metabolites compared to control. Conclusion, moringa seed cake can be used as an alternative protein source to soybean meal in fattening calves rations at level up to 50% to improve growth performance and net profit without adverse effects.

A nationwide investigation of trace elements in rice and wheat flour in China: Levels, spatial distributions and implications for human exposure.

Rises in trace element contents in rice and wheat flour, which are staple foods for almost all the Chinese population, associated with rapid economic development have raised major concerns. This study aimed to assess trace element concentrations in these foods nationwide in China and associated human exposure risks. For these purposes, nine trace elements were measured in 260 rice samples and 181 wheat flour samples with 17 and 12 widely scattered geographical origins in China, respectively. Mean concentrations (mg kg-1) of the trace elements declined in the following orders: Zn > Cu > Ni > Pb > As > Cr > Cd > Se > Co in rice, and Zn > Cu > Ni > Se > Pb > Cr > Cd > As > Co in wheat flour. Significant regional differences in levels of trace elements in both rice and wheat flour were detected (p < 0.05), which may be related to local economic indicators. The hazard index (HI) of trace elements in rice samples from all origins exceeded 1, mainly due to the contribution of As, suggesting a potential non-carcinogenic risk. The total carcinogenic risk (TCR) for rice and wheat flour of all origins exceeded the safe level.

Estimating the cost and cost-effectiveness of adding zinc to, and improving the performance of, Burkina Faso's mandatory wheat flour fortification programme.

Zinc is an essential micronutrient that promotes normal growth, development and immune function. In the context of persistent dietary zinc inadequacies, large-scale food fortification can help fill the gap between intake and requirements. Burkina Faso mandates wheat flour fortification with iron and folic acid. We used activity-based cost modelling to estimate the cost of adding zinc to the country's wheat flour fortification standard assuming (1) no change in compliance with the national standard, and (2) a substantial improvement in compliance. We used household food consumption data to model effective coverage, that is, the number of women of reproductive age (WRA) predicted to achieve adequate zinc density (zinc intake/1000 kcal) with the addition of fortification to diets. Without interventions, the prevalence of inadequate dietary zinc density was ~35.5%. With no change in compliance, the annual average incremental cost of adding zinc to fortified wheat flour was $10,347, which would effectively cover <1% of WRA at an incremental cost of ~$0.54/WRA effectively covered. Improving compliance added ~$300,000/year to the cost of the fortification programme without zinc; including zinc added another ~$78,000/year but only reduced inadequate intake among WRA by 3.6% at an incremental cost of ~$0.45/WRA effectively covered. Although the incremental cost of adding zinc to wheat flour is low ($0.01/wheat flour consumer/year), given low levels of wheat flour consumption, zinc fortification of wheat flour alone contributes marginally to, but will not fully close, the dietary zinc gap. Future research should explore potential contributions of zinc to a broader set of delivery vehicles.

Foodborne disease outbreaks in flour and flour-based food products from microbial pathogens in the United States, and their health economic burden.

The most comprehensive and inclusive estimates for the economic burden of foodborne illness yield values as high as $97.4 billion USD annually. However, broad incidence and cost estimates have limited use if they cannot be attributed to specific foods, for the purposes of food safety control. In this study, we estimated the economic burden of foodborne illnesses resulting from flour and flour-based food products in the United States from the years 2001 to 2021. The outbreak, illness burden, and health economic data are combined to generate these estimates. Our model combined outbreak data with published Centers for Disease Control and Prevention multipliers to estimate the annual number of illnesses associated with flour-borne pathogens. We then integrated illness severity data with an updated economic model that accounts for costs related to medical care, productivity loss, loss of life, along with the quality of life loss that entails pain and suffering. In total, 752 cases and 223 hospitalizations from flour-related illnesses were reported from 2001 to 2021, with an average of 37.6 cases of reported cases annually. However, the actual number of cases, accounting for underreporting and underdiagnosis, can be as high as 19,440 annually. Pathogens involved in these outbreaks are Salmonella, E. coli O157:H7, and E. coli O121. Our estimates suggest average annual economic losses, including healthy years of life lost, of $108 and $258 million using two alternative models.

Quinolizidine alkaloids in lupine flour and lupine products from the German retail market and risk assessment of the results regarding human health.

This study describes the analysis of five quinolizidine alkaloids (QA), i.e. 13-OH-lupanine, lupanine, lupinine, angustifoline and sparteine in 30 samples of lupine flours, lupine seeds and derived products collected 2019-2021 on the German retail market. QA occur as secondary metabolites in plants of lupine species. Certain QA are of toxicological relevance. The analytical determination performed by LC-MS/MS revealed some samples with high QA concentrations (up to 21,000 mg/kg), particularly in bitter lupine seeds. As those concentrations would result in substantial exceedances of the maximum tolerable intake values proposed by health authorities, they must be considered as a health concern.

Prevented cases of neural tube defects and cost savings after folic acid fortification of flour in Brazil.

Anencephaly, encephalocele, and spina bifida are congenital neural tube defects and are the main causes of neonatal morbidity and mortality and impose a heavy economic burden on health systems. This study to estimates the direct costs of neural tube defects from the perspective of the Brazilian Ministry of Health, and the prevented cases and cost savings during the period in which mandatory folic acid fortification was in effect in the country (2010-2019). It is a top-down cost-of-illness oriented study based on the prevalence of the disorders in Brazil. Data were collected from the Brazilian Ministry of Health's outpatient and hospital information system databases. The direct cost was estimated from the total patient-years, allocated by age and type of disorder. Prevented cases and cost savings were determined by the difference in the prevalence of the disorders in the pre- and post-fortification periods based on the total number of births and the sum of outpatient and hospital costs during the period. The total cost of outpatient and hospital services for these disorders totaled R$ 92,530,810.63 (Int$ 40,565,896.81) in 10 years; spina bifida accounted for 84.92% of the total cost. Hospital costs were expressive of all three disorders in the first year of the patient's life. Between 2010 and 2019, mandatory folic acid fortification prevented 3,499 live births with neural tube defects and resulted in R$ 20,381,586.40 (Int$ 8,935,373.25) in hospital and outpatient cost savings. Flour fortification has proved to be a valuable strategy in preventing pregnancies with neural tube defects. Since its implementation, there has been a 30% decrease in the prevalence of neural tube defects and a 22.81% decrease associated in hospital and outpatient costs.

Exposure Monitoring Strategies for Applying Low-Cost PM Sensors to Assess Flour Dust in Industrial Bakeries.

Low-cost particulate matter (PM) sensors provide new methods for monitoring occupational exposure to hazardous substances, such as flour dust. These devices have many possible benefits, but much remains unknown about their performance for different exposure monitoring strategies in the workplace. We explored the performance of PM sensors for four different monitoring strategies (time-weighted average and high time resolution, each quantitative and semi-quantitative) for assessing occupational exposure using low-cost PM sensors in a field study in the industrial bakery sector. Measurements were collected using four types of sensor (PATS+, Isensit, Airbeam2, and Munisense) and two reference devices (respirable gravimetric samplers and an established time-resolved device) at two large-scale bakeries, spread over 11 participants and 6 measurement days. Average PM2.5 concentrations of the low-cost sensors were compared with gravimetric respirable concentrations for 8-h shift periods and 1-min PM2.5 concentrations of the low-cost sensors were compared with time-resolved PM2.5 data from the reference device (quantitative monitoring strategy). Low-cost sensors were also ranked in terms of exposure for 8-h shifts and for 15-min periods with a shift (semi-quantitative monitoring strategy). Environmental factors and methodological variables, which can affect sensor performance, were investigated. Semi-quantitative monitoring strategies only showed more accurate results compared with quantitative strategies when these were based on shift-average exposures. The main factors that influenced sensor performance were the type of placement (positioning the devices stationary versus personal) and the company or workstation where measurements were collected. Together, these findings provide an overview of common strengths and drawbacks of low-cost sensors and different ways these can be applied in the workplace. This can be used as a starting point for further investigations and the development of guidance documents and data analysis methods.

Assessment of the Bioaccessibility of Elaeagnus angustifolia L. Flour and Its Use in Cracker Formulation.

In this study, in vitro digestion of polyphenols of oleaster (Elaeagnus angustifolia L.) flour (OF) and the potential use of OF in cracker production were studied. The results showed that 21.90 mg gallic acid equivalent (GAE)/g dry matter (DM) of total polyphenol (TP), 28.15 mg rutin equivalent (RE)/g DM of total flavonoid (TF) and 7709.13 mmol ascorbic acid equivalent (AAE)/100 g DM of antioxidant capacity (AC) were found in OF. The bioaccessibility and content of the OF polyphenols and their AC during in vitro digestion varied depending on the digestion stage. The stability of the OF polyphenols was higher in gastric stage (41.92%) than intestinal one (34.01%). OF was used to replace flour in the cracker formulation at the levels of 5, 10 and 15% (w/w) and increased the TP contents and AC of the crackers compared to the sample without OF (control). The addition of OF to the cracker dough increased the bioaccessibility of the cracker polyphenols. After digestion, bioaccessibilities of enriched crackers (107.90-126.81%) were found higher than that of control sample (93.73%). However, as the level of OF in cracker increased, bioaccessibility of polyphenols decreased. The results generally indicated that oleaster has a good potential for the enrichment of foods.