Source attribution at the food sub-product level for the development of the Canadian Food Inspection Agency risk assessment model.

Decreasing the health burden caused by foodborne pathogens is challenging and it depends on the identification of the most significant hazards and food sources causing illnesses, so adequate mitigation strategies can be implemented. In this regard, the Canadian Food Inspection Agency (CFIA) has developed the Establishment-based Risk Assessment (ERA) model, so that a more effective and efficient allocation of resources can be assigned to the highest food safety risk areas. To assess risk, the model considers the type of food sub-products being manufactured by establishments and its scope is limited to the 17 most important foodborne pathogens representing the highest level of food safety risk. However, the information on source attribution at the sub-product level based on a structured approach is limited. To overcome this challenge, an expert elicitation was conducted in 2016 to estimate the relative contribution and associated certainty of each sub-product for 31 pathogen-commodity combinations to the total Canadian health burden associated with foodborne illnesses (expressed in DALYs). These DALYs represent 78% of the total Canadian health burden associated with federally-regulated food commodities considered within the model. A total of 49 Canadian experts recruited using a "snow ball" sampling strategy participated in the study by completing an electronic survey. Results of the elicitation displayed variable levels of health burden allocation between the pathogens and the different commodity sub-products. Assessment of the certainty levels showed some combinations being evaluated with more confidence (e.g., Campylobacter and eggs/poultry sub-products) than others, where a bimodal distribution of certainty was observed (e.g., Toxoplasma in pork sub-products). Furthermore, no participant raised concerns on the food classification scheme, suggesting their agreement with the proposed sub-products categorization of the elicitation. Relative contribution estimates will be included in the CFIA ERA model and used to enhance its applicability for risk prioritization and effective resource allocation during food establishment inspections. While substantial uncertainty around the central tendency estimates was found, these estimates provide a good basis for regulatory oversight and public health policy.

Selection of risk factors to be included in the Canadian Food Inspection Agency risk assessment inspection model for food establishments.

The Canadian Food Inspection Agency (CFIA) is developing a risk assessment model for food establishments. Previous research on the significance of food safety risk factors determined by literature review and expert advice served as the bases for the current study, to further refine, discriminate and select the most important criteria to be included in the model. This process considered the availability of data sources, the clarity and measurability of the selected factors, undertook the elimination of lower-rated risk factors and grouped those with similar focus of attention, enabling the selection of a final list of risk factors for the model. A method of assessment for the remaining factors was then proposed to allow the quantification of individual risk factors within the model. From the 155 risk factors initially identified, 17 consolidated factors were kept and will be considered for the development of the risk assessment model.

Dioxin-like polychlorinated biphenyls in marine fish from Shandong, China, and human dietary exposure.

The occurrence and human dietary exposure of 12 dioxin-like polychlorinated biphenyls (DL-PCBs) in 41 marine fish samples from Shandong Province of China were investigated. The DL-PCB congeners were extracted using automated Soxhlet extraction, purified via a composite column clean-up procedure and analysed by gas chromatography-triple quadrupole mass spectrometry. DL-PCB congeners were found in all analysed samples, with a mean concentration of 0.887 ng/g ww (wet weight). The TEQ concentrations of DL-PCBs in individual fish samples ranged from 0.011 to 9.214 pg WHO TEQ/g ww. The mean dietary intake for all fish species was 36.5 pg TEQ/kg bw/month, which was lower than the provisional tolerable monthly intake of 70 pg TEQ/kg bw/month set by the Joint FAO/WHO Expert Committee on Food Additives. To monitor the trend of DL-PCBs in fish for food safety control, it is necessary to maintain a surveillance programme.

Aflatoxin M1 in fresh milk collected from local markets of Karachi, Pakistan.

During 2016-2017, 156 samples of fresh milk samples were collected from local markets of Karachi, Pakistan and analysed for aflatoxin M1 (AFM1) contamination using ELISA technique. AFM1 was detected in 143 (91.7%) samples, ranged from 20 to 3090 ng L-1 with a mean level of 346.2 ng L-1. In 125 (80.1%) samples, the AFM1 contamination was greater than the maximum limit (ML = 50 ng L-1) set by EU. However, in 51 (32.7%) samples, the AFM1 level was higher than the ML of 500 ng L-1 as assigned by the USA. Statistical analysis showed that the AFM1 level in milk samples from summer was significantly (p < 0.05) higher than that obtained in winter. It was concluded that the AFM1 levels in the tested samples appear to be a serious public health problem. Therefore, immediate measures should be taken and re-evaluation done for the procedures for farming, transportation, refrigeration, and storage for the control of AFM1 level in milk samples.

Assessment of Mycotoxin Exposure in Breastfeeding Mothers with Celiac Disease.

OBJECTIVE: To assess the risk of mycotoxin exposure (aflatoxin M1, ochratoxin A, and zearalenone) in celiac disease (CD) breastfeeding mothers and healthy control mothers, as well as in their offspring, by quantifying these contaminants in breast milk. STUDY DESIGN: Thirty-five breastfeeding women with CD on a gluten-free diet and 30 healthy breastfeeding controls were recruited. Milk sampling was performed three times per day for three consecutive days. Mycotoxin content was investigated by an analytical method using immunoaffinity column clean-up and high-performance liquid chromatography (HPLC) with fluorometric detection. RESULTS: Aflatoxin M1 (AFM1) was detected in 37% of CD group samples (mean ± SD = 0.012 ± 0.011 ng/mL; range = 0.003-0.340 ng/mL). The control group showed lower mean AFM1 concentration levels in 24% of the analyzed samples (0.009 ± 0.007 ng/mL; range = 0.003-0.067 ng/mL, ANOVA on ranks, p-value < 0.01). Ochratoxin A and zearalenone did not differ in both groups. CONCLUSION: Breast milk AFM1 contamination for both groups is lower than the European safety threshold. However, the estimated exposures of infants from CD mothers and control mothers was much higher (≃15 times and ≃11 times, respectively) than the threshold set by the joint FAO/WHO Expert Committee on Food Additives (JECFA). Since incongruities exist between JECFA and the European Union standard, a novel regulatory review of the available data on this topic is desirable. Protecting babies from a neglected risk of high AFM1 exposure requires prompt regulatory and food-control policies.

Co-occurrence of mycotoxins in commercial formula milk and cereal-based baby food on the Qatar market.

The present study was conducted to explore the occurrence of mycotoxins in commercial baby foods in Doha-Qatar. LCMS/MS- and HPLC-based analysis of baby food (n = 67) for 12 mycotoxins confirmed the presence of aflatoxin M1 (AFM1, 33%), ochratoxin A (OTA, 31%), deoxynivalenol (DON, 27%), aflatoxin B1 (AFB1, 22%), fumonisin B2 (FB2, 10%), zearalenone (ZEN, 4%) and T-2 toxin (2%). Noodles exhibited the maximum contamination percentage, with 33% of the samples being contaminated above the EU maximum limits, for at least one mycotoxin. Among the multi-grain flake samples, up to 28% and for the milk and milk-based-cereal samples, 14% contained at least one mycotoxin above the EU maximum limits. From all cereal-based food samples, 22%, 5%, 2% and 2% were concurrently contaminated with 2, 3, 4 and 5 mycotoxins, respectively. The occurrence of toxicological important mycotoxins in Qatari market warrants the implementation of strict regulatory limits to protect human health.

Polycyclic aromatic hydrocarbons in teas using QuEChERS and HPLC-FLD.

Polycyclic aromatic hydrocarbons (PAHs) are food-processing contaminants considered to be carcinogenic and genotoxic. Due to its drying process stage, teas may be contaminated with PAHs. The aim of the study was to validate an analytical method involving QuEChERS and HPLC-FLD for the determination of PAH4 in teas and evaluate the contamination levels in 10 different types of teas from Brazil. Recoveries varied from 54% to 99% and relative standard deviations from 1% to 21%. Limits of detection and quantification were from 0.03 to 0.3 µg/kg and 0.1 to 0.5 µg/kg, respectively. Mate tea presented the highest PAH levels, with PAH4 varying from 194 to 1795 µg/kg; followed by black (1.8-186 µg/kg), white (24-119 µg/kg), and green teas (3.1-92 µg/kg). Teas with lowest PAH4 were strawberry, lemongrass, peppermint, and boldo. Only trace levels of PAHs were detected in tea infusions, so apparently it would not affect PAH intake by Brazilian population.

Occurrence and risk assessment of mycotoxins, acrylamide, and furan in Latvian beer.

This work reports data on the occurrence of nine mycotoxins and two food processing contaminants - acrylamide and furan - in a total of 100 beers produced in Latvia. Mycotoxins were detected by high-performance liquid chromatography (HPLC) coupled with time-of-flight mass spectrometry, acrylamide by HPLC coupled with quadrupole-Orbitrap mass spectrometry, and furan by headspace gas chromatography-mass spectrometry. The most frequently occurring mycotoxins were HT-2 and deoxynivalenol (DON), which were detected in 52% and 51% of the analysed samples. The highest content was observed for DON, reaching the maximum of 248 µg kg-1. Furan was ubiquitous, and 74% of the samples contained acrylamide. In terms of the estimated exposure, the biggest potential risk was identified for HT-2 representing more than 11% of tolerable weekly intake. The margin of exposure approach indicated the exposure to furan through beer as significant, this parameter being close to the critical limit.

Glyphosate residues in Swiss market foods: monitoring and risk evaluation.

A total of 243 samples of diverse foodstuffs were analysed for glyphosate and aminomethylphosphonic acid (AMPA) using a liquid chromatography triple quadrupole mass spectrometry (LC/MS/MS) method with a relatively low limit of quantification in the range of 0.0005-0.0025 mg kg-1. Main contributors for dietary glyphosate and AMPA intake were cereals and pulses. The results suggest that pasta is a very important foodstuff for dietary glyphosate residue intake in Switzerland. Interestingly all samples of wine, fruit juice and nearly all samples of honey tested positive for glyphosate although at very low levels. A dietary risk assessment was conducted. Food products for analysis were not selected purely at random, rather products were selected for which high levels of glyphosate residues were suspected. However, even in samples where high residue levels were expected, no exceedances of maximum residue levels were found. Consequently, human exposure did not exceed neither acceptable daily intake nor acute reference dose. Therefore, glyphosate residues found in the sampled foodstuffs from the Swiss market were of no concern for human health.

Inspector Perceptions of the Food and Drug Administration's Newest Recommended Food Facility Inspection Format: Training Matters.

The Food and Drug Administration publishes the Food Code to guide restaurant inspections. The most recent version proposes a three-tier system categorizing violations as priority, priority foundation, and core. This study used a scenario-based questionnaire to examine inspector perceptions and preferences for inspection formats. Results suggest that inspectors would be able to maintain consistent evaluations when changing to the three-tier system, although the classifying terms under the three-tier system were confusing. Additionally, inspectors were not very positive about the new system; they were concerned that the new system would not be easy to understand and use, inspections would take a longer time, it would not accurately reflect the amount of risk associated with violations, and it would not be easy for consumers and managers to understand and use. The results suggest the need for additional training for inspectors before adoption, especially on the rationale and benefits of changing to a three-tier system.

Non-invasive ultrasonic technology for continuous monitoring of pork loin and ham dry salting.

Online ultrasound measurements were taken using pulse-echo mode in loins (Longissimus dorsi) and hams at different salting times (up to 30days). From the time-domain ultrasonic wave, the time of flight (TOF) was computed as well as its variation between two signals (ΔTOF). A progressive decrease in TOF during dry salting was found, which was linked to the salt gain, water loss and the reduction in sample thickness. Predictive models based on the ultrasonic parameters (ΔTOF and initial time of flight, TOF0) correctly classified 85% of the loins and 90% of the hams into 3 groups of salt content (low/medium/high). The results obtained confirm that the use of the ultrasonic pulse-echo technique is of great potential in the non-destructive monitoring of dry salting in pork loins and hams, as well as in the prediction of the salt gain for classification purposes.

Costs of Food Safety Investments in the Meat and Poultry Slaughter Industries.

To develop regulations efficiently, federal agencies need to know the costs of implementing various regulatory alternatives. As the regulatory agency responsible for the safety of meat and poultry products, the U.S. Dept. of Agriculture's Food Safety and Inspection Service is interested in the costs borne by meat and poultry establishments. This study estimated the costs of developing, validating, and reassessing hazard analysis and critical control points (HACCP), sanitary standard operating procedures (SSOP), and sampling plans; food safety training for new employees; antimicrobial equipment and solutions; sanitizing equipment; third-party audits; and microbial tests. Using results from an in-person expert consultation, web searches, and contacts with vendors, we estimated capital equipment, labor, materials, and other costs associated with these investments. Results are presented by establishment size (small and large) and species (beef, pork, chicken, and turkey), when applicable. For example, the cost of developing food safety plans, such as HACCP, SSOP, and sampling plans, can range from approximately $6000 to $87000, depending on the type of plan and establishment size. Food safety training costs from approximately $120 to $2500 per employee, depending on the course and type of employee. The costs of third-party audits range from approximately $13000 to $24000 per audit, and establishments are often subject to multiple audits per year. Knowing the cost of these investments will allow researchers and regulators to better assess the effects of food safety regulations and evaluate cost-effective alternatives.

Organochlorine pesticides in canned tuna and sardines on the Serbian market.

The aim of this study was to determine the level of organochlorine (OC) pesticides in 57 samples of canned tuna and 31 samples of canned sardines in vegetable oil, collected from supermarkets in Serbia. OC pesticides α-HCH, ß-HCH, δ-HCH, dichlorodiphenyltrichloroethane (DDT), DDE, DDD, dielderin, endosulfane I, endosulfane II, endosulan sulfate, endrin, endrin ketone, heptachlor, heptachlor epoxide, lindane, aldrin, metoxichlor, cis-chlordane and trans-chlordane were determined using a GS-MS method. The highest concentrations (µg kg-1, arithmetic means) in canned tuna were for δ-HCH (60.6 ± 97.0) and p, p´-DDT (55.0 ± 25.1), while the corresponding values in canned sardines were for δ-HCH (90.7 ± 102.7) and endosulfane II (78.0 ± 145.9). Mean level for the sum of endosulfans was above the maximum limit in canned sardines (85.0 µg kg-1). Also, dieldrin (39.7 µg kg-1) was measured above the ML.

Heavy metals in aromatic spices by inductively coupled plasma-mass spectrometry.

Objective of this study was to determine the content of Cd, Hg, As and Pb in common spices traded in the Italian market, using inductively coupled plasma-mass spectrometry (ICP-MS). The results were compared with the maximum limits established by the national Legislative Decree (LD) no. 107 implementing the Council Directive 88/388/EEC and by international organisations, such as Food and Agriculture Organization (FAO) and World Health Organization (WHO). Food safety for spices was assessed considering the tolerable weekly intake (TWI) and the provisional tolerable weekly intake (PTWI), respectively, for Cd and Hg and the 95% lower confidence limit of the benchmark dose of 1% extra risk (BMDL01) for As and Pb. Investigated elements in all samples were within the maximum limits as set by the national and international normative institutions. Nevertheless, the heavy metal content of some spices exceeded the PTWI, TWI and BMDL01, which needs attention when considering consumer's health.

Aluminium content of foods originating from aluminium-containing food additives.

Aluminium (Al) levels of 90 food samples were investigated. Nineteen samples contained Al levels exceeding the tolerable weekly intake (TWI) for young children [body weight (bw): 16 kg] when consuming two servings/week. These samples were purchased multiple times at specific intervals and were evaluated for Al levels. Al was detected in 27 of the 90 samples at levels ranging from 0.01 (limit of quantitation) to 1.06 mg/g. Of these, the Al intake levels in two samples (cookie and scone mix, 1.3 and 2 mg/kg bw/week, respectively) exceeded the TWI as established by European Food Safety Authority, although the level in the scone mix was equivalent to the provisional TWI (PTWI) as established by Joint Food and Agriculture Organization of the United Nations/World Health Organization Expert Committee on Food Additives. The Al levels markedly decreased in 14 of the 19 samples with initially high Al levels. These results indicated reductions in the Al levels to below the PTWI limits in all but two previously identified food samples.

Simple detection of residual enrofloxacin in meat products using microparticles and biochips.

A simple and sensitive method for detecting enrofloxacin, a major veterinary fluoroquinolone, was developed. Monoclonal antibody specific for enrofloxacin was immobilised on a chip and fluorescent dye-labelled microparticles were covalently bound to the enrofloxacin molecules. Enrofloxacin in solution competes with the microparticle-immobilised enrofloxacin (enroMPs) to bind to the antibody on the chip. The presence of enrofloxacin was verified by detecting the fluorescence of enrofloxacin-bound microparticles. Under optimum conditions, a high dynamic range was achieved at enrofloxacin concentrations ranging from 1 to 1000 µg kg(-1). The limits of detection and quantification for standard solutions were 5 and 20 µg kg(-1) respectively, which are markedly lower than the maximum residue limit. Using simple extraction methods, recoveries from fortified beef, pork and chicken samples were 43.4-62.3%. This novel method also enabled approximate quantification of enrofloxacin concentration: the enroMP signal intensity decreased with increasing enrofloxacin concentration. Because of its sensitivity, specificity, simplicity and rapidity, the method described herein will facilitate the detection and approximate quantification of enrofloxacin residues in foods in a high-throughput manner.

Panorama sobre a regulamentação do sistema APPCC em estabelecimentos de carne de aves sob inspeção federal / The regulation of the HACCP system in poultry establishments under federal inspection

Desde 2006, o Ministério da Agricultura, Pecuária e Abastecimento (MAPA) vem desenvolvendo regulamentação específica para aplicação do sistema de Análise de Perigos e Pontos Críticos de Controle (APPCC) nos matadouros de aves sob inspeção federal, incluindo diretrizes para a implantação desse programa de qualidade nas indústrias. Este artigo apresenta um panorama sobre a evolução dessa regulamentação, atualmente estagnada, e os métodos vigentes para fiscalização da aplicação do sistema APPCC em estabelecimentos de carne de aves. Dessa forma, os autores buscam facilitar a compreensão do processo regulatório por pesquisadores e técnicos da área e, com isso, incentivar esses profissionais a contribuir para o aperfeiçoamento das diretrizes governamentais.

Polycyclic aromatic hydrocarbons in cereal products on the Turkish market.

The contamination level of four EU marker polycyclic aromatic hydrocarbons (PAHs) in some cereal-derived products was surveyed in this study. Thirty-eight samples, 20 bread and 18 breakfast cereals, were purchased from retail shops and local markets of East Black sea region in Turkey. The samples were analysed for four EU marker PAHs, using ultrasonic extraction, solid-phase extraction (SPE) clean up and stable-isotope dilution gas chromatography with mass-spectrometric (GC/MS) detection. The method was validated with the parameters linearity, accuracy, precision, limit of detection (LOD), limit of quantitation (LOQ) and uncertainty. Total content of the four PAHs in bread varied from 0.19 to 0.46 µg kg(-1) and in breakfast cereals from 0.10 to 0.87 µg kg(-1).

Establishment of a standard reference material (SRM) herbal DNA barcode library of Vitex negundo L. (lagundi) for quality control measures.

The majority of the population in the Philippines relies on herbal products as their primary source for their healthcare needs. After the recognition of Vitex negundo L. (lagundi) as an important and effective alternative medicine for cough, sore throat, asthma and fever by the Philippine Department of Health (DOH), there was an increase in the production of lagundi-based herbal products in the form of teas, capsules and syrups. The efficiency of these products is greatly reliant on the use of authentic plant material, and to this day no standard protocol has been established to authenticate plant materials. DNA barcoding offers a quick and reliable species authentication tool, but its application to plant material has been less successful due to (1) lack of a standard DNA barcoding loci in plants and (2) poor DNA yield from powderised plant products. This study reports the successful application of DNA barcoding in the authentication of five V. negundo herbal products sold in the Philippines. Also, the first standard reference material (SRM) herbal library for the recognition of authentic V. negundo samples was established using 42 gene accessions of ITS, psbA-trnH and matK barcoding loci. Authentication of the herbal products utilised the SRM following the BLASTn and maximum-likelihood (ML) tree construction criterion. Barcode sequences were retrieved for ITS and psbA-trnH of all products tested and the results of the study revealed that only one out of five herbal products satisfied both BLASTn and ML criterion and was considered to contain authentic V. negundo. The results prompt the urgent need to utilise DNA barcoding in authenticating herbal products available in the Philippine market. Authentication of these products will secure consumer health by preventing the negative effects of adulteration, substitution and contamination.

Mycotoxins in wheat flour and intake assessment in Shandong province of China.

In the present study, the occurrence and contamination levels of eight mycotoxins were investigated in wheat flour samples (n = 359) from Shandong Province of China. Samples were determined using a multi-mycotoxin method based on isotope dilution ultrahigh performance liquid chromatography-tandem mass spectrometry. The results indicated that the most frequently found mycotoxins were deoxynivalenol (DON) (97.2%), nivalenol (40.4%) and deoxynivalenol-3-glucoside (33.4%), and mean contamination levels in positive samples were 86.7, 3.55 and 3.34 µg kg(-1), respectively. The obtained data were further used to estimate the daily intake of the local population, and indicated that wheat flour consumption contributes little to DON exposure. However, with the aim to keep the contamination levels under control and to establish a more precise evaluation of the mycotoxin burden in Shandong Province, more sample data from different harvest years and seasons are needed in the future.