Optimization and comparison of the production of galactooligosaccharides using free or immobilized Aspergillus oryzae ß-galactosidase, followed by purification using silica gel.

The aim of this study was to optimize and compare the production of galactooligosaccharides (GOSs) by free and cotton cloth-immobilized Aspergillus oryzae ß-galactosidase, and perform economical evaluation of production of GOSs (100%) between them. Using the response surface method, the optimal reaction time (3.9 h), initial lactose concentration (57.13%), and enzyme to lactose ratio (44.81 U/g) were obtained for the free enzyme, which provided a GOSs yield of 32.62%. For the immobilized enzyme, the optimal yield of GOSs (32.48%) was obtained under reaction time (3.09 h), initial lactose concentration (52.74%), and temperature (50.0 ℃). And it showed desirable reusability during five successive enzymatic reactions. The recovery rate of GOSs (100%) is 65% using silica gel filtration chromatography. The economical evaluation showed almost no difference in the manufacturing cost for the GOSs (100%) between these two systems, and that the recovery rate had a great impact on the cost.

Valid Assessment of Carbohydrate Intolerance and the Need for a Distinction to Carbohydrate Malabsorption. Comment on "Roles of Lactose and Fructose Malabsorption and Dietary Outcomes in Children Presenting with Chronic Abdominal Pain.", Nutrients, 2019, 11, 3063.

We have read with interest the recent paper by Posovszky and Roesler et al [1] that reports, based on the doctoral thesis by Dr. Roesler [2] [...].

No more cleaning up - Efficient lactic acid bacteria cell catalysts as a cost-efficient alternative to purified lactase enzymes.

ß-galactosidases, commonly referred to as lactases, are used for producing lactose-free dairy products. Lactases are usually purified from microbial sources, which is a costly process. Here, we explored the potential that lies in using whole cells of a food-grade dairy lactic acid bacterium, Streptococcus thermophilus, as a substitute for purified lactase. We found that S. thermophilus cells, when treated with the antimicrobial peptide nisin, were able to hydrolyze lactose efficiently. The rate of hydrolysis increased with temperature; however, above 50 °C, stability was compromised. Different S. thermophilus strains were tested, and the best candidate was able to hydrolyze 80% of the lactose in a 50 g/L solution in 4 h at 50 °C, using only 0.1 g/L cells (dry weight basis). We demonstrated that it was possible to grow the cell catalyst on dairy waste, and furthermore, that a cell-free supernatant of a culture of a nisin-producing Lactococcus lactis strain could be used instead of purified nisin, which reduced cost of use significantly. Finally, we tested the cell catalysts in milk, where lactose also was efficiently hydrolyzed. The method presented is natural and low-cost, and allows for production of clean-label and lactose-free dairy products without using commercial enzymes from recombinant microorganisms. KEY POINTS: • Nisin-permeabilized Streptococcus thermophilus cells can hydrolyze lactose efficiently. • A low-cost and more sustainable alternative to purified lactase enzymes. • Reduction of overall sugar content. • Clean-label production of lactose-free dairy products.

Whey permeate as the raw material in galacto-oligosaccharide synthesis using commercial enzymes.

Galacto-oligosaccharides (GOS), molecules with prebiotic properties are considered promising in the food industry. Its synthesis can be performed by enzymatic pathway, using commercial microbial enzymes. The reaction, known as transgalactosylation, is mediated by the enzyme ß-galactosidase and its catalysis is influenced during the process by substrate concentration present (in this case lactose), pH, and temperature, among others. The use of whey permeate, a by-product of the dairy industry, demonstrates the interest in making such processes viable from an economic and technological point of view. The main of this work was to use whey permeate as raw material in an enzymatic GOS synthesis, comparing three commercial enzymes of different microbial sources. For better performance, the results on lactose conversion, yield, and specific productivity were evaluated. The commercial enzyme of Kluyveromyces lactis (Lactozyme™ 2600 L) showed the best results for lactose conversion (89.27%), yield (25 g GOS/100 g lactose) and specific productivity (51 g GOS/g enzyme*h). Thus, it can be considered suitable for further technological development. Aspergillus oryzae commercial enzyme also showed good results and could be used for other studies either. However, the Escherichia coli commercial enzyme did not present good results in GOS synthesis, being more appropriate to lactose hydrolysis reactions. All the three enzymes showed a decrease in the production and even depletion of GOS molecules, and therefore, smaller reaction times should be established. New stages of optimization and processes development should be considered in future works, in order to obtain best yields and productivities.

Validity of a Portable Breath Analyser (AIRE) for the Assessment of Lactose Malabsorption.

Hydrogen (H2) measurement in exhaled breath is a reliable and non-invasive method to diagnose carbohydrate malabsorption. Currently, breath H2 measurement is typically limited to clinic-based equipment. A portable breath analyser (AIRE, FoodMarble Digestive Health Limited, Dublin, Ireland) is a personalised device marketed for the detection and self-management of food intolerances, including lactose malabsorption (LM). Currently, the validity of this device for breath H2 analysis is unknown. Individuals self-reporting dairy intolerance (six males and six females) undertook a lactose challenge and a further seven individuals (all females) underwent a milk challenge. Breath samples were collected prior to and at frequent intervals post-challenge for up to 5 h with analysis using both the AIRE and a calibrated breath hydrogen analyser (BreathTracker, QuinTron Instrument Company Inc., Milwaukee, WI, USA). A significant positive correlation (p < 0.001, r > 0.8) was demonstrated between AIRE and BreathTracker H2 values, after both lactose and milk challenges, although 26% of the AIRE readings demonstrated the maximum score of 10.0 AU. Based on our data, the cut-off value for LM diagnosis (25 ppm H2) using AIRE is 3.0 AU and it is effective for the identification of a response to lactose-containing foods in individuals experiencing LM, although its upper limit is only 81 ppm.

Modeling of lactose enzymatic hydrolysis using Monte Carlo method

Background: Mathematical modeling is useful in the analysis, prediction, and optimization of an enzymatic process. Unlike the conventional modeling methods, Monte Carlo method has special advantages in providing representations of the molecule's spatial distribution. However, thus far, Monte Carlo modeling of enzymatic system is namely based on unimolecular basis, not suitable for practical applications. In this research, Monte Carlo modeling is performed for enzymatic hydrolysis of lactose for the purpose of real-time applications. Results: The enzyme hydrolysis of lactose, which is conformed to Michaelis­Menten kinetics, is modeled using the Monte Carlo modeling method, and the simulation results prove that the model predicts the reaction kinetics very well. Conclusions: Monte Carlo modeling method can be used to model enzymatic reactions in a simple way for real-time applications.

Microbial production of sialic acid and sialylated human milk oligosaccharides: Advances and perspectives.

Sialic acids (SAs) are important functional sugars, and monomers of sialylated human milk oligosaccharides (sialylated HMOs or sialyllactoses), which are crucial for improving infant development and can facilitate infant brain development, maintain brain health, and enhance immunity. The most common form of SA is N-acetylneuraminic acid (NeuAc), and the main forms of sialyllactoses are 6'-sialyllactose (6'-SL) and 3'-sialyllactose (3'-SL). As functional food additive, the demand for NeuAc and sialyllactoses will continuously increase due to their wide and important fields of application. However, NeuAc and sialyllactoses produced by traditional extraction methods are inefficient and may cause allergen contamination, and cannot keep up with the rapidly increasing market demand. Therefore, the production of NeuAc and sialyllactoses by sustainable biotechnological methods have attracted increasing attention. In particular, the development of metabolic engineering and synthetic biology techniques and strategies have promoted efficient biosynthesis of NeuAc and sialyllactoses. In this review, we first discussed the application of NeuAc and sialyllactoses. Secondly, metabolic engineering and protein engineering-fueled progress of whole-cell catalysis and de novo synthesis of NeuAc and sialyllactoses were systematically summarized and compared. Furthermore, challenges of efficient microbial production of NeuAc and sialyllactoses as well as strategies for overcoming the challenges were discussed, such as clustered regularly interspaced short palindromic repeats interference (CRISPRi)-aided identification of key precursor transport pathways, synergistically debottleneck of kinetic and thermodynamic limits in synthetic pathways, and dynamic regulation of metabolic pathways for balancing cell growth and production. We hope this review can further facilitate the understanding of limiting factors that hampered efficient production of sialic acid and sialyllactoses, as well as contribute to the development of strategies for the construction of efficient production hosts for high-level production of sialic acid and sialyllactose based on synthetic biology tools and strategies.

Development of a novel, robust and cost-efficient process for valorizing dairy waste exemplified by ethanol production.

BACKGROUND: Delactosed whey permeate (DWP) is a side stream of whey processing, which often is discarded as waste, despite of its high residual content of lactose, typically 10-20%. Microbial fermentation is one of the most promising approaches for valorizing nutrient rich industrial waste streams, including those generated by the dairies. Here we present a novel microbial platform specifically designed to generate useful compounds from dairy waste. As a starting point we use Corynebacterium glutamicum, an important workhorse used for production of amino acids and other important compounds, which we have rewired and complemented with genes needed for lactose utilization. To demonstrate the potential of this novel platform we produce ethanol from lactose in DWP. RESULTS: First, we introduced the lacSZ operon from Streptococcus thermophilus, encoding a lactose transporter and a ß-galactosidase, and achieved slow growth on lactose. The strain could metabolize the glucose moiety of lactose, and galactose accumulated in the medium. After complementing with the Leloir pathway (galMKTE) from Lactococcus lactis, co-metabolization of galactose and glucose was accomplished. To further improve the growth and increase the sugar utilization rate, the strain underwent adaptive evolution in lactose minimal medium for 100 generations. The outcome was strain JS95 that grew fast in lactose mineral medium. Nevertheless, JS95 still grew poorly in DWP. The growth and final biomass accumulation were greatly stimulated after supplementation with NH4+, Mn2+, Fe2+ and trace minerals. In only 24 h of cultivation, a high cell density (OD600 of 56.8 ± 1.3) was attained. To demonstrate the usefulness of the platform, we introduced a plasmid expressing pyruvate decarboxylase and alcohol dehydrogenase, and managed to channel the metabolic flux towards ethanol. Under oxygen-deprived conditions, non-growing suspended cells could convert 100 g/L lactose into 46.1 ± 1.4 g/L ethanol in DWP, a yield of 88% of the theoretical. The resting cells could be re-used at least three times, and the ethanol productivities obtained were 0.96 g/L/h, 2.2 g/L/h, and 1.6 g/L/h, respectively. CONCLUSIONS: An efficient process for producing ethanol from DWP, based on C. glutamicum, was demonstrated. The results obtained clearly show a great potential for this newly developed platform for producing value-added chemicals from dairy waste.

Assessment of lactase activity in humans by measurement of galactitol and galactonate in serum and urine after milk intake.

Background: Lactase is an enzyme that hydrolyzes lactose into glucose and galactose in the small intestine, where they are absorbed. Hypolactasia is a common condition, primarily caused by genetic programming, that leads to lactose maldigestion and, in certain cases, lactose intolerance. Galactitol and galactonate are 2 products of hepatic galactose metabolism that are candidate markers for the intake of lactose-containing foods. Objectives: The primary objective of the study was to explore the changes in serum and urine metabolomes during postprandial dairy product tests through the association between lactase persistence genotype and the postprandial dynamics of lactose-derived metabolites. Methods: We characterized the 6-h postprandial serum kinetics and urinary excretion of lactose, galactose, galactitol, and galactonate in 14 healthy men who had consumed a single dose of acidified milk (800 g) which contained 38.8 g lactose. Genotyping of LCT-13910 C/T (rs4988235) was performed to assess primary lactase persistence. Results: There were 2 distinct postprandial responses, classified as high and low metabolite responses, observed for galactose, and its metabolites galactitol and galactonate, in serum and urine. In all but 1 subject, there was a concordance between the high metabolite responses and genetic lactase persistence and between the low metabolite responses and genetic lactase nonpersistence (accuracy 0.92), galactitol and galactonate being more discriminative than galactose. Conclusions: Postprandial galactitol and galactonate after lactose overload appear to be good proxies for genetically determined lactase activity. The development of a noninvasive lactose digestion test based on the measurement of these metabolites in urine could be clinically useful. This trial was registered at clinicaltrials.gov as NCT02230345.

Milk production of Holstein-Friesian cows of divergent Economic Breeding Index evaluated under seasonal pasture-based management.

The objective of this study was to validate the effect of genetic improvement using the Irish genetic merit index, the Economic Breeding Index (EBI), on total lactation performance and lactation profiles for milk yield, milk solids yield (fat plus protein; kg), and milk fat, protein, and lactose content within 3 pasture-based feeding treatments (FT) and to investigate whether an interaction exists between genetic group (GG) of Holstein-Friesian and pasture-based FT. The 2 GG were (1) extremely high EBI representative of the top 5% nationally (referred to as the elite group) and (2) representative of the national average EBI (referred to as the NA group). Cows from each GG were randomly allocated each year to 1 of 3 pasture-based FT: control, lower grass allowance, and high concentrate. The effects of GG, FT, year, parity, and the interaction between GG and FT adjusted for calving day of year on milk and milk solids (fat plus protein; kg) production across lactation were studied using mixed models. Cow was nested within GG to account for repeated cow records across years. The overall and stage of lactation-specific responses to concentrate supplementation (high concentrate vs. control) and reduced pasture allowance (lower grass allowance vs. control) were tested. Profiles of daily milk yield, milk solids yield, and milk fat, protein, and lactose content for each week of lactation for the elite and NA groups within each FT and for each parity group within the elite and NA groups were generated. Phenotypic performance was regressed against individual cow genetic potential based on predicted transmitting ability. The NA cows produced the highest milk yield. Milk fat and protein content was higher for the elite group and consequently yield of solids-corrected milk was similar, whereas yield of milk solids tended to be higher for the elite group compared with the NA group. Milk lactose content did not differ between GG. Responses to concentrate supplementation or reduced pasture allowance did not differ between GG. Milk production profiles illustrated that elite cows maintained higher production but with lower persistency than NA cows. Regression of phenotypic performance against predicted transmitting ability illustrated that performance was broadly in line with expectation. The results illustrate that the superiority of high-EBI cattle is consistent across diverse pasture-based FT. The results also highlight the success of the EBI to deliver production performance in line with the national breeding objective: lower milk volume with higher fat and protein content.

Exploitation of acid-tolerant microbial species for the utilization of low-cost whey in the production of acetic acid and propylene glycol.

Whey from cheese and yoghurt production operations contains useful constituents such as whey protein and lactose. However, the separation and extraction processes are difficult and costly, and hence, whey has limited end user demand and is typically disposed of as waste. Treatment and disposal of these high BOD wastes are both energy intensive and expensive. However, improper disposal of these wastes can pollute surface and ground water resources. The use of these low or negative cost substrates for the production of value-added products such as acetic acid and propylene glycol (PG) is of great significance in changing overhead costs to revenue streams. The present study focuses on bioproduction of acetic acid and PG from whey lactose and whey powder containing lactose and protein as an alternative to high cost nutritive medium. It was found that Lactobacillus buchneri, an acid-tolerant bacterium, is able to ferment lactose at pH ~ 4.2 to low molecular weight compounds such as acetic acid and PG each at 25-30 g L-1 concentration when using lactose as a major carbon substrate. The typical molar ratio of acetic acid to PG was close to 1:1 at the end of fermentation. The productivity of acetic acid and PG was improved using a high cell density fermentation with cotton cheesecloth as an immobilization matrix. The use of whey powder with immobilized fermentation system showed a similar performance to that of cultures fed with pure lactose at pH 4.2, resulting in a 57% conversion of lactose in whey to acetate and PG in total, against a stoichiometric maximum of 72%.

Safety assessment and functional properties of four enterococci strains isolated from regional Argentinean cheese.

The members of the Enterococcus genus are widely distributed in nature. Its strains have been extensively reported to be present in plant surfaces, soil, water and food. In an attempt to assess their potential application in food industry, four Enterococcus faecium group-strains recently isolated from Argentinean regional cheese products were evaluated using a combination of whole genome analyses and in vivo assays. In order to identify these microorganisms at species level, in silico analyses using their newly reported sequences were conducted. The average nucleotide identity (ANI), in silico DNA-DNA hybridization, and phylogenomic trees constructed using core genome data allowed IQ110, GM70 and GM75 strains to be classified as E. faecium while IQ23 strain was identified as E. durans. Besides their common origin, the strains showed differences in their genetic structure and mobile genetic element content. Furthermore, it was possible to determine the absence or presence of specific features related to growth in milk, cheese ripening, probiotic capability and gut adaptation including sugar, amino acid, and peptides utilization, flavor compound production, bile salt tolerance as well as biogenic amine production. Remarkably, all strains encoded for peptide permeases, maltose utilization, bile salt tolerance, diacetyl and tyramine production genes. On the other hand, some variability was observed regarding citrate and lactose utilization, esterase, and cell wall-associated proteinase. In addition, while strains were predicted to be non-human pathogens by the in silico inspection of pathogenicity and virulence factors, only the GM70 strain proved to be non-virulent in Galleria mellonella model. In conclusion, we propose that, in order to improve the rational selection of strains for industrial applications, a holistic approach involving a comparative genomic analysis of positive and negative features as well as in vivo evaluation of virulence behavior should be performed.

Overproduction of cellulase by Trichoderma reesei RUT C30 through batch-feeding of synthesized low-cost sugar mixture.

Cellulase is a prerequisite for the bioconversion of lignocellulosic biomass, but its high cost presents the biggest challenge. In this article, low-cost mixture was produced from glucose through the transglycosylation reaction catalyzed by ß-glucosidase for cellulase overproduction by Trichodema reesei RUT C30. As a result, cellulase titer of 90.3FPU/mL, which was more than 10 folds of that achieved with lactose as inducer, was achieved at 144h. Meanwhile, cellulase productivity was drastically increased to 627.1FPU/L/h, at least 3-5 folds higher than previously reported by the fungal species. The crude enzyme was further tested by hydrolyzing NaOH-pretreated corn stover with 15% solid loading, and 96.6g/L glucose was released with 92.6% sugar yield at 96h and 44.8g/L ethanol was obtained.

Assessment of vitamin D status and serum CrossLaps levels in adults with primary lactose malabsorption.

BACKGROUND/OBJECTIVES: Primary adult-type lactose malabsorption (PALM) is a widespread inherited autosomal recessive condition, which is considered to be associated with osteoporosis. This prospective study aimed at assessing the 25-hydroxy-vitamin D (25(OH)D) status and serum CrossLaps levels in individuals with PALM and normal controls. SUBJECTS/METHODS: All participants (n=210) underwent genotyping for the LCT C/T-13910 polymorphism, 25(OH)D and CrossLaps measurements and clinical examinations. In addition, the anthropometric data (that is, height, weight and body mass index) were determined. RESULTS: Fifty-five individuals with PALM (that is, LCT C/C-13910 homozygotes) showed lower 25(OH)D (mean: 24.95±10.04 vs 28.59±9.56 ng/ml, P=0.018) and higher CrossLaps serum levels (mean: 0.46±0.31 vs 0.43±0.49 ng/ml, P=0.251) compared with 155 normal controls (that is, LCT C/T-13910 hetero- or T/T-13910 homozygotes). Anthropometric data were similar between PALM probands and controls. CONCLUSIONS: Individuals with PALM were found to have lower 25(OH)D and higher CrossLaps serum levels compared with normal controls. In order to preserve life-long bone health, routine 25(OH)D and CrossLaps serum measurements should be performed in individuals with PALM.

Detecting shifts in gene regulatory networks during time-course experiments at single-time-point temporal resolution.

Comprehensively understanding the dynamics of biological systems is one of the greatest challenges in biology. Vastly improved biological technologies have provided vast amounts of information that must be understood by bioinformatics and systems biology researchers. Gene regulations have been frequently modeled by ordinary differential equations or graphical models based on time-course gene expression profiles. The state-of-the-art computational approaches for analyzing gene regulations assume that their models are same throughout time-course experiments. However, these approaches cannot easily analyze transient changes at a time point, such as diauxic shift. We propose a score that analyzes the gene regulations at each time point. The score is based on the information gains of information criterion values. The method detects the shifts in gene regulatory networks (GRNs) during time-course experiments with single-time-point resolution. The effectiveness of the method is evaluated on the diauxic shift from glucose to lactose in Escherichia coli. Gene regulation shifts were detected at two time points: the first corresponding to the time at which the growth of E. coli ceased and the second corresponding to the end of the experiment, when the nutrient sources (glucose and lactose) had become exhausted. According to these results, the proposed score and method can appropriately detect the time of gene regulation shifts. The method based on the proposed score provides a new tool for analyzing dynamic biological systems. Because the score value indicates the strength of gene regulation at each time point in a gene expression profile, it can potentially infer hidden GRNs from time-course experiments.

Relationship between sol-gel conditions and enzyme stability: a case study with ß-galactosidase/silica biocatalyst for whey hydrolysis.

The sol-gel process has been very useful for preparing active and stable biocatalysts, with the possibility of being reused. Especially those based on silica are well known. However, the study of the enzyme behavior during this process is not well understood until now and more, if the surfactant is involved in the synthesis mixture. This work is devoted to the encapsulation of ß-galactosidase from Bacillus circulans in silica by sol-gel process, assisted by non-ionic Triton X-100 surfactant. The correlation between enzyme activity results for the ß-galactosidase in three different environments (soluble in buffered aqueous reference solution, in the silica sol, and entrapment on the silica matrix) explains the enzyme behavior under stress conditions offered by the silica sol composition and gelation conditions. A stable ß-galactosidase/silica biocatalyst is obtained using sodium silicate, which is a cheap source of silica, in the presence of non-ionic Triton X-100, which avoids the enzyme deactivation, even at 40 °C. The obtained biocatalyst is used in the whey hydrolysis for obtaining high value products from this waste. The preservation of the enzyme stability, which is one of the most important challenges on the enzyme immobilization through the silica sol-gel, is achieved in this study.

Continuous xylose fermentation by Clostridium acetobutylicum--Assessment of solventogenic kinetics.

This work deals with the specific butanol production rate of Clostridium acetobutylicum using xylose--a relevant fraction of lignocellulosic feedstock for biofuel production--as carbon source. The tests were carried out in a CSTR equipped with a microfiltration unit. The dilution rate (D) ranged between 0.02 and 0.22 h(-1) and the ratio R between the permeate stream rate and the stream fed to the reactor ranged between 14% and 88%. The biomass present in the broth was identified as a heterogeneous cell population consisting of: acidogenic cells, solventogenic cells and spores. The results were processed to assess the concentration of acidogenic cells, solventogenic cells and spores. The specific butanol production rate was also assessed. The max butanol productivity was 1.3 g L(-1) h(-1) at D = 0.17 h(-1) and R = 30%. A comparison between the results reported in a previous work carried out with lactose was made.

Continuous lactose fermentation by Clostridium acetobutylicum--assessment of solventogenic kinetics.

This work reports the results of a series of tests on the specific butanol production rate by Clostridium acetobutylicum continuous cultures. The tests were carried out using lactose as carbon source to mimic cheese-whey. A continuous stirred tank reactor equipped with a microfiltration unit was used. The dilution rate (D) ranged between 0.02 and 0.15h(-1) and the ratio R of the permeate stream rate to the stream fed to the reactor ranged between 14% and 95%. For each set of D and R values, the continuous cultures were characterized in terms of concentration of cells, acids and solvents. Results were processed to assess the concentration of acidogenic cells, solventogenic cells, spores and the specific butanol production rate. The max butanol productivity was 0.5gL(-1)h(-1) at D=0.1h(-1) and R=95%. The butanol productivity referred to solventogenic cells was expressed as a function of concentration of lactose, acids and butanol.

Cost-effective production of recombinant human interleukin 24 by lactose induction and a two-step denaturing and one-step refolding method.

Recombinant human interleukin 24 (rhIL24) is a member of the interleukin 10 (IL10) family of cytokines with novel therapeutic properties. Human IL24 possesses three N glycosylation sites and a disulfide bridge. The cost and composition of culture media is critical for commercial-scale production of recombinant proteins in E. coli. Addition of yeast extract and glucose to medium enhances rhIL24 production, and the use of lactose instead of IPTG for induction drops the cost and decreases toxicity. In addition, a two-step denaturing and one-step refolding (2DR) strategy improves rhIL24 production. The 2DR strategy replaces a more conventional approach for protein solubilization and refolding. LC-MS/MS provides definitive identification and quantitative information on rhIL24. Single-step purified rhIL24 displayed biological activity on HepG2 hepatocellular carcinoma cells, but no effect on L02 cells. Proliferation analysis suggests that rhIL24 may have potential use as a medication. In the present study, we developed a simple process for producing quality product with high purity. The expression and purification of rhIL24 described here may be a step towards inexpensive large-scale production.

Improved method for expression and isolation of the Mycoplasma hominis arginine deiminase from the recombinant strain of Escherichia coli.

Arginine deiminase is a promising anticancer drug active against melanoma, hepatocarcinoma and other tumors. Recombinant strains of Escherichia coli that express arginine deiminase from pathogenic bacteria Mycoplasma have been developed. However, production costs of heterologous arginine deiminase are high due to use of an expensive inducer and extraction buffer, as well as using diluted culture for enzyme induction. We report on a new advanced protocol for Mycoplasma hominis arginine deiminase expression, extraction and renaturation. The main improvements include manipulation with dense suspensions of E. coli, use of lactose instead of isopropyl ß-D-1-thiogalactopyranoside as an inducer and a cheaper but not less efficient buffer for solubilization of arginine deiminase inclusion bodies. In addition, supplementation of the storage culture medium with glucose and substrate (arginine) significantly stabilized the recombinant arginine deiminase producer. Homogenous preparations of recombinant arginine deiminase were obtained using anion-exchange and hydrophobic chromatography. The purified enzyme retained a specific activity of 30-34 U/mg for 12 months when stored at 4°C in 20 mM sodium phosphate buffer pH 7.2 containing 1 M NaCl.