Assessment of the scalability of a microtiter plate system for screening of oleaginous microorganisms.

Recent developments in molecular biology and metabolic engineering have resulted in a large increase in the number of strains that need to be tested, positioning high-throughput screening of microorganisms as an important step in bioprocess development. Scalability is crucial for performing reliable screening of microorganisms. Most of the scalability studies from microplate screening systems to controlled stirred-tank bioreactors have been performed so far with unicellular microorganisms. We have compared cultivation of industrially relevant oleaginous filamentous fungi and microalga in a Duetz-microtiter plate system to benchtop and pre-pilot bioreactors. Maximal glucose consumption rate, biomass concentration, lipid content of the biomass, biomass, and lipid yield values showed good scalability for Mucor circinelloides (less than 20% differences) and Mortierella alpina (less than 30% differences) filamentous fungi. Maximal glucose consumption and biomass production rates were identical for Crypthecodinium cohnii in microtiter plate and benchtop bioreactor. Most likely due to shear stress sensitivity of this microalga in stirred bioreactor, biomass concentration and lipid content of biomass were significantly higher in the microtiter plate system than in the benchtop bioreactor. Still, fermentation results obtained in the Duetz-microtiter plate system for Crypthecodinium cohnii are encouraging compared to what has been reported in literature. Good reproducibility (coefficient of variation less than 15% for biomass growth, glucose consumption, lipid content, and pH) were achieved in the Duetz-microtiter plate system for Mucor circinelloides and Crypthecodinium cohnii. Mortierella alpina cultivation reproducibility might be improved with inoculation optimization. In conclusion, we have presented suitability of the Duetz-microtiter plate system for the reproducible, scalable, and cost-efficient high-throughput screening of oleaginous microorganisms.

The influence of effective microorganisms (EM) and yeast on the degradation of strobilurins and carboxamides in leafy vegetables monitored by LC-MS/MS and health risk assessment.

The aim of this study was to determine the behaviour of strobilurin and carbocyamides commonly used in chemical protection of lettuce depending on carefully selected effective microorganisms (EM) and yeast (Y). Additionally, the assessment of the chronic health risk during a 2-week experiment was performed. The statistical method for correlation of physico-chemical parameters and time of degradation for pesticides was applied. In this study, the concentration of azoxystrobin, boscalid, pyraclostrobin and iprodione using liquid chromatography-mass spectrometry (LC-MS/MS) in the matrix of lettuce plants was performed, and there was no case of concentration above maximum residues levels. Before harvest, four fungicides and their mixture with EM (1 % and 10 %) and/or yeast 5 % were applied. In our work, the mixtures of 1%EM + Y and 10%EM + Y both stimulated and inhibited the degradation of the tested active substances. Adding 10%EM to the test substances strongly inhibited the degradation of iprodione, and its concentration decreased by 30 %, and in the case of other test substances, the degradation was approximately 60 %. Moreover, the addition of yeast stimulated the distribution of pyraclostrobin and boscalid in lettuce leaves. The risk assessment for the pesticides ranged from 0.4 to 64.8 % on day 1, but after 14 days, it ranged from 0.0 to 20.9 % for children and adults, respectively. It indicated no risk of adverse effects following exposure to individual pesticides and their mixtures with EM and yeast.

Fermentation process improvement of a Chinese traditional food: soybean residue cake.

UNLABELLED: Fermentation process improvement of soybean residue cake, a Chinese traditional fermented food, and its physicochemical analysis during fermentation were studied. One of the dominant strains in the fermentation was isolated and identified as Mucor racemosus Fresenius. The fermentation process was improved by subsection fermentation. The crude protein content decreased from 19.95 ± 0.03% in the raw soybean residue to 16.85 ± 0.10% in the fermented products, and the formaldehyde nitrogen content increased from 0.068 ± 0.004% to 0.461 ± 0.022% in final fermented cakes. Hardness of samples significantly (P < 0.05) increased whereas springiness, cohesiveness, and resilience significantly (P < 0.05) decreased with increasing fermentation time, respectively. Microstructure observations showed obvious change of the surface of cake samples during the fermentation process. PRACTICAL APPLICATION: During the soybean processing, it will produce plenty of by-products, and the most part of them is soybean residue. The discarded soybean residue causes economic loss. Fortunately, we can obtain nutritious and delicious fermented soybean residue cakes by fermenting soybean residue as raw material.