Development of a quantitative microbiological spoilage risk assessment (QMSRA) model for cooked ham sliced at retail.

A quantitative microbiological spoilage risk assessment model (QMSRA) for cooked ham sliced at retail was developed based on a stochastic growth model for lactic acid bacteria (LAB), which are considered as the specific spoilage organisms (SSO), and a "spoilage-response" relationship characterizing the variability in consumer's perception of spoilage. In a simulation involving 10,000 cooked ham purchases, the QMSRA model predicted a median of zero spoilage events for up to 4.5 days of storage. After storage times of 5 and 6 days, the model predicted 1,790 and 8,570 spoilage events, respectively. A sensitivity analysis showed that domestic storage temperature was the most significant factor affecting LAB concentration in cooked ham, followed by the LAB contamination level at slicing. A scenario analysis was performed testing better temperature control of consumer's refrigerators, better hygiene conditions during slicing and a combination of the two strategies. Among the tested scenarios, a 2 log reduction in the LAB contamination at slicing combined with a 2 °C decrease in domestic storage temperature resulted in zero risk of spoilage for up to 12 days of storage. The QMSRA model developed in the present study can be a useful tool for quality management decisions.

Risk factors for listeriosis due to sausage consumption in Mexico: consumer practices, bacterial survival, and quantitative microbial risk assessment.

Listeriosis is a foodborne disease caused by Listeria monocytogenes (Lm), which represents a public health problem. Lm has been identified as an important contaminating bacterium of ready-to-eat meat products (RTEM) in Mexico. The objective was to explore the risk factors for acquiring listeriosis due to sausage consumption by defining the consumer profile, evaluating the survival of Lm in sausage (5, 10, and 25 °C for 32 days) and performing a quantitative microbiological risk assessment. The survey of 100 participants revealed that the factors compromising the safety of the RTEM by the consumer are the extension of the shelf life. Acquiring packaged RTEM was observed as a safe habit. All respondents stated that they were unaware of listeriosis, but 18% reported infections linked to RTEM, mainly sausage. The sausage supports the growth of Lm, whose population increases in congruence with temperature (25 °C > 10 °C >5 °C) and storage time (P ≤ 0.05). The increase in temperature decreases the adaptation time (Lag25 °C = 1.0 h, Lag10 °C= 92.5 h, Lag5 °C = 226.1 h) and increases the growth rate (µ25 °C = 4.43 CFU/h, µ10 °C = 0.075 CFU/h, µ5 °C = 0.0026 CFU/h) of Lm on the sausage. The risk of listeriosis due to sausage consumption increased according to the increase in temperature: 5.53 × 10-8-1.42 × 10-5 (5 °C), 0.00616-0.111 (10 °C), and 0.109-1.00 (25 °C). Consumer education in the hygienic management of RTEM and information on associated pathogens will minimize the risk of disease.

A quantitative risk assessment of Listeria monocytogenes from prevalence and concentration data: Application to a traditional ready to eat (RTE) meat product.

Ready to Eat (RTE) cooked meat products are among the most consumed RTE food subcategories in the EU/EEA. They are also associated with the highest number of identified listeriosis cases per year (>850), thus posing a public health risk especially among the susceptible population. This study estimated the risk of listeriosis from Italian head cheese (Coppa di Testa) consumption using a Quantitative Microbiological Risk Assessment (QMRA) based on data of prevalence and starting concentrations of Listeria monocytogenes in the product during a 3-year period (n = 1568). A consumer survey (n = 162) was conducted to provide information on domestic storage time and consumption habits, and storage conditions were determined from recordings of temperatures of domestic refrigerators (n = 57). A probabilistic model was designed for the evaluation of the growth of L. monocytogenes at each stage of the product pathway from production to consumption, using Monte Carlo simulations and employing the @Risk software. Risks associated to consumption of vacuum-packed and sliced-at-retail head cheese were assessed: The model predicted that the risk of listeriosis per serving of vacuum-packed product was in the 10-4 and 10-6 range (mean) for the high-risk and general populations respectively, and listeriosis cases were estimated to be greater than those due to consumption of sliced product (with risks in the range of 10-7 and 10-8). Overall, the model predicted that the mean number of listeriosis cases ranged from 0.001 to 0.24 and from 0.06 to 10 per one hundred thousand people, for the healthy and the high-risk population, respectively. Scenario analyses indicated that better control of the temperature of domestic refrigerators is effective in reducing the predicted risk of listeriosis for the longer stored vacuum-packed product by ~80 % for both the healthy and high-risk populations, whereas a shorter use-by-date of 30 days is an effective risk mitigation measure for both types of packed product. Model assumptions, as well as data gaps are discussed.

To culture or not to culture: careful assessment of metabarcoding data is necessary when evaluating the microbiota of a modified-atmosphere-packaged vegetarian meat alternative throughout its shelf-life period.

BACKGROUND: As the increased consumption of ready-to-eat meat alternatives is a fairly recent trend, little is known about the composition and dynamics of the microbiota present on such products. Such information is nonetheless valuable in view of spoilage and food safety prevention. Even though refrigeration and modified-atmosphere-packaging (MAP) can extend the shelf-life period, microbial spoilage can still occur in these products. In the present study, the microbiota of a vegetarian alternative to poultry-based charcuterie was investigated during storage, contrasting the use of a culture-dependent method to a culture-independent metagenetic method. RESULTS: The former revealed that lactic acid bacteria (LAB) were the most abundant microbial group, specifically at the end of the shelf-life period, whereby Latilactobacillus sakei was the most abundant species. Metabarcoding analysis, in contrast, revealed that DNA of Xanthomonas was most prominently present, which likely was an artifact due to the presence of xanthan gum as an ingredient, followed by Streptococcus and Weissella. CONCLUSIONS: Taken together, these results indicated that Lb. sakei was likely the most prominent specific spoilage organisms (SSO) and, additionally, that the use of metagenetic analysis needs to be interpreted with care in this specific type of product. In order to improve the performance of metagenetics in food samples with a high DNA matrix but a low bacterial DNA load, selective depletion techniques for matrix DNA could be explored.

'We dry contaminated meat to make it safe': An assessment of knowledge, attitude and practices on anthrax during an outbreak, Kisumu, Kenya, 2019.

INTRODUCTION: Anthrax is the highest-ranked priority zoonotic disease in Kenya with about ten human cases annually. Anthrax outbreak was reported in Kisumu East Sub County after some villagers slaughtered and ate beef from a cow suspected to have died of anthrax. We aimed at establishing the magnitude of the outbreak, described associated factors, and assessed community knowledge, attitude, and practices on anthrax. METHODS: We reviewed human and animal records, conducted case search and contact tracing using standard case definitions in the period from July 1through to July 28, 2019. A cross-sectional study was conducted to assess community knowledge, attitude, and practices towards anthrax. The household selection was done using multistage sampling. We cleaned and analyzed data in Ms. Excel and Epi Info. Descriptive statistics were carried out for continuous and categorical variables while analytical statistics for the association between dependent and independent variables were calculated. RESULTS: Out of 53 persons exposed through consumption or contact with suspicious beef, 23 cases (confirmed: 1, probable: 4, suspected: 18) were reviewed. The proportion of females was 52.17% (12/23), median age 13.5 years and range 45 years. The attack rate was 43.4% (23/53) and the case fatality rate was 4.35% (1/23). Knowledge level, determined by dividing those considered to be 'having good knowledge' on anthrax (numerator) by the total number of respondents (denominator) in the population regarding cause, transmission, symptoms and prevention was 51% for human anthrax and 52% for animal anthrax. Having good knowledge on anthrax was associated with rural residence [OR = 5.5 (95% CI 2.1-14.4; p<0.001)], having seen a case of anthrax [OR = 6.2 (95% CI 2.8-14.2; p<0.001)] and among those who present cattle for vaccination [OR = 2.6 (95% CI 1.2-5.6; p = 0.02)]. About 23.2% (26/112) would slaughter and sell beef to neighbors while 63.4% (71/112) would bury or burn the carcass. Nearly 93.8% (105/112) believed vaccination prevents anthrax. However, 5.4% (62/112) present livestock for vaccination. CONCLUSION: Most anthrax exposures were through meat consumption. Poor knowledge of the disease might hamper prevention and control efforts.

Analysis of the assessment of antimicrobial susceptibility. Non-typhoid Salmonella in meat and meat products as model (systematic review).

BACKGROUND: The scientific publications of antimicrobial susceptibilities and resistance must be precise, with interpretations adjusted to the standard. In this frame, knowledge of antimicrobial resistance is fundamental in pathogenic microorganisms such as Salmonella spp., known for many annual deaths worldwide. The objective of this work was to compare the interpretation of standards, the concentrations, and the breakpoints, to study antimicrobial resistance in Non-Typhoidal Salmonella (NTS) isolated from beef, pork, and chicken meat, meat products, and propose additional considerations that improve the use and usefulness of published results. RESULTS: After refining the search based on meeting the inclusion and exclusion criteria, 48 papers were selected. In 33 (68.8%) of them, the disc diffusion method was used, in 11 (22.9%) the MIC determination method, and in 4 (8.33%) were used both. In 24 (50%) of the articles, the selection of a different (correct) standard could have had an impact on the interpretation of antimicrobial susceptibility, which observed when considering three scenarios, i) comparison between the year of the isolation versus the implemented standard, ii) comparison between the year of submission versus implemented standard and iii) comparison between the year of publication versus implemented standard. CONCLUSIONS: The most frequent scenario was the inadequate selection of standards, indicating that some studies had not ensured that applied standards kept in line with the date of isolation, date of publication and interpretation of susceptibilities. We proposed 2 years for standards use for resistance and multi-resistance interpretations. On the other hand, we invite researchers to publish their results in the shortest possible time, and editors and reviewers of scientific journals to prioritise these types of studies and verify the correspondence between the standard cited and the one used and the one to be taken into account.

Identification and safety assessment of Enterococcus thailandicus TC1 isolated from healthy pigs.

Enterococci have the dual characteristics of being opportunistic pathogens and promising probiotics. The isolation from patients of CDC PNS-E2, a newly described Enterococcus species Enterococcus sanguinicola, may pose potential hazards. Enterococcus thailandicus from fermented sausage is a senior subjective synonym of E. sanguinicola. In this study, Enterococcus thailandicus TC1 was first isolated in healthy pigs in Tongcheng, China and identified by phenotypic analysis and 16S rRNA-based techniques. To evaluate the strain safety, an approach including virulence factors, antibiotic resistance, and animal experiments was adopted. The results show that cylA, gelE, esp, agg, ace, efaAfm, efaAfs, ptsD genes were undetected, and that the strain was sensitive or poorly resistant to some clinically relevant antibiotics. However, the isolated strain demonstrated ß-hemolytic activity in rabbit blood agar plates. Analysis of animal experiments revealed that the isolated strain had no adverse effect on translocation and the internal organ indices, though significant differences in histology (villi height, crypts height) of ileum were observed. The data acquired suggest that E. thailandicus TC1 may be associated with a potential health risk.

Quantitative risk assessment of Listeria monocytogenes in ready-to-eat (RTE) cooked meat products sliced at retail stores in Greece.

A quantitative microbial risk assessment (QMRA) model predicting the listeriosis risk related to the consumption of Ready- To- Eat (RTE) cooked meat products sliced at retail stores in Greece was developed. The probability of illness per serving assessed for 87 products available in the Greek market was found highly related to the nitrite concentration; products having a lower concentration showed a higher risk per serving. The predicted 95th percentiles of the annual listeriosis cases totaled 33 of which 13 cases were <65 years old and 20 cases ≥65 years old. The highest number of cases was predicted for mortadella, smoked turkey, boiled turkey and parizer, which were the most frequently consumed product categories. Two scenarios for assessing potential interventions to reduce the risk were tested: setting a use-by date of 14 days (these products have no use-by date based on current European Union legislation) and improving the temperature control during domestic storage. The two scenarios resulted in a decrease of the 95th and 99th percentiles of the total annual cases by 97% and 88%, respectively.

Effects of "fresh mechanically deboned meat" inclusion on nutritional value, palatability, shelf-life microbiological risk and digestibility in dry dog food.

Fresh mechanically deboned meat (MDM) is usually claimed as high-quality ingredient on dry pet food recipes and this aspect may positively influence consumer choice. It is important to determine the scientifically sustainability of this claim and to assess the microbiological safety of MDM inclusion in dry pet food. Objectives were: 1) to evaluate the effect of inclusion of MDM in dry dog food on fatty acid profile and in vivo and in vitro digestibility, proposing a new system (DaisyII Incubator) to measure the in vitro digestibility for dogs; 2) to compare palatability of dry dog food containing MDM with dry dog food in which meat by-products (MBP) are the only animal protein sources; 3) to determine, whether or not, the inclusion of that ingredient changes the microbiology and the storage quality. Results indicated that MDM product was characterized by significant higher nutritional value in terms of fatty acids profile, in vitro digestibility (HV-IVD method) and lower palatability than the MBP product. Microbiological risk assessment showed no microbiological hazards for either product. After 6-months storage, the total mesophilic bacterial count ranged between 1.77 and 2.09 log CFU/g feed, while polyamine values were higher in the MDM (0.37 g/kg) than in the MBP (0.27 g/kg). The DaisyII Incubator was found to be a valid instrument for studying in vitro digestibility also for dogs, providing data simply, quickly, with less variability and costs than in vivo trials. In conclusion, MDM inclusion in dry dog food is microbiologically safe and it can improve its nutritional quality, at the expense of a reduced palatability. The higher polyamine levels fount in MDM-enriched petfood after 6-months storage, however, may represent a possible hazard, and further studies are still warranted.

Risk management tool to define a corrective storage to enhance Salmonella inactivation in dry fermented sausages.

The resistance of Salmonella to the harsh conditions occurring in shelf-stable dry fermented sausages (DFS) poses a food safety challenge for producers. The present study aimed to model the behaviour of Salmonella in acid (with starter culture) and low-acid (without starter culture) DFS as a function of aw and storage temperature in order to build a decision supporting tool supporting the design of a corrective storage strategy to enhance the safety of DFS. Salmonella spp. were inoculated in the raw meat batter at ca. 6 Log cfu/g with a cocktail of 3 strains (CTC1003, CTC1022 and CTC1754) just before mixing with the other ingredients and additives. After stuffing, sausages were fermented and ripened following industrial processing conditions. Different drying-times were applied to obtain three batches with different aw (0.88, 0.90 and 0.93). Afterwards, DFS were stored at 4, 8, 15 and 25 °C for a maximum of three months and Salmonella spp. were periodically enumerated. The Weibull model was fitted to Log counts data to estimate inactivation kinetic parameters. The impact of temperature and aw on the primary inactivation parameters was evaluated using a polynomial equation. The results of the challenge tests showed that Salmonella spp. levels decreased during storage at all the assayed conditions, from 0.8 Log (in low-acid DFS at 4 °C) up to 6.5 Log (in acid DFS at 25 °C). The effect of both aw and temperature was statistically significant. Delta (δ) parameter decreased by decreasing aw and increasing temperature, while the shape (p) parameter ranged from above 1 (concave) at 10 °C to below 1 at 25 °C (convex). A common secondary model for the p parameter was obtained for each type of DFS, acid and low-acid, indicating that acidification during the production of DFS affected the time for the first Log reduction (δ) during the subsequent storage, but not the overall shape (p parameter) of the inactivation. The developed models covered representative of real conditions, such as Salmonella contamination in the raw materials and its adaptation to the harsh processing conditions. The good predictive performance shown when applying the models to independent data (i.e. up to 80% of the predictions within the 'Acceptable Simulation Zone' for acid sausages) makes them a suitable and reliable risk management tool to support manufacturers to assess and design a lethality treatment (i.e. corrective storage) to enhance the Salmonella inactivation in the product before DFS are released to the market.

Assessment of Internalin A Gene Sequences and Cell Adhesion and Invasion Capacity of Listeria monocytogenes Strains Isolated from Foods of Animal and Related Origins.

Listeria monocytogenes is a foodborne pathogen of global relevance that causes outbreaks and sporadic cases of listeriosis, acquired through the consumption of contaminated products, including milk or meat products and ready-to-eat meat products subjected to intensive handling. The objective of the present study was to classify L. monocytogenes isolated from various food-related sources in the Federal District of Brazil and surrounding areas to sequence internalin A (inlA) genes from these isolates and assess their adhesion and invasion capacity using Caco-2 cells. In addition, 15 were classified as group I, 3 as group II, and 7 classified as group IV. Premature stop codons (PMSCs) at the nucleotide position 976 (GAA→TAA) of the inlA gene were identified in 5 of the 25 isolates. Adhesion and invasion tests in Caco-2 cells showed that all the isolates were capable of adhesion and cellular invasion, with isolates containing PMSCs exhibiting on average higher invasion capacity than those without PMSCs (p = 0.041) and a median of adhesion very distinctive from those without stop codons. These results are the first report of PMSCs in the inlA gene of L. monocytogenes from the Federal District of Brazil and Brazil.

Occurrence of extended-spectrum ß-lactamase and AmpC-producing Escherichia coli in retail meat products from the Maritime Provinces, Canada.

This study was conducted to determine the occurrence of antimicrobial resistance to the extended-spectrum cephalosporins (ESC) in Escherichia coli isolates. The isolates were collected from retail meat products collected in the Maritime Provinces of Canada. Our analyses involved the use of both selective and traditional culture methods; we also conducted genotype analyses using multiplex polymerase chain reactions. ESC-resistant (ESC-R) E. coli were detected in 33 of 559 samples (5.9%) using the traditional culture method, compared with 151 of 557 samples (27.1%) using the selective culture method. We recovered more isolates of ESC-R E. coli from poultry compared with beef and pork (P < 0.001). Multidrug resistance, extended-spectrum ß-lactamase (ESBL), and AmpC phenotypes were more common in chicken-derived isolates than other retail meat products (P < 0.001). From the 98 isolates examined, 76 isolates (77.6%) were positive for either ESBL and AmpC ß-lactamases or both. Among the 76 isolates, blaCMY-2 (78.9%), blaCTXM (46.1%), blaTEM (21.1%), and blaSHV (1.3%) genes were detected. Among the blaCTXM-producing isolates, blaCTXM-1, blaCTXM-2, and blaCTXM-9 phylogenetic groups were detected. ß-lactamase genes were more commonly detected in chicken-derived isolates compared with other meat types (P < 0.01). This study demonstrates the occurrence of ESBL- and AmpC-resistance genes in retail meat products in the Maritime Provinces of Canada. We found that selective culture significantly improved the recovery of ESC-R E. coli isolates from retail meat samples.

Assessment of silver release and biocidal capacity from silver nanocomposite food packaging materials.

In this study, silver release from commercially available food-contact materials in food simulants (water, acetic acid, ethanol-water and olive oil) and meats (tuna, ham, and turkey) was assessed. Additionally, the antimicrobial capacity of migrated silver was examined in meats. Largest silver release was observed in simulants from food touch papers (25 ± 11 mg/kg) as compared to bag, cutting board and containers. Silver ion and silver nanoparticles were released from food touch paper in food simulants. Food touch paper released the highest amount of silver in tuna (0.5 ± 0.02 mg/kg) than ham (0.2 ± 0.08 mg/kg) or turkey (0.3 ± 0.08 mg/kg) in the same conditions. Tuna exhibited the lowest pH and higher number of bacterial populations on day 0 compared with other foods. Nonetheless, a significant antibacterial capacity of released silver was noticed predominantly in turkey for Gram-negative bacteria. Our study suggests silver released in food simulants indicate an overestimation of silver migration; thus, precaution should be maintained when extrapolating such findings to "real" food. Moreover, further investigations are needed to determine if the amount of silver released from food touch paper in certain foods (for example turkey in the present study) possess any risk to human health.

One Health approach to Clostridioides difficile in Japan.

Clostridioides difficile infections (CDIs) are predominantly a healthcare-associated illness in developed countries, with the majority of cases being elderly and hospitalize patients who used antibiotic therapy. Recently, the incidence of community-associated CDIs (CA-CDIs) in younger patients without a previous history of hospitalization or antibiotic treatment has been increasing globally. C. difficile is sometimes found in the intestine of many animals, such as pigs, calves, and dogs. Food products such as retail meat products and vegetables sometimes contain C. difficile. C. difficile has also been isolated from several environments such as compost manure, rivers, and soils. Yet, direct transmission of C. difficile from animals, food products, and environments to humans has not been proven, although these strains have similar molecular characteristics. Therefore, it has been suggested that there is a relationship between CA-CDIs and C. difficile from animals, food products, and the environment. To clarify the importance of the presence of C. difficile in several sources, characterization of C. difficile in these sources is required. However, the epidemiology of C. difficile in animals, food products, and the environment is not well studied in Japan. This review summarizes recent trends of CDIs and compares the molecular characteristics of C. difficile in Japanese animals, food products, and the environment. The prevalence trends of C. difficile in Japan are similar to those in the rest of the world. Therefore, I recommend using a One Health approach to CDI surveillance, monitoring, and control.

Assessment of safety aspect and probiotic potential of autochthonous Enterococcus faecium strains isolated from spontaneous fermented sausage.

OBJECTIVE: The objectives of this research project were isolation, identification, and evaluation of the safety aspect and probiotics properties of 21 Enterococcus faecium strains isolated from sausages originated from southeastern Serbia. RESULTS: Analyzed E. faecium isolates showed tolerance to simulated gastrointestinal conditions. All the examined isolates grew well on media with 0.1% and 0.2% of phenol. None of the tested isolates were histamine-producers, while the synthesis of tyramine was observed for E. faecium sk8-1 and sk8-17. Full resistance to antibiotics was not observed for any examined isolate of E. faecium (penicillin, amoxicillin, and ofloxacin showed the effect on all tested isolates). An inhibition zone against examined pathogens was exhibited by all strains, with the largest inhibition zone against Pseudomonas spp., Proteus spp. and E. coli (12-30 mm/MIC values ranged from 0.5 to 12 mg mL-1). CONCLUSION: The results indicated that E. faecium isolates from spontaneously fermented sausage showed a potential for further investigation and possible application as probiotics.

Assessment of oxidative stability and physicochemical, microbiological, and sensory properties of beef patties formulated with baobab seed (Adansonia digitata) extract.

The present study was conducted to evaluate the oxidative stability and the physicochemical, microbiological, and sensory properties of beef patties formulated with different concentrations (1%, 2%, and 3%) of baobab seed extract (BSE) during storage at 4 °C. The BSE contained a considerable number of phenolic compounds and exhibited antioxidant and antimicrobial activities (both on gram-positive and negative bacteria). The chemical composition of the patties was not altered by BSE treatment. However, the addition of 2% and 3% BSE improved the lipid stability and enhanced the antioxidant activity of beef patties during storage. Furthermore, the shelf-life of patties formulated with 2% and 3% of BSE increased from 7 days (control group) to 21 days. Moreover, the patties formulated with BSE received overall acceptability in the sensory evaluation. In conclusion, the inclusion of 2% or 3% BSE could be recommended as a natural antioxidant additive in beef patties.

Growth of Clostridium perfringens in cooked chicken during cooling: One-step dynamic inverse analysis, sensitivity analysis, and Markov Chain Monte Carlo simulation.

The objective of this study was to determine the kinetic parameters and apply Markov Chain Monte Carlo (MCMC) simulation to predict the growth of Clostridium perfringens from spores in cooked ground chicken meat during dynamic cooling. Inoculated samples were exposed to various cooling conditions to observe dynamic growth. A combination of 4 cooling profiles was used in one-step inverse analysis with the Baranyi model as the primary model and the cardinal parameters model as the secondary model. Six kinetic parameters of the Baranyi model and the cardinal parameters model, including Q0, Ymax, µopt, Tmin, Topt, and Tmax, were estimated. The estimated Tmin, Topt, and Tmax were 14.8, 42.9, and 50.5 °C, respectively, with a µopt of 5.25 h-1 and maximum cell density of 8.4 log CFU/g. Correlation analysis showed that both Q0 and Ymax are weakly correlated to other parameters, while the remaining parameters are mostly mildly to strongly correlated with each other. Although it may be difficult to estimate highly correlated parameters using a single temperature profile, one-step analysis with multiple different temperature profiles helped estimate them successfully. The estimated parameters were used as the prior information to construct the posterior distribution for Bayesian analysis. MCMC simulation was used to predict the bacterial growth using different dynamic temperature profiles for validation of the accuracy of the predictive models. The MCMC simulation results showed that the Bayesian analysis produced more accurate predictions of bacterial growth during cooling than the deterministic method. With Bayesian analysis, the root-mean-square-error (RMSE) of prediction was only 0.1 log CFU/g with all residual errors within ±0.25 log CFU/g. Therefore, Bayesian analysis is recommended for predicting the growth of C. perfringens in cooked meat during cooling.

Treatment of pastirma with pulsed UV light: Modeling of Staphylococcus aureus inactivation and assessment of quality changes.

The efficacy of pulsed UV (PUV) light treatment carried out in a wide range of fluence was investigated on pastirma slices by characterizing Staphylococcus aureus inactivation using mathematical models and by assessing the treatment effects on quality attributes. Pastirma slices inoculated on top surface with S. aureus were subjected to pulsed UV light for 5, 15, 25, 35, and 45 s at 5, 8, and 13 cm from the quartz window. Although the 5 cm/45 s treatment (72.3 J/cm2) yielded a maximum reduction of 2.99 log cfu/cm2 for S. aureus, this treatment changed the color, moisture, and thiobarbituric acid-reactive substances (TBARS) values of pastirma significantly (p < 0.05). The quality of pastirma tended to change above 20 J/cm2, below which the highest log reduction of S. aureus was ∼1.3 log cfu/cm2 obtained after the 8 cm/15 s treatment (18 J/cm2). Kamau's model provided better fit to inactivation data (root mean square error: 0.049-0.116, Af: 1.013-1.046, R2: 0.991-0.999) than Cerf's and Weibull models.

Assessment of Microbial Contamination in Products of Animal Origin: Stretched-curd Cheese, Yogurt and Fresh Sausage

Abstract Animal products are sources of microbiological contamination when the process has hygienic-sanitary control fails. Therefore, this work aims the evaluation of the pathogenic microorganisms presented in samples from the Brazil southern region of yogurt (N = 101), stretched curd cheese (N = 31), fresh sausage (N = 22) and processing water (N = 63). Analyses of coliforms at 45 °C, Staphylococcus aureus, Salmonella sp. and Escherichia coli were performed. Analysis indicated processing water is an important contamination source to be monitored, because the majority of samples presented results above the regulation limits. Thermal treatment and fermentation such as stretched curd cheese and yogurt appeared to be more stable against contamination during processing. In this study, for coliforms at 45 °C, only one cheese sample and 12% of total yogurt samples exceeded the Brazilian legislation limit. None of sausage samples presented any contamination. On the other hand, values found in both processing water and dairy products indicated failures in application and monitoring of good manufactured practices.

Domestic refrigerator temperatures in Spain: Assessment of its impact on the safety and shelf-life of cooked meat products.

Temperature is one of the main factors governing the growth of microorganisms. The aim of the present study was to provide temperature conditions representative of the food products stored in domestic refrigerators and to assess the impact of the temperature (fluctuation) on the shelf-life of refrigerated cooked meat products, from the safety and the spoilage point of view. The analysis of the time-temperature profiles recorded from 160 domestic refrigerators of households from small (28%) and large (72%) municipalities in Catalonia (Spain) showed that the 24 h-mean temperature could be described by a normal distribution (mean = 5.4 °C, standard deviation = 2.3 °C) with a mean value within the upper limit of the appropriate storage temperature of refrigerated products (i.e. ≤6 °C). The impact of door openings or day and night was not significant. Temperature distribution showed differences depending on the season, being higher in the cold season than in the warm one. Noteworthy, refrigerators of elderly (≥ 65 years old) households showed a higher percentage of time at temperatures >8 °C in comparison with those of the general population. Overall, the 75th percentile of the distribution of the 24 h-mean temperature values was 6.7 °C. This study can be used as a scientific evidence of the consumer storage stage when food business operators or laboratories conduct shelf-life studies. According to the simulation of the growth of Listeria monocytogenes and lactic acid bacteria in cooked meat products, risk scenarios were identified in which the critical level of the pathogen could be reached before lactic acid bacteria achieved the spoilage level. The fluctuation of the refrigerator temperature ranged from 0.5 up to 12.2 °C within the 24 h-profile. The assessment of the safety of cooked meat products stored at constant temperature or under different time-temperature profiles showed that both the mean and the fluctuation of the profile had an impact on the shelf-life, which was higher at low temperatures. The improvement of the household refrigerated storage would be an effective way to increase food safety of refrigerated ready-to-eat food.