Assessment of the safety and immunogenicity of Rhodococcus equi-secreted proteins combined with either a liquid nanoparticle (IMS 3012) or a polymeric (PET GEL A) water-based adjuvant in adult horses and foals--identification of promising new candidate antigens.

Rhodococcus equi is the most common infectious cause of mortality in foals between 1 and 6 months of age. Because of an increase in the number of antibiotic-resistant strains, the optimization of a prophylactic strategy is a key factor in the comprehensive management of R. equi pneumonia. The objectives of this study were to assess the safety and immunogenicity of R. equi-secreted proteins (ReSP) co-administered with either the nanoparticular adjuvant Montanide™ IMS 3012 VG, or a new polymeric adjuvant Montanide™ PET GEL A, and to further investigate the most immunogenic proteins for subsequent immunization/challenge experiments in the development of a vaccine against rhodoccocal pneumonia. The approach involved two phases. The first phase aimed to investigate the safety of vaccination in six adult horses. The second phase aimed to determine the safety and immunogenicity of vaccination in twelve 3-week-old foals. We set out to develop a method based on ultrasound measurements for safety assessment in adult horses in order to evaluate any in situ changes at the injection site, in the skin or the underlying muscle, with quantitative and qualitative data revealing that administration of ReSP combined with the Pet Gel A adjuvant led to an increase in local inflammation, associated with 4- to 7-fold higher levels of anti-R. equi IgGa, IgGb and IgGT, compared to administration of ReSP associated with IMS 3012 adjuvant, but without any impact on animal demeanor. Investigations were then performed in foals with serological and clinical follow-up until 6 months of age. Interestingly, we observed in foals a much lower incidence of adverse local tissue reactions at the injection site than in adult horses, with transient and moderate swelling for the group that received ReSP combined with Pet Gel A. Immunized foals with Pet Gel A adjuvant exhibited a similar response in both IgGa and IgGT levels, but a lower response in IgGb levels, compared to adult horses, with a subisotype profile that may however reflect a bias favorable to R. equi resistance. From the crude extract of secreted proteins, dot-blot screening enabled identification of cholesterol oxidase, mycolyl transferase 3, and PSP (probable secreted protein) as the most immunogenic candidates. Taken together, these results are encouraging in developing a vaccine for foals.

Development of a live, attenuated, potential vaccine strain of R. equi expressing vapA and the virR operon, and virulence assessment in the mouse.

Pneumonia caused by Rhodococcus equi remains a significant problem in foals. The objective of this study was to develop a safe and efficacious attenuated strain of R. equi for eventual use in oral immunization of foals. The approach involved expression of vapA in a live, virulence plasmid-negative, strain of R. equi (strain 103-). PCR-amplified fragments of the vapA gene, with and without the upstream genes virR, orf5, vapH, orf7 and orf8 (orf4-8), were cloned into a shuttle vector pNBV1. These plasmids, named pAW48A and pAWVapA respectively, were electroporated into strain 103-. The presence of the recombinant vectors in the attenuated strain (103-) and the integrity of the inserted genes were confirmed, and both constructs expressed VapA. The virulence of the two strains was compared to that of wild type R. equi 103+ and negative controls by their intravenous inoculation into mice, followed by examination of liver clearance 4 days later. Mice inoculated with R. equi 103-, 103-/pAWVapA and 103-/pNBV1 completely cleared infection, whereas strain 103-/pAW48A persisted in 47% of mice.

Assessment in mice of vapA-DNA vaccination against Rhodococcus equi infection.

There is a need to produce a vaccine against Rhodococcus equi pneumonia in foals in which immunity against infection is largely based on a type 1, cell-mediated, immune response. The VapA protein of the virulence plasmid of R. equi is highly immunogenic. To assess the potential of vapA-DNA to produce immunity, C57BL/6 and BALB/c mice were immunized with a DNA vaccine constructed from vapA incorporated into pcDNA3.1. The plasmid construct expressed VapA in a COS-7 cell line. Intramuscular immunization of mice resulted in enhanced clearance of R. equi from the liver of intravenously challenged mice compared to non-immunized controls. This effect was more marked when pORF-IL-12, a plasmid expressing murine IL12, was included with the vaccine. Antibody developed to VapA, with an IgG2a response being more marked in mice immunized with pcDNA-vapA than in non-immunized or in mice immunized with the mixed vapA and IL-12 plasmid constructs. In conclusion, this study has shown for the first time that DNA immunization with vapA enhances the immune responses of mice against R. equi infection, that the IgG subisotype response is consistent with a type 1-based immune response, and that this can be enhanced by injection of the IL-12 gene.

Assessment of the immunogenic potential of Rhodococcus equi virulence associated protein (VapA) in mice.

The development of immunity to Rhodococcus equi, particularly to a virulence-associated protein (VapA) based antigen preparation, was examined in CD1 and BALB/c mice after intraperitoneal vaccination. Immunization with VapA based antigen without adjuvant markedly enhanced organ clearance in CD1 mice but not in BALB/c mice. Delayed type hypersensitivity response and antibody titres in VapA based antigen immunized BALB/c mice were less than in CD1 mice. By contrast also to CD1 mice, sera from immunized BALB/c mice did not react as strongly with VapA in western blots. Use of adjuvants (aluminium hydroxide, iscoms) interfered markedly with the immunogenic properties of the VapA based antigen, in the case of aluminium hydroxide by apparently driving a Th2 type of response. Unexpectedly, iscom adjuvants also impaired immunity and, despite the highest DTH response, produced a low IgG2a response, suggesting that iscomization of the antigen produced a low interferon gamma and high interleukin 2 response. Passive immunization of BALB/c mice with serum from mice immunized with live virulent strain 103+ resulted in only temporary and slight enhancement of organ clearance, supporting the central importance of cellular immunity to R. equi. Immunization with live virulence plasmid- and VapA-positive R. equi strain 103 resulted in marked liver clearance, in marked DTH response and high antibody titres. By contrast, immunization with live virulence plasmid- and VapA-negative strain 103 resulted in slight but variable enhancement of clearance, but insignificant DTH and antibody. The virulence plasmid, and by implication VapA, was thus shown to be critical in determining a highly effective protection to live organisms.