Extracorporeal life support without systemic anticoagulation: a nitric oxide-based non-thrombogenic circuit for the artificial placenta in an ovine model.

BACKGROUND: Clinical translation of the extracorporeal artificial placenta (AP) is impeded by the high risk for intracranial hemorrhage in extremely premature newborns. The Nitric Oxide Surface Anticoagulation (NOSA) system is a novel non-thrombogenic extracorporeal circuit. This study aims to test the NOSA system in the AP without systemic anticoagulation. METHODS: Ten extremely premature lambs were delivered and connected to the AP. For the NOSA group, the circuit was coated with DBHD-N2O2/argatroban, 100 ppm nitric oxide was blended into the sweep gas, and no systemic anticoagulation was given. For the Heparin control group, a non-coated circuit was used and systemic anticoagulation was administered. RESULTS: Animals survived 6.8 ± 0.6 days with normal hemodynamics and gas exchange. Neither group had any hemorrhagic or thrombotic complications. ACT (194 ± 53 vs. 261 ± 86 s; p < 0.001) and aPTT (39 ± 7 vs. 69 ± 23 s; p < 0.001) were significantly lower in the NOSA group than the Heparin group. Platelet and leukocyte activation did not differ significantly from baseline in the NOSA group. Methemoglobin was 3.2 ± 1.1% in the NOSA group compared to 1.6 ± 0.6% in the Heparin group (p < 0.001). CONCLUSIONS: The AP with the NOSA system successfully supported extremely premature lambs for 7 days without significant bleeding or thrombosis. IMPACT: The Nitric Oxide Surface Anticoagulation (NOSA) system provides effective circuit-based anticoagulation in a fetal sheep model of the extracorporeal artificial placenta (AP) for 7 days. The NOSA system is the first non-thrombogenic circuit to consistently obviate the need for systemic anticoagulation in an extracorporeal circuit for up to 7 days. The NOSA system may allow the AP to be implemented clinically without systemic anticoagulation, thus greatly reducing the intracranial hemorrhage risk for extremely low gestational age newborns. The NOSA system could potentially be applied to any form of extracorporeal life support to reduce or avoid systemic anticoagulation.

The effect of air exposure on leucocyte and cytokine activation in an in-vitro model of cardiotomy suction.

INTRODUCTION: Cardiopulmonary bypass (CPB) is known to cause a systemic inflammatory and immune response. OBJECTIVE: An in-vitro model of cardiotomy suction was designed to quantify the effects of incrementally increased air-blood exposure on leucocyte marker CD11b and cytokine activation in two common anticoagulants, heparin and citrate. METHODS: Fresh human blood was exposed to increasing amounts of air flow for ten minutes. Leucocyte and cytokine levels were measured prior to and after ten minutes of air flow. Cytokine levels were also measured after air exposure when incubated for 24 hours at 37oC. RESULTS: Leucocyte activation, measured by CD11b, was elevated between baseline and air flow rates up to 50 mL/min. After 10 minutes of air exposure, no measured cytokine levels were elevated. After 24 hours of incubation, cytokine levels of TNFα, IL-10, IL-6, and IL-8 were elevated. However, only IL-8 was significantly elevated in citrated blood, but not in heparinized blood, when compared to baseline samples that were also incubated for 24 hours. CONCLUSION: This study investigates CD11b levels in response to an air stimulus in blood that was anticoagulated with citrate or heparin. Exposure to an air stimulus activates leucocytes. Activation of CD11b was less when using heparin as an anticoagulant compared to citrate. Cytokine activation occurs with air stimulation, but levels do not immediately rise, indicating that time is required to generate free cytokines.

Portable Nitric Oxide (NO) Generator Based on Electrochemical Reduction of Nitrite for Potential Applications in Inhaled NO Therapy and Cardiopulmonary Bypass Surgery.

A new portable gas phase nitric oxide (NO) generator is described for potential applications in inhaled NO (INO) therapy and during cardiopulmonary bypass (CPB) surgery. In this system, NO is produced at the surface of a large-area mesh working electrode by electrochemical reduction of nitrite ions in the presence of a soluble copper(II)-ligand electron transfer mediator complex. The NO generated is then transported into gas phase by either direct purging with nitrogen/air or via circulating the electrolyte/nitrite solution through a gas extraction silicone fiber-based membrane-dialyzer assembly. Gas phase NO concentrations can be tuned in the range of 5-1000 ppm (parts per million by volume for gaseous species), in proportion to a constant cathodic current applied between the working and counter electrodes. This new NO generation process has the advantages of rapid production times (5 min to steady-state), high Faraday NO production efficiency (ca. 93%), excellent stability, and very low cost when using air as the carrier gas for NO (in the membrane dialyzer configuration), enabling the development of potentially portable INO devices. In this initial work, the new system is examined for the effectiveness of gaseous NO to reduce the systemic inflammatory response (SIR) during CPB, where 500 ppm of NO added to the sweep gas of the oxygenator or to the cardiotomy suction air in a CPB system is shown to prevent activation of white blood cells (granulocytes and monocytes) during extracorporeal circulation with cardiotomy suction conducted with five pigs.

Improved in vivo performance of amperometric oxygen (PO2) sensing catheters via electrochemical nitric oxide generation/release.

A novel electrochemically controlled release method for nitric oxide (NO) (based on electrochemical reduction of nitrite ions) is combined with an amperometric oxygen sensor within a dual lumen catheter configuration for the continuous in vivo sensing of the partial pressure of oxygen (PO2) in blood. The on-demand electrochemical NO generation/release method is shown to be fully compatible with amperometric PO2 sensing. The performance of the sensors is evaluated in rabbit veins and pig arteries for 7 and 21 h, respectively. Overall, the NO releasing sensors measure both venous and arterial PO2 values more accurately with an average deviation of -2 ± 11% and good correlation (R(2) = 0.97) with in vitro blood measurements, whereas the corresponding control sensors without NO release show an average deviation of -31 ± 28% and poor correlation (R(2) = 0.43) at time points >4 h after implantation in veins and >6 h in arteries. The NO releasing sensors induce less thrombus formation on the catheter surface in both veins and arteries (p < 0.05). This electrochemical NO generation/release method could offer a new and attractive means to improve the biocompatibility and performance of implantable chemical sensors.

Blood biocompatibility of surface-bound multi-walled carbon nanotubes.

Blood clots when it contacts foreign surfaces following platelet activation. This can be catastrophic in clinical settings involving extracorporeal circulation such as during heart-lung bypass where blood is circulated in polyvinyl chloride tubing. Studies have shown, however, that surface-bound carbon nanotubes may prevent platelet activation, the initiator of thrombosis. We studied the blood biocompatibility of polyvinyl chloride, surface-modified with multi-walled carbon nanotubes in vitro and in vivo. Our results show that surface-bound multi-walled carbon nanotubes cause platelet activation in vitro and devastating thrombosis in an in vivo animal model of extracorporeal circulation. The mechanism of the pro-thrombotic effect likely involves direct multi-walled carbon nanotube-platelet interaction with Ca(2+)-dependant platelet activation. These experiments provide evidence, for the first time, that modification of surfaces with nanomaterials modulates blood biocompatibility in extracorporeal circulation.

Measurement of tear glucose levels with amperometric glucose biosensor/capillary tube configuration.

An amperometric needle-type electrochemical glucose sensor intended for tear glucose measurements is described and employed in conjunction with a 0.84 mm i.d. capillary tube to collect microliter volumes of tear fluid. The sensor is based on immobilizing glucose oxidase on a 0.25 mm o.d. platinum/iridium (Pt/Ir) wire and anodically detecting the liberated hydrogen peroxide from the enzymatic reaction. Inner layers of Nafion and an electropolymerized film of 1,3-diaminobenzene/resorcinol greatly enhance the selectivity for glucose over potential interferences in tear fluid, including ascorbic acid and uric acid. Further, the new sensor is optimized to achieve very low detection limits of 1.5 ± 0.4 µM of glucose (S/N = 3) that is required to monitor glucose levels in tear fluid with a glucose sensitivity of 0.032 ± 0.02 nA/µM (n = 6). Only 4-5 µL of tear fluid in the capillary tube is required when the needle sensor is inserted into the capillary. The glucose sensor was employed to measure tear glucose levels in anesthetized rabbits over an 8 h period while also measuring the blood glucose values. A strong correlation between tear and blood glucose levels was found, suggesting that measurement of tear glucose is a potential noninvasive substitute for blood glucose measurements, and the new sensor configuration could aid in conducting further research in this direction.

The Effects of the Combined Argatroban/Nitric Oxide-Releasing Polymer on Platelet Microparticle-Induced Thrombogenicity in Coated Extracorporeal Circuits.

Clotting, anticoagulation, platelet consumption, and poor platelet function are major factors in clinical extracorporeal circulation (ECC). We have shown that nitric oxide-releasing (NOReL) coatings prevent thrombosis in a rabbit model of ECC without systemic anticoagulation. Nitric oxide-releasing prevents platelet adhesion and activation, resulting in preserved platelet count and function. Previous work has shown that activated platelets form platelet-derived microparticles (PMPs). These experiments were designed to determine if PMPs can identify platelet function during ECC. The objective of this study is to investigate the effects of NOReL on platelet activation and PMP formation during ECC. Uncoated ECCs, including with and without systemic heparin, and NOReL-coated ECCs, including DBHD/N2O2 and argatroban (AG)/DBHD/N2O2-coated ECCs without systemic heparin, were tested in a 4-hour rabbit thrombogenicity model. Before and after ECC exposure, platelets were stimulated with collagen, and PMPs were measured using flow cytometry. The uncoated ECCs clotted within the first hour, while the NOReL-coated ECCs circulated for 4 hours. During pre-ECC blood exposure, platelets stimulated with collagen produced PMPs. With post-ECC exposure, platelets from uncoated circuits generated less PMPs than baseline (mean ± SDs: 23246 ± 3611 baseline vs. 1300 ± 523 uncoated post circuit, p = 0.018) when stimulated with collagen. However, platelets from the AG/DBHD/N2O2-coated ECCs generated a greater number of PMPs as baseline values (23246 ± 3611 baseline vs. 37040 ± 3263 AG/DBHD/N2O2 post 4 hours circuit, p = 0.023). Blood exposure during ECC results in platelet activation and clotting in uncoated ECCs. The remaining circulating platelets have lost function, as demonstrated by the low PMP formation in response to collagen. AG/DBHD/N2O2-coated ECCs prevented significant platelet activation and clotting, while DBHD/N2O2 trended towards prevention of platelet activation. In addition, function of the circulating platelets was preserved, as demonstrated by PMP formation in response to collagen. These results indicate that PMPs may be an important measure of platelet activation during ECC. Platelet-derived microparticles may provide a simplified way to measure platelet function during clinical ECC.

Polydiacetylene Liposome Microarray toward Facile Measurement of Platelet Activation in Whole Blood.

The necessity of a simple measurement of platelet activation has been increasing in clinical medicine to regulate the proper dose of the antiplatelet drugs for patients having clinical outcomes in acute situations such as angina pectoris, stroke, or peripheral vascular disease or procedures involving angioplasty or coronary thrombolysis. We developed a self-signaling polydiacetylene (PDA) liposome microarray to detect activated platelets from whole blood samples in a single step. A specific antibody, 9F9 antibody, to platelet-bound fibrinogen was selected and conjugated to the PDA liposome microarray to quantify the fibrinogen-bound platelets. The developed PDA liposome-9F9 microarray generated an intense fluorescence signal when activated platelets in whole blood were introduced and also successfully distinguished the reduced platelet activation in the presence of Tirofiban, a model antiplatelet drug. The results of this single-step benchtop assay incorporates simple, sensitive, and rapid attributes that can detect the extent of platelet activation prior to needed clinical procedures.

Comparison of Diazeniumdiolated Dialkylhexanediamines as Nitric Oxide Release Agents on Nonthrombogenicity in an Extracorporeal Circulation Model.

When blood from a patient is circulated through extracorporeal circuits (ECCs), such as in cardiopulmonary bypass or extracorporeal life support, platelets in the blood are activated and form a thrombus. This is prevented clinically with a range of different systemic anticoagulation agents (e.g., heparin); however, this increases a patient's risk of hemorrhage. Previous work with nitric oxide (NO) releasing materials using the combined diazeniumdiolated diamine, N-N-di-N'-butyl-1,6-hexanediamine (DBHD), and a polymer-linked thrombin inhibitor, argatroban (AG), showed significant nonthrombogenicity in ECCs using a 4 h rabbit model. Herein, we evaluated if diazeniumdiolated N-N-di-N'-propyl-1,6-hexanediamine (DPHDN2O2), which has a slightly lower degree of lipophilicity compared to DBHDN2O2, would provide similar nonthrombogenicity as the AG/DBHDN2O2-polymer-coated circuits. While DPHDN2O2 releases NO at a higher flux rate than DBHDN2O2 when coated (within CarboSil polymer) on the inner wall of polyvinyl chloride tubing, neither coated circuit significantly affected animal hemodynamics. Both diazeniumdiolated diamines, in combination with immobilized AG or alone, significantly reduced thrombus formation similarly in the 4 h rabbit model (vs uncoated control): AG/DBHDN2O2: 0.12 ± 0.03 cm2; DBHDN2O2: 2.57 ± 0.82 cm2; AG/DPHDN2O2: 0.68 ± 0.22 cm2; DPHDN2O2: 1.87 + 1.26 cm2; uncoated control: 6.95 ± 0.82 cm2. AG/DPHDN2O2 was no different than AG/DBHDN2O in preserving platelet count and function. In addition, AG did not leach into the systemic circulation as the total clotting times were insignificantly different from the baseline values (AG/DPHDN2O2: 12.7 + 0.5 s (n = 3); AG/DBHDN2O2: 12.3 + 0.7 s (n = 3); baseline: 13.9 + 0.3 s (n = 13)). Based on these results, both DPHDN2O2 and DPHDN2O2 are good candidates as NO donor molecules for creating nonthrombogenic polymer coatings for ECCs.

A CCR2/CCR5 antagonist attenuates an increase in angiotensin II-induced CD11b+ monocytes from atherogenic ApoE-/- mice.

OBJECTIVE: Monocyte infiltration into the vessel wall, a process primarily mediated by the interaction between monocyte chemoattractant protein-1 (MCP-1) and its receptor, CCR2, is a key step in atherogenesis. Angiotensin II (Ang II) enhances this monocyte infiltration by increasing the endothelial binding integrin, CD11b. However, the modulation of the Ang II-induced CD11b expression in monocytes in not clear. The aim of this study was to determine if MCP-1/MCP-2 receptor (CCR2) interaction regulates monocyte CD11b expression after 7 days of Ang II infusion. METHODS AND RESULTS: In ApoE(-/-) mice continuous subcutaneous infusion of Ang II (0.75 mg/kg/day) for 7 days significantly increased CD11b expression in circulating monocytes as measured by flow cytometry. CD11b expression in ApoE(-/-) was increased from 135 +/- 9 to 176 +/- 12 mean fluorescent intensity (MFI), control and Ang II-treated, respectively while in C57B/J wildtype mice CD11b increased from 128 +/- 13 to 174 +/- 8 MFI, control and Ang II-treated, respectively. Interestingly, co-infusion of either MCP-1 neutralizing antibody (25 microg/kg/day) or a CCR2 antagonist (500 microg/kg/day) with Ang II for 7 days effectively inhibited monocyte CD11b expression and this inhibition was accompanied by a down-regulated vascular infiltration of Mac-2 positive monocyte-derived macrophages. CONCLUSION: Our data in the atherogenic ApoE(-/-) mouse demonstrates that the Ang II induced increase in both monocytic CD11b integrin expression and monocyte vascular infiltration occurs early in atherogenesis. These Ang II-induced monocytic changes are in part regulated through the MCP-1/CCR2 interaction.

The T- and L-type calcium channel blocker (CCB) mibefradil attenuates leg edema induced by the L-type CCB nifedipine in the spontaneously hypertensive rat: a novel differentiating assay.

Among the L-type calcium channel blockers (CCBs), particularly dihydropyridines like nifedipine [1,4-dihydro-2,6-dimethyl-4-(2-nitrophenyl)-3,5-pyridinedicarboxylic acid dimethyl ester], a common adverse effect is vasodilatory edema. Newer CCBs, such as the T- and L-type CCB, mibefradil [(1S,2S)-2-[2[[3-(2-benzimidazolylpropyl]methylamino]ethyl]-6-fluoro-1,2,3,4-tetrahydro-1-isopropyl-2-naphthyl methoxyacetate dihydrochloride hydrate], demonstrate antihypertensive efficacy similar to that of their predecessors but seem to have a reduced propensity to cause edema. Using a magnetic resonance imaging (MRI) T(2) mapping technique, we investigated the ability of mibefradil to reduce extracellular water accumulation caused by the L-type CCB, nifedipine, in the hindleg skeletal muscle of the spontaneously hypertensive rat. Mibefradil (10 mg/kg i.v.) and nifedipine (1 mg/kg i.v.) lowered mean arterial blood pressure by 97 +/- 5 and 77 +/- 4 mm Hg, respectively. MRI edema index (expressed as percentage increase of integral T(2) over predrug control) was significantly higher with nifedipine (2606 +/- 86%; p < 0.05) than with mibefradil (981 +/- 171%) measured 30 to 60 min after the start of drug infusion. The hindleg edema caused by nifedipine was dose dependently decreased by coadministration of mibefradil (0, 0.3, or 3 mg/kg). The hindleg edema formation was not due to albumin leakage into the interstitial space based on immunostaining. However, a 4.2-fold increase in the arterial L-/T-type CC mRNA expression ratio was observed compared with the venous L/T ratio as shown by quantitative reverse transcription polymerase chain reaction. These results demonstrate the novel utility of MRI to measure extravascular water after acute exposure to CCBs and indicate that T-type CCB activity may reduce L-type CCB-induced vasodilatory edema in the skeletal muscle vasculature, possibly by a differential effect on arteriole and venule dilatation.

A nonpeptide, piperidine renin inhibitor provides renal and cardiac protection in double-transgenic mice expressing human renin and angiotensinogen genes.

INTRODUCTION: Controlling hypertension by angiotensin converting enzyme inhibitors (ACEI) or angiotensin receptor blockers (ARB), mechanisms that inhibit later pathway steps in the renin-angiotensin system (RAS), have clinically afforded protection against cardiac and renal disease. MATERIALS AND METHODS: In order to determine if blocking the RAS rate-limiting step of angiotensin II generation via renin inhibition could afford similar end organ protection in a human-relevant preclinical model, this study investigated the cardiac and renal effects of a nonpeptide, piperidine renin inhibitor (RI; 100 mg/kg/day PO) in double transgenic mice (dTGM) which express both human renin and angiotensinogen genes. RI was compared to the ARB, candesartan (3 mg/kg/day PO), and to the ACEI, enalapril (60 mg/kg/day PO) in a 4-week dosing paradigm. These doses of RI, ACEI and ARB were previously found to normalize mean blood pressure (MBP) to 110 + 3, 109 + 7 and 107 + 6 mmHg, respectively, after 1 day of treatment. RESULTS AND DISCUSSION: In the dTGM, PRA, plasma aldosterone, GFR, microalbuminuria and left ventricular free wall thickness (LVH) were higher than in the wild type C57BL/6 mice. Microalbuminuria and LVH were significantly reduced by 93% and 9% for the RI, 83% and 13% for enalapril and 73% and 6% for candesartan, respectively. PRA and aldosterone were reduced by the RI 56% and 23%, respectively. These results suggest that the RI provides protection against cardiac and renal disease, similar to ARB and ACEI.

Attenuation of Thrombin-Mediated Fibrin Formation via Changes in Fibrinogen Conformation Induced by Reaction with S-nitroso-N-acetylpenicillamine, but not S-nitrosoglutathione.

Previous work in a 4 h rabbit thrombogenicity model has shown that a nitric oxide- (NO) generating polymer extracorporeal circuits (ECC) with infusion of S-nitroso-N-acetyl-penicillamine (SNAP) preserved platelets eventhough platelets were activated as shown by an increase in the glycoprotein, p-selectin. The platelet preservation mechanism was shown to be due to a changing fibrinogen structure leading to attenuation of platelet aggregation. Understanding the effects that SNAP, another RSNO, S-nitroso-glutathione (GSNO) as well as the non-RSNO, sodium nitroprusside (SNP), may have on human fibrinogen polymerization, this in vitro study evaluated the released NO effects on the thrombin-mediated fibrin formation and fibrinogen structure. Thrombin-induced fibrin formation at 300 µM SNAP (50 + 11% of baseline) was significantly reduced compared to SNAP's parent, N-acetyl-penicillamine (NAP) (95 + 13%) after 1 h of RSNO exposure. GSNO, its parent, glutathione (GSH) and 1000 ppm NO gas did not attenuate the thrombin-mediated fibrin formation. SNAP, NAP and SNP exposure for 1 h, however, did not decrease thrombin activity by directly inhibiting thrombin itself. Changes in fibrinogen conformation as measured by intrinsic tryptophan fluorescence significantly decreased in the 300 µM SNAP (38057 + 1196 mean fluorescence intensity (MFI) and SNP (368617 + 541 MFI) groups versus the NAP control (47937 + 1196 MFI). However, infused 1000 ppm NO gas had no direct effect on the ITF after 1 h incubation at 37°C. High performance liquid chromatography (HPLC) showed that fibrinogen degradation by 0.03 U/ml thrombin was concentration-dependently reduced after 1 h with SNAP but not with NAP or SNP. Western blotting showed RSNOs, SNAP, NAP and the non-RSNO, SNP-incubated fibrinogen solutions showed that the percent level of the Aγ dimer to total Aγ dimer + γ monomer was significantly reduced in the case of the SNAP group when compared to SNP group. These results suggest that NO donors such as SNAP and SNP induce fibrinogen conformational changes by potentially nitrosating fibrinogen tyrosine residues. These NO-mediated fibrinogen changes induced via NO donors may provide another mechanism of NO for improving thromboresistance in ECC.

Reduction of Thrombosis and Bacterial Infection via Controlled Nitric Oxide (NO) Release from S-Nitroso-N-acetylpenicillamine (SNAP) Impregnated CarboSil Intravascular Catheters.

Nitric oxide (NO) has many important physiological functions, including its ability to inhibit platelet activation and serve as potent antimicrobial agent. The multiple roles of NO in vivo have led to great interest in the development of biomaterials that can deliver NO for specific biomedical applications. Herein, we report a simple solvent impregnation technique to incorporate a nontoxic NO donor, S-nitroso-N-acetylpenicillamine (SNAP), into a more biocompatible biomedical grade polymer, CarboSil 20 80A. The resulting polymer-crystal composite material yields a very stable, long-term NO release biomaterial. The SNAP impregnation process is carefully characterized and optimized, and it is shown that SNAP crystal formation occurs in the bulk of the polymer after solvent evaporation. LC-MS results demonstrate that more than 70% of NO release from this new composite material originates from the SNAP embedded CarboSil phase, and not from the SNAP species leaching out into the soaking solution. Catheters prepared with CarboSil and then impregnated with 15 wt % SNAP provide a controlled NO release over a 14 d period at physiologically relevant fluxes and are shown to significantly reduce long-term (14 day) bacterial biofilm formation against Staphylococcus epidermidis and Pseudonomas aeruginosa in a CDC bioreactor model. After 7 h of catheter implantation in the jugular veins of rabbit, the SNAP CarboSil catheters exhibit a 96% reduction in thrombus area (0.03 ± 0.01 cm2/catheter) compared to the controls (0.84 ± 0.19 cm2/catheter) (n = 3). These results suggest that SNAP impregnated CarboSil can become an attractive new biomaterial for use in preparing intravascular catheters and other implanted medical devices.

Improved hemocompatibility of silicone rubber extracorporeal tubing via solvent swelling-impregnation of S-nitroso-N-acetylpenicillamine (SNAP) and evaluation in rabbit thrombogenicity model.

UNLABELLED: Blood-contacting devices, including extracorporeal circulation (ECC) circuits, can suffer from complications due to platelet activation and thrombus formation. Development of nitric oxide (NO) releasing polymers is one method to improve hemocompatibility, taking advantage of the ability of low levels of NO to prevent platelet activation/adhesion. In this study a novel solvent swelling method is used to load the walls of silicone rubber tubing with the NO donor S-nitroso-N-acetylpenicillamine (SNAP). This SNAP-silicone rubber tubing exhibits an NO flux of ca. 1×10(-10)molcm(-2)min(-1), which mimics the range of NO release from the normal endothelium, which is stable for at least 4h. Images of the tubing before and after swelling, obtained via scanning electron microscopy, demonstrate that this swelling method has little effect on the surface properties of the tubing. The SNAP-loaded silicone rubber and silicone rubber control tubing are used to fabricate ECC circuits that are evaluated in a rabbit model of thrombogenicity. After 4h of blood flow, the SNAP-loaded silicone rubber circuits were able to preserve the blood platelet count at 64% of baseline (vs. 12% for silicone rubber control). A 67% reduction in the degree of thrombus formation within the thrombogenicity chamber was also observed. This study demonstrates the ability to improve the hemocompatibility of existing/commercial silicone rubber tubing via a simple solvent swelling-impregnation technique, which may also be applicable to other silicone-based blood-contacting devices. STATEMENT OF SIGNIFICANCE: Localized nitric oxide (NO) release can be achieved from biomedical grade polymers doped with S-nitroso-N-acetylpenicillamine (SNAP). Despite the promising in vitro and in vivo biocompatibility results reported for these NO releasing polymers, many of these materials may face challenges in being translated to clinical applications, especially in the areas of polymer processing and manufacturing. In this study, we report a solvent swelling-impregnation technique to incorporate SNAP into extracorporeal circuit (ECC) tubing. These NO-releasing ECCs were able to attenuate the activation of platelets and maintain their functionality, while significantly reducing the extent of thrombus formation during 4h blood flow in the rabbit model of thrombogenicity.

Attenuation of thrombosis and bacterial infection using dual function nitric oxide releasing central venous catheters in a 9day rabbit model.

UNLABELLED: Two major problems with implanted catheters are clotting and infection. Nitric oxide (NO) is an endogenous vasodilator as well as natural inhibitor of platelet adhesion/activation and an antimicrobial agent, and NO-releasing polymers are expected to have similar properties. Here, NO-releasing central venous catheters (CVCs) are fabricated using Elast-eon™ E2As polymer with both diazeniumdiolated dibutylhexanediamine (DBHD/NONO) and poly(lactic-co-glycolic acid) (PLGA) additives, where the NO release can be modulated and optimized via the hydrolysis rate of the PLGA. It is observed that using a 10% w/w additive of a PLGA with ester end group provides the most controlled NO release from the CVCs over a 14d period. The optimized DBHD/NONO-based catheters are non-hemolytic (hemolytic index of 0%) and noncytotoxic (grade 0). After 9d of catheter implantation in the jugular veins of rabbits, the NO-releasing CVCs have a significantly reduced thrombus area (7 times smaller) and a 95% reduction in bacterial adhesion. These results show the promise of DBHD/NONO-based NO releasing materials as a solution to achieve extended NO release for longer term prevention of clotting and infection associated with intravascular catheters. STATEMENT OF SIGNIFICANCE: Clotting and infection are significant complications associated with central venous catheters (CVCs). While nitric oxide (NO) releasing materials have been shown to reduce platelet activation and bacterial infection in vitro and in short-term animal models, longer-term success of NO-releasing materials to further study their clinical potential has not been extensively evaluated to date. In this study, we evaluate diazeniumdiolate based NO-releasing CVCs over a 9d period in a rabbit model. The explanted NO-releasing CVCs were found to have significantly reduced thrombus area and bacterial adhesion. These NO-releasing coatings can improve the hemocompatibility and bactericidal activity of intravascular catheters, as well as other medical devices (e.g., urinary catheters, vascular grafts).

Improved Hemocompatibility of Multilumen Catheters via Nitric Oxide (NO) Release from S-Nitroso-N-acetylpenicillamine (SNAP) Composite Filled Lumen.

Blood-contacting devices, such as intravascular catheters, suffer from challenges related to thrombus formation and infection. Nitric oxide (NO) is an endogenous antiplatelet and antimicrobial agent. Exogenous release of NO from various polymer matrices has been shown to reduce thrombosis and infection of/on implantable medical devices. However, the clinical applications of such materials have been hindered due to factors such as NO donor leaching and thermal instability. In this study, a novel approach is demonstrated in which one lumen of commercial dual lumen catheters is dedicated to the NO release chemistry, allowing the other lumen to be available for clinical vascular access. A composite consisting of poly(ethylene glycol) (PEG) and S-nitroso-N-acetylpenicillamine (SNAP) is used to fill the NO-releasing lumen of commercial 7 French silicone catheters. Physiological levels of NO are released from the SNAP-PEG catheters for up to 14 d, as measured by chemiluminescence NO analyzer (in PBS buffer at 37 °C). PEG facilitates the NO release from SNAP within the lumen by increasing the water absorption and slowly dissolving the solid SNAP-PEG composite. In a CDC biofilm bioreactor, the SNAP-PEG catheters are found to reduce >97% bacterial adhesion as compared to the PEG controls for single bacterial species including E. coli and S. aureus. SNAP-PEG and PEG control catheters were implanted in rabbit veins for 7 h (single lumen) and 11 d (dual lumen) to evaluate their hemocompatibility properties. Significant reductions in thrombus formation on the SNAP-PEG vs PEG controls were observed, with ca. 85% reduction for 7 h single lumen catheters and ca. 55% reduction for 11 d dual lumen catheters.

Extracellular matrix metalloproteinase inducer (EMMPRIN) is induced upon monocyte differentiation and is expressed in human atheroma.

OBJECTIVE: Because extracellular matrix metalloproteinase inducer (EMMPRIN), a tumor cell-derived protein, induces matrix metalloproteinases (MMPs) in fibroblasts and because MMPs are important in atheroma formation, we investigated if EMMPRIN was expressed in granulocyte/macrophage-colony stimulating factor (GM-CSF)-differentiated human peripheral blood monocytes (HPBM) and macrophage foam cells. In addition, EMMPRIN was studied for its expression in human atheroma. METHODS AND RESULTS: After 10 days of GM-CSF-induced monocyte differentiation, EMMPRIN mRNA increased 5- to 8-fold relative to undifferentiated monocytes. GM-CSF treatment of HPBM revealed that both EMMPRIN mRNA and protein were upregulated by day 2 over undifferentiated monocytes. GM-CSF-differentiated HPBM showed characteristic macrophage phenotype by showing increases in pancake-like morphology and increases in biochemical markers such as apolipoprotein E, MMP-9, and cholesterol ester (CE). While acetylated LDL treatment of the 10-day GM-CSF-differentiated HPBM increased CE mass 13- to 321-fold, EMMPRIN expression was unchanged relative to nonlipid-loaded macrophages. In human coronary atherosclerotic samples, EMMPRIN was observed in CD68(+) macrophage-rich areas as well as areas of MMP-9 expressions. CONCLUSIONS: Based on these data, we conclude that monocyte differentiation induces EMMPRIN expression, CE enrichment of foam cells has no further effect on EMMPRIN expression, and EMMPRIN is present in human atheroma. Therefore, EMMPRIN may play a role in atherosclerosis development.

Origin of Long-Term Storage Stability and Nitric Oxide Release Behavior of CarboSil Polymer Doped with S-Nitroso-N-acetyl-D-penicillamine.

The prolonged and localized delivery of nitric oxide (NO), a potent antithrombotic and antimicrobial agent, has many potential biomedical applications. In this work, the origin of the long-term storage stability and sustained NO release mechanism of S-nitroso-N-acetyl-D-penicillamine (SNAP)-doped CarboSil 20 80A polymer, a biomedical thermoplastic silicone-polycarbonate-urethane, is explored. Long-term (22 days) localized NO release is achieved by utilizing a cross-linked silicone rubber as topcoats, which can greatly reduce the amount of SNAP, NAP, and NAP disulfide leaching from the SNAP-doped CarboSil films, as measured by LC-MS. Raman spectroscopy and powder X-ray diffraction characterization of SNAP-doped CarboSil films demonstrate that a polymer-crystal composite is formed during the solvent evaporation process when SNAP exceeds its solubility in CarboSil (ca. 3.4-4.0 wt %). Further, when exceeding this solubility threshold, SNAP exists in an orthorhombic crystal form within the bulk of the polymer. The proposed mechanism of sustained NO release in SNAP-doped CarboSil is that the solubilized SNAP in the polymer matrix decomposes and releases NO, primarily in the water-rich regions near the polymer/solution interface, and the dissolved SNAP in the bulk polymeric phase becomes unsaturated, resulting in the dissolution of crystalline SNAP within the bulk of the polymer. This is a very slow process that ultimately leads to NO release at the physiological flux levels for >3 weeks. The increased stability of SNAP within CarboSil is attributed to the intermolecular hydrogen bonds between the SNAP molecules that crystallize. This crystallization also plays a key role in maintaining RSNO stability within the CarboSil polymer for >8 months at 37 °C (88.5% remains). Further, intravascular catheters fabricated with this new material are demonstrated to significantly decrease the formation of Staphylococcus aureus biofilm (a leading cause of nosocomial bloodstream infections) (in vitro) over a 7 day period, with 5 log units reduction of viable cell count on catheter surfaces. It is also shown that the NO release catheters can greatly reduce thrombus formation on the catheter surfaces during 7 h implantation in rabbit veins, when compared to the control catheters fabricated without SNAP. These results suggest that the SNAP-doped CarboSil system is a very attractive new composite material for creating long-term NO release medical devices with increased stability and biocompatibility.

Thromboresistant/anti-biofilm catheters via electrochemically modulated nitric oxide release.

Inexpensive nitric oxide (NO) release strategies to prevent thrombosis and bacterial infections are desirable for implantable medical devices. Herein, we demonstrate the utility of electrochemically modulated NO release from a catheter model using an inner copper wire working electrode and an inorganic nitrite salt solution reservoir. These catheters generate NO surface fluxes of >1.0 × 10(-10)mol min(-1) cm(-2) for more than 60 h. Catheters with an NO flux of 1.1 × 10(-10)mol min(-1) cm(-2) are shown to significantly reduce surface thrombus formation when implanted in rabbit veins for 7h. Further, the ability of these catheters to exhibit anti-biofilm properties against bacterial species commonly causing bloodstream and urinary catheter infections is examined. Catheters releasing NO continuously during the 2d growth of Staphylococcus aureus exhibit a 6 log-unit reduction in viable surface bacteria. We also demonstrate that catheters generating NO for only 3h at a flux of 1.0 × 10(-10)mol min(-1) cm(-2) lower the live bacterial counts of both 2d and 4d pre-formed Escherichia coli biofilms by >99.9%. Overall, the new electrochemical NO-release devices could provide a cost-effective strategy to greatly enhance the biocompatibility and antimicrobial properties of intravascular and urinary catheters, as well as other implantable medical devices.