Susceptibility of pESI positive Salmonella to treatment with biocide chemicals approved for use in poultry meat processing as compared to Salmonella without the pESI plasmid.

Salmonella is a common cause of human foodborne illness, which is frequently associated with consumption of contaminated or undercooked poultry meat. Serotype Infantis is among the most common serotypes isolated from poultry meat products globally. Isolates of serotype Infantis carrying the pESI plasmid, the most dominant strain of Infantis, have been shown to exhibit oxidizer tolerance. Therefore, 16 strains of Salmonella with and without pESI carriage were investigated for susceptibility to biocide chemical processing aids approved for use in US poultry meat processing: peracetic acid (PAA), cetylpyridinium chloride (CPC), calcium hypochlorite, and sodium hypochlorite. Strains were exposed for 15 s to simulate spray application and 90 min to simulate application in an immersion chiller. All strains tested were susceptible to all concentrations of PAA, CPC, and sodium hypochlorite when applied for 90 min. When CPC, calcium hypochlorite, and sodium hypochlorite were applied for 15 s to simulate spray time, strains responded similarly to each other. However, strains responded variably to exposure to PAA. The variation was not statistically significant and appears unrelated to pESI carriage. Results highlight the necessity of testing biocide susceptibility in the presence of organic material and in relevant in situ applications.

Selective pre-enrichment method to lessen time needed to recover Salmonella from commercial poultry processing samples.

Conventional Salmonella detection is time consuming, often employing a 24-h pre-enrichment step in buffered peptone water (BPW), followed by a 24-h selective enrichment in either Rappaport Vassiliadis (RV) or tetrathionate (TT) broths before streaking onto selective indicator agar. To reduce this time, we sought to optimize pre-enrichment for Salmonella recovery by evaluating the addition of selective chemicals to BPW. Duplicate samples each representative of 500 carcasses were collected by catching processing water drip under moving carcass shackle lines immediately after feather removal in each of nine commercial processing plants. Carcass drip samples were cultured under selective pre-enrichment conditions in parallel with BPW pre-enrichment followed by RV and TT selective enrichment. Addition of bile salts (1 g/L) and novobiocin (0.015 g/L) resulted in Salmonella recovery from 89% samples when plated directly after pre-enrichment compared to 67% recovery in non-selective BPW alone. Salmonella serovar identities were determined using CRISPR-SeroSeq. Overall, serovars matched between selective pre-enrichment and traditional enrichment methods. These data suggest that increasing the selectivity of Salmonella pre-enrichment step may lessen the need for a separate selective enrichment step thereby reducing time required for Salmonella isolation by 24 h.

An Open-Source Program (Haplo-ST) for Whole-Genome Sequence Typing Shows Extensive Diversity among Listeria monocytogenes Isolates in Outdoor Environments and Poultry Processing Plants.

A reliable and standardized classification of Listeria monocytogenes is important for accurate strain identification during outbreak investigations. Current whole-genome sequencing (WGS)-based approaches for strain characterization are either difficult to standardize, rendering them less suitable for data exchange, or are not freely available. Thus, we developed a portable and open-source tool, Haplo-ST, to improve standardization and provide maximum discriminatory potential to WGS data tied to a multilocus sequence typing (MLST) framework. Haplo-ST performs whole-genome MLST (wgMLST) for L. monocytogenes while allowing for data exchangeability worldwide. This tool takes in (i) raw WGS reads as input, (ii) cleans the raw data according to user-specified parameters, (iii) assembles genes across loci by mapping to genes from reference strains, and (iv) assigns allelic profiles to assembled genes and provides a wgMLST subtyping for each isolate. Data exchangeability relies on the tool assigning allelic profiles based on a centralized nomenclature defined by the widely used BIGSdb-Lm database. Tests of Haplo-ST's performance with simulated reads from L. monocytogenes reference strains demonstrated high sensitivity (97.5%), and coverage depths of ≥20× were found to be sufficient for wgMLST profiling. We then used Haplo-ST to characterize and differentiate between two groups of L. monocytogenes isolates derived from the natural environment and poultry processing plants. Phylogenetic reconstruction identified lineages within each group, and no lineage specificity was observed with isolate phenotypes (transient versus persistent) or origins. Genetic differentiation analyses between isolate groups identified 21 significantly differentiated loci, potentially enriched for adaptation and persistence of L. monocytogenes within poultry processing plants.IMPORTANCE We have developed an open-source tool (https://github.com/swarnalilouha/Haplo-ST) that provides allele-based subtyping of L. monocytogenes isolates at the whole-genome level. Along with allelic profiles, this tool also generates allele sequences and identifies paralogs, which is useful for phylogenetic tree reconstruction and deciphering relationships between closely related isolates. More broadly, Haplo-ST is flexible and can be adapted to characterize the genome of any haploid organism simply by installing an organism-specific gene database. Haplo-ST also allows for scalable subtyping of isolates; fewer reference genes can be used for low-resolution typing, whereas higher resolution can be achieved by increasing the number of genes used in the analysis. Our tool enabled clustering of L. monocytogenes isolates into lineages and detection of potential loci for adaptation and persistence in food processing environments. Findings from these analyses highlight the effectiveness of Haplo-ST in subtyping and evaluating relationships among isolates in studies of bacterial population genetics.

Dry and heat stress affects H2S production of Salmonella on selective plating media.

The pH of Salmonella pre-enrichment media can become acidic (pH 4.0-5.0) when feeds/ingredients are incubated for 24 h. Salmonella in feed that have been stressed by heat and desiccation exhibit different pH tolerances than non-stressed cultures. Acidic conditions can result in cell injury/death and affect biochemical pathways. In this study, eight serotypes of Salmonella were grown in sterile meat and bone meal that was subjected to desiccation and heat stress. Cultures of non-stressed and stressed isolates were subsequently exposed to acidic pH from 4.0 to 7.0 in 0.5 pH increments (3 replicates/pH increment) in citrate buffer. At 6 and 24 h, serial dilutions were plated in duplicate on XLT-4 (xylose lysine tergitol-4) agar. Four serotypes showed an impaired ability to decarboxylate lysine on XLT-4. This inability to decarboxylate lysine was dependent on isolate, stress status, and incubation time. When the isolates' ability to decarboxylate lysine was examined using biochemical tests, cultures were found to be able to decarboxylate lysine with the exception of S. Infantis. This suggests that XLT-4 contains a biochemical stressor(s) which affects the rate of decarboxylation by these Salmonella. These results suggest that acidic conditions may influence the detection and confirmation of Salmonella in feed.

Impact of desiccation and heat exposure stress on Salmonella tolerance to acidic conditions.

In a recent study, the pH of commonly used Salmonella pre-enrichment media became acidic (pH 4.0 to 5.0) when feed or feed ingredients were incubated for 24 h. Acidic conditions have been reported to injure or kill Salmonella. In this study, cultures of four known feed isolates (S. montevideo, S. senftenberg, S. tennessee, and S. schwarzengrund) and four important processing plant isolates (S. typhimurium, S. enteritidis, S. infantis, and S. heidelberg) were grown on meat and bone meal and later subjected to desiccation and heat exposure to stress the microorganism. The impact of stress on the isolates ability to survive in acidic conditions ranging from pH 4.0 to 7.0 was compared to the non-stressed isolate. Cell injury was determined on xylose lysine tergitol 4 (XLT4) and cell death determined on nutrient agar (NA). When measured by cell death in non-stressed Salmonella, S. typhimurium was the most acid tolerant and S. heidelberg was the most acid sensitive whereas in stressed Salmonella, S. senftenberg was the most acid tolerant and S. tennessee was the most acid sensitive. The pH required to cause cell injury varied among isolates. With some isolates, the pH required for 50% cell death and 50% cell injury was similar. In other isolates, cell injury occurred at a more neutral pH. These findings suggest that the pH of pre-enrichment media may influence the recovery and bias the serotype of Salmonella recovered from feed during pre-enrichment.

Successional changes in the chicken cecal microbiome during 42 days of growth are independent of organic acid feed additives.

BACKGROUND: Poultry remains a major source of foodborne bacterial infections. A variety of additives with presumed anti-microbial and/or growth-promoting effects are commonly added to poultry feed during commercial grow-out, yet the effects of these additives on the gastrointestinal microbial community (the GI microbiome) as the bird matures remain largely unknown. Here we compared temporal changes in the cecal microbiome to the effects of formic acid, propionic acid, and medium-chain fatty acids (MCFA) added to feed and/or drinking water. RESULTS: Cecal bacterial communities at day of hatch (n = 5 birds), 7d (n = 32), 21d (n = 27), and 42d (n = 36) post-hatch were surveyed using direct 454 sequencing of 16S rRNA gene amplicons from each bird in combination with cultivation-based recovery of a Salmonella Typhimurium marker strain and quantitative-PCR targeting Clostridium perfringens. Treatment effects on specific pathogens were generally non-significant. S. Typhimurium introduced by oral gavage at day of hatch was recovered by cultivation from nearly all birds sampled across treatments at 7d and 21d, but by 42d, S. Typhimurium was only recovered from ca. 25% of birds, regardless of treatment. Sequencing data also revealed non-significant treatment effects on genera containing known pathogens and on the cecal microbiome as a whole. In contrast, temporal changes in the cecal microbiome were dramatic, highly significant, and consistent across treatments. At 7d, the cecal community was dominated by three genera (Flavonifractor, Pseudoflavonifractor, and a Lachnospiracea sequence type) that accounted for more than half of sequences. By 21d post-hatch, a single genus (Faecalibacterium) accounted for 23-55% of sequences, and the number of Clostridium 16S rRNA gene copies detected by quantitative-PCR reached a maximum. CONCLUSIONS: Over the 42 d experiment, the cecal bacterial community changed significantly as measured by a variety of ecological metrics and increases in the complexity of co-occurrence networks. Management of poultry to improve animal health, nutrition, or food safety may need to consider the interactive effects of any treatments with the dramatic temporal shifts in the taxonomic composition of the cecal microbiome as described here.

Detection and Distribution of Clustered Regularly Interspaced Short Palindromic Repeats (CRISPRs) in Campylobacter jejuni Isolates from Chicken Livers.

Campylobacter jejuni is the leading foodborne bacterial pathogen that causes human gastroenteritis worldwide linked to the consumption of undercooked broiler livers. Application of bacteriophages during poultry production has been used as an alternative approach to reduce contamination of poultry meat by Campylobacter. To make this approach effective, understanding the presence of the bacteriophage sequences in the CRISPR spacers in C. jejuni is critical as they may confer bacterial resistance to bacteriophage treatment. Therefore, in this study, we explored the distribution of the CRISPR arrays from 178 C. jejuni isolated from chicken livers between January and July 2018. Genomic DNA of C. jejuni isolates was extracted, and CRISPR type 1 sequences were amplified by PCR. Amplicons were purified and sequenced by the Sanger dideoxy sequencing method. Direct repeats (DRs) and spacers of CRISPR sequences were identified using the CRISPRFinder program. Further, spacer sequences were submitted to the CRISPRTarget to identify potential homology to bacteriophage types. Even though CRISPR-Cas is reportedly not an active system in Campylobacter, a total of 155 (87%) C. jejuni isolates were found to harbor CRISPR sequences; one type of DR was identified in all 155 isolates. The CRISPR loci lengths ranged from 97 to 431 nucleotides. The numbers of spacers ranged from one to six. A total of 371 spacer sequences were identified in the 155 isolates that could be grouped into 51 distinctive individual sequences. Further comparison of these 51 spacer sequences with those in databases showed that most spacer sequences were homologous to Campylobacter bacteriophage DA10. The results of our study provide important information relative to the development of an effective bacteriophage treatment to mitigate Campylobacter during poultry production.

Novel epidemic clones of Listeria monocytogenes, United States, 2011.

We identified a novel serotype 1/2a outbreak strain and 2 novel epidemic clones of Listeria monocytogenes while investigating a foodborne outbreak of listeriosis associated with consumption of cantaloupe during 2011 in the United States. Comparative analyses of strains worldwide are essential to identification of novel outbreak strains and epidemic clones.

Prevalence and concentration of Salmonella and Campylobacter in the processing environment of small-scale pastured broiler farms.

A growing niche in the locally grown food movement is the small-scale production of broiler chickens using the pasture-raised poultry production model. Limited research exists that focuses on Salmonella and Campylobacter contamination in the environment associated with on-farm processing of pasture-raised broilers. The objective of this study was to establish data relative to Salmonella and Campylobacter prevalence and concentration in soil and mortality compost resulting from prior processing waste disposal in the small-scale, on-farm broiler processing environment. Salmonella and Campylobacter concentrations were determined in soil (n = 42), compost (n = 39), and processing wastewater (PWW; n = 46) samples from 4 small broiler farms using a 3-tube most probable number (MPN) method for Salmonella and direct plating method for Campylobacter. Salmonella prevalence and concentration (mean log10 MPN per sample weight or volume) in soil [60%, 0.97 (95% CI: 0.66 to 1.27)], compost [64%, 0.95 (95% CI: 0.66 to 1.24)], and wastewater [48%, 1.29 (95% CI: 0.87 to 1.71)] were not significantly different (P > 0.05). Although Campylobacter prevalence was not significantly different by sample type (64.3, 64.3, and 45.7% in soil, compost, and PWW, respectively), the concentration (mean log10 cfu) of this pathogen was significantly lower (P < 0.05) in wastewater [2.19 (95% CI: 0.36 to 3.03)] samples compared with soil [3.08 (95% CI: 2.23 to 3.94)], and compost [3.83 (95% CI: 2.71 to 4.95)]. These data provide insight into small-scale poultry production waste disposal practices and provides a record of data that may serve as a guide for future improvement of these practices. Further research is needed regarding the small-scale broiler production environment in relation to improving disposal of processing waste for optimum control of human pathogens.

Prevalence and Subtype Characterization of Campylobacter in Ceca of Commercial Broiler Chickens at Processing - A 452 Flock, Seven-year Survey.

Human Campylobacter infections have been associated with chicken and other poultry meat products. Environmental conditions such as temperature and season can affect Campylobacter recoverability from chicken meat products. In the presented study, we sought to investigate the relationship between ambient weather conditions and the isolation of Campylobacter from chicken flocks, as well as the subtype of these isolates. Campylobacter was isolated from the ceca of broilers collected in a commercial processing facility over 7 years, representing 452 flocks. Isolates were subjected to whole-genome sequencing and subtyping by multilocus sequence typing (MLST). Approximately 60% (269/452) of flocks sampled were positive for Campylobacter. There was no significant effect on the presence of detectable Campylobacter by month, season, temperature, or rainfall during grow-out or transportation. Sixty-eight different STs were detected; 45 C. jejuni and 23 C. coli. Diversity as measured by Shannon's diversity index was higher in the spring and fall than in mid-winter and summer. We concluded that in the warm temperate climate of the Southeastern U.S., seasonality does not affect the rate of Campylobacter isolation from broilers, but the diversity of isolates was higher in the milder spring and fall seasons.

Filter sterilized carcass rinsate for recovery of Salmonella species with various concentrations of cetylpyridinium chloride.

Controlling Salmonella in poultry processing continues to be important to processors and consumers. Cetylpyridinium chloride (CPC) has proven to be effective in vitro in controlling Salmonella. This study evaluated the recovery of Salmonella after overnight storage in 4°C filter-sterilized carcass rinsate containing CPC from 0.44 to 909 ppm (µg/mL). Ten Salmonella serotypes (18 strains), of which 6 serotypes are commonly isolated from poultry products, were grown in Bacto-Tryptic Soy Broth overnight at 37°C. Serial dilutions of a CPC/propylene glycol solution were prepared in 24-well tissue culture plates containing filter-sterilized carcass rinsate. Approximately 107 cfu/mL of each Salmonella serotype was added to the appropriate wells. Inoculated plates were stored overnight at 4°C. After storage, triplicate plates of brilliant green agar with sulfapyridine (BGS) were surface inoculated with 10 µL of the contents for each well, streaked for isolation, and incubated at 37°C for 24 h. Three replications were conducted. The presence of typical colonies on BGS plates was recorded as growth and verified through biochemical and serological testing. Of the serotypes chosen, Salmonella Kentucky, Dublin, and Enteritidis were the least resistant to CPC with a median minimum inhibitory concentration (MIC) of 14.22 µg/mL (range from 3.55 to 56.88 µg/mL); S. Typhimurium demonstrated a median MIC of 114.00 µg/mL (range from 28.44 to 114.00 µg/mL). Residual CPC potentially remaining attached to a carcass or in the weep after processing could potentially alter which Salmonella serotype is recovered from a carcass rinse due to different growth patterns during regulatory testing, with a potential for more virulent strains not to be recovered.

Exudate From Retail Chicken Liver Packaging Allows for Survival of Naturally Occurring Campylobacter, Coliforms, and Aerobic Microorganisms Under Drying Conditions.

Campylobacter spp. are a leading cause of human foodborne illness associated with chicken meat products in the United States. Chicken livers, including exudate from packaging, commonly carry Campylobacter and could be a source of illness if mishandled. Survivability of naturally occurring Campylobacter, total aerobic bacteria, and coliforms was determined under drying conditions in two consumer simulated environments: moist sponge and solid surface. Fresh chicken liver exudate was dispensed onto sponges and glass slides and allowed to dry under ambient conditions for 7 days. Bacterial concentration was measured at 0, 6, 24, 48, 72, and 168 h. Total aerobic population did not decrease by more than one log over 7 days and did not correlate to water activity or time in either simulation. Coliform concentrations increased in sponge simulations but decreased in solid surface simulations. Further, coliform concentrations were significantly higher in sponge simulations than in solid surface. Campylobacter was naturally present in exudate and survived at least to 6 h in every trial. Campylobacter was recoverable at 24 h in some sponge trials. However, Campylobacter concentration was strongly correlated to water activity. Fresh chicken liver exudate could present a risk of campylobacteriosis to consumers if mishandled even after drying.

Despite Shared Geography, Campylobacter Isolated from Surface Water Are Genetically Distinct from Campylobacter Isolated from Chickens.

We tested the hypothesis that Campylobacter isolated from chicken ceca and river water in an overlapping geographic area would share genetic information. Isolates of C. jejuni from chicken ceca were collected from a commercial slaughter plant and isolates of C. jejuni were also collected from rivers and creeks in the same watershed. Isolates were subjected to whole-genome sequencing and the data were used for core genome multilocus sequence typing (cgMLST). Cluster analysis showed that there were four distinct subpopulations, two from chickens and two from water. Calculation of fixation statistic (Fst) showed that all four subpopulations were significantly distinct. Greater than 90% of the loci were differentiated by subpopulation. Only two genes showed clear differentiation of both chicken subpopulations from both water subpopulations. Sequence fragments of the CJIE4 bacteriophage family were found frequently in the main chicken subpopulation and the water outgroup subpopulation but were sparsely found in the main water population and not at all in the chicken outgroup. CRISPR spacers that targeted the phage sequences were common in the main water subpopulation, only once in the main chicken subpopulation, and not at all in the chicken or water outgroups. Restriction enzyme genes also showed a biased distribution. These data suggest that there is little transfer of C. jejuni genetic material between chickens and nearby river water. Campylobacter differentiation according to these two sources does not show clear evidence of evolutionary selection; the differentiation is probably due to geospatial isolation, genetic drift, and the action of CRISPRs and restriction enzymes. IMPORTANCE Campylobacter jejuni causes gastroenteritis in humans, and chickens and environmental water are leading sources of infection. We tested the hypothesis that Campylobacter isolated from chicken ceca and river water in an overlapping geographic area would share genetic information. Isolates of Campylobacter were collected from water and chicken sources in the same watershed and their genomes were sequenced and analyzed. Four distinct subpopulations were found. There was no evidence of sharing genetic material between the subpopulations. Phage profiles, CRISPR profiles and restriction systems differed by subpopulation.

Buffered Peptone Water Formulation Does Not Influence Growth of pESI-positive Salmonella enterica Serovar Infantis.

Salmonella enterica is a major cause of human foodborne illness and is often attributed to poultry food sources. S. enterica serovar Infantis, specifically those carrying the pESI plasmid, has become a frequently isolated serotype from poultry meat samples at processing and has caused numerous recent human infections. In 2016, the USDA-Food Safety and Inspection Service changed the official sampling method for raw poultry products from BPW to using neutralizing BPW (nBPW) as the rinsing agent in order to prevent residual antimicrobial effects from acidifying and oxidizing processing aids. This change was contemporaneous to the emergence of pESI-positive ser. Infantis as a prevalent serovar in poultry, prompting some to question if nBPW could be selecting for this prevalent serovar. We performed two experiments: a comparison of ser. Infantis growth in BPW versus nBPW, and a simulation of regulatory sampling methods. We found that when inoculated into both broths, ser. Infantis initially grows slightly slower in nBPW than in BPW but little difference was seen in abundance after 6 h of growth. Additionally, the use of nBPW to simulate poultry rinse sample and overnight cold shipping to a regulatory lab did not affect the survival or subsequent growth of ser. Infantis in BPW. We concluded that the change in USDA-FSIS methodology to include nBPW in sampling procedures has likely not affected the emergence of S. ser. Infantis as a prevalent serovar in chicken and turkey meat product samples.

Whole-genome sequencing of Listeria innocua recovered from retail milk and dairy products in Egypt.

The similarity of the Listeria innocua genome with Listeria monocytogenes and their presence in the same niche may facilitate gene transfer between them. A better understanding of the mechanisms responsible for bacterial virulence requires an in-depth knowledge of the genetic characteristics of these bacteria. In this context, draft whole genome sequences were completed on five L. innocua isolated from milk and dairy products in Egypt. The assembled sequences were screened for antimicrobial resistance and virulence genes, plasmid replicons and multilocus sequence types (MLST); phylogenetic analysis of the sequenced isolates was also performed. The sequencing results revealed the presence of only one antimicrobial resistance gene, fosX, in the L. innocua isolates. However, the five isolates carried 13 virulence genes involved in adhesion, invasion, surface protein anchoring, peptidoglycan degradation, intracellular survival, and heat stress; all five lacked the Listeria Pathogenicity Island 1 (LIPI-1) genes. MLST assigned these five isolates into the same sequence type (ST), ST-1085; however, single nucleotide polymorphism (SNP)-based phylogenetic analysis revealed 422-1,091 SNP differences between our isolates and global lineages of L. innocua. The five isolates possessed an ATP-dependent protease (clpL) gene, which mediates heat resistance, on a rep25 type plasmids. Blast analysis of clpL-carrying plasmid contigs showed approximately 99% sequence similarity to the corresponding parts of plasmids of L. monocytogenes strains 2015TE24968 and N1-011A previously isolated from Italy and the United States, respectively. Although this plasmid has been linked to L. monocytogenes that was responsible for a serious outbreak, this is the first report of L. innocua containing clpL-carrying plasmids. Various genetic mechanisms of virulence transfer among Listeria species and other genera could raise the possibility of the evolution of virulent strains of L. innocua. Such strains could challenge processing and preservation protocols and pose health risks from dairy products. Ongoing genomic research is necessary to identify these alarming genetic changes and develop preventive and control measures.

Ciliate ingestion and digestion: flow cytometric measurements and regrowth of a digestion-resistant Campylobacter jejuni.

We measured ingestion and digestion rates of the pathogenic bacterium Campylobacter jejuni by a freshwater ciliate Colpoda sp. to determine whether Campylobacter is able to resist protist digestion. Campylobacter and the nonpathogenic bacterium Pseudomonas putida LH1 were labeled with a 5-chloromethylfluorescein diacetate, which fluoresces in intact and active cells but fades when exposed to low pH environments, such as protistan food vacuoles. Ingestion and digestion rates were measured via flow cytometry as the change in ciliate fluorescence over time, which corresponded to the quantity of intracellular bacteria. The rate of Campylobacter ingestion exceeded the digestion rate. Ciliates retained labeled Campylobacter 5 h after ingestion was stopped. In contrast, ciliates grazing upon P. putida returned to baseline fluorescence within 5 h, indicating that P. putida were completely digested. The ability of intracellular Campylobacter to remain viable after ingestion was tested by sorting individual ciliates and bacterial cells into Campylobacter-selective media. Campylobacter growth occurred in 15% (± 5 SE) of wells seeded with highly fluorescent ciliates, whereas only 4% (± 1) of wells seeded with free-living Campylobacter exhibited growth. A key advantage of this approach is that it is rapid and should be applicable to other phagocytotis studies.

Assessing Salmonella prevalence and complexity through processing using different culture methods.

Conventional Salmonella surveillance requires a week for isolation, confirmation, and subsequent serotyping. We previously showed that this could be reduced by 24 h by combining the pre-enrichment and enrichment steps into a single selective pre-enrichment step and was tested on directly after picking. The goal of this study was 2-fold: 1) to evaluate the use of selective pre-enrichment through each step of processing, including postintervention when the Salmonella load is reduced, and 2) to assess any changes in serovar populations in Salmonella positive samples. Duplicate carcass drip samples, each representative of 500 broiler carcasses, were collected by catching processing water drip under moving carcass shackle lines in each of three commercial broiler slaughter plants. Samples were collected post-pick, post-inside-outside bird wash (IOBW), and post-chill; duplicate wing rinses were performed pre- and post-antimicrobial parts dip. Each processing plant was sampled 6 times for a total of 180 samples collected. The number of Salmonella positives identified with selective pre-enrichment conditions (48/180) was similar to traditional selective enrichment culture conditions (52/180), showed good concordance in recovery rate between the 2 culture methods (Fisher's exact test, P = 0.72). We also found that the incidence of Salmonella reduced dramatically after antimicrobial intervention (post-pick 66.7% vs. post chill 8.3%). When serovar populations were evaluated in Salmonella positive samples using CRISPR-SeroSeq, we detected four different Salmonella serovars, Kentucky, Infantis, Schwarzengrund, and Typhimurium, and their incidence rose between post-pick and post-IOBW. The relative abundance of Infantis within individual samples increased between post-pick and post-IOBW while the relative abundance of the other 3 serovars decreased. These results suggest that a selective pre-enrichment step reduces the time required for Salmonella isolation without negatively affecting detection and serovar profiles in culture positive samples were not altered between culture conditions used.

Prevalence and Characterization of Quinolone Resistance in Campylobacter spp. Isolates in Chicken Livers from Retail Stores in Georgia, USA.

ABSTRACT: Campylobacter is a bacterial pathogen that causes human foodborne illnesses worldwide, and outbreaks have been associated with consumption of undercooked chicken livers. The objectives of this study were to compare two PCR assays of 250 Campylobacter isolates for identification to species, to assess antibiotic resistance of the isolates, and to analyze genetic diversity of the quinolone resistance determining regions (QRDRs) of the isolates. A double-blind design was used to identify the species of Campylobacter; 181 (72%) of the isolates were identified as Campylobacter jejuni, and 69 (28%) isolates were identified as Campylobacter coli by both PCR assays. A total of 93 (37.2%) isolates were resistant to at least one antibiotic. Among 88 C. jejuni isolates, 33 (18%) were resistant to nalidixic acid (NAL) and ciprofloxacin (CIP), 25 (14%) were resistant to tetracycline (TET), and 18 (10%) were resistant to NAL and TET. Two C. jejuni isolates were resistant to four of the tested antibiotics, and one isolate was resistant to five antibiotics. Two C. coli isolates were resistant to TET, and two were resistant to NAL, CIP, and TET. The amino acid sequences of the QRDRs for the isolates had eight point mutations and could be classified into 12 groups. Thirty-eight C. jejuni isolates resistant to NAL and CIP had a point mutation at residue 86 (substitution from threonine to isoleucine). However, six isolates without this substitution were resistant to NAL and/or CIP. Ten isolates with a point mutation at residue 86 were susceptible to NAL and CIP. This observation suggests that in addition to the substitution at residue 86 other mechanisms may confer resistance to quinolones. Further studies are needed to elucidate mechanisms for quinolone resistance in Campylobacter. The Campylobacter spp. isolated from chicken livers in this study were resistant to quinolones and other classes of antibiotics.

Cecal Microbial Hydrogen Cycling Potential Is Linked to Feed Efficiency Phenotypes in Chickens.

In chickens, early life exposure to environmental microbes has long-lasting impacts on gastrointestinal (GI) microbiome development and host health and growth, via mechanisms that remain uncharacterized. In this study, we demonstrated that administrating a fecal microbiome transplant (FMT) from adults to day-of-hatch chicks results in significantly higher body mass of birds and decreased residual feed intake (RFI), implying enhanced feed efficiency, at 6 weeks of age. To assess the potential mechanisms through which FMT affects adult bird phenotype, we combined 16 S rRNA gene amplification, metagenomic, and comparative genomic approaches to survey the composition and predicted activities of the resident microbiome of various GI tract segments. Early life FMT exposure had a long-lasting significant effect on the microbial community composition and function of the ceca but not on other GI segments. Within the ceca of 6-week-old FMT birds, hydrogenotrophic microbial lineages and genes were most differentially enriched. The results suggest that thermodynamic regulation in the cecum, in this case via hydrogenotrophic methanogenic and sulfur-cycling lineages, potentially serving as hydrogen sinks, may enhance fermentative efficiency and dietary energy harvest capacity. Our study provides a specific mechanism of action through which early-life microbiome transplants modulate market-relevant phenotypes in poultry and, thereby, may represent a significant advance toward microbiome-focused sustainable agriculture.

Survey of Meat Collected from Commercial Broiler Processing Plants Suggests Low Levels of Semicarbazide Can Be Created during Immersion Chilling.

ABSTRACT: Semicarbazide (SEM) is routinely employed as an indicator for the use of nitrofurazone, a banned antimicrobial. The validity of SEM as a nitrofurazone marker has been scrutinized because of other possible sources of the compound. Nonetheless, a U.S. trade partner rejected skin-on chicken thighs because of SEM detection and suspected nitrofurazone use. Because nitrofurazone has been banned in U.S. broiler production since 2003, we hypothesized that incidental de novo SEM formation occurs during broiler processing. To assess this possibility, raw leg quarters were collected from 23 commercial broiler processing plants across the United States and shipped frozen to our laboratory, where liquid chromatography-mass spectrometry was used to quantitatively assess for SEM. Leg quarter samples were collected at four points along the processing line: hot rehang (transfer from the kill line to the evisceration line), prechill (before the chilling process), postchill (immediately following chilling), and at the point of pack. Thigh meat with skin attached was removed from 535 leg quarters and analyzed in triplicate for SEM concentrations. The concentrations ranged from 0 to 2.67 ppb, with 462 (86.4%) of 535 samples below the regulatory decision level of 0.5 ppb of SEM. The 73 samples over the 0.5-ppb limit came from 21 plants; 53 (72.6%) of positive samples were in meat collected after chilling (postchill or point of pack). The difference in both prevalence and concentration of SEM detected before and after chilling was highly significant (P < 0.0001). These data support our hypothesis that SEM detection in raw broiler meat is related to de novo creation of the chemical during processing.