Validation of Preload Assessment Technologies at Altitude in a Porcine Model of Hemorrhage.

INTRODUCTION: Dynamic preload assessment measures including pulse pressure variation (PPV), stroke volume variation (SVV), pleth variability index (PVI), and hypotension prediction index (HPI) have been utilized clinically to guide fluid management decisions in critically ill patients. These values aid in the balance of correcting hypotension while avoiding over-resuscitation leading to respiratory failure and increased mortality. However, these measures have not been previously validated at altitude or in those with temporary abdominal closure (TAC). METHODS: Forty-eight female swine (39 ± 2 kg) were separated into eight groups (n = 6) including all combinations of flight versus ground, hemorrhage versus no hemorrhage, and TAC versus no TAC. Flight animals underwent simulated aeromedical evacuation via an altitude chamber at 8000 ft. Hemorrhagic shock was induced via stepwise hemorrhage removing 10% blood volume in 15-min increments to a total blood loss of 40% or a mean arterial pressure of 35 mmHg. Animals were then stepwise transfused with citrated shed blood with 10% volume every 15 min back to full blood volume. PPV, SVV, PVI, and HPI were monitored every 15 min throughout the simulated aeromedical evacuation or ground control. Blood samples were collected and analyzed for serum levels of serum IL-1ß, IL-6, IL-8, and TNF-α. RESULTS: Hemorrhage groups demonstrated significant increases in PPV, SVV, PVI, and HPI at each step compared to nonhemorrhage groups. Flight increased PPV (P = 0.004) and SVV (P = 0.003) in hemorrhaged animals. TAC at ground level increased PPV (P < 0.0001), SVV (P = 0.0003), and PVI (P < 0.0001). When TAC was present during flight, PPV (P = 0.004), SVV (P = 0.003), and PVI (P < 0.0001) values were decreased suggesting a dependent effect between altitude and TAC. There were no significant differences in serum IL-1ß, IL-6, IL-8, or TNF-α concentration between injury groups. CONCLUSIONS: Based on our study, PPV and SVV are increased during flight and in the presence of TAC. Pleth variability index is slightly increased with TAC at ground level. Hypotension prediction index demonstrated no significant changes regardless of altitude or TAC status, however this measure was less reliable once the resuscitation phase was initiated. Pleth variability index may be the most useful predictor of preload during aeromedical evacuation as it is a noninvasive modality.

Just Say NO: Inhaled Nitric Oxide Effect on Respiratory Parameters Following Traumatic Brain Injury in Humans and a Porcine Model.

INTRODUCTION: The mechanism of post-traumatic brain injury (TBI) hypoxemia involves ventilation/perfusion mismatch and loss of pulmonary hypoxic vasoconstriction. Inhaled nitric oxide (iNO) has been studied as an adjunct treatment to avoid the use of high positive end-expiratory pressure and inspired oxygen in treatment-refractory hypoxia. We hypothesized that iNO treatment following TBI would improve systemic and cerebral oxygenation via improved matching of pulmonary perfusion and ventilation. METHODS: Thirteen human patients with isolated TBI were enrolled and randomized to receive either placebo or iNO with measured outcomes including pulmonary parameters, blood gas data, and intracranial pressure (ICP) /perfusion. To complement this study, a porcine model of TBI (including 10 swine) was utilized with measured outcomes of brain tissue blood flow and oxygenation, ventilator parameters, and blood gas data both after administration and following drug removal and clearance. RESULTS: There were no clinically significant changes in pulmonary parameters in either the human or porcine arm following administration of iNO when compared to either the placebo group (human arm) or the internal control (porcine arm). Analysis of pooled human data demonstrated the preservation of alveolar recruitment in TBI patients. There were no clinically significant changes in human ICP or cerebral perfusion pressure following iNO administration compared to controls. CONCLUSIONS: iNO had no significant effect on clinically relevant pulmonary parameters or ICPs following TBI in both human patients and a porcine model. The pressure-based recruitment of the human lungs following TBI was preserved. Further investigation will be needed to determine the degree of utility of iNO in the setting of hypoxia after polytrauma.

Postinjury Treatment to Mitigate the Effects of Aeromedical Evacuation After Traumatic Brain Injury in a Porcine Model.

INTRODUCTION: Early aeromedical evacuation after traumatic brain injury (TBI) has been associated with worse neurologic outcomes in murine studies and military populations. The goal of this study was to determine if commonly utilized medications, including allopurinol, propranolol, or tranexamic acid (TXA), could mitigate the secondary traumatic brain injury experienced during the hypobaric and hypoxic environment of aeromedical evacuation. METHODS: Porcine TBI was induced via controlled cortical injury. Twenty nonsurvival pigs were separated into four groups (n = 5 each): TBI+25 mL normal saline (NS), TBI+4 mg propranolol, TBI+100 mg allopurinol, and TBI+1g TXA. The pigs then underwent simulated AE to an altitude of 8000 ft for 4 h with an SpO2 of 82-85% and were sacrificed 4 h later. Hemodynamics, serum cytokines, and hippocampal p-tau accumulation were assessed. An additional survival cohort was partially completed with TBI/NS (n = 5), TBI/propranolol (n = 2) and TBI/allopurinol groups (n = 2) survived to postinjury day 7. RESULTS: There were no significant differences in hemodynamics, tissue oxygenation, cerebral blood flow, or physiologic markers between treatment groups and saline controls. Transient differences in IL-1b and IL-6 were noted but did not persist. Neurological Severity Score (NSS) was significantly lower in the TBI + allopurinol group on POD one compared to NS and propranolol groups. P-tau accumulation was decreased in the nonsurvival animals treated with allopurinol and TXA compared to the TBI/NS group. CONCLUSIONS: Allopurinol, propranolol, and TXA, following TBI, do not induce adverse changes in systemic or cerebral hemodynamics during or after a simulated postinjury flight. While transient changes were noted in systemic cytokines and p-tau accumulation, further investigation will be needed to determine any persistent neurological effects of injury, flight, and pharmacologic treatment.

Antimicrobial Coating Prevents Ventilator-Associated Pneumonia in a 72 hour Large Animal Model.

BACKGROUND: The primary goal of this study was to demonstrate that endotracheal tubes coated with antimicrobial lipids plus mucolytic or antimicrobial lipids with antibiotics plus mucolytic would significantly reduce pneumonia in the lungs of pigs after 72 hours of continuous mechanical ventilation compared to uncoated controls. MATERIALS AND METHODS: Eighteen female pigs were mechanically ventilated for up to 72 hours through uncoated endotracheal tubes, endotracheal tubes coated with the antimicrobial lipid, octadecylamine, and the mucolytic, N-acetylcysteine, or tubes coated with octadecylamine, N-acetylcysteine, doxycycline, and levofloxacin (6 pigs per group). No exogenous bacteria were inoculated into the pigs, pneumonia resulted from the pigs' endogenous oral flora. Vital signs were recorded every 15 minutes and arterial blood gas measurements were obtained for the duration of the experiment. Pigs were sacrificed either after completion of 72 hours of mechanical ventilation or just prior to hypoxic arrest. Lungs, trachea, and endotracheal tubes were harvested for analysis to include bacterial counts of lung, trachea, and endotracheal tubes, lung wet and dry weights, and lung tissue for histology. RESULTS: Pigs ventilated with coated endotracheal tubes were less hypoxic, had less bacterial colonization of the lungs, and survived significantly longer than pigs ventilated with uncoated tubes. Octadecylamine-N-acetylcysteine-doxycycline-levofloxacin coated endotracheal tubes had less bacterial colonization than uncoated or octadecylamine-N-acetylcysteine coated tubes. CONCLUSION: Endotracheal tubes coated with antimicrobial lipids plus mucolytic and antimicrobial lipids with antibiotics plus mucolytic reduced bacterial colonization of pig lungs after prolonged mechanical ventilation and may be an effective strategy to reduce ventilator-associated pneumonia.

Early Identification of Acute Lung Injury in a Porcine Model of Hemorrhagic Shock.

BACKGROUND: Acute lung injury (ALI) is a frequent complication after severe trauma. Lung-protective ventilation strategies and damage control resuscitation have been proposed for the prevention of ALI; however, there are no clinical or laboratory parameters to predict who is at risk of developing ALI after trauma. In the present study, we explored pulmonary inflammatory markers as a potential predictor of ALI using a porcine model of hemorrhagic shock. MATERIALS AND METHODS: Female swine were randomized to mechanical ventilation with low tidal volume (VT) (6 mL/kg) or high VT (12 mL/kg). After equilibration, animals underwent pressure-controlled hemorrhage (mean arterial pressure [MAP] 35 ± 5 mmHg) for 1 h, followed by resuscitation with fresh whole blood or Hextend. They were maintained at MAP of 50 ± 5 mmHg for 3 h in the postresuscitation phase. Bronchoalveolar lavage fluids were collected hourly and analyzed for inflammatory markers. Lung samples were taken, and porcine neutrophil antibody staining was used to evaluate the presence of neutrophils. ELISA evaluated serum porcine surfactant protein D levels. Sham animals were used as negative controls. RESULTS: Pigs that underwent hemorrhagic shock had higher heart rates, lower cardiac output, lower MAPs, and worse acidosis compared with sham at the early time points (P < 0.05 each). There were no significant differences in central venous pressure or pulmonary capillary wedge pressure between groups. Pulmonary neutrophil infiltration, as defined by neutrophil antibody staining on lung samples, was greater in the shock groups regardless of resuscitation fluid (P < 0.05 each). Bronchoalveolar lavage fluid neutrophil levels were not different between groups. There were no differences in levels of porcine surfactant protein D between groups at any time points, and the levels did not change over time in each respective group. CONCLUSIONS: Our study demonstrates the reproducibility of a porcine model of hemorrhagic shock that is consistent with physiologic changes in humans in hemorrhagic shock. Pulmonary neutrophil infiltration may serve as an early marker for ALI; however, the practicality of this finding has yet to be determined.

Systemic Inflammatory Effect of Hypobaria During Aeromedical Evacuation after Porcine Traumatic Brain Injury.

BACKGROUND: Traumatic brain injury (TBI)-related morbidity is caused largely by secondary injury resulting from hypoxia, excessive sympathetic drive, and uncontrolled inflammation. Aeromedical evacuation (AE) is used by the military for transport of wounded soldiers to higher levels of care. We hypothesized that the hypobaric, hypoxic conditions of AE may exacerbate uncontrolled inflammation after TBI that could contribute to more severe TBI-related secondary injury. STUDY DESIGN: Thirty-six female pigs were used to test TBI vs Sham TBI, hypoxia vs normoxia, and hypobaria vs ground conditions. TBI was induced by controlled cortical injury, hypobaric conditions of 12,000 ft were established in an altitude chamber, and hypoxic exposure was titrated to 85% SpO 2 while at altitude. Serum cytokines, ubiquitin C-terminal hydrolase L1, and TBI biomarkers were analyzed via ELISA. Gross analysis and staining of cortex and hippocampus tissue was completed for glial fibrillary acidic protein and phosphorylated tau. RESULTS: Serum interleukin-1ß, interleukin-6, and tumor necrosis factor-α were significantly elevated after TBI in pigs exposed to altitude-induced hypobaria/hypoxia, as well as hypobaria alone, compared with ground level/normoxia. No difference in TBI biomarkers after TBI or hypobaric, hypoxic exposure was noted. No difference in brain tissue glial fibrillary acidic protein or phosphorylated tau when comparing the most different conditions of Sham TBI + ground or normoxia with the TBI + hypobaria/hypoxia group was noted. CONCLUSIONS: The hypobaric environment of AE induces systemic inflammation after TBI. Severe inflammation may play a role in exacerbating secondary injury associated with TBI and contribute to worse neurocognitive outcomes. Measures should be taken to minimize barometric and oxygenation changes during AE after TBI.

Oxygen supplies in disaster management.

Mass casualty events and disasters, both natural and human-generated, occur frequently around the world and can generate scores of injured or ill victims in need of resources. Of the available medical supplies, oxygen remains the critical consumable resource in disaster management. Strategic management of oxygen supplies in disaster scenarios remains a priority. Hospitals have large supplies of liquid oxygen and a supply of compressed gas oxygen cylinders that allow several days of reserve, but a large influx of patients from a disaster can strain these resources. Most backup liquid oxygen supplies are attached to the main liquid system and supply line. In the event of damage to the main system, the reserve supply is rendered useless. The Strategic National Stockpile supplies medications, medical supplies, and equipment to disaster areas, but it does not supply oxygen. Contracted vendors can deliver oxygen to alternate care facilities in disaster areas, in the form of concentrators, compressed gas cylinders, and liquid oxygen. Planning for oxygen needs following a disaster still presents a substantial challenge, but alternate care facilities have proven to be valuable in relieving pressure from the mass influx of patients into hospitals, especially for those on home oxygen who require only an electrical source to power their oxygen concentrator.

Effectiveness of Negative Pressure Wound Therapy During Aeromedical Evacuation Following Soft Tissue Injury and Infection.

INTRODUCTION: Negative pressure wound therapy (NPWT) is utilized early after soft tissue injury to promote tissue granulation and wound contraction. Early post-injury transfers via aeromedical evacuation (AE) to definitive care centers may actually induce wound bacterial proliferation. However, the effectiveness of NPWT or instillation NPWT in limiting bacterial proliferation during post-injury AE has not been studied. We hypothesized that instillation NPWT during simulated AE would decrease bacterial colonization within simple and complex soft tissue wounds. METHODS: The porcine models were anesthetized before any experiments. For the simple tissue wound model, two 4-cm dorsal wounds were created in 34.9 ± 0.6 kg pigs and were inoculated with Acinetobacter baumannii (AB) or Staphylococcus aureus 24 hours before a 4-hour simulated AE or ground control. During AE, animals were randomized to one of the five groups: wet-to-dry (WTD) dressing, NPWT, instillation NPWT with normal saline (NS-NPWT), instillation NPWT with Normosol-R® (NM-NPWT), and RX-4-NPWT with the RX-4 system. For the complex musculoskeletal wound, hind-limb wounds in the skin, subcutaneous tissue, peroneus tertius muscle, and tibia were created and inoculated with AB 24 hours before simulated AE with WTD or RX-4-NPWT dressings. Blood samples were collected at baseline, pre-flight, and 72 hours post-flight for inflammatory cytokines interleukin (IL)-1ß, IL-6, IL-8 and tumor necrosis factor alpha. Wound biopsies were obtained at 24 hours and 72 hours post-flight, and the bacteria were quantified. Vital signs were measured continuously during simulated AE and at each wound reassessment. RESULTS: No significant differences in hemodynamics or serum cytokines were noted between ground or simulated flight groups or over time in either wound model. Simulated AE alone did not affect bacterial proliferation compared to ground controls. The simple tissue wound arm demonstrated a significant decrease in Staphylococcus aureus and AB colony-forming units at 72 hours after simulated AE using RX-4-NPWT. NS-NPWT during AE more effectively prevented bacterial proliferation than the WTD dressing. There was no difference in colony-forming units among the various treatment groups at the ground level. CONCLUSION: The hypoxic, hypobaric environment of AE did not independently affect the bacterial growth after simple tissue wound or complex musculoskeletal wound. RX-4-NPWT provided the most effective bacterial reduction following simulated AE, followed by NS-NPWT. Future research will be necessary to determine ideal instillation fluids, negative pressure settings, and dressing change frequency before and during AE.

Use of a single ventilator to support 4 patients: laboratory evaluation of a limited concept.

INTRODUCTION: A mass-casualty respiratory failure event where patients exceed available ventilators has spurred several proposed solutions. One proposal is use of a single ventilator to support 4 patients. METHODS: A ventilator was modified to allow attachment of 4 circuits. Each circuit was connected to one chamber of 2 dual-chambered, test lungs. The ventilator was set at a tidal volume (V(T)) of 2.0 L, respiratory frequency of 10 breaths/min, and PEEP of 5 cm H(2)O. Tests were repeated with pressure targeted breaths at 15 cm H(2)O. Airway pressure, volume, and flow were measured at each chamber. The test lungs were set to simulate 4 patients using combinations of resistance (R) and compliance (C). These included equivalent C and R, constant R and variable C, constant C and variable R, and variable C and variable R. RESULTS: When R and C were equivalent the V(T) distributed to each chamber of the test lung was similar during both volume (range 428-442 mL) and pressure (range 528-544 mL) breaths. Changing C while R was constant resulted in large variations in delivered V(T) (volume range 257-621 mL, pressure range 320-762 mL). Changing R while C was constant resulted in a smaller variation in V(T) (volume range 418-460 mL, pressure range 502-554 mL) compared to only C changes. When R and C were both varied, the range of delivered V(T) in both volume (336-517 mL) and pressure (417-676 mL) breaths was greater, compared to only R changes. CONCLUSIONS: Using a single ventilator to support 4 patients is an attractive concept; however, the V(T) cannot be controlled for each subject and V(T) disparity is proportional to the variability in compliance. Along with other practical limitations, these findings cannot support the use of this concept for mass-casualty respiratory failure.

AARC Clinical Practice Guidelines: Artificial Airway Suctioning.

Artificial airway suctioning is a key component of airway management and a core skill for clinicians charged with assuring airway patency. Suctioning of the artificial airway is a common procedure performed worldwide on a daily basis. As such, it is imperative that clinicians are familiar with the most-effective and efficient methods to perform the procedure. We conducted a systematic review to assist in the development of evidence-based recommendations that pertain to the care of patients with artificial airways. From our systematic review, we developed guidelines and recommendations that addressed questions related to the indications, complications, timing, duration, and methods of artificial airway suctioning. By using a modified version of the RAND/UCLA Appropriateness Method, the following recommendations for suctioning were developed for neonatal, pediatric, and adult patients with an artificial airway: (1) breath sounds, visual secretions in the artificial airway, and a sawtooth pattern on the ventilator waveform are indicators for suctioning pediatric and adult patients, and an acute increase in airway resistance may be an indicator for suctioning in neonates; (2) as-needed only, rather than scheduled, suctioning is sufficient for neonatal and pediatric patients; (3) both closed and open suction systems may be used to safely and effectively remove secretions from the artificial airway of adult patients; (4) preoxygenation should be performed before suctioning in pediatric and adult patients; (5) the use of normal saline solution should generally be avoided during suctioning; (6) during open suctioning, sterile technique should be used; (7) suction catheters should occlude < 70% of the endotracheal tube lumen in neonates and < 50% in pediatric and adult patients, and suction pressure should be kept below -120 mm Hg in neonatal and pediatric patients and -200 mm Hg in adult patients; (8) suction should be applied for a maximum of 15 s per suctioning procedure; (9) deep suctioning should only be used when shallow suctioning is ineffective; (10) routine bronchoscopy for secretion removal is not recommended; and (11) devices used to clear endotracheal tubes may be used when airway resistance is increased due to secretion accumulation.

Oxygenation and Respiratory System Compliance Associated With Pulmonary Contusion.

BACKGROUND: Blunt pulmonary contusions are associated with severe chest injuries and are independently associated with worse outcomes. Previous preclinical studies suggest that contusion progression precipitates poor pulmonary function; however, there are few current clinical data to corroborate this hypothesis. We examined pulmonary dynamics and oxygenation in subjects with pulmonary contusions to evaluate for impaired respiratory function. METHODS: A chest injury database was reviewed for pulmonary contusions over 5 years at an urban trauma center. This database was expanded to capture mechanical ventilation parameters for the first 7 days on all patients with pulmonary contusion and who were intubated. Daily [Formula: see text]:[Formula: see text], oxygenation indexes (OI), and dynamic compliances were calculated. Pulmonary contusions were stratified by severity. The Fisher exact and chi square tests were performed on categorical variables, and Mann-Whitney U-tests were performed on continuous variables. Significance was assessed at a level of 0.05. RESULTS A TOTAL OF: 1,176 patients presented with pulmonary contusions, of whom, 301 subjects (25.6%) required intubation and had available invasive mechanical ventilation data. Of these, 144 (47.8%) had mild-moderate pulmonary contusion and 157 (52.2%) had severe pulmonary contusion. Overall injury severity score was high, with a median injury severity score of 29 (interquartile range, 22-38). The median duration of mechanical ventilation for mild-moderate pulmonary contusion was 7 d versus 10 d for severe pulmonary contusion (P = .048). All the subjects displayed moderate hypoxemia, which worsened until day 4-5 after intubation. Severe pulmonary contusion was associated with significantly worse early hypoxia on day 1 and day 2 versus mild-moderate pulmonary contusion. Severe pulmonary contusion also had a higher oxygenation index than mild-moderate pulmonary contusion. This trend persisted after adjustment for other factors, including transfusion and fluid administration. CONCLUSIONS: Pulmonary contusions played an important role in the course of subjects who were acutely injured and required mechanical ventilation. Contusions were associated with hypoxemia not fully characterized by [Formula: see text]: [Formula: see text], and severe contusions had durable elevations in the oxygenation index despite confounders.

Bench evaluation of 7 home-care ventilators.

BACKGROUND: Portable ventilators continue to decrease in size while increasing in performance. We bench-tested the triggering, battery duration, and tidal volume (V(T)) of 7 portable ventilators: LTV 1000, LTV 1200, Puritan Bennett 540, Trilogy, Vela, iVent 101, and HT50. METHODS: We tested triggering with a modified dual-chamber test lung to simulate spontaneous breathing with weak, normal, and strong inspiratory effort. We measured battery duration by fully charging the battery and operating the ventilator with a V(T) of 500 mL, a respiratory rate of 20 breaths/min, and PEEP of 5 cm H(2)O until breath-delivery ceased. We tested V(T) accuracy with pediatric ventilation scenarios (V(T) 50 mL or 100 mL, respiratory rate 50 breaths/min, inspiratory time 0.3 s, and PEEP 5 cm H(2)O) and an adult ventilation scenario (V(T) 400 mL, respiratory rate 30 breaths/min, inspiratory time 0.5 s, and PEEP 5 cm H(2)O). We measured and analyzed airway pressure, volume, and flow signals. RESULTS: At the adult settings the measured V(T) range was 362-426 mL. On the pediatric settings the measured V(T) range was 51-182 mL at the set V(T) of 50 mL, and 90-141 mL at the set V(T) of 100 mL. The V(T) delivered by the Vela at both the 50 mL and 100 mL, and by the HT50 at 100 mL, did not meet the American Society for Testing and Materials standard for V(T) accuracy. Triggering response and battery duration ranged widely among the tested ventilators. CONCLUSIONS: There was wide variability in battery duration and triggering sensitivity. Five of the ventilators performed adequately in V(T) delivery across several settings. The combination of high respiratory rate and low V(T) presented problems for 2 of the ventilators.

Performance of portable ventilators for mass-casualty care.

INTRODUCTION: Disasters and mass-casualty scenarios may overwhelm medical resources regardless of the level of preparation. Disaster response requires medical equipment, such as ventilators, that can be operated under adverse circumstances and should be able to provide respiratory support for a variety of patient populations. OBJECTIVE: The objective of this study was to evaluate the performance of three portable ventilators designed to provide ventilatory support outside the hospital setting and in mass-casualty incidents, and their adherence to the Task Force for Mass Critical Care recommendations for mass-casualty care ventilators. METHODS: Each device was evaluated at minimum and maximum respiratory rate and tidal volume settings to determine the accuracy of set versus delivered VT at lung compliance settings of 0.02, 0.08 and 0.1 L/cm H20 with corresponding resistance settings of 10, 25, and 5 cm H2O/L/sec, to simulate patients with ARDS, severe asthma, and normal lungs. Additionally, different FIO2 settings with each device (if applicable) were evaluated to determine accuracy of FIO2 delivery and evaluate the effect on delivered VT. Ventilators also were tested for duration of battery life. RESULTS: VT decreased with all three devices as compliance decreased. The decrease was more pronounced when the internal compressor was activated. At the 0.65 FIO2 setting on the MCV 200, the measured FIO2 varied widely depending on the set VT. Battery life range was 311-582 minutes with the 73X having the longest battery life. Delivered VT decreased toward the end of battery life with the SAVe having the largest decrease. The respiratory rate on the SAVe also decreased approaching the end of battery life. CONCLUSION: The 73X and MCV 200 were the closest to satisfying the Task Force for Mass Critical Care requirements for mass casualty ventilators, although neither had the capability to provide PEEP. The 73X provided the most consistent tidal volume delivery across all compliances, had the longest battery duration and the least decline in VT at the end of battery life.

Maximizing oxygen delivery during mechanical ventilation with a portable oxygen concentrator.

BACKGROUND: Transportation of the critically ill or injured war fighter requires the coordinated care and judicious use of resources. Availability of oxygen (O2) supplies for the mechanically ventilated patient is crucial. Size and weight of cylinders makes transport difficult and presents an increased risk of fire. A proposed solution is to use a portable oxygen concentrator (POC) for mechanical ventilation. We tested the SeQual Eclipse II POC paired with the Impact 754 and Pulmonetics LTV-1200 ventilators in the laboratory and evaluated the fraction of inspired oxygen (FIO2) across a range of minute volumes. METHODS: Each ventilator was attached to a test lung and pressure, volume, flow, and inspired oxygen (FIO2) was measured by a gas or flow analyzer. Ventilators were tested at a tidal volume (VT) of 500 mL; an inspiratory time of 1.0 second; respiratory rates of 10, 20, and 30 breaths per minute; and positive end-expiratory pressure of 0 and 10 cm H2O. The LTV 1200 was tested with and without the expiratory bias flow. The Eclipse II was modified to provide pulse dosing on inspiration at 3 volumes (64, 128, and 192 mL) and continuous flow at 1 L/min to 3 L/min. Six combinations of ventilator settings were used with each POC setting for evaluation. O2 was injected at the ventilator gas outlet and patient y-piece for pulse dose and continuous flow. Additionally, continuous flow O2 was injected into the oxygen inlet port of the LTV 1200, and a reservoir bag, on the inlet port of the Impact 754. All tests were done with both ventilators using continuous flow, wall source O2 as a control. We also measured the FIO2 with the concentrator on the highest pulse dose setting while decreasing ventilator VT to compensate for the added volume. RESULTS: The delivered FIO2 was highest when oxygen was injected into the ventilator circuit at the patient y-piece using pulse dosing, with the VT corrected. The next highest FIO2 was with continuous flow at the inlet (LTV), and reservoir (Impact). Electrical power consumption was less during pulse dose operation. SUMMARY: Oxygen is a finite resource, which is cumbersome to transport and may present a fire hazard. The relatively high FIO2 delivered by the POC makes this method of O2 delivery a viable alternative to O2 cylinders. However, patients requiring an FIO2 of 1.0 would require additional compressed oxygen. This system allows O2 delivery up to 76% solely using electricity. An integrated ventilator or POC capable of automatically compensating VT for POC output is desirable. Further patient testing needs to be done to validate these laboratory findings.

Battery performance of 4 intensive care ventilator models.

BACKGROUND: Hospital electrical power failure represents an important challenge in the intensive care unit. Despite the presence of backup generators, total electrical power failure may still occur. Life-support equipment should have a reliable internal battery to ensure patient safety. We tested the duration of operation of the internal battery of 4 intensive care ventilators. METHODS: In our laboratory we evaluated one each of 4 ventilator models available in our facility (Evita XL, Puritan Bennett 840, Avea, and Servo 300), with volume-control and pressure-control ventilation, and with positive end-expiratory pressure (PEEP) of zero and 20 cm H(2)O. We then randomly selected and tested 6 Evita XL and 4 Servo 300 ventilators from our inventory to determine the variability of internal battery duration among ventilators of the same model. The ventilator settings were identical to the previous tests, other than fraction of inspired oxygen, which was set at 0.6, and PEEP was 5 cm H(2)O. RESULTS: The battery-duration range of the tested ventilators was 20.5-170.5 min, and the mean +/- SD battery duration was 80.4 +/- 49.3 min. Changes in breath type and PEEP did not significantly impact battery duration. Among the ventilators of the same model, the battery-duration range was 5-69 min and the mean +/- SD battery duration was 28.9 +/- 21.4 min. Use of a compressor significantly shortened battery duration. There was no correlation between battery duration and battery age (r = -0.263). CONCLUSIONS: The duration of ventilator operation on internal battery ranged widely among the tested devices. Clinicians need to be aware of these differences in the event of power failure.

Intrathoracic Pressure Regulator Performance in the Setting of Hemorrhage and Acute Lung Injury.

INTRODUCTION: Intrathoracic pressure regulation (ITPR) can be utilized to enhance venous return and cardiac preload by inducing negative end expiratory pressure in mechanically ventilated patients. Previous preclinical studies have shown increased mean arterial pressure (MAP) and decreased intracranial pressure (ICP) with use of an ITPR device. The aim of this study was to evaluate the hemodynamic and respiratory effects of ITPR in a porcine polytrauma model of hemorrhagic shock and acute lung injury (ALI). METHODS: Swine were anesthetized and underwent a combination of sham, hemorrhage, and/or lung injury. The experimental groups included: no injury with and without ITPR (ITPR, Sham), hemorrhage with and without ITPR (ITPR/Hem, Hem), and hemorrhage and ALI with and without ITPR (ITPR/Hem/ALI, Hem/ALI). The ITPR device was initiated at a setting of -3 cmH2O and incrementally decreased by 3 cmH2O after 30 minutes on each setting, with 15 minutes allowed for recovery between settings, to a nadir of -12 cmH2O. Histopathological analysis of the lungs was scored by blinded, independent reviewers. Of note, all animals were chemically paralyzed for the experiments to suppress gasping at ITPR pressures below -6 cmH2O. RESULTS: Adequate shock was induced in the hemorrhage model, with the MAP being decreased in the Hem and ITPR/Hem group compared with Sham and ITPR/Sham, respectively, at all time points (Hem 54.2 ± 6.5 mmHg vs. 88.0 ± 13.9 mmHg, p < 0.01, -12 cmH2O; ITPR/Hem 59.5 ± 14.4 mmHg vs. 86.7 ± 12.1 mmHg, p < 0.01, -12 cmH2O). In addition, the PaO2/FIO2 ratio was appropriately decreased in Hem/ALI compared with Sham and Hem groups (231.6 ± 152.5 vs. 502.0 ± 24.6 (Sham) p < 0.05 vs. 463.6 ± 10.2, (Hem) p < 0.01, -12 cmH2O). Heart rate was consistently higher in the ITPR/Hem/ALI group compared with the Hem/ALI group (255 ± 26 bpm vs. 150.6 ± 62.3 bpm, -12 cmH2O) and higher in the ITPR/Hem group compared with Hem. Respiratory rate (adjusted to maintain pH) was also higher in the ITPR/Hem/ALI group compared with Hem/ALI at -9 and - 12 cmH2O (32.8 ± 3.0 breaths per minute (bpm) vs. 26.8 ± 3.6 bpm, -12 cmH2O) and higher in the ITPR/Hem group compared with Hem at -6, -9, and - 12 cmH2O. Lung compliance and end expiratory lung volume (EELV) were both consistently decreased in all three ITPR groups compared with their controls. Histopathologic severity of lung injury was worse in the ITPR and ALI groups compared with their respective injured controls or Sham. CONCLUSION: In this swine polytrauma model, we demonstrated successful establishment of hemorrhage and combined hemorrhage/ALI models. While ITPR did not demonstrate a benefit for MAP or ICP, our data demonstrate that the ITPR device induced tachycardia with associated increase in cardiac output, as well as tachypnea with decreased lung compliance, EELV, PaO2/FIO2 ratio, and worse histopathologic lung injury. Therefore, implementation of the ITPR device in the setting of polytrauma may compromise pulmonary function without significant hemodynamic improvement.

Accuracy of the oxygen cylinder duration calculator of the LTV-1000 portable ventilator.

BACKGROUND: Resource planning is essential for successful transport of the mechanically ventilated patient. Mechanically ventilated patients require adequate oxygen supplies to ensure transport is completed without incident. The LTV-1000 portable ventilator utilizes a program to calculate oxygen cylinder duration, based on cylinder size, fraction of inspired oxygen (F(IO(2))), and current minute ventilation. We evaluated the accuracy of the cylinder-duration algorithm in a laboratory setting. METHODS: The LTV-1000 was attached to a test lung. Lung compliance was set at 0.04 L/cm H(2)O, and airway resistance was 5.0 cm H(2)O/L/s. We tested 7 different combinations of ventilator settings a minimum of 2 times each. With each setting, minute ventilation was kept at 10 L/min. Breath type, positive end-expiratory pressure, and F(IO(2)) were varied to evaluate the accuracy of the algorithm across a range of clinical scenarios. The cylinder-duration calculation from the ventilator program and manual calculation was determined at each setting and compared to the actual cylinder duration. RESULTS: The ventilator algorithm and the manual calculation underestimated the actual cylinder duration by 12 +/- 3% with each test. The range of differences between calculated and actual cylinder duration was 2-26 min across the 7 conditions. CONCLUSION: Actual cylinder duration averaged 12% longer than the cylinder duration estimated by the algorithm of the LTV-1000. One explanation is that the E cylinders may contain more liters of oxygen than indicated by the sticker on the side of the tank. Additionally, the bias flow during expiration is affected by inspiratory-expiratory ratio and respiratory rate. Clinicians should be aware of these differences when planning for patient transport.

Impact of Oxygenation Status on the Noninvasive Measurement of Hemoglobin.

BACKGROUND: Noninvasive monitoring of hemoglobin (SpHgb) via pulse oximetry has the potential to alert caregivers to blood loss. Previous studies have demonstrated that changes in oxygenation may impact accuracy. METHODS: Twenty normal volunteers were monitored using SpHgb at sea level, during ascent to 14,000 feet, at 14,000 feet with 100% oxygen delivery, and again at sea level. Each period consisted of 15 minutes of monitoring. SpHgb measurements were compared to a blood sample using Bland Altman analysis. The loss of the SpHgb signal was also recorded. RESULTS: The mean difference in measured hemoglobin (Hgb) between a venous sample and SpHgb was -2.6 ± 0.96 at 14,000 feet. Ascent to 14,000 feet resulted in a predictable fall in SpO2 and was associated with loss of the SpHgb signal for half the period of observation (7.4 minutes). In the other three conditions, SpHgb signal was missing 1 to 12.6% of the time. The nadir SpO2 was not predictive of the loss of SpHgb signal. DISCUSSION: Changes in oxygenation in normal volunteers are associated with short-term SpHgb signal loss (<10 minutes), but no impact on the measured SpHgb.