Heterologous expression in Escherichia coli of Neurospora crassa neutral trehalase as an active enzyme.

Neutral trehalase from Neurospora crassa was expressed in Escherichia coli as a polypeptide of approximately 84 kDa in agreement with the theoretical size calculated from the corresponding cDNA. The recombinant neutral trehalase, purified by affinity chromatography exhibited a specific activity of 80-150 mU/mg protein. Optima of pH and temperature were 7.0 and 30 degrees C, respectively. The enzyme was absolutely specific for trehalose, and was quite sensitive to incubation at 40 degrees C. The recombinant enzyme was totally dependent on calcium, and was inhibited by ATP, copper, silver, aluminium and cobalt. K(M) was 42 mM, and V(max) was 30.6 nmol of glucose/min. The recombinant protein was phosphorylated by cAMP-dependent protein kinase, but not significantly activated. Immunoblotting with polyclonal antiserum prepared against the recombinant protein showed that neutral trehalase protein levels increased during exponential phase of N. crassa growth and dropped at the stationary phase. This is the first report of a neutral trehalase produced in E. coli with similar biochemical properties described for fungi native neutral trehalases, including calcium-dependence.

Fructose-1,6-bisphosphate couples glycolytic flux to activation of Ras.

Yeast and cancer cells share the unusual characteristic of favoring fermentation of sugar over respiration. We now reveal an evolutionary conserved mechanism linking fermentation to activation of Ras, a major regulator of cell proliferation in yeast and mammalian cells, and prime proto-oncogene product. A yeast mutant (tps1∆) with overactive influx of glucose into glycolysis and hyperaccumulation of Fru1,6bisP, shows hyperactivation of Ras, which causes its glucose growth defect by triggering apoptosis. Fru1,6bisP is a potent activator of Ras in permeabilized yeast cells, likely acting through Cdc25. As in yeast, glucose triggers activation of Ras and its downstream targets MEK and ERK in mammalian cells. Biolayer interferometry measurements show that physiological concentrations of Fru1,6bisP stimulate dissociation of the pure Sos1/H-Ras complex. Thermal shift assay confirms direct binding to Sos1, the mammalian ortholog of Cdc25. Our results suggest that the Warburg effect creates a vicious cycle through Fru1,6bisP activation of Ras, by which enhanced fermentation stimulates oncogenic potency.Yeast and cancer cells both favor sugar fermentation in aerobic conditions. Here the authors describe a conserved mechanism from yeast to mammals where the glycolysis intermediate fructose-1,6-bisphosphate binds Cdc25/Sos1 and couples increased glycolytic flux to increased Ras proto-oncoprotein activity.

Uncoupling of the glucose growth defect and the deregulation of glycolysis in Saccharomyces cerevisiae Tps1 mutants expressing trehalose-6-phosphate-insensitive hexokinase from Schizosaccharomyces pombe.

In the yeast Saccharomyces cerevisiae inactivation of trehalose-6-phosphate (Tre6P) synthase (Tps1) encoded by the TPS1 gene causes a specific growth defect in the presence of glucose in the medium. The growth inhibition is associated with deregulation of the initial part of glycolysis. Sugar phosphates, especially fructose-1,6-bisphosphate (Fru1,6bisP), hyperaccumulate while the levels of ATP, Pi and downstream metabolites are rapidly depleted. This was suggested to be due to the absence of Tre6P inhibition on hexokinase. Here we show that overexpression of Tre6P (as well as glucose-6-phosphate (Glu6P))-insensitive hexokinase from Schizosaccharomyces pombe in a wild-type strain does not affect growth on glucose but still transiently enhances initial sugar phosphate accumulation. We have in addition replaced the three endogenous glucose kinases of S. cerevisiae by the Tre6P-insensitive hexokinase from S. pombe. High hexokinase activity was measured in cell extracts and growth on glucose was somewhat reduced compared to an S. cerevisiae wild-type strain but expression of the Tre6P-insensitive S. pombe hexokinase never caused the typical tps1Delta phenotype. Moreover, deletion of TPS1 in this strain expressing only the Tre6P-insensitive S. pombe hexokinase still resulted in a severe drop in growth capacity on glucose as well as sensitivity to millimolar glucose levels in the presence of excess galactose. In this case, poor growth on glucose was associated with reduced rather than enhanced glucose influx into glycolysis. Initial glucose transport was not affected. Apparently, deletion of TPS1 causes reduced activity of the S. pombe hexokinase in vivo. Our results show that Tre6P inhibition of hexokinase is not the major mechanism by which Tps1 controls the influx of glucose into glycolysis or the capacity to grow on glucose. In addition, they show that a Tre6P-insensitive hexokinase can still be controlled by Tps1 in vivo.

Development of a D-xylose fermenting and inhibitor tolerant industrial Saccharomyces cerevisiae strain with high performance in lignocellulose hydrolysates using metabolic and evolutionary engineering.

BACKGROUND: The production of bioethanol from lignocellulose hydrolysates requires a robust, D-xylose-fermenting and inhibitor-tolerant microorganism as catalyst. The purpose of the present work was to develop such a strain from a prime industrial yeast strain, Ethanol Red, used for bioethanol production. RESULTS: An expression cassette containing 13 genes including Clostridium phytofermentans XylA, encoding D-xylose isomerase (XI), and enzymes of the pentose phosphate pathway was inserted in two copies in the genome of Ethanol Red. Subsequent EMS mutagenesis, genome shuffling and selection in D-xylose-enriched lignocellulose hydrolysate, followed by multiple rounds of evolutionary engineering in complex medium with D-xylose, gradually established efficient D-xylose fermentation. The best-performing strain, GS1.11-26, showed a maximum specific D-xylose consumption rate of 1.1 g/g DW/h in synthetic medium, with complete attenuation of 35 g/L D-xylose in about 17 h. In separate hydrolysis and fermentation of lignocellulose hydrolysates of Arundo donax (giant reed), spruce and a wheat straw/hay mixture, the maximum specific D-xylose consumption rate was 0.36, 0.23 and 1.1 g/g DW inoculum/h, and the final ethanol titer was 4.2, 3.9 and 5.8% (v/v), respectively. In simultaneous saccharification and fermentation of Arundo hydrolysate, GS1.11-26 produced 32% more ethanol than the parent strain Ethanol Red, due to efficient D-xylose utilization. The high D-xylose fermentation capacity was stable after extended growth in glucose. Cell extracts of strain GS1.11-26 displayed 17-fold higher XI activity compared to the parent strain, but overexpression of XI alone was not enough to establish D-xylose fermentation. The high D-xylose consumption rate was due to synergistic interaction between the high XI activity and one or more mutations in the genome. The GS1.11-26 had a partial respiratory defect causing a reduced aerobic growth rate. CONCLUSIONS: An industrial yeast strain for bioethanol production with lignocellulose hydrolysates has been developed in the genetic background of a strain widely used for commercial bioethanol production. The strain uses glucose and D-xylose with high consumption rates and partial cofermentation in various lignocellulose hydrolysates with very high ethanol yield. The GS1.11-26 strain shows highly promising potential for further development of an all-round robust yeast strain for efficient fermentation of various lignocellulose hydrolysates.