RESUMO
Anaerobic co-digestion of fat-oil-grease (FOG) and food waste (FW) with sewage sludge (SS) in wastewater treatment plants is a method used to increase biogas production. In this study, digestion scenarios were compared using plant-wide modeling and life cycle assessment: Scenario-0 (mono-digestion of waste-activated sludge (WAS)), Scenario-1 (co-digestion of WAS with FOG), and Scenario-2 (co-digestion of WAS with FW). Scenario-0, with the highest energy use and landfilling of FOG/FW, has the worst environmental impact. Scenario-1 and Scenario-2 minimize the environmental load by energy recovery and avoiding landfilling of organic waste. Scenario-wise, the change in greenhouse gas (GHG) emissions from treatment was negligible. However, due to the impact of landfilling, GHG emissions in Scenario-0 were 21% and 30% higher than in Scenario-1 and 2, respectively. The environmental benefit of anaerobic co-digestion of FOG/FW with SS is not only in the contribution to energy production but also in the recycling of organic waste.
Assuntos
Gases de Efeito Estufa , Eliminação de Resíduos , Animais , Esgotos , Perda e Desperdício de Alimentos , Alimentos , Metano/análise , Hidrocarbonetos , Biocombustíveis/análise , Estágios do Ciclo de Vida , Digestão , Anaerobiose , Reatores BiológicosRESUMO
Recently, one of the main purposes of wastewater treatment plants is to achieve a neutral or positive energy balance while meeting the discharge criteria. Aerobic granular sludge (AGS) technology is a promising technology that has low energy and footprint requirements as well as high treatment performance. The effect of co-treatment of municipal wastewater and food waste (FW) on the treatment performance, granule morphology, and settling behavior of the granules was investigated in the study. A biochemical methane potential (BMP) test was also performed to assess the methane potential of mono- and co-digestion of the excess sludge from the AGS process. The addition of FW into wastewater enhanced the nutrient treatment efficiency in the AGS process. BMP of the excess sludge from the AGS process fed with the mixture of wastewater and FW (195 ± 17 mL CH4/g VS) was slightly higher than BMP of excess sludge from the AGS process fed with solely wastewater (173 ± 16 mL CH4/g VS). The highest methane yield was observed for co-digestion of excess sludge from the AGS process and FW, which was 312 ± 8 mL CH4/g VS. Integration of FW as a co-substrate in the AGS process would potentially enhance energy recovery and the quality of effluent in municipal wastewater treatment.
Assuntos
Esgotos , Eliminação de Resíduos Líquidos , Águas Residuárias , Esgotos/química , Águas Residuárias/química , Eliminação de Resíduos Líquidos/métodos , Metano , Alimentos , Reatores Biológicos , Perda e Desperdício de AlimentosRESUMO
The disintegration of raw sludge is of importance for enhancing biogas production and facilitates the degradation of substrates for microorganisms so that the efficiency of digestion can be increased. In this study, the effect of hydrodynamic cavitation (HC) as a pretreatment approach for waste activated sludge (WAS) was investigated at two upstream pressures (0.83 and 1.72 MPa) by using a milli-scale apparatus which makes sludge pass through an orifice with a restriction at the cross section of the flow. The HC probe made of polyether ether ketone (PEEK) material was tested using potassium iodide solution and it was made sure that cavitation occurred at the selected pressures. The analysis on chemical effects of HC bubbles collapse suggested that not only cavitation occurred at low upstream pressure, i.e., 0.83 MPa, but it also had high intensity at this pressure. The pretreatment results of HC implementation on WAS were also in agreement with the chemical characterization of HC collapse. Release of soluble organics and ammonium was observed in the treated samples, which proved the efficiency of the HC pretreatment. The methane production was improved during the digestion of the treated samples compared to the control one. The digestion of treated WAS sample at lower upstream pressure (0.83 MPa) resulted in higher methane production (128.4 mL CH4/g VS) compared to the treated sample at higher upstream pressure (119.1 mL CH4/g VS) and control sample (98.3 mL CH4/g VS). Thus, these results showed that the HC pretreatment for WAS led to a significant increase in methane production (up to 30.6%), which reveals the potential of HC in full-scale applications.
Assuntos
Hidrodinâmica , Metano , Esgotos , Eliminação de Resíduos Líquidos , Esgotos/química , Eliminação de Resíduos Líquidos/métodos , Metano/metabolismo , Biocombustíveis/análise , Reatores BiológicosRESUMO
The objective of this study is to develop a mechanistic model to predict the long-term dynamic performance of High-Rate Activated Sludge (HRAS) process, including the removal of carbon (COD), nitrogen (N), and phosphorus (P). The model was formulated with inspiration from Activated Sludge Models No. 1 and 3 (ASM1 and ASM3) to incorporate essential mechanisms, such as adsorption and storage substrate, specific to HRAS systems. A stepwise protocol was followed for calibration with dynamic data from a pilot-scale HRAS plant. Sensitivity analysis identified influential model parameters, including maximum specific growth rate (µ), growth yield (YH), storage yield (YSTO), storage rate (kSTO), decay rate (b), and half saturation of the readily biodegradable substrate for growth (KS1). The calibrated model achieved prediction efficiencies above the normalized Mean Absolute Error (MAE) of 70 % for mixed liquor suspended solids (MLSS), total chemical oxygen demand (TCOD), soluble COD (SCOD), particulate COD (XCOD), total nitrogen (TN), ammonia nitrogen (SNH), total phosphorus (TP), soluble TP (STP), and particulate TP (XTP). Uncertainty analysis revealed that SCOD was underestimated. Based on the dynamic profiles of uncertainty bands and observed data, there is potential for improving the estimation of dynamic behavior in STP. The observed discrepancies may be attributed to variations in wastewater characteristics during the monitoring period, particularly concerning the phosphorus (P) fractions of the readily biodegradable substrate (SS) and soluble inerts (SI), which were not considered as dynamically changing parameters in the model.
RESUMO
Biogas production from anaerobic sludge digestion plays a central role for wastewater treatment plants to become more energy-efficient or even energy-neutral. Dedicated configurations have been developed to maximize the diversion of soluble and suspended organic matter to sludge streams for energy production through anaerobic digestion, such as A-stage treatment or chemically enhanced primary treatment (CEPT) instead of primary clarifiers. Still, it remains to be investigated to what extent these different treatment steps affect the sludge characteristics and digestibility, which may also impact the economic feasibility of the integrated systems. In this study, a detailed characterization has been performed for sludge obtained from primary clarification (primary sludge), A-stage treatment (A-sludge) and CEPT. The characteristics of all sludges differed significantly from each other. The organic compounds in primary sludge consisted mainly of 40% of carbohydrates, 23% of lipids, and 21% of proteins. A-sludge was characterized by a high amount of proteins (40%) and a moderate amount of carbohydrates (23%), and lipids (16%), while in CEPT sludge, organic compounds were mainly 26% of proteins, 18% of carbohydrates, 18% of lignin, and 12% of lipids. The highest methane yield was obtained from anaerobic digestion of primary sludge (347 ± 16 mL CH4/g VS) and A-sludge (333 ± 6 mL CH4/g VS), while it was lower for CEPT sludge (245 ± 5 mL CH4/g VS). Furthermore, an economic evaluation has been carried out for the three systems, considering energy consumption and recovery, as well as effluent quality and chemical costs. Energy consumption of A-stage was the highest among the three configurations due to aeration energy demand, while CEPT had the highest operational costs due to chemical use. Energy surplus was the highest by the use of CEPT, resulting from the highest fraction of recovered organic matter. By considering the effluent quality of the three systems, CEPT had the highest benefits, followed by A-stage. Integration of CEPT or A-stage, instead of primary clarification in existing wastewater treatment plants, would potentially improve the effluent quality and energy recovery.
Assuntos
Esgotos , Eliminação de Resíduos Líquidos , Esgotos/química , Eliminação de Resíduos Líquidos/métodos , Águas Residuárias , Metano/metabolismo , Carboidratos , Lipídeos , Reatores Biológicos , AnaerobioseRESUMO
Coagulants such as aluminum sulfate (Al2(SO4)3 (alum)) and ferric chloride (FeCl3) used in water treatment plants (WTPs) led to the generation of sludge that is usually disposed to landfills. However, the utilization of WTP sludge is being encouraged by authorities to achieve sustainable development. This study aims to investigate WTP sludge utilization in a pilot-scale high-rate activated sludge (HRAS) system as a substitute for conventional coagulants. Based on jar tests, the iron sludge was selected for pilot-scale testing due to its superior ability to enhance the treatment efficiency of the HRAS process compared to alum sludge. Iron sludge addition (20.1 ± 1.6 mg dry sludge/L wastewater) slightly improved the removal efficiency of particulate chemical oxygen demand (pCOD) from 74 % to 81 % (p-value: 0.014). Iron sludge addition had a distinct effect on the sludge characteristics of the HRAS process. The average median particle size (d50) increased from 96 ± 3 to 163 ± 14 µm (p-value<0.00) with the addition of iron sludge, which improved the settleability of the HRAS process sludge. However, the biochemical methane potential (BMP) of the HRAS process sludge decreased by 8.9 % (p-value<0.00) after iron sludge addition. In a scenario analysis of WTP sludge use in a hypothetical HRAS plant, the effluent quality index (EQI), an indicator of environmental impact, was calculated and the cost related to the operation (the transfer and landfill disposal of WTP and HRAS process sludge, energy and chemical consumption of the HRAS plant) was estimated. As a result, using WTP sludge in the HRAS plant did not significantly affect the EQI of the plant but decreased overall cost by 11 %. The results showed that the use of WTP sludge as a coagulant in wastewater treatment could achieve mutual benefits for WTPs and WWTPs and have the potential to realize the circular economy model.
Assuntos
Esgotos , Purificação da Água , Eliminação de Resíduos Líquidos/métodos , Ferro , Purificação da Água/métodosRESUMO
BACKGROUND: Acute appendicitis (AA) is one of the most common causes of abdominal pain in patients presenting to the emergency department with abdominal pain, and despite developments in radiological imaging for its diagnosis, researchers are still in pursuit of a simpler, cheaper, and safer biomarker. Our study investigated the usability of the neutrophil-albumin ratio, a biomarker that predicts prognosis in cases with severe inflammation, in diagnosing AA and anticipating perforation. METHODS: Our study is a retrospective and cross-sectional study. The study was conducted with patients who presented to the emergency department between January 2018 and December 2020 and were hospitalized with a preliminary diagnosis of AA. The cases were first divided into two groups as 'Not appendicitis' and 'AA,' and then the patients with 'AA' were divided into two subgroups as 'Perforated' and 'Non-perforated.' The demographic data of the patients, their symptoms, physical examination findings, and the decision-making process for surgery were noted. The neutrophil count and albumin levels detected in the blood samples obtained at the time of admission to the emergency department were noted. Afterward, the neutrophil-albumin ratio (NAR) was calculated and the cutoff level was determined to predict the diagnosis of AA and the development of perforation. RESULTS: The rate of complaints of pain in the periumbilical region was significantly higher in the patient group without AA compared to the patients in the AA group (70.6% and 40.3%, p=0.034). Although the leukocyte count, neutrophil count and percentage, and NAR were significantly higher in the AA group, the lymphocyte count was found to be significantly lower (p=0.005). However, no significant correlation was found between the NAR and the development of perforation (p=0.697). CONCLUSION: The NAR is useful for the diagnosis of AA. Nevertheless, it is not a sufficient biomarker for detecting perforation.
Assuntos
Apendicite , Neutrófilos , Humanos , Estudos Retrospectivos , Estudos Transversais , Contagem de Leucócitos , Biomarcadores , Albuminas , Dor Abdominal , Apendicite/cirurgia , Doença Aguda , Proteína C-Reativa/análiseRESUMO
Energy-rich sludge can be obtained from primary clarifiers preceding biological reactors. Alternatively, the incoming wastewater can be sent to a very-high-loaded activated sludge system, i.e., a so-called A-stage. However, the effects of applying an A-stage instead of a primary clarifier, on the subsequent sludge digestion for long-term operation is still unknown. In this study, biogas production and permeate quality, and filterability characteristics were investigated in a lab-scale anaerobic membrane bioreactor for primary sludge and A-stage sludge (A-sludge) treatment. A higher specific methane yield was obtained from digestion of A-sludge compared to primary sludge. Similarly, specific methanogenic activity was higher when the anaerobic membrane bioreactor was fed with A-sludge compared to primary sludge. Plant-wide mass balance analysis indicated that about 35% of the organic matter in wastewater was recovered as methane by including an A-stage, compared to about 20% with a primary clarifier.
Assuntos
Esgotos , Purificação da Água , Anaerobiose , Reatores Biológicos , Metano , Eliminação de Resíduos Líquidos , Águas ResiduáriasRESUMO
Conventional activated sludge (CAS) process is one of the most commonly applied processes for municipal wastewater treatment. However, it requires a high energy input and does not promote energy recovery. Currently, high-rate activated sludge (HRAS) process is gaining importance as a good option to reduce the energy demand of wastewater treatment and to capture organic matter for valorizing through anaerobic digestion (AD). Besides, food waste addition to wastewater can help to increase the organic matter content of wastewater and thus, energy recovery in AD. The objective of this study is to evaluate the applicability of co-treatment of municipal wastewater and food waste in a pilot-scale HRAS system as well as to test the minimal hydraulic retention times (HRTs) such as 60 and 30 min. Food waste addition to the wastewater resulted in a 10% increase in chemical oxygen demand (COD) concentration of influent. In the following stages of the study, the pilot-scale system was operated with wastewater solely under the HRTs of 60 and 30 min. With the decrease of HRT, particulate COD removal increased; however, soluble COD removal decreased. The results demonstrated that if the settling process is optimized, more particulate matter can be diverted to sludge stream.
Assuntos
Alimentos , Eliminação de Resíduos Líquidos/métodos , Anaerobiose , Análise da Demanda Biológica de Oxigênio , Reatores Biológicos , Projetos Piloto , Esgotos , Eliminação de Resíduos Líquidos/instrumentação , Águas Residuárias/químicaRESUMO
Life cycle assessment (LCA) is a beneficial tool to evaluate the performance of wastewater treatment plants (WWTPs) and to compare different upgrading options. The main objective of this study is to investigate the environmental impact of upgrading options of a preliminary WWTP in Istanbul, Turkey. The preliminary plant currently consists of mechanical treatment units and various upgrading options including primary treatment and high-rate activated sludge system (HRAS) process as well as the addition of food waste to wastewater were compared. Results showed that the baseline scenario (S0) had worse performance than all future scenarios (S1-3) except for climate change. The scenario of adding food waste to wastewater (S3) has the best performance in climate change, terrestrial acidification, terrestrial ecotoxicity and fossil depletion. Increased addition of food waste was also tested in the sensitivity analysis, and major improvements were obtained especially in climate change and terrestrial ecotoxicity.
Assuntos
Eliminação de Resíduos Líquidos , Águas Residuárias , Meio Ambiente , Aditivos Alimentares , EsgotosRESUMO
The main aim of the study was to evaluate the co-digestion performance of OFMSW with different wastes. Leachate, reverse osmosis (RO) concentrate collected from a leachate treatment facility and dewatered sewage sludge taken from a wastewater treatment plant (WWTP) were used for co-digestion in this paper. An extra effort was made to observe the effect of leachate inclusion in the co-digestion. In the study, the mono-digestion of OFMSW, leachate, RO concentrate and sewage sludge as well as digestion of 7 different waste mixtures were carried out for this objective. The experiments were carried out for approximately 50days under mesophilic conditions. The highest methane yield was 785L CH4/kg VSadded in the reactor, which had only OFMSW. While the methane yield derived from OFMSW was found higher than previous studies, methane yield of leachate was found to be 110L CH4/kg VSadded, which was lower than findings in the literature. The mono-substrate of OFMSW was followed by the reactor of having waste mixture of leachate+sewage sludge+OFMSW+water (C7) with 391L CH4/kg VSadded, which was the only combination included water. In order to understand the effect of leachate and water inclusions on co-digestion, two separate waste combinations; leachate+sewage sludge+OFMSW+water (C7) and leachate+sewage sludge+OFMSW (C1) were prepared that had different amounts of leachate but same amounts of other wastes. The methane yield of leachate+sewage sludge+OFMSW+water (C7) indicated that addition of some water instead of leachate could stimulate biogas production. Methane yield of this reactor was found to be 71% higher than the waste combination of leachate+sewage sludge+OFMSW (C1). It could be thought that the high amount of non-biodegradable matters in leachate could be responsible for lower methane yield in leachate+sewage sludge+OFMSW (C1) reactor. Methane yields of the reactors showed that co-digestion of OFMSW and leachate could be a solution not only for treatment of leachate and but also increasing the biogas potential of leachate. Leachate addition could also adjust optimum total solids (TS) content in anaerobic digestion. It was also understood that RO concentrate did not affect the methane yield in a negative way. The similar characterization of leachate and RO concentrate in this study could offer the utilization of RO concentrate instead of leachate. The findings showed that volatile solids (VS) removals were changed from 32% to 61% in the reactors. While the reactor of leachate+RO concentrate+OFMSW (C6) had the highest VS removal, the reactor of the sole substrate leachate had the lowest VS removal.