In vitro toxicity assessment of nanocrystals in tissue-type cells and macrophage cells.

Nanocrystals (NCs), a type of innovative material particle, are a potential drug delivery platform that aims to improve the bioavailability of hydrophobic drugs. However, due to the lack of consideration of their toxicity, existing studies have not investigated whether the nanoscale properties of NCs, such as particle sizes, may lead to NC-induced toxicity. Because of the disparity between the rapid development of NCs and the lack of studies regarding NC toxicity, the present study investigated possible NC toxicity and clarified the relationship between particle sizes and NC toxicity. RAW264.7 and HepG2 cells were chosen as representatives of macrophage cells and tissue-type cells, respectively. Monosodium urate NCs were used as a drug model. Different particle sizes of monosodium urate NCs were prepared using precipitation methods. Methyl tetrazolium, lactate dehydrogenase, oxidative stress and apoptosis/necrosis assays were then used to evaluate cell damage and recovery. The results showed that small NC particle sizes produced higher toxicity than larger ones. In immune cells, these cytotoxic effects were greater than in tissue cells. After removal of small NCs, tissue cell damage could be significantly reversed, while immune cells were only slightly restored. However, after removal of large NCs, both cell types had almost no recovery. In summary, despite conventional wisdom, our research confirmed that NCs are not very safe and that NC particle sizes are closely related to the degree of NC toxicity.

Apoferritin Nanocage for Brain Targeted Doxorubicin Delivery.

An ideal brain-targeted nanocarrier must be sufficiently potent to penetrate the blood-brain barrier (BBB) and sufficiently competent to target the cells of interest with adequate optimized physiochemical features and biocompatibility. However, it is an enormous challenge to the researchers to organize the above-mentioned properties into a single nanocarrier particle. New frontiers in nanomedicine are advancing the research of new biomaterials. Herein, we demonstrate a straightforward strategy for brain targeting by encapsulating doxorubicin (DOX) into a naturally available and unmodified apoferritin nanocage (DOX-loaded APO). APO can specifically bind to cells expressing transferrin receptor 1 (TfR1). Because of the high expression of TfR1 in both brain endothelial and glioma cells, DOX-loaded APO can cross the BBB and deliver drugs to the glioma with TfR1. Subsequent research demonstrated that the DOX-loaded APO had good physicochemical properties (particle size of 12.03 ± 0.42 nm, drug encapsulation efficiency of 81.8 ± 1.1%) and significant penetrating and targeting effects in the coculture model of bEnd.3 and C6 cells in vitro. In vivo imaging revealed that DOX-loaded APO accumulated specifically in brain tumor tissues. Additionally, in vivo tumor therapy experiments (at a dosage of 1 mg/kg DOX) demonstrated that a longer survival period was observed in mice that had been treated with DOX-loaded APO (30 days) compared with mice receiving free DOX solution (19 days).

Chiral analysis of ammuxetine enantiomers in dog plasma using online SPE/liquid chromatography with tandem mass spectrometric detection after precolumn chiral derivatization.

Ammuxetine (AMT), a novel chiral antidepressant candidate compound, exhibits better antidepression effects than duloxetine in different animal models. In this article, a chiral derivatization method, combined with online solid phase extraction (online SPE) and liquid chromatography-tandem mass spectrometry (LC-MS/MS), was developed for the chiral separation of AMT enantiomers after administration of racemic AMT to dogs. The derivatization reaction employed 2,3,4,6-tetra-O-acetyl-b-glucopyr-anosyl isothiocyanate (GITC) as a precolumn chiral derivatization reagent. A SPE column Retain PEP Javelin (10 × 2.1 mm) was used to remove proteins and other impurities in plasma samples. The enantiomeric derivatives were separated on a ZORBAX SB-C18 column (50 × 2.1 mm × 3.5 µm) with an isocratic elution procedure. The selected multiple reaction monitoring mode of the positive ion was performed and the parent to the product transitions m/z 681.0/543.1 and m/z 687.4/543.1 were used to measure the derivatives of AMT and duloxetine (internal standard) with electrospray ionization. The method was validated in terms of specificity, linearity, sensitivity, precision, accuracy, matrix effect, and stability. The method was applied to a pharmacokinetics study of AMT racemate in dogs. The results suggested that the pharmacokinetic of AMT enantiomers might be stereoselective in dogs.

Simultaneous determination of metolazone and valsartan in plasma by on-line SPE coupled with liquid chromatography/tandem mass spectrometry.

Combination of metolazone (0.5 mg) and valsartan (80 mg) has been verified as a promising therapy treatment for hypertension. In order to facilitate to pharmacokinetic research, it needs a method for the simultaneously determination of metolazone and valsartan in biological samples. However, there are no relative reports so far. In order to facilitate to pharmacokinetic research, an on-line solid phase extraction coupled with liquid chromatography-tandem mass spectrometry method for the simultaneous determination of metolazone and valsartan in beagle dog plasma was developed and validated in this study. An on-line solid phase extraction column Retain PEP Javelin (10 mm × 2.1 mm) was used to remove impurities in plasma samples. The metolazone, valsartan and internal standard (losartan) were separated on a Poroshell 120 SB-C18 column (4.6 mm × 50 mm × 2.7 µm) with a gradient elution procedure. Acidified acetonitrile/water mixture was used as a mobile phase. The selected multiple-reaction monitoring mode in positive ion was performed and the parent to the product transitions m/z 366/259, m/z 436.2/291 and m/z 423.4/207 were used to measure the metolazone, valsartan and losartan. The method was linear over the range of 0.1-100 ng/mL and 1-1000 ng/mL for metolazone and valsartan, respectively. This method was validated in terms of specificity, linearity, sensitivity, precision, accuracy, matrix effect, and stability and then successfully applied to pharmacokinetic studies of the metolazone and valsartan combination tablets in beagle dogs.

Does Thermosensitive Liposomal Vinorelbine Improve End-Point Survival after Percutaneous Radiofrequency Ablation of Liver Tumors in a Mouse Model?

Purpose To investigate the role of thermosensitive liposome-encapsulated vinorelbine (Thermo-Vin) in combined radiofrequency (RF) ablation of liver tumors. Materials and Methods Approval from the institutional animal care and use committee was obtained before this study. First, the anticancer efficacy of Thermo-Vin was assessed in vitro (H22 cells) for 72 hours at 37°C or 42°C. Next, 203 H22 liver adenocarcinomas were implanted in 191 mice for in vivo study. Tumors were randomized into seven groups: (a) no treatment, (b) treatment with RF ablation alone, (c) treatment with RF ablation followed by free vinorelbine (Free-Vin) at 30 minutes, (d) treatment with RF ablation followed by empty liposomes (Empty-Lip+RF), (e) treatment with RF ablation followed by Thermo-Vin (5 mg/kg), (f) treatment with RF ablation followed by Thermo-Vin (10 mg/kg), and (g) treatment with RF ablation followed by Thermo-Vin (20 mg/kg). Tumor destruction areas and pathologic changes were compared for different groups at 24 and 72 hours after treatment. Kaplan-Meier analysis was used to compare end-point survival (tumor < 30 mm in diameter). Additionally, the effect of initial tumor size on long-term outcome was analyzed. Results In vitro, both Free-Vin and Thermo-Vin dramatically inhibited H22 cell viability at 24 hours. Likewise, in vivo, 10 mg/kg Thermo-Vin+RF ablation increased tumor destruction compared with RF ablation (P = .001). Intratumoral vinorelbine accumulation with Thermo-Vin+RF increased 15-fold compared with Free-Vin alone. Thermo-Vin substantially increased apoptosis at the coagulation margin and suppressed cellular proliferation in the residual tumor (P < .001). The Thermo-Vin+RF study arm also had better survival than the arm treated with RF ablation alone (mean, 37.6 days ± 20.1 vs 23.4 days ± 5.0; P = .001), the arm treated with Free-Vin+RF (23.3 days ± 1.2, P = .002), or the arm treated with Empty-Lip+RF (20.8 days ± 0.4, P < .001) in animals with medium-sized (10-12-mm) tumors. No significant difference in end-point survival was noted in the treatment arms with large or small tumors. Conclusion Thermo-Vin can effectively increase tumor destruction and improve animal survival. End-point survival is most affected in animals with medium-sized tumors, suggesting that combination therapy should be tailored to tumor size and the expected volume of ablation of the device used. (©) RSNA, 2016 Online supplemental material is available for this article.

Polymer Nanoparticles Modified with Photo- and pH-Dual-Responsive Polypeptides for Enhanced and Targeted Cancer Therapy.

The cationic nature of cell penetrating peptides (CPPs) and their absence of cell selectivity restrains their applications in vivo. In this work, polymer nanoparticles (NPs) modified with photo- and pH-responsive polypeptides (PPPs) were successfully developed and respond to near-infrared (NIR) light illumination at the tumor site and a lowered tumor extracellular pH (pHe). In PPPs, the internalization function of CPPs (positively charged) is quenched by a pH-sensitive inhibitory peptide (negatively charged), which is linked via a photocleavable group. Small interfering RNA (siRNA) was loaded into NPs by a double-emulsion technique. In vivo experiments included siRNA loading, cellular uptake, cell apoptosis, siRNA transfection, tumor targeting delivery, and the in vivo antitumor efficacy. Results showed that the prepared PPP-NPs could selectively accumulate at the tumor sites and internalized into the tumor cells by the NIR light illumination and the lowered pHe at the tumor site. These studies demonstrated that PPP-NPs are a promising carrier for future tumor gene delivery.

Thermo-Sensitive Liposome co-Loaded of Vincristine and Doxorubicin Based on Their Similar Physicochemical Properties had Synergism on Tumor Treatment.

PURPOSE: To develop vincristine (VCR) and doxorubicin (DOX) co-encapsulated thermo-sensitive liposomes (VD-TSL) against drug resistance, with increased tumor inhibition rate and decreased system toxicity, improving drug targeting efficiency upon mild hyperthermia (HT) in solid tumor. METHODS: Based on similar physicochemical properties, VCR and DOX were co-loaded in TSL with pH gradient active loading method and characterized. The time-dependent drug release profiles at 37 and 42°C were assessed by HPLC. Then we analysed the phospholipids in filtrate after ultrafiltration and studied VD-TSL stability in mimic in vivo conditions and long-time storage conditions (4°C and -20°C). Cytotoxic effect was studied on PANC and sw-620 using MTT. Intracellular drug delivery was studied by confocal microscopy on HT-1080. In vivo imaging of TSL pharmacokinetic and biodistribution was performed on MCF-7 tumor-bearing nude mice. And therapeutic efficacy on these xenograft models were followed under HT. RESULTS: VD-TSL had excellent particle distribution (about 90 nm), high entrapment efficiency (>95%), obvious thermo-sensitive property, and good stability. MTT proved VD-TSL had strongest cell lethality compared with other formulations. Confocal microscopy demonstrated specific accumulation of drugs in tumor cells. In vivo imaging proved the targeting efficiency of TSL under hyperthermia. Then therapeutic efficacy revealed synergism of VCR and DOX co-loaded in TSL, together with HT. CONCLUSION: VD-TSL could increase drug efficacy and decrease system toxicity, by making good use of synergism of VCR and DOX, as well as high targeting efficiency of TSL.

Synchronous delivery of felodipine and metoprolol tartrate using monolithic osmotic pump technology.

The synchronous sustained-release of two drugs was desired urgently for patients needing combination therapy in long term. However, sophisticated technologies were used generally to realize the simultaneous delivery of two drugs especially those with different physico-chemical properties. The purpose of this study was to obtain the concurrent release of felodipine and metoprolol tartrate, two drugs with completely different solubilities, in a simple monolithic osmotic pump system (FMOP). Two types of blocking agents were used in monolithic osmotic pump tablets and the synchronous sustained-release of FMOP was acquired in vitro. The tablets were also administered to beagle dogs and the plasma levels of FMOP were determined by HPLC-MS/MS. The pharmacokinetic parameters were calculated using a non-compartmental model. Cmax of both felodipine and metoprolol from the osmotic pump tablets were lower, tmax and mean residence time of both felodipine and metoprolol from the osmotic pump tablets were longer significantly than those from immediate release tablets. These results verified prolonged release of felodipine and metoprolol tartrate from osmotic pump formulations. The similar absorption rate between felodipine and metoprolol in beagles was also obtained by this osmotic pump formulation. Therefore, it could be supposed that the accordant release of two drugs with completely different solubilities may be realized just by using monolithic osmotic pump technology.

Development and uniform evaluation of ropinirole osmotic pump tablets with REQUIP XL both in vitro and in beagle dogs.

REQUIP XL, prolonged release formulation of ropinirole hydrochloride (RH) in market, could release ropinirole constantly and showed satisfactory therapeutic effect and good compliance. REQUIP XL was composed of more than 10 kinds of excipients and prepared by Geomatrix technology, which was complex and laborious. The purpose of this study was to obtain a dosage form of RH with similar in vitro release profile and bioequivalence in vivo compared to REQUIP XL. Osmotic pump tablet combined with fast release phase was selected as the delivery system of RH and similar release curves were obtained in different media. The tablets were also administered to beagle dogs and the pharmacokinetic parameters were calculated using a non-compartmental model. Cmax, tmax, mean residence time (MRT), and area under the curve from 0 to 24 h (AUC0-24) were 3.97 ± 0.53 ng/mL, 3.58 ± 0.49 h, 8.29 ± 0.93 h, and 35.20 ± 8.11 ng/mL c h for ropinirole osmotic pump tablets (ROPT) and 4.15 ± 1.07 ng/mL, 2.92 ± 0.49 h, 7.84 ± 1.09 h, and 34.34 ± 10.06 ng/mL c h for REQUIP XL. The log-transformed mean Cmax and AUC0-24 of ROPT were about 92.15% and 102.49% relative to that of REQUIP XL, respectively. The 90% confidence intervals of Cmax and AUC0-24 for ROPT were 75.69-115.31% and 88.89-122.30%, respectively. So it could be concluded that ROPT was uniform with REQUIP XL both in vitro and in beagles and the release profiles of Geomatrix technology may be obtained by osmotic pump combined with fast release technology.

Preparation, release and pharmacokinetics of a risperidone elementary osmotic pump system.

Preparation and in vitro/in vivo evaluation of risperidone elementary osmotic pump (RIS-EOP) formulations were investigated. A method for the preparation of RIS-EOP tablets was developed by modulating RIS solubility with citric acid. The influence of osmotic agents and the compositions of semipermeable membrane on drug release profiles was evaluated. The formulation of RIS-EOP was optimized by orthogonal design. The in vitro release profile of the optimum formulation achieved to deliver RIS at an approximate zero-order up to 12 h. The pharmacokinetic profiles of RIS-EOP were evaluated compared with immediate release tablets in beagle dogs. The mean tmax and mean residence time of RIS-EOP for RIS and its active metabolite, 9-hydroxyrisperidone, were remarkably longer, compared with immediate release tablets. These results corroborated prolonged release of RIS from EOP formulations. Moreover, drug plasma levels with lower fluctuations could be achieved with RIS-EOP tablets. These results suggested that increasing drug solubility by adding or reacting with alkali/acid might be used for the preparation of EOP tablets of certain poorly water-soluble drugs.

A novel accelerated in vitro release method to evaluate the release of thymopentin from PLGA microspheres.

A novel accelerated method of good correlations with "real-time" release to evaluate in vitro thymopentin release from poly (D, L-lactide-co-glycolide) (PLGA) microsphere was developed. Thymopentin-loaded microspheres were made from three types of PLGA, and peptide release was studied in various conditions. Incomplete release of peptide (<60%) from microspheres was found in accelerated testing with two typical release media. This problem was circumvented by adding organic solvents to the release media and varying the temperature in the media heating process. Release media containing three kinds of organic solvents at 50 °C were tested, respectively, and hydro-alcoholic solution was selected for further study. After the surfactant concentration (0.06%, W/V) and ethanol concentration (20%, V/V) were fixed, a gradient heating program, consisting of three stages and each stage with a different temperature, was introduced to enhance the correlations between the short- and long-term release. After adjusting the heating time of each stage, a good correlation (R(2) = 9896, formulation 8 K; R(2) = 0.9898, formulation 13 K; R(2) = 0.9886, formulation 28 K) between accelerated and "real-time" release was obtained. By optimizing the conditions as ethanol concentration and temperature gradients, this accelerated method may be appropriate for similar peptide formulations that not well correlate with "real-time" release.

A novel oral preparation of hydroxysafflor yellow A base on a chitosan complex: a strategy to enhance the oral bioavailability.

Hydroxysafflor yellow A (HSYA), the main active pharmaceutical ingredient of the safflower plant (Carthamus tinctorius L.), is a hydrophilic drug with low oral bioavailability (BA). The objective of the present study was to improve the oral BA of HSYA by formulation design. The effect of several pharmaceutical excipients on enhancing BA, including Poloxamer 188 (P188), sodium caprate (SC), sodium deoxycholate, and ß-cyclodextrin (ß-CD), was investigated through animal models. Sodium caprate, with a relative BA of 284.2%, was able to improve the oral BA of HSYA. Furthermore, HSYA can bind with chitosan (CS) by Coulomb attraction and form a HSYA-CS complex. The preparation process was optimized, and the binding rate reached 99.4%. HSYA granules were prepared using a HSYA-CS complex and SC. The results of the pharmacokinetics showed that the relative BA of HSYA granules was 476%, much higher than HSYA/SC.

[Current status and prospect of translational medicine in nanotechnology].

Nowadays, nanotechnologies have shown wide application foreground in the biomedical field of medicine laboratory tests, drug delivery, gene therapy and bioremediation. However, in recent years, nanomaterials have been labeled poisonous, because of the disputes and misunderstandings of mainstream views on their safety. Besides, for the barriers of technical issues in preparation like: (1) low efficacy (poor PK & PD and low drug loading), (2) high cost (irreproducibility and difficulty in scale up), little of that research has been successfully translated into commercial products. Currently, along with the new theory of "physical damage is the origin of nanotoxicity", biodegradability and biocompatibility of nanomaterials are listed as the basic principle of safe application of nanomaterials. Combining scientific design based on molecular level with precision control of process engineering will provide a new strategy to overcome the core technical challenges. New turning point of translational medicine in nanotechnology may emerge.

Effects of formulation parameters on encapsulation efficiency and release behavior of thienorphine loaded PLGA microspheres.

To develop a long-acting injectable thienorphine biodegradable poly (d, l-lactide-co-glycolide) (PLGA) microsphere for the therapy of opioid addiction, the effects of formulation parameters on encapsulation efficiency and release behavior were studied. The thienorphine loaded PLGA microspheres were prepared by o/w solvent evaporation method and characterized by HPLC, SEM, laser particle size analysis, residual solvent content and sterility testing. The microspheres were sterilized by gamma irradiation (2.5 kGy). The results indicated that the morphology of the thienorphine PLGA microspheres presented a spherical shape with smooth surface, the particle size was distributed from 30.19 ± 1.17 to 59.15 ± 0.67 µm and the drug encapsulation efficiency was influenced by drug/polymer ratio, homogeneous rotation speed, PVA concentration in the water phase and the polymer concentration in the oil phase. These changes were also reflected in drug release. The plasma drug concentration vs. time profiles were relatively smooth for about 25 days after injection of the thienorphine loaded PLGA microspheres to beagle dogs. In vitro and in vivo correlation was established.

[A review on the influences of size and surface charge of liposome on its targeted drug delivery in vivo].

Liposomes can be cleared by the reticuloendothelial system (RES) when it is in the blood circulation in the body. And they can accumulate in the organs rich in RES in the body by passive targeting. Targeting of the liposomes is an important factor for its use as a drug carrier, and particle size as well as surface charge are important for its in vivo targeting. In this paper, studies on the influences of particle size and surface charge of the liposomes on cell binding and phagocytosis mechanism were reviewed. A comprehensive review on passive targeting effect of the particle size and surface charge of liposomes on blood, liver, spleen as well as tumor tissue was made. At last, an outlook for future research directions was made.

In-vitro/in-vivo studies of the biodegradable poly-(D,L-lactide-co-glycolide) microspheres of a novel luteinizing hormone-releasing hormone antagonist for prostate cancer treatment.

The introduction of luteinizing hormone-releasing hormone (LHRH) analogs and their antagonists is revolutionizing the treatment of prostate cancer. In this study, poly(D,L-lactideco-glycolide) (PLGA) microspheres containing a highly potent LHRH antagonist (LXT-101) of interest in the indication of prostate cancer were evaluated on release mechanisms in vitro and biological performance in vivo. LXT-101 microspheres were prepared by the water/oil/water double emulsion method and the solid/oil/oil method. The results showed that the mechanism of LXT-101 releasing from PLGA 14,000 microspheres was the cooperation of drug diffusion and polymer degradation. This clarified the relationship between the microsphere characterization and hormone level in vivo. The larger microspheres (33 µm) could inhibit the testosterone level to castration for a longer time (35 days) than the smaller microspheres (15 µm, 14 days). The formulation containing the hydrophilic additive (polyethylene glycol 6000) could suppress the testosterone level to castration for a longer time (> 35 days) than the formulation without polyethylene glycol (14 days). The appearance of testis, vesicular seminalis, and prostates changed after treatment. The weights of sexual organs decreased significantly. The in-vivo release of the LXT-101 PLGA 14,000 microspheres curve showed that in-vivo release started immediately after day 1 (22.7%) and was rapid during the first 5 days (40.2% release). The LXT-101 microspheres could be a promising drug delivery system candidate to treat sex hormone-dependent tumors and other related disorders.

Improving efficiency of adriamycin crossing blood brain barrier by combination of thermosensitive liposomes and hyperthermia.

Adriamycin (ADM)-encapsulated thermosensitive liposomes (ts-lip-ADM) and common liposomes (lip-ADM) were developed and evaluated. The encapsulation efficiency of the two liposomes were above 99%, and the average sizes of liposomes were about 120 nm. Temperature-dependent drug release from loaded liposomes in vitro was investigated: more than 90% of loaded ADM was released from ts-lip-ADM within 30 min at 42°C, while less than 3% was released from lip-ADM at 42°C beyond 120 min. An in vitro model of blood brain barrier (BBB) was established and evaluated by permeability and transendothelial electrical resistance (TEER). The model was employed to study the permeability of liposomes in vitro. The permeability of ts-lip-ADM could be increased significantly after the temperature was raised to 42°C, which was about 10-16, 22-38, 38-45, 50-105 fold to that of ts-lip-ADM (37°C), lip-ADM (42°C), lip-ADM (37°C) and free ADM, respectively. C6 glioma-bearing mice model was developed and used to evaluate body distribution and anti-tumor efficacy in vivo. Mice were IV injected at a drug dose of 10 mg/kg. After administration the heads of mice were heated in water bath at 42°C for 30 min. The maximum brain concentration of ts-lip-ADM was 6.4, 3.7 fold compared with that of ADM solution and lip-ADM, respectively. The survival time of mice administered ts-lip-ADM (44 d) was remarkably longer than that of other three groups. This study indicates that ADM-encapsulated thermosensitive liposomes combined hyperthermia could enhance ADM delivery across BBB and prolong survival time of glioma-bearing mice.

Epirubicin-encapsulated long-circulating thermosensitive liposome improves pharmacokinetics and antitumor therapeutic efficacy in animals.

In the present work, a long-circulating epirubicin hydrochloride (EPI)-containing thermosensitive liposome aiming at antitumor therapy, DPPC/MSPC/DSPG/DSPE-mPEG(2000) (EPI-LTSL), was developed and evaluated. Nonthermosensitive and traditional liposomes, HSPC/cholesterol/DSPG/DSPE-mPEG(2000) (EPI-NTSL) and HSPC/cholesterol (EPI-LIP), were also prepared at the same time for comparison. Temperature-dependent EPI release from loaded liposomes in vitro was characterized by the fluorescence method. Different liposome preparations were administered in rats by intravenous injection at the same dosage of 12 mg·kg(-1). EPI and internal standard daunorubicin hydrochloride (DAU) were analyzed by high-performance liquid chromatography and verified by LC tandem mass spectrometry. In the pharmacodynamics study, the EPI-LTSL was combined with local hyperthermia for target-specific delivery to the anesthetized and tumor-bearing mice. According to the in vitro results, more than 90% of loaded EPI was released from MSPC-containing liposome (EPI-LTSL) within 4 minutes at 43°C, while at 37°C, less than 5% was released beyond 60 minutes. However, less than 5% of drug was released at 43°C for the other two liposomes without MSPC (EPI-NTSL and EPI-LIP). The results of the pharmacokinetics study in rats showed that not only the circulation time of EPI was prolonged significantly, but also the concentration in vivo was promoted for EPI-LTSL, compared to EPI-NTSL and EPI-solution. The mean tumor inhibitory rate for EPI-LTSL, EPI-NTSL, and EPI-solution were 61.1, 39.6, and 43.1%, respectively.

Effects of gamma-irradiation on PLGA microspheres loaded with thienorphine.

Ionizing radiation can be used as a drug sterilization technique, provided that the drug itself is not modified and that no toxic products are produced; moreover, if the irradiated product is a drug delivery system, its drug release characteristics must not be significantly altered by radiation. The aim of this work was to study the effects of sterilization by ionizing radiation on PLGA microspheres, containing thienorphine. Thienorphine PLGA microspheres were prepared by the O/W solvent evaporation method and characterized by HPLC, SEM and laser particle size analysis. Our experimental results showed that gamma-rays did not alter the drug content, and did not modify the kinetics of drug release from microspheres. Moreover, no significant changes in the shape and in the size distribution of microspheres were found after irradiation. In conclusion, the sterilization method is adequate because microspheres not underwent any change after exposition to gamma-irradiation.