[Single-laboratory Validation Study and Surveillance Using an Improved Multiresidue Analytical Method for Veterinary Drugs in Livestock Products by LC-MS/MS].

A method for the rapid analysis of multiclass residual veterinary drugs in poultry muscle, egg, and raw milk was validated in accordance with Japanese guidelines. Using LC-MS/MS, 20 veterinary drugs, including sulfonamides, coccidiostats, and macrolides were analyzed in one injection. Analytes were extracted from the samples with acetonitrile and then dehydrated and salted out using magnesium sulfate, trisodium citrate, and sodium chloride. This method was assessed by performing recovery tests of chicken muscle, duck muscle, egg, and raw milk spiked with 20 new target analytes at concentrations of 10 and 100 µg/kg. According to this method, 17 out of 20 target analytes satisfied the guideline criteria in chicken muscle and duck muscle, and all 20 target analytes met the criteria in egg and raw milk. The limit of quantification was less than MRLs for all analytes. Residues were detected in 4 out of 99 samples and analyzed using the validated method, finding that the levels of all residues were lower than the limits of quantification. These results suggest that continuous monitoring for a new trend of veterinary drugs is necessary.

[Simultaneous Determination of Pesticide Residues in Brown Rice Using GC-MS/MS and LC-MS/MS].

This study developed a method that simultaneously detected 283 pesticide residues in brown rice using GC-MS/MS and LC-MS/MS. In this method, we examined the desirable amount of sodium chloride required for salting out and the SPE cartridge required for clean-up. Pesticide residues from the sample were extracted with acetonitrile using a homogenizer and mixed with salts including anhydrous magnesium, two types of citrate, and sodium chloride. The sample solution of the acetonitrile layer was cleaned up using the GCB/NH2 (200 mg/200 mg, 6 mL) SPE cartridge. The determination method was validated using two concentrations (0.01 and 0.1 µg/g) of 283 pesticides based on the validation guideline of the Ministry of Health, Labor and Welfare in Japan. Of the 283 pesticides, 250 were detected satisfactorily. In addition, 59 brown rice samples sold in Tokyo were surveyed using the same method. Out of 44 samples, 12 pesticide residues below MRLs were detected. Therefore, this developed method is useful for the simultaneous determination of pesticide residues in brown rice.

[Surveillance of Acaricides in Honey].

By using the LC-MS/MS method developed by us, we determined the residual amounts of acaricides in honey samples commercially available in Tokyo from April 2015 to March 2021. The results of analyzing 127 honey samples, amitraz was detected in 85 samples at the level of 1.1-34.1 µg/kg. Propargite was detected in 3 samples at 2.4-3.8 µg/kg. None of them was beyond the Japanese MRLs or uniform limits. In these survey for 6 years, amitraz was detected in high rate throughout the year. But, the present results imply that amitraz has been used properly in actual bee-keeping because of no violation of MRL and less fluctuation in the detected levels. On the other hand, propargite was detected at the levels over LOQ in domestic honey samples for the first time in 2020, which may suggest a new trend of acaricide use in apiculture in Japan.

[Determination of Caffeine, Theobromine, and Theophylline in Chocolate Using LC-MS].

A simultaneous determination method for caffeine, theobromine, and theophylline in chocolate was developed. Three compounds were ultrasonically extracted twice (15 min at 50℃) in an acetonitrile-water (1 : 1, v/v). The extract was purified using Oasis HLB SPE cartridge, and the purified processed by LC-MS. The method exhibited recoveries of 97.4-100.2%, RSDs of repeatability of 1.0-2.8%, and RSDs of within-laboratory reproducibility of 2.0-7.9%. This method was simpler and more selective than existing methods, and was practical for caffeine, theobromine, and theophylline analysis in chocolate.

[Determination of Tributyltin and Triphenyltin in Fish and Shellfish Using Accelerated Solvent Extraction and Liquid Chromatography with Tandem Mass Spectrometry].

A determination method for tributyltin (TBT) and triphenyltin (TPT) in fish and shellfish using an accelerated solvent extractor (ASE) and LC-MS/MS was developed. The chromatographic separation was conducted on a Poroshell 120 EC-C18 column using an isocratic mobile phase of 0.1% formic acid in 70% methanol. Sample preparation was performed using ASE at 125℃ with n-hexane and a cleanup using a Florisil cartridge. Internal calibration curves using deuterium-labeled TBT and TPT were employed for quantification. For both TBT and TPT, the calibration curves were linear in the range of 0.2-250 ng/mL, and the method quantification limits were 0.8 ng/g for both TBT and TPT. A National Institute for Environmental Studies certified reference material, No. 15 (adductor muscle of scallop), was analyzed to assess the performance of the developed method. The trueness, relative standard deviations of repeatability, and within laboratory reproducibility of this method, evaluated using a recovery test with four spiked fish species and one shellfish, ranged from 89.3 to 105.3%, 1.0 to 4.5%, and 1.3 to 7.6%, respectively.

[Determination of Antibacterial Agents for Animals in Swine Muscles by Microbiological Screening and LC-MS/MS].

The determination of antibacterial agents for animals in swine muscles was improved by microbiological screening and liquid chromatography-mass spectrometry (LC-MS/MS) analyses. In the first instance, the residual drugs were extracted from the samples using the Na2EDTA-McIlvaine buffer (pH 6.0). Subsequently, the agents were purified utilizing a PLS-3 cartridge and extracted with acetonitrile. Considering the microbiological methods, the sensitivities of the investigated drugs were higher and the test plate conditions were improved using a new reference organism Geobacillus stearothermophilus. As a result, a microbiological screening approach able to detect 33 drugs at MRL was developed in Japan. Remarkable, no false positives were detected. Moreover, the same preparation method enabled rapid and reliable microbiological screening, resulting in efficient screening with no undeterminable results.

[Determination of Antifungal Drugs in Fish and Livestock Products Using LC-MS/MS].

We developed an analytical method for determining 15 antifungal drugs, 2 antiparasitic drugs, and 3 veterinary drugs in fish and livestock products using LC-MS/MS. First, 50% ethanol was added to their products, and the mixture was homogenized to reduce drug degradation. Thereafter, 20 drugs were extracted from the pretreated sample mixture using acetonitrile. Cleanup was performed using an alumina-N SPE cartridge. Finally, chromatographic separation was performed using a fully porous octadecyl silanized silica column. The new method is applicable to fish in which the matrix hampers accurate analysis. It was validated on 8 fish and livestock products. Drug recovery rates ranged from 70.2 to 109.3%, RSDs of repeatability were <18.0%, and RSDs of within-laboratory reproducibility were <18.7%. It fulfills the Japanese guideline criteria. The limits of quantification were estimated as 3 ng/g.

[A Rapid and Simple Method for Detection of Colchicum autumnale Using PCR].

Colchicum autumnale is a perennial, toxic plant that originated in Europe and North Africa. Although inedible, it is occasionally consumed accidentally because it resembles the edible Allium victorialis and other related species. This misidentification has led to episodes of food poisoning in Japan. However, determining the causative agent of a food poisoning outbreak by observing the sample visually or analyzing the chemical composition is challenging when dealing with small samples. Therefore, we developed a novel set of PCR primers that anneal to the internal transcribed spacer (ITS) region of C. autumnale ribosomal DNA, designed to detect the presence of C. autumnale in small samples. These primers successfully detected C. autumnale in all samples in which it was present, and did not give a positive PCR band in the 48 other distinct crop species tested, in which it was not present. Further, our method could amplify DNA from samples of C. autumnale that had been heat-treated and digested using artificial gastric fluids. Thus, this PCR strategy is highly specific and can be used to distinguish C. autumnale simply and rapidly from various other crops.

Multi-residue Determination of Polar Veterinary Drugs in Livestock and Fishery Products by Liquid Chromatography/Tandem Mass Spectrometry.

Residues of 37 polar veterinary drugs belonging to six families (quinolones, tetracyclines, macrolides, lincosamides, sulfonamides, and others) in livestock and fishery products were determined using a validated LC-MS/MS method. There were two key points in sample preparation. First, extraction was performed with two solutions of different polarity. Highly polar compounds were initially extracted with Na2EDTA-McIlvaine's buffer (pH 7.0). Medium polar compounds were then extracted from the same samples with acetonitrile containing 0.1% formic acid. Secondly, cleanup was performed using a single SPE polymer cartridge. The first extracted solution was applied to the cartridge. Highly polar compounds were retained on the cartridge. Then, the second extracted solution was applied to the same cartridge. Both highly and medium polar compounds were eluted from the cartridge. This method satisfied the guideline criteria for 37 out of 37 drugs in swine muscle, chicken muscle, bovine muscle, prawn, salmon trout, red sea bream, milk, and honey; 35 out of 37 in egg; and 34 out of 37 in flounder. The LOQ ranged from 0.1 to 5 µg/kg. Residues were detected in 24 out of 110 samples and analyzed using the validated method.

Development and performance evaluation of a microbiological method for screening and LC-MS/MS for conformation of sulfonamides in animal-derived foods.

This study developed a highly sensitive microbiological method utilizing a novel microtiter plate to screen 10 sulfonamides in chicken muscles, eggs, and prawns. This plate was fabricated from agar incorporating trimethoprim and spread with Bacillus megaterium. After residue detection by bioassay, the same test solutions were analyzed by LC-MS/MS for accurate identification and quantification. It also proved eco-friendly compared to using other quantitative methods. The residual drugs were extracted with McIlvaine buffer and purified using an Oasis® MCX cartridge. A triethylamine/methanol/water (0.5:75:24.5, v/v/v) mixture was used as the eluate. The obtained LOD values of the bioassay ranged from 5 to 25 µg kg-1 allowing the detection of the target drugs at the MRLs established in Japan. Adhering to ISO/IEC 17025 standards, the performance of the bioassay was evaluated. Based on the inhibition zone size in bioassay results, quality control yielded a Z score within ±2, indicating reasonable control over the screening process. Proficiency testing of a chicken muscle sample spiked with sulfadimidine demonstrated the inhibition zone detection of the bioassay and quantified value alignment of LC-MS/MS with reference values. In a surveillance study of 91 samples, sulfamethoxazole was detected in one prawn sample.

Simultaneous determination of five carbapenems, highly polar antibiotics, in milk by LC-MS/MS.

The simultaneous determination of five carbapenems (biapenem, doripenem, ertapenem, imipenem, and meropenem) in raw and pasteurised bovine milk samples using LC-MS/MS was achieved and validated. Chromatographic separation was conducted on an InertSustain® AQ-C18 column using 0.1% formic acid in water and acetonitrile as the mobile phase. Target compounds were extracted using acetonitrile/water (20:80, v/v). After the removal of lipids with acetonitrile-saturated hexane, the dissolved protein was denatured with acetic acid. A portion of the supernatant was passed through an Oasis® PRiME HLB cartridge to remove the matrix. This novel method was validated in accordance with the Japanese validation guidelines and exhibited good trueness, ranging from 86.3% to 96.2%, using matrix-matched calibration curves. The relative standard deviation of repeatability ranged from 1.0% to 6.3%, and that of within-laboratory reproducibility ranged from 1.6% to 7.1%. The limit of quantification was 1.0 µg kg-1 for all analytes. None of the 60 milk samples commercially available in Tokyo contained any analytes. This novel method exhibited high-quality performance and can easily be implemented for the routine monitoring of carbapenems, which are highly polar antibiotics in milk.

Development of a simple screening method for analyzing cereulide toxin in fried rice using liquid chromatography-tandem mass spectrometry.

PURPOSE: The presence of cereulide, an emetic toxin produced by Bacillus cereus, in fried rice samples is critical evidence of food poisoning even in situations where B. cereus could not be detected. This study aims to develop a screening method for analyzing cereulide in fried rice using the QuEChERS procedure and liquid chromatography-tandem mass spectrometry (LC-MS/MS). METHODS: Cereulide was identified and quantified in fried rice samples using the QuEChERS extraction method and LC-MS/MS. The accuracies of the methods were determined by analyzing fortified blank samples at two concentrations (10 and 50 µg/kg) conducted on three samples daily for five days. RESULTS: The QuEChERS procedure removed matrix compounds from fried rice. Characteristic MS/MS spectra enabled the identification of cereulide. As the matrix effects in seven fried rice samples were within ± 6%, an external solvent calibration curve could be used for quantification. This method exhibited good accuracy ranging from 88 to 89%. The relative standard deviations for both repeatability and intra-laboratory reproducibility were < 4%. These standard deviations satisfied the criteria of the Japanese validation guidelines for residues (MHLW 2010, Director Notice, Syoku-An No. 1224-1). The limit of quantification was 2 µg/kg. The applicability of this method was confirmed using the analysis of cereulide in fried rice samples incubated with emetic Bacillus cereus. CONCLUSIONS: The QuEChERS extraction procedure described herein showed substantial promise as a reliable screening tool for cereulide in fried rice sample.

Validation and application of an immunochromatographic test to detect four macrolides and two lincosamides in raw cow milk.

In this study, an immunochromatographic test (using the Charm QUAD2® Test) was used to screen for residual macrolides and lincosamides in raw cow's milk. The validation parameters (selectivity/specificity, detection capability (CCß), and ruggedness) were in agreement with the requirements of[EC] 2021. The selectivity of the immunochromatographic test was verified by the negative results of microbiological tests. The false-positive rate was 0%. The CCß values of the immunochromatographic test for various antibiotics in milk were as follows: erythromycin 0.02 mg/kg, spiramycin 0.1 mg/kg, tilmicosin 0.025 mg/kg, tylosin 0.05 mg/kg, lincomycin 0.15 mg/kg, and pirlimycin 0.15 mg/kg. The determined CCß values were lower than the respective maximum residue limits (MRLs; regulatory limits in Japan) for milk, except for lincomycin (equal to the MRL). The presence of antibiotic groups other than macrolides and lincosamides did not interfere with the specificity of the test. It showed no significant difference in lot-to-lot repeatability. The results obtained by the two researchers showed no significant differences. Finally, the test was applied to milk samples obtained from a tylosin-treated cow. The outcome was positive and in agreement with the results of the chemical analytical and microbiological methods. Therefore, this validated immunochromatographic test is expected to be suitable for routine analysis to ensure milk safety.

Proteomic identification and quantification of Clostridium perfringens enterotoxin using a stable isotope-labelled peptide via liquid chromatography-tandem mass spectrometry.

PURPOSE: Detection of Clostridium perfringens enterotoxin (CPE) in human stool is critical evidence of food poisoning. However, processing patient-derived samples is difficult and very few methods exist to confirm the presence of CPE. In this study, a technique was developed using proteomic analysis to identify and quantify CPE in artificial gut fluid as an alternative. METHODS: The standard CPE was spiked into artificial gut fluids, and effective methods were developed by employing both a stable isotope-labelled internal standard peptide and liquid chromatography-tandem mass spectrometry (LC-MS/MS). RESULTS: Proteotypic peptide EILDLAAATER formed by tryptic digestion was selected for quantitation of CPE. The peptide was identified using product ion spectra. Although the nontoxic peptides originating from CPE showed very low detectability in extraction and tryptic digestion, they could be detected with sufficient sensitivity using the method we developed. Based on a spiked recovery test at two concentrations (50 and 200 µg/kg), the recovery values were 85 and 78%, respectively. The relative standard deviations of repeatability and within-laboratory reproducibility were less than 8 and 11%, respectively. These standard deviations satisfied the criteria of the Japanese validation guidelines for residues (MHLW 2010, Director Notice, Syoku-An No. 1224-1). The limit of quantification (LOQ) was estimated to be 50 µg/kg. The combination of the product ion spectra and relative ion ratio supported CPE identification at the LOQ level. CONCLUSIONS: To the best of our knowledge, this is the first report of proteomic analysis of CPE using LC-MS/MS. The method would greatly help in assessing CPE reliably.

Rapid determination of nitroimidazole residues in honey by liquid chromatography/tandem mass spectrometry.

We developed a rapid and efficient means of determining residues of four nitroimidazoles-i.e., dimetridazole, ipronidazole, metronidazole, and ronidazole-and three hydrophilic metabolites- i.e., 2-hydroxymethyl-1-methyl-5-nitroimidazole, 1 -methyl-2-(2'-hydroxyisopropyl)-5-nitroimidazole, and 1-(2-hydroxyethyl)-2-hydroxymethyl-nitroimidazole--in honey. We applied a QuEChERS (Quick, Easy, Cheap, Effective, Rugged, and Safe) procedure improved to suit a nitroimidazole analysis, which is fast (approximately 30 min) and uses less organic solvent. The procedure involves initial single-phase extraction of 5 g of honey with acetonitrile containing 1% acetic acid, followed by liquid-liquid partitioning involving the addition of 5 g sodium chloride, 1.5 g trisodium citrate dihydrate, and 4 g magnesium sulfate. Moreover, matrix from honey was reduced by an SPE method with an alumina-N cartridge. The samples were analyzed using LC/MS/MS. Chromatographic separation of these nitroimidazoles and metabolites was performed in the gradient mode on a pentafluorophenylpropyl-bonded silica column (150x2.0 mm, 3 pm particle size) at 40 degrees C. The mobile phase consisted of a 0.01% acetic acid solution and acetonitrile, and the flow rate was 0.2 mL/min. The method was validated using honey spiked with these nitroimidazoles from 0.1 to 0.5 microg/kg. The overall recovery of the seven nitroimidazoles ranged from 76.1 to 98.5%; intra- and interassay CV values were <9.5 and <14.2%, respectively. The LOQ ranged from 0.1 to 0.5 microg/kg. LC/MS/MS coupled with the QuEChERS method showed good potential as a method for determining nitroimidazole residues in honey.

Rapid determination of fumagillin residues in honey by liquid chromatography-tandem mass spectrometry using the QuEChERS method.

A new, rapid, and efficient method for determining the fumagillin residues in honey was developed. The samples extracted were analyzed using LC/MS/MS. Chromatographic separation of fumagillin was performed in gradient mode on a C8 column (100 x 2.0 mm, 5 microm) at 40 degrees C. The mobile phase consisted of a mixture of 2 mM ammonium formate-0.01% formic acid solution and methanol; the flow rate was set to 0.2 mL/min. Under these conditions, it was possible to measure fumagillin and its isomers as a single peak. The sample preparation procedure used is based on the QuEChERS (quick, easy, cheap, effective, rugged, and safe) method, which is fast (approximately 30 min) and uses less organic solvent. The fumagillin was extracted with acetonitrile containing 0.1% formic acid, then purified using a solid-phase extraction method with an Oasis mixed-mode weak anion-exchange cartridge. The overall recovery of fumagillin ranged from 88.1 to 99.4%; the intra- and interassay CVs were <4.5% and <4.9%, respectively. The LOQ was 0.1 microg/kg. LC/MS/MS coupled with the QuEChERS method showed strong potential as a method for determining fumagillin residues in honey.

Analyses of the brominated vegetable oil in soft drinks using gas chromatography-flame ionization detector and atmospheric pressure gas chromatography-quadrupole/time-of-flight mass spectrometry.

Herein, a new method for quantifying the brominated vegetable oil content in commercial soft drinks was developed, which accelerated the sample preparation process and improved analytical efficiency. First, simple and accurate chromatographic separation techniques were performed using a VF-5ht column for both GC-FID (quantitative) and APGC-QTOF (qualitative) analyses. The samples were subjected to chromatography on a reversed-phase solid-phase extraction cartridge. (PoraPak™RxnRP). Transesterification using a boron trifluoride methanol complex in methanol solution was performed. When validating this method, the analyte recovery percentages were between 82.2% and 99.9%, and the recovery and standard deviation of repeatability values were between 1.2% and 3.5%. Using an isotope library, the bromostearic acid methyl esters (9,10-dibromostearic acid methyl ester, 9,10,12,13-tetrabromostearic acid methyl ester, and hexabromostearic acid methyl ester) in the sample mixtures were qualitatively confirmed via APGC-QTOF. A novel aqueous ammonium adduct, which has not been previously reported, was also confirmed. These results indicated that this new method was simple, accurate, and also allowed for precise qualitative and quantitative confirmation as well as high reproducibility.

Monitoring of residual antibacterial agents in animal and fishery products in Tokyo from 2003 to 2019: application and verification of a screening strategy based on microbiological methods.

Residual antibacterial agents in 5909 animal and fishery products in Tokyo, Japan, were investigated over 17 consecutive years (2003-2019). Monitoring of 32 antibacterial agents (lincosamides, macrolides, penicillins, quinorones and tetracyclines) per product was accomplished via two steps: screening (by microbiological methods) and confirmation (by instrumental methods). Microbiological screening methods identified presumptive groups and determined semi-quantitative values. The instrumental methods quantified 81 residues of 11 different antibacterial agents in 72 samples. The screening strategy based on microbiological methods demonstrated the following: (i) the majority of the samples (over 99%) met Japanese regulations, (ii) using multiple methods provided a reliable inspection system with accurate quantitative values and (iii) there was a constant presence of tetracyclines and unexpected residues (lincomycin and norfloxacin) in various products. Thus, this long-term monitoring and screening strategy provided evidence that the frequencies and trends of residual antibacterial agents not only enhance food safety but also help to prevent antimicrobial resistance.

Rapid determination of fluoroquinolone residues in honey by a microbiological screening method and liquid chromatography.

A rapid and efficient method was developed for the simultaneous determination of seven fluoroquinolone (FQ) residues: norfloxacin, ciprofloxacin, danofloxacin, enrofloxacin, orbifloxacin, sarafloxacin, and difloxacin in honey. The samples were first screened with a microbiological method by using test plates made from metal-free purified agar seeded with Bacillus subtilis BGA. When a sample was found to contain FQ residues by using the microbiological method, it was analyzed by LC with fluorescence detection (LC/FL). FQs were extracted with Na2EDTA-McIlvaine buffer and purified by a dual SPE method in which a cation-exchange cartridge was connected to an anion-exchange cartridge. The overall recoveries of the seven FQs ranged from 70.0 to 92.1%. The intra-assay and interassay CVs were < or = 7.8 and < or = 5.1%, respectively. For the microbiological method, the LOD values ranged from 2 to 9 microg/kg. For LC/FL, the LOQ values ranged from 2 to 7 microg/kg. The developed method was used to analyze 70 honey samples. In 14 samples in which the microbiological method detected the presence of FQ residues, norfloxacin, ciprofloxacin, and enrofloxacin were identified by LC/FL.

Determination of bithionol, bromophen, nitroxynil, oxyclozanide, and tribromsalan in milk with liquid chromatography coupled with tandem mass spectrometry.

LC/MS/MS was developed to determine the residues of bithionol (BTN), bromofen (BMF), nitroxynil (NTX), oxyclozanide (OCZ), and tribromsalan (TBS) in milk. Samples were extracted with ethyl acetate and cleaned up by liquid-liquid separation with acetonitrile and n-hexane. The compounds were determined by RP-LC using a C18 column with 0.1% formic acid-methanol. Mass spectral acquisition was performed in the negative mode by applying selected-reaction monitoring. The method was validated in milk spiked with these compounds at 5-600 microg/kg; average recoveries were in the range 83.8-97.1%, with RSD values of 1.4-8.0%. The interassay RSDs were less than 11%. The LODs of these compounds in milk were 0.1 microg/kg. The method was applied to 24 raw milk samples. The concentration of these compounds in all samples was lower than the Japanese maximum residue limits. The method is rapid, sensitive, and specific for monitoring residues of BTN, BMF, NTX, OCZ, and TBS in milk.