Microbial Community and Chemical Characteristics of Swine Manure during Maturation.

Swine diet formulations have the potential to lower animal emissions, including odor and ammonia (NH). The purpose of this study was to determine the impact of manure storage duration on manure chemical and microbial properties in swine feeding trials. Three groups of 12 pigs were fed a standard corn-soybean meal diet over a 13-wk period. Urine and feces were collected at each feeding and transferred to 12 manure storage tanks. Manure chemical characteristics and headspace gas concentrations were monitored for NH, hydrogen sulfide (HS), volatile fatty acids, phenols, and indoles. Microbial analysis of the stored manure included plate counts, community structure (denaturing gradient gel electrophoresis), and metabolic function (Biolog). All odorants in manure and headspace gas concentrations were significantly ( < 0.01) correlated for length of storage using quadratic equations, peaking after Week 5 for all headspace gases and most manure chemical characteristics. Microbial community structure and metabolic utilization patterns showed continued change throughout the 13-wk trial. Denaturing gradient gel electrophoresis species diversity patterns declined significantly ( < 0.01) with time as substrate utilization declined for sugars and certain amino acids, but functionality increased in the utilization of short chain fatty acids as levels of these compounds increased in manure. Studies to assess the effect of swine diet formulations on manure emissions for odor need to be conducted for a minimum of 5 wk. Efforts to determine the impact of diets on greenhouse gas emissions will require longer periods of study (>13 wk).

Particulate emissions from a beef cattle feedlot using the flux-gradient technique.

Data on air emissions from open-lot beef cattle () feedlots are limited. This research was conducted to determine fluxes of particulate matter with an aerodynamic diameter ≤10 µm (PM) from a commercial beef cattle feedlot in Kansas using the flux-gradient technique, a widely used micrometeorological method for air emissions from open sources. Vertical PM concentration profiles and micrometeorological parameters were measured at the feedlot using tapered element oscillating microbalance PM samplers and eddy covariance instrumentations (i.e., sonic anemometer and infrared hygrometer), respectively, from May 2010 through September 2011, representing feedlot conditions with air temperatures ranging from -24 to 39°C. Calculated hourly PM fluxes varied diurnally and seasonally, ranging up to 272 mg m h, with an overall median of 36 mg m h. For warm conditions (air temperature of 21 ± 10°C), the highest hourly PM fluxes (range 116-146 mg m h) were observed during the early evening period, from 2000 to 2100 h. For cold conditions (air temperature of -2 ± 8°C), the highest PM fluxes (range 14-27 mg m h) were observed in the afternoon, from 1100 to 1500 h. Changes in the hourly trend of PM fluxes coincided with changes in friction velocity, air temperature, sensible heat flux, and surface roughness. The PM emission was also affected by the pen surface water content, where a water content of at least 20% (wet basis) would be sufficient to effectively reduce PM emissions from pens by as much as 60%.

Comparison of AERMOD and WindTrax dispersion models in determining PM10 emission rates from a beef cattle feedlot.

UNLABELLED: Reverse dispersion modeling has been used to determine air emission fluxes from ground-level area sources, including open-lot beef cattle feedlots. This research compared Gaussian-based AERMOD, the preferred regulatory dispersion model of the US. Environmental Protection Agency (EPA), and WindTrax, a backward Lagrangian stochastic-based dispersion model, in determining PM10 emission rates for a large beef cattle feedlot in Kansas. The effect of the type of meteorological data was also evaluated. Meteorological conditions and PM10 concentrations at the feedlot were measured with micrometeorological/eddy covariance instrumentation and tapered element oscillating microbalance (TEOM) PM10 monitors, respectively, from May 2010 through September 2011. Using the measured meteorological conditions and assuming a unit emission flux (i.e., 1 microg/m2-sec), each model was used to calculate PM10 concentrations (referred to as unit-flux concentrations). PM10 emission fluxes were then back-calculated using the measured and calculated unit-flux PM10 concentrations. For AERMOD, results showed that the PM10 emission fluxes determined using the two different meteorological data sets evaluated (eddy covariance-derived and AERMET-generated) were basically the same. For WindTrax, the two meteorological data sets (sonic anemometer data set, a three-variable data set composed of wind parameters, surface roughness, and atmospheric stability) also produced basically the same PM10 emission fluxes. Back-calculated emission fluxes from AERMOD were 32 to 69% higher than those from WindTrax. IMPLICATIONS: This work compared the PM10 emission rates determined from a large commercial cattle feedlot in Kansas by reverse dispersion modeling using AERMOD and WindTrax. Emission fluxes derived from AERMOD were greater than those from WindTrax by mean factors of 1.3 to 1.6. Based on the high linearity observed between the two models, emission fluxes derived from one dispersion model for the purpose of simulating dispersion could be applied to the other model using appropriate conversion factors.

The effect of benzoic acid with or without a direct-fed microbial on the nutrient metabolism and gas emissions of growing pigs.

Twenty-four gilts (PIC 337 × 1050, PIC Genus, Hendersonville, TN) with an initial body weight (BW) of 33.09 ± 1.33 kg were used to investigate the effects of benzoic acid (BA) and a Bacillus-based direct-fed microbial (DFM) on the nutrient metabolism and manure gas emissions of growing pigs. Pigs were blocked by BW, placed into metabolism stalls, and randomly assigned to one of four dietary treatments: basal control (PC), low nitrogen (NC), PC plus 0.3% BA (PC+BA; VevoVitall, DSM Nutritional Products), and PC plus 0.3% BA and 0.025% DFM (PC+BA+DFM; PureGro, DSM Nutritional Products). Pigs were fed a common diet from day 0 to 14, and the experimental diets were fed in two phases (day 14 to 28 and day 28 to 53). The experiment consisted of four collection periods, with each period subdivided into two subperiods to collect samples for gas emissions and nutrient balance. Firstly, manure samples were collected for 72 h. Twice daily, urine and feces were weighed, and urine pH was measured. After each period, manure was subsampled and taken to the lab to measure gas emissions. Secondly, urine and feces were quantitatively collected for 96 h to allow for measurement of nutrient digestibility (ATTD) and retention. Data were analyzed as repeated measures in SAS 9.4 (SAS Inst., Cary, NC) with fixed effects of treatment, collection period, and block. Pig was the experimental unit, and results were considered significant at P ≤ 0.05 and a tendency at 0.05 < P ≤ 0.10. Pigs fed PC+BA had the greatest ADG compared to pigs fed NC (P = 0.016), with intermediate ADG for pigs fed PC or PC+BA+DFM (P ≥ 0.148). The ATTD of dry matter, gross energy, P, and N did not differ between treatments (P ≥ 0.093). However, the ATTD of Ca was reduced in pigs fed PC+BA+DFM compared to pigs fed PC+BA (P = 0.012). Pigs fed PC+BA or NC excreted less urinary N compared to PC and PC+BA+DFM (P ≤ 0.034), which contributed to greater nitrogen retention in PC+BA compared to PC (P = 0.016). Furthermore, decreased manure pH from pigs fed PC+BA or NC resulted in lower ammonia (NH3) emissions compared to pigs fed PC+BA+DFM or PC. There was no effect of dietary treatment on manure hydrogen sulfide, methane, or carbon dioxide emissions. In conclusion, supplementing 0.3% BA improved N retention and reduced manure pH and NH3 emissions, similar to feeding pigs low N, but improved the ADG of pigs when compared to feeding a low N diet.

Diet formulation as a strategy to improve economic and nutritional efficiency may be combined with nonnutritive feed additives, such as organic acids, specifically benzoic acid, and direct-fed microbials, to further improve nutrient utilization in pigs. Therefore, the objective of this trial was to investigate the effect of supplementing benzoic acid with or without a direct-fed microbial on the nutrient metabolism and emissions of ammonia, hydrogen sulfide, carbon dioxide, and methane from the manure of growing pigs. Feeding a diet containing 0.3% benzoic acid did not affect nutrient digestibility but reduced urinary nitrogen excretion, which resulted in improved nitrogen retention compared to the basal diet. Furthermore, benzoic acid reduced urine and manure pH, contributing to reduced manure ammonia emissions. However, supplementing the direct-fed microbial alongside benzoic acid attenuated these effects.

Concentrations of particulate matter emitted from large cattle feedlots in Kansas.

Particulate matter (PM) emitted from cattle feedlots are thought to affect air quality in rural communities, yet little is known about factors controlling their emissions. The concentrations of PM (i.e., PM2.5, PM10, and total suspended particulates or TSP) upwind and downwind at two large cattle feedlots (KS1, KS2) in Kansas were measured with gravimetric samplers from May 2006 to October 2009 (at KS1) and from September 2007 to April 2008 (at KS2). The mean downwind and net (i.e., downwind - upwind) mass concentrations of PM2.5, PM10, and TSP varied seasonally, indicating the need for multiple-day, seasonal sampling. The downwind and net concentrations were closely related to the moisture content of the pen surface. The PM2.5/PM10 and PM2.5/TSP ratios at the downwind sampling location were also related to the moisture content of the pen surface, humidity, and temperature. Measurement of the particle size distribution downwind of the feedlot with a cascade impactor showed geometric mean diameter ranging from 7 to 18 microm, indicating that particles that were emitted from the feedlots were generally large in size.

Dietary composition and particle size effects on swine manure characteristics and gas emissions.

Nutrients excreted from animals affect the nutritive value of manure as a soil amendment as well as the composition of gases emitted from manure storage facilities. There is a dearth of information, however, on how diet type in combination with dietary particle size affects nutrients deposited into manure storage facilities and how this affects manure composition and gas emissions. To fill this knowledge gap, an animal feeding trial was performed to evaluate potential interactive effects between feed particle size and diet composition on manure characteristics and manure-derived gaseous emissions. Forty-eight finishing pigs housed in individual metabolism crates that allowed for daily collection of urine and feces were fed diets differing in fiber content and particle size. Urine and feces were collected and stored in 446-L stainless steel containers for 49 d. There were no interactive effects between diet composition and feed particle size on any manure or gas emission parameter measured. In general, diets higher in fiber content increased manure nitrogen (N), carbon (C), and total volatile fatty acid (VFA) concentrations and increased manure VFA emissions but decreased manure ammonia emissions. Decreasing the particle size of the diet lowered manure N, C, VFAs, phenolics, and indole concentrations and decreased manure emissions of total VFAs. Neither diet composition nor particle size affected manure greenhouse gas emissions.

Dietary protein and cellulose effects on chemical and microbial characteristics of Swine feces and stored manure.

The objectives of this study were to investigate the effects of dietary crude protein (14.5 or 12.0%) and cellulose (8.7 or 2.5%) levels on composition of feces and manure after 8 wk of diet feeding and storage. Pigs were fed twice daily; after each feeding, urine and feces were collected and added to manure storage containers. On weeks 2 and 8 after initiation of the experiment, fresh fecal and manure samples were obtained. On Week 8, increased dietary cellulose resulted in significantly higher levels of volatile fatty acids (VFA) and phenols in feces compare to other diets. In contrast, dietary protein had the greatest effect on manure chemical composition; lower protein decreased sulfur content, ammonia, and phenolic compound concentrations. High levels of either dietary cellulose or protein tended to increase microbial community similarity in fecal samples, but only high protein increased similarity among manure sample microbial communities. Fecal and manure samples from Week 8 differed from samples taken in Week 2 both in chemical and microbiological composition. Week 2 samples had lower concentrations of many of chemical compounds and microbial diversity than samples from Week 8. The fecal results indicate that after 2 wk of feeding experimental diets the animals were not fully adapted to the diets. More importantly, after only 2 wk of urine and fecal collection, manure was not representative of stored manure, limiting its usefulness in developing standards and recommendations for on-farm management practices.

Alcohol, volatile fatty acid, phenol, and methane emissions from dairy cows and fresh manure.

There are approximately 2.5 million dairy cows in California. Emission inventories list dairy cows and their manure as the major source of regional air pollutants, but data on their actual emissions remain sparse, particularly for smog-forming volatile organic compounds (VOCs) and greenhouse gases (GHGs). We report measurements of alcohols, volatile fatty acids, phenols, and methane (CH4) emitted from nonlactating (dry) and lactating dairy cows and their manure under controlled conditions. The experiment was conducted in an environmental chamber that simulates commercial concrete-floored freestall cow housing conditions. The fluxes of methanol, ethanol, and CH4 were measured from cows and/or their fresh manure. The average estimated methanol and ethanol emissions were 0.33 and 0.51 g cow(-1) h(-1) from dry cows and manure and 0.7 and 1.27 g cow(-1) h(-1) from lactating cows and manure, respectively. Both alcohols increased over time, coinciding with increasing accumulation of manure on the chamber floor. Volatile fatty acids and phenols were emitted at concentrations close to their detection limit. Average estimated CH4 emissions were predominantly associated with enteric fermentation from cows rather than manure and were 12.35 and 18.23 g cow(-1) h(-1) for dry and lactating cows, respectively. Lactating cows produced considerably more gaseous VOCs and GHGs emissions than dry cows (P < 0.001). Dairy cows and fresh manure have the potential to emit considerable amounts of alcohols and CH4 and research is needed to determine effective mitigation.

Impact of narasin on manure composition, microbial ecology, and gas emissions from finishing pigs fed either a corn-soybean meal or a corn-soybean meal-dried distillers grains with solubles diets.

An experiment was conducted to determine the effect of feeding finishing pigs a corn-soybean (CSBM) diet or a CSBM diet supplemented with 30% dried distillers grains with solubles (DDGS), in combination with or without a growth-promoting ionophore (0 or 30 mg narasin/kg of diet), has on manure composition, microbial ecology, and gas emissions. Two separate groups of 24 gilts (initial BW = 145.1 kg, SD = 7.8 kg) were allotted to individual metabolism crates that allowed for total but separate collection of feces and urine during the 48-d collection period. After each of the twice-daily feedings, feces and urine from each crate was collected and added to its assigned enclosed manure storage tank. Each tank contained an individual fan system that pulled a constant stream of air over the manure surface for 2 wk prior to air (day 52) and manure sampling (day 53). After manure sampling, the manure in the tanks was dumped and the tanks cleaned for the second group of pigs. Except for total manure Ca and P output as a percent of intake and for manure methane product rate and biochemical methane potential (P ≤ 0.08), there were no interactions between diet composition and narasin supplementation. Narasin supplementation resulted in increased manure C (P = 0.05), increased manure DM, C, S, Ca, and phosphorus as a percent of animal intake (P ≤ 0.07), and increased manure volatile solids and foaming capacity (P ≤ 0.09). No effect of narasin supplementation was noted on manure VFA concentrations or any of the gas emission parameters measured (P ≥ 0.29). In contrast, feeding finishing pigs a diet containing DDGS dramatically affected manure composition as indicated by increased concentration of DM, C, ammonia, N, and total and volatile solids (P = 0.01), increased manure DM, N, and C as a percent of animal intake (P = 0.01), increased manure total VFA and phenols (P ≤ 0.05), decreased gas emissions of ammonia and volatile sulfur compounds (VSC; P = 0.01), increased emissions of phenols and indoles (P ≤ 0.06), decreased methane production rate (P = 0.01), and slight differences in microbial ecology (R ≤ 0.47). In conclusion, feeding a diet which contains an elevated level of indigestible fiber (i.e., DDGS) resulted in more fiber in the manure which therefore dramatically affected manure composition, gas emissions, and microbial ecology, while narasin supplementation to the diet did not exhibit a significant effect on any of these parameters in the resultant swine manure.

Effects of soil storage on the microbial community and degradation of metsulfuron-methyl.

The effect storage had on the microbial biomass in two soils (Trevino and Fargo) was compared to the effect storage had on each soil's capacity to degrade metsulfuron-methyl. Soils were collected from the field and used fresh (<3 weeks old) or stored at 20 and 4 degrees C for 3 or 6 months. The phospholipid fatty acid content of the soils was used to monitor changes in the microbial biomass during storage and incubation in a flow-through apparatus. In both soils, [phenyl-U-14C]metsulfuron-methyl was used to monitor changes in the route and rate of degradation along with 14CO2 evolution (mineralization). Total microbial biomasses in both soils were significantly reduced for soils incubated in the flow-through apparatus, whereas only the Trevino soil's microbial biomass was significantly reduced as a result of storage. The microbial communities of both soils were significantly different as a result of storage as shown by discriminant analysis. In both soils, degradation rate, pathway of degradation, and mineralization of metsulfuron-methyl were significantly affected by storage compared to fresh soil. The half-life of metsulfuron-methyl increased significantly (P < 0.05) in the Trevino soil from 45 days (fresh) to 63 days (stored soil), whereas in the Fargo soil half-lives increased significantly (P < 0.05) from 23 days (fresh) to 29 days (soils stored for 6 months). In both soils, mineralization of [14C]metsulfuron-methyl was significantly (P < 0.05) higher in fresh soils compared to stored soils. The degradation pathways of metsulfuron-methyl changed with storage as evidenced by the loss of formation of one biologically derived metabolite (degradate) in stored soils compared to fresh soils.

Bias of Tedlar bags in the measurement of agricultural odorants.

Odor regulations typically specify the use of dynamic dilution olfactometery (DDO) as a method to quantify odor emissions, and Tedlar bags are the preferred holding container for grab samples. This study was conducted to determine if Tedlar bags affect the integrity of sampled air from animal operations. Air samples were collected simultaneously in both Tedlar bags and Tenax thermal desorption tubes. Sample sources originated from either a hydrocarbon-free air tank, dynamic headspace chamber (DHC), or swine-production facility, and were analyzed by gas chromatography-mass spectrometry-olfactometry (GC-MS-O). Several background contaminants were identified from Tedlar bags, which included the odorous compounds N,N-dimethyl acetamide (DMAC), acetic acid, and phenol. Samples from the DHC demonstrated that recovery of malodor compounds was dependent on residence time in the Tedlar bag with longer residence time leading to lower recovery. After 24 h of storage, recovery of C3-C6 volatile fatty acids (VFA) averaged 64%, 4-methylphenol and 4-ethylphenol averaged 10%, and indole and 3-methylindole were below the detection limits of GC-MS-O. The odor activity value (OAV) of grab samples collected in Tedlar bags were 33 to 65% lower following 24 h of storage. These results indicate that significant odorant bias occurs when using Tedlar bags for the sampling of odors from animal production facilities.

Field sampling method for quantifying odorants in humid environments.

Most air quality studies in agricultural environments use thermal desorption analysis for quantifying semivolatile organic compounds (SVOCs) associated with odor. The objective of this study was to develop a robust sampling technique for measuring SVOCs in humid environments. Test atmospheres were generated at ambient temperatures (23 +/- 1.5 degrees C) and 25, 50, and 80% relative humidity (RH). Sorbent material used included Tenax, graphitized carbon, and carbon molecular sieve (CMS). Sorbent tubes were challenged with 2, 4, 8, 12, and 24 L of air at various RHs. Sorbent tubes with CMS material performed poorly at both 50 and 80% RH dueto excessive sorption of water. Heating of CMS tubes during sampling or dry-purging of CMS tubes post sampling effectively reduced water sorption with heating of tubes being preferred due to the higher recovery and reproducibility. Tenaxtubes had breakthrough of the more volatile compounds and tended to form artifacts with increasing volumes of air sampled. Graphitized carbon sorbent tubes containing Carbopack X and Carbopack C performed best with quantitative recovery of all compounds at all RHs and sampling volumes tested. The graphitized carbon tubes were taken to the field for further testing. Field samples taken from inside swine feeding operations showed that butanoic acid, 4-methylphenol, 4-ethylphenol, indole, and 3-methylindole were the compounds detected most often above their odor threshold values. Field samples taken from a poultry facility demonstrated that butanoic acid, 3-methylbutanoic acid, and 4-methylphenol were the compounds above their odor threshold values detected most often, relative humidity, CAFO, VOC, SVOC, thermal desorption, swine, poultry, air quality, odor.