摘要
Objective To reduce the energy consumption and cost of steam sterilizers at sterile supply centers .Methods Routine data of the steam sterilizers from January to June of 2016 were collected from one hospital in Changchun .Usage by timeframe of these sterilizers was analyzed , including their performance when they are powered on , standby (idle), and powered off and their energy expenditure at such states .Sustainable and stepwise energy saving strategy was developed , with the reduction of standby ( idle) period and energy saving amount of energy and cost .Results Usage of sterilizers was found with obvious peak and valley hours , while their standby hours during the latter were long and in a few timeframes . After implementation of the energy saving management strategy , their standby hours at various timeframes averaged ≤3 h (P<0.001).For six months, we reduced 5818 hours of standby time, 97 tons of steam, 2910 kW · h of electricity , saving cost over 30000 yuan ( 17%) .Conclusions The energy-saving management strategy could reduce the consumption of energy and cost effectively .
摘要
AIM To prepare the chrysin-phospholipid complex and to investigate its pharmacokinetic behaviors.METHODS Solvent evaporation method was used for preparing the complex.With preparation temperature,preparation time,chrysin concentration and drug-lipid ratio (chrysin-phospholipid) as influencing factors,together with recombination rate as an evaluation index,the preparation was optimized by orthogonal test.The obtained complex was analyzed by X-ray diffraction,differential scanning calorimetry,1H-NMR and 31P-NMR,whose solubility was examined as well.SD rats were intragastrically administered with chrysin and its phospholipid complex,respectively.The blood concentration of chrysin was detected by HPLC,after which the pharmacokinetic parameters were calculated.RESULTS The optimal conditions were determined to be 40 ℃ for preparation temperature,2 h for preparation time,20 mg/mL for chrysin concentration,and 1 ∶ 2 for drug-lipid ratio,the recombination rate was close to 100%.Chrysin existed in an amorphous state in the phospholipid complex,which was a new phase rather than physical mixture (chrysin-phosphatidylcholine),and no new chemical bond was generated.Phospholipid complex could significantly increase chrysin's apparent solubility in water and n-octanol,the Cmax,AUC0-t and AUC0-∞ were also obviously increased as compared with raw medicine.CONCLUSION Phospholipid complex can improve both the solubility of chrysin and its oral bioavailability.