ABSTRACT
In the frame of efforts to add value to the Mediterranean currant cultivation and processing sectors, which is essential for their sustainability, sweet wine production is proposed from the finishing side-stream (FSS) of premium quality Corinthian currants, involving complete fermentation using an alcohol-tolerant yeast followed by (i) the addition of FSS to extract sugars or (ii) syrup made from FSS to adjust sweetness. Wine was also made by (iii) ceasing fermentation at the desired sugar level by ethanol addition. The non-fortified wines had 15.2-15.5% ethanol, 115-145 g/L residual sugar, 7.2-7.6 g/L titratable acidity, low volatile acidity (VA; <0.33 g/L), 280-330 mg/L phenolic content (TPC) (as gallic acid), and 23.8-35.6 mg/L antioxidant capacity (AC) (as ascorbic acid). In total, 160 volatiles were identified by SPME GC-MS, including compounds derived from the grapes, the raisin drying, and the fermentation process. The non-fortified wines had better characteristics (mainly VA, AC, and TPC) than the fortified wine, while sweetness adjustment by FSS is the simplest and lowest cost method since it does not involve ethanol or syrup addition. The proposed methods can lead to good quality sweet wines with a characteristic fruity (grape/raisin) flavor that could be commercialized as specialty raisin beverages or liqueurs.
Subject(s)
Ribes , Vitis , Wine , Wine/analysis , Antioxidants , Carbohydrates/analysis , Sugars , Ethanol , Saccharomyces cerevisiae , FermentationABSTRACT
This paper studies the reduction of crystallinity degree (CD) of cellulose treated with starch gel (SG), and the correlation of CD with the fermentation efficiency of cellulose to fuel-grade ethanol. Cellulose bioconversion from wood sawdust, consisting of three processes, was conducted in the same batch (one-step). The XRD and TEM analysis revealed 11% reduction in cellulose CD after its treatment with SG. One-step bioconversion process was performed employing two cell factories (CF) of non-engineered S. cerevisiae. CFs contained non- engineered S. cerevisiae cells covered with either SG entrapping Trichoderma reesei or cellulases prepared in the laboratory and immobilized in SG. The consolidated fermentation of treated cellulose resulted in an increase of bioethanol concentration (60-90%) in 2-day fermentation and the maximum ethanol concentration reached was approximately 5 mL/L (3.95 g/L). The fermentation efficiency for grade-fuel ethanol production was improved by cellulose pretreatment using SG to achieve reduced CD.
Subject(s)
Cellulose , Saccharomyces cerevisiae , Cellulose/metabolism , Ethanol , Fermentation , Saccharomyces cerevisiae/metabolism , StarchABSTRACT
Vinegar has been used for its health promoting properties since antiquity. Nowadays, these properties are investigated, scientifically documented, and highlighted. The health benefits of vinegar have been associated with the presence of a variety of bioactive components such as acetic acid and other organic acids, phenolic compounds, amino acids, carotenoids, phytosterols, vitamins, minerals, and alkaloids, etc. These components are known to induce responses in the human body, such as antioxidant, antidiabetic, antimicrobial, antitumor, antiobesity, antihypertensive, and anti-inflammatory effects. The diversity and levels of bioactive components in vinegars depend on the raw material and the production method used. Cereal vinegars, which are more common in the Asia-Pacific region, are usually made from rice, although other cereals, such as millet, sorghum, barley, malt, wheat, corn, rye, oats, bran and chaff, are also used. A variety of bioactive components, such as organic acids, polyphenols, amino acids, vitamins, minerals, alkaloids, melanoidins, butenolides, and specific compounds such as γ-oryzanol, tetramethylpyrazine, γ-aminobutyric acid, etc., have been associated with the health properties of cereal vinegars. In this work, the bioactive components and the related health effects of cereal vinegars are reviewed, and the most recent scientific literature is presented and discussed.
ABSTRACT
Fruit wastes and side-streams can be used for vinegar production to create added value for the agri-food sector and enhance farmer incomes and local economies. In this study, methods for vinegar production by wild and selected acetic acid bacteria (the quick starter Acetobacter aceti and the acid-resistant Komagataeibacter europaeus), free (FC) and immobilized (IC) on a natural cellulosic carrier, are proposed using sweet wine made from the industrial finishing side-stream (FSS) of Corinthian currants as raw material. The results showed all cultures can produce vinegar with 46.65 ± 5.43 g/L acidity, from sweet FSS wine containing 5.08 ± 1.19% alcohol. The effect of immobilization was more obvious in the case of the selected culture, presenting better acetification efficiency, both fresh and after cold storage for 2 months. The vinegars had an antioxidant capacity of 263.5 ± 8.4 and 277.1 ± 6.7 mg/L (as ascorbic acid) and phenolic content 333.1 ± 12.0 and 222.2 ± 2.9 mg/L (as gallic acid) (for FC and IC, respectively). They also had a rich volatilome (140 compounds identified by SPME GC-MS), with higher percentages of esters identified in vinegars made by IC. The results are encouraging for vinegar production with IC of a mixed A. aceti and K. europaeus culture.
ABSTRACT
The industrial currants finishing generates a considerable amount of side-stream (FSS) with great potential for biotechnological exploitation. The chemical composition of FSS generated from the premium quality Vostitsa currants was studied. Its use for wine making (at low temperatures, using both free and immobilized yeast) combined with baker's yeast production (with minor nutrient supplementation), is also proposed. Analysis showed that FSS has a rich volatilome (including Maillard reaction/lipid degradation products), increased antioxidant capacity, and total lipid and phenolic contents, compared to the marketable product (currants). However, acidity levels and the presence of specific volatiles (such as acetate esters and higher alcohols) may be indicative of microbial spoilage. The wines made from FSS were methanol free and contained higher levels of terpenes (indicating hydrolysis of bound forms) and fermentation-derived volatiles, compared to FSS. A preliminary technoeconomic analysis for integrated wine/baker's yeast industrial production, showed that the investment is realistic and worthwhile.
Subject(s)
Ribes/chemistry , Saccharomyces cerevisiae/growth & development , Volatile Organic Compounds/analysis , Wine/analysis , Antioxidants/chemistry , Cells, Immobilized/chemistry , Cells, Immobilized/metabolism , Chromatography, High Pressure Liquid , Fermentation , Gas Chromatography-Mass Spectrometry , Ribes/metabolism , Saccharomyces cerevisiae/chemistry , Saccharomyces cerevisiae/metabolism , Sugars/analysis , Tartrates/analysis , TemperatureABSTRACT
The aim of this work was to develop bioprocesses to produce a high-value microbial product, bacterial cellulose (BC), utilizing the industrial side-stream of Corinthian currants finishing (CFS), with/without the addition of N-sources and cheese whey, and at various process conditions (temperature, pH level, and sugar concentration). For the optimization of BC production, the response surface methodology based on the central composite design was applied. Among the possible retrieved combinations, the most ideal conditions for BC in CFS extracts supplemented with N-source were 28 °C, pH 6.42, and 46.24 g/L concentration of sugars. In a similar manner, the best conditions for BC production in CFS/whey mixtures were pH 6.36, 50.4% whey percentage in the mixture, and 1.7% yeast extract. The textural characteristics of the produced BC, at different times of production and using different drying methods, were studied by scanning electron microscopy, X-ray diffractometry, porosimetry, Fourier-transform infrared spectroscopy, and thermogravimetric/differential thermal analysis, revealing increased porosity of BC compared with delignified cellulosic materials of plant origin, and a level of crystallinity that depended on the BC production time. The proposed methodology can be used to produce foods with potential prebiotic properties, using the highly nutritious CFS and the abundant cheese whey effluent as raw materials.