High cell density sequential batch fermentation for enhanced propionic acid production from glucose and glycerol/glucose mixture using Acidipropionibacterium acidipropionici.

BACKGROUND: Propionic acid fermentation from renewable feedstock suffers from low volumetric productivity and final product concentration, which limits the industrial feasibility of the microbial route. High cell density fermentation techniques overcome these limitations. Here, propionic acid (PA) production from glucose and a crude glycerol/glucose mixture was evaluated using Acidipropionibacterium acidipropionici, in high cell density (HCD) batch fermentations with cell recycle. The agro-industrial by-product, heat-treated potato juice, was used as N-source. RESULTS: Using 40 g/L glucose for nine consecutive batches yielded an average of 18.76 ± 1.34 g/L of PA per batch (0.59 gPA/gGlu) at a maximum rate of 1.15 gPA/L.h, and a maximum biomass of 39.89 gCDW/L. Succinic acid (SA) and acetic acid (AA) were obtained as major by-products and the mass ratio of PA:SA:AA was 100:23:25. When a crude glycerol/glucose mixture (60 g/L:30 g/L) was used for 6 consecutive batches with cell recycle, an average of 35.36 ± 2.17 g/L of PA was obtained per batch (0.51 gPA/gC-source) at a maximum rate of 0.35 g/L.h, and reaching a maximum biomass concentration of 12.66 gCDW/L. The PA:SA:AA mass ratio was 100:29:3. Further addition of 0.75 mg/L biotin as a supplement to the culture medium enhanced the cell growth reaching 21.89 gCDW/L, and PA productivity to 0.48 g/L.h, but also doubled AA concentration. CONCLUSION: This is the highest reported productivity from glycerol/glucose co-fermentation where majority of the culture medium components comprised industrial by-products (crude glycerol and HTPJ). HCD batch fermentations with cell recycling are promising approaches towards industrialization of the bioprocess.

Bacterial Skin Dysbiosis in Darier Disease.

INTRODUCTION: Darier disease is a rare inherited disease with dominant skin manifestations including keratotic papules and plaques on sebaceous and flexural areas. Secondary infection of skin lesions is common, and Staphylococcus aureus commonly colonizes these lesions. The aim of the study was to characterize the bacterial microbiome of cutaneous Darier lesions compared to normal-looking skin and disease severity. METHODS: All patients with a history of Darier followed up at Emek Medical Center were invited to participate in the study. Patients that did not use antibiotics in the past month and signed informed consent had four skin sites sampled with swabs: scalp, chest, axilla, and palm. All samples were analyzed for bacterial microbiome using 16S rDNA sequencing. RESULTS: Two hundred and eighty microbiome samples obtained from lesional and non-lesional skin of the scalp, chest, axilla, and palm of 42 Darier patients were included in the analysis. The most abundant bacterial genera across all skin sites were Propionibacterium, Corynebacterium, Paracoccus, Micrococcus, and Anaerococcus. Scalp and chest lesions featured a distinct microbiome configuration that was mainly driven by an overabundance of Staphylococci species. Patients with more severe disease exhibited microbiome alterations in the chest, axilla, and palm compared with patients with only mild disease, driven by Peptoniphilus and Moryella genera in scalp and palmar lesions, respectively. CONCLUSION: Staphylococci were significantly associated with Darier lesions and drove Darier-associated dysbiosis. Severity of the disease was associated with two other bacterial genera. Whether these associations also hold a causative role and may serve as a therapeutic target remains to be determined and requires further investigation.

Co-culturing Propionibacterium freudenreichii and Bifidobacterium animalis subsp. lactis improves short-chain fatty acids and vitamin B12 contents in soy whey.

The lack of vitamin B12 in unprocessed plant-based foods can lead to health problems in strict vegetarians and vegans. The main aim of this study was to investigate the potential synergy of co-culturing Bifidobacterium animalis subsp. lactis and Propionibacterium freudenreichii in improving production of vitamin B12 and short-chain fatty acids in soy whey. Different strategies including mono-, sequential and simultaneous cultures were adopted. Growth, short-chain fatty acids and vitamin B12 were assessed throughout the fermentation while free amino acids, volatiles, and isoflavones were determined on the final day. P. freudenreichii monoculture grew well in soy whey, whereas B. lactis monoculture entered the death phase by day 4. Principal component analysis demonstrates that metabolic changes in both sequential cultures did not show drastic differences to those of P. freudenreichii monoculture. However, simultaneous culturing significantly improved vitamin B12, acetic acid and propionic acid contents (1.3 times, 5 times, 2.5 times, compared to the next highest treatment [sequential cultures]) in fermented soy whey relative to other culturing modes. Hence, co-culturing of P. freudenreichii and B. lactis would provide an alternative method to improve vitamin B12, acetic acid and propionic acid contents in fermented foods.

Membrane-based continuous fermentation with cell recycling for propionic acid production from glycerol by Acidipropionibacterium acidipropionici.

BACKGROUND: Microbial production of propionic acid (PA) from renewable resources is limited by the slow growth of the producer bacteria and product-mediated inhibition. The present study evaluates high cell density continuous PA fermentation from glycerol (Gly) using Acidipropionibacterium acidipropionici DSM 4900 in a membrane-based cell recycling system. A ceramic tubular membrane filter of 0.22 µm pore size was used as the filtering device for cell recycling. The continuous fermentations were run sequentially at dilution rates of 0.05 and 0.025 1/h using varying glycerol concentrations and two different yeast extract concentrations. RESULTS: PA volumetric productivity of 0.98 g/L.h with a product yield of 0.38 gPA/gGly was obtained with 51.40 g/L glycerol at a yeast extract concentration of 10 g/L. Increasing the glycerol and yeast extract concentrations to 64.50 g/L and 20 g/L, respectively, increased in PA productivity, product yield, and concentration to 1.82 g/L.h, 0.79 gPA/gGly, and 38.37 g/L, respectively. However, lowering the dilution rate to 0.025 1/h reduced the production efficiency. The cell density increased from 5.80 to 91.83 gCDW/L throughout the operation, which lasted for a period of 5 months. A tolerant variant of A. acidipropoinici exhibiting growth at a PA concentration of 20 g/L was isolated at the end of the experiment. CONCLUSIONS: Applying the current approach for PA fermentation can overcome several limitations for process industrialization.

Developing a single-stage continuous process strategy for vitamin B12 production with Propionibacterium freudenreichii.

BACKGROUND: Vitamin B12 is a widely used compound in the feed and food, healthcare and medical industries that can only be produced by fermentation because of the complexity of its chemical synthesis. Besides, the use of Generally Recognized as Safe (GRAS) and Qualified Presumption of Safety (QPS) microorganisms, like Propionibacterium freudenreichii, especially non-GMO wild-type producers, are becoming an interesting alternative in markets where many final consumers have high health and ecological awareness. In this study, the production of vitamin B12 using the Propionibacterium freudenreichii NBRC 12391 wild-type strain was characterized and optimized in shake flasks before assessing several scale-up strategies. RESULTS: Initial results established that: (i) agitation during the early stages of the culture had an inhibitory effect on the volumetric production, (ii) 5,6-dimethylbenzimidazole (DMBI) addition was necessary for vitamin B12 production, and (iii) kinetics of vitamin B12 accumulation were dependent on the induction time when DMBI was added. When scaling up in a bioreactor, both batch and fed-batch bioprocesses proved unsuitable for obtaining high volumetric productivities mainly due to carbon source limitation and propionic acid inhibition, respectively. To overcome these drawbacks, an anaerobic single-phase continuous bioprocess strategy was developed. This culture strategy was maintained stable during more than 5 residence times in two independent cultures, resulting in 5.7-fold increase in terms of volumetric productivity compared to other scale-up strategies. CONCLUSION: Overall, compared to previously reported strategies aimed to reduce propionic acid inhibition, a less complex anaerobic single-phase continuous and more scalable bioprocess was achieved.

Efficacy and safety of Propionibacterium extract gel versus glyceryl trinitrate ointment in the treatment of chronic anal fissure: a randomized controlled trial.

AIM: Chronic anal fissure (CAF) is an extremely frequent finding in clinical practice. Several topical agents have been proposed for its treatment with the common goal of increasing anodermal blood flow to promote healing. The aim of this study was to compare the efficacy and safety of a Propionibacterium extract gel (PeG) and 0.4% glyceryl trinitrate ointment (GTN) in patients with CAF. METHOD: Patients were randomly allocated to a PeG or GTN group and medication was administered every 12 h for 40 days. The primary outcome was the success rate, as measured by a decrease in the REALISE scoring system for anal fissure at 10, 20 and 40 days after initiating either treatment. The secondary outcomes recorded at the same time points were healing rate, visual analogue scales for itching and burning, rate of complications and adverse events, patient quality of life and satisfaction, and cost analysis. RESULTS: A total of 120 patients were enrolled, and 96 patients (PeG, n = 53; GTN, n = 43) completed the primary outcomes. A significant decrease over time in the REALISE score was observed in both groups. Adverse events occurred more frequently in the GTN group than in the PeG group, peaking at visit 1 [37 (63.8%) vs. 2 (3.4%), respectively], with headache being the most prevalent. The between-treatment cumulative average costs per patient were significantly higher for GTN than that for PeG at each follow-up visit. There were no other significant differences between the two groups for any of the other outcomes. CONCLUSION: While there was no difference in healing rates between the two treatments, PeG was more cost-effective and associated with fewer adverse events.

Regulating vitamin B12 biosynthesis via the cbiMCbl riboswitch in Propionibacterium strain UF1.

Vitamin B12 (VB12) is a critical micronutrient that controls DNA metabolic pathways to maintain the host genomic stability and tissue homeostasis. We recently reported that the newly discovered commensal Propionibacterium, P. UF1, regulates the intestinal immunity to resist pathogen infection, which may be attributed in part to VB12 produced by this bacterium. Here we demonstrate that VB12 synthesized by P. UF1 is highly dependent on cobA gene-encoding uroporphyrinogen III methyltransferase, and that this vitamin distinctively regulates the cobA operon through its 5' untranslated region (5' UTR). Furthermore, conserved secondary structure and mutagenesis analyses revealed a VB12-riboswitch, cbiMCbl (140 bp), within the 5' UTR that controls the expression of downstream genes. Intriguingly, ablation of the cbiMCbl significantly dysregulates the biosynthesis of VB12, illuminating the significance of this riboswitch for bacterial VB12 biosynthesis. Collectively, our finding is an in-depth report underscoring the regulation of VB12 within the beneficial P. UF1 bacterium, through which the commensal metabolic network may improve gut bacterial cross-feeding and human health.

Fermentation strategies to improve propionic acid production with propionibacterium ssp.: a review.

Propionic acid (PA) is a carboxylic acid applied in a variety of processes, such as food and feed preservative, and as a chemical intermediate in the production of polymers, pesticides and drugs. PA production is predominantly performed by petrochemical routes, but environmental issues are making it necessary to use sustainable processes based on renewable materials. PA production by fermentation with the Propionibacterium genus is a promising option in this scenario, due to the ability of this genus to consume a variety of renewable carbon sources with higher productivity than other native microorganisms. However, Propionibacterium fermentation processes present important challenges that must be faced to make this route competitive, such as: a high fermentation time, product inhibition and low PA final titer, which increase the cost of product recovery. This article summarizes the state of the art regarding strategies to improve PA production by fermentation with the Propionibacterium genus. Firstly, strategies associated with environmental fermentation conditions and nutrition requirements are discussed. Subsequently, advantages and disadvantages of various strategies proposed to improve process performance (high cell concentration by immobilization or recycle, co-culture fermentation, genome shuffling, evolutive and metabolic engineering, and in situ recovery) are evaluated.

Comparison of Propionibacterium genomes: CRISPR-Cas systems, phage/plasmid diversity, and insertion sequences.

The clustered regularly interspaced short palindromic repeats (CRISPR)-Cas systems constitute the adaptive immune system in prokaryotes that provide resistance against invasive genetic elements. The genus Propionibacterium comprises gram-positive, facultative anaerobe, non-spore-forming bacteria, and is the source of some B group vitamins such as B12 as well as bacteriocins. Some of the selected species of the genus Propionibacterium spp. were reclassified into the three genera in 2016 (Acidipropionibacterium spp., Pseudopropionibacterium spp., Cutibacterium spp.). Therefore, this study compared CRISPR/Cas systems, Cas 1 and repeat sequences phylogeny, phage/plasmid surveys as well as insertion sequences of new genera members. In this study, a total of 34 genomes of 13 species were observed with a bioinformatic approach. CRISPR-Cas + + and CRISPRDetect were used to detect CRISPR/Cas systems, direct repeats, and spacers. 39 CRISPR-Cas systems were detected. Type I-E, Type I-U, and one incomplete III-B CRISPR-Cas subtypes were identified. Most of the strains had Cas1/Cas4 fusion proteins. Pseudopropionibacterium propionicum strains had two types I-U and one of the CRISPR loci had csx17 cas genes. Common phage invaders were Propionibacterium phage E6, G4, E1, Anatole, and Doucette. The BLSM62 similarity score of all Cas1 sequences was 48.4% while the pairwise identity of repeat sequences was 48.7%. Common insertion sequences were ISL3, IS3, IS30. The diversity analysis of the CRISPR/Cas system in the genus Propionibacterium provided a new perspective for determining the role of the CRISPR-Cas system in the evolution of new genera.

Microaerobic metabolism of lactate and propionate enhances vitamin B12 production in Propionibacterium freudenreichii.

BACKGROUND: Propionibacterium freudenreichii is used in biotechnological applications to produce vitamin B12. Although cultured mainly in anaerobic conditions, microaerobic conditions can greatly enhance biomass formation in P. freudenreichii. Since B12 yields may be coupled to biomass formation, microaerobic conditions show great potential for increasing B12 yields in P. freudenreichii. RESULTS: Here we show biomass formation increases 2.7 times for P. freudenreichii grown in microaerobic conditions on lactate versus anaerobic conditions (1.87 g/L vs 0.70 g/L). Consumption of lactate in microaerobic conditions resulted first in production of pyruvate, propionate and acetate. When lactate was depleted, pyruvate and propionate were oxidised with a concomitant sixfold increase in the B12 titer compared to anaerobic conditions, showing potential for propionate and pyruvate as carbon sources for B12 production. Consequently, a fed-batch reactor with anaerobically precultured lactate-grown cells was fed propionate in microaerobic conditions resulting in biomass increase and production of B12. Vitamin yields increased from 0.3 [Formula: see text] B12 per mmol lactate in anaerobic conditions to 2.4 [Formula: see text] B12 per mmol lactate and 8.4 [Formula: see text] B12 per mmol propionate in microaerobic conditions. Yield per cell dry weight (CDW) increased from 41 [Formula: see text] per g CDW in anaerobic conditions on lactate to 92 [Formula: see text] per g CDW on lactate and 184 [Formula: see text] per g CDW on propionate in microaerobic conditions. CONCLUSIONS: Here we have shown both B12 yield per substrate and per CDW were highest on cells oxidising propionate in microaerobic conditions, showing the potential of propionate for biotechnological production of vitamin B12 by P. freudenreichii.

Use of apple pomace, glycerine, and potato wastewater for the production of propionic acid and vitamin B12.

Propionic acid bacteria (PAB) are a source of valuable metabolites, including propionic acid and vitamin B12. Propionic acid, a food preservative, is synthesized from petroleum refining by-products, giving rise to ecological concerns. Due to changing food trends, the demand for vitamin B12 has been expected to increase in the future. Therefore, it is necessary to look for new, alternative methods of obtaining these compounds. This study was conducted with an aim of optimizing the production of PAB metabolites using only residues (apple pomace, waste glycerine, and potato wastewater), without any enzymatic or chemical pretreatment and enrichment. Media consisting of one, two, or three industrial side-streams were used for the production of PAB metabolites. The highest production of propionic acid was observed in the medium containing all three residues (8.15 g/L, yield: 0.48 g/g). In the same medium, the highest production of acetic acid was found - 2.31 g/L (0.13 g/g). The presence of waste glycerine in the media had a positive effect on the efficiency of propionic acid production and P/A ratio. The concentration of vitamin B12 obtained in the wet biomass of Propionibacterium freudenreichii DSM 20271 ranged from 90 to 290 µg/100 g. The highest production of cobalamin was achieved in potato wastewater and apple pomace, which may be a source of the precursors of vitamin B12 - cobalt and riboflavin. The results obtained show both propionic acid and vitamin B12 can be produced in a more sustainable manner through the fermentation of residues which are often not properly managed. KEY POINTS: • The tested strain has been showed metabolic activity in the analyzed industrial side-streams (apple pomace, waste glycerine, potato wastewater). • All the side-streams were relevant for the production of propinic acid. • The addition of waste glycerine increases the propionic acid production efficiency and P/A ratio. • B12 was produced the most in the media containing potato wastewater and apple pomace as dominant ingredients.

Genomic rearrangements in the aspA-dcuA locus of Propionibacterium freudenreichii are associated with aspartase activity.

Propionibacterium freudenreichii is crucial in Swiss-type cheese manufacture. Classic propionic acid fermentation yields the nutty flavor and the typical eyes. Co-metabolism of aspartate pronounces the flavor of the cheese; however, it also increases the size of the eyes, which can induce splitting and reduce the cheese quality. Aspartase (EC 4.3.1.1) catalyzes the deamination of aspartate, yielding fumarate and ammonia. The aspartase activity varies considerably among P. freudenreichii strains. Here, the correlation between aspartase activity and the locus of aspartase-encoding genes (aspA ) and dcuA encoding the C4-dicarboxylate transporter was investigated in 46 strains to facilitate strain selection for cheese culture. Low aspartase activity was correlated with a particular genomic rearrangement: low in vitro aspartase activity always occurred in strains with gene clusters aspA - dcuA where the dcuA was frameshifted, producing a stop codon or was disrupted by an ISL3-like element. The low aspartase activity could be due to the protein sequence of the aspartase or a dysfunctional DcuA. The highest values of aspartase activity were detected in strains with aspA1 - aspA2-dcuA with a DcuA sequence sharing 99.07 - 100% identity with the DcuA sequence of strain DSM 20271 T and an additional C4-dicarboxylate transporter belonging to the DcuAB family.

A Unique Enhancement of Propionibacterium freudenreichii's Ability to Remove Pb(II) from Aqueous Solution by Tween 80 Treatment.

Microbial agents have promise for the bioremediation of Pb(II)-polluted environments and wastewater, the biodecontamination of foods, and the alleviation of toxicity in living organisms. The dairy bacterium Propionibacterium freudenreichii is poorly able to remove Pb(II) from aqueous solution at 25 ppm, ranging from 0 to 10% of initial concentration. Here, we report on an original strong enhancement of this activity (ranging from 75% to 93%, p < 0.01) following the addition of a polysorbate detergent (Tween® 80) during or either shortly after the growth of a P. freudenreichii culture. We evaluated the optimal Tween® 80 concentration for pretreatment conditions, documented the role of other detergents, and explored the possible mechanisms involved. Our results reveal a novel, environmentally friendly, low-cost pretreatment procedure for enhancing the selective removal of lead from water by probiotic-documented bacteria.

Evaluation of a Gel Containing a Propionibacterium Extract in an In Vivo Model of Wound Healing.

Inappropriate wound healing (WH) management can cause significant comorbidities, especially in patients affected by chronic and metabolic diseases, such as diabetes. WH involves several different, partially overlapping processes, including hemostasis, inflammation, cell proliferation, and remodeling. Oxidative stress in WH contributes to WH impairment because of the overexpression of radical oxygen species (ROS) and nitrogen species (RNS). This study aimed to evaluate the in vitro antioxidative action of a gel containing a Propionibacterium extract (Emorsan® Gel) and assess its skin re-epithelialization properties in a mouse model of WH. The scavenging effects of the bacterial extract were assessed in vitro through the ABTS and DPPH assays and in L-929 murine fibroblasts. The effects of the Emorsan® Gel were studied in vivo in a murine model of WH. After WH induction, mice were treated daily with vehicle or Emorsan® Gel for 6 or 12 days. According to the in vitro tests, the Propionibacterium extract exerted an inhibitory effect on ROS and RNS, consequently leading to the reduction in malondialdehyde (MDA) and nitrite levels. Before proceeding with the in vivo study, the Emorsan® Gel was verified to be unabsorbed. Therefore, the observed effects could be ascribed to a local action. The results obtained in vivo showed that through local reduction of oxidative stress and inflammation (IL-1ß, TNF-α), the Emorsan® Gel significantly reduced the infiltration of mast cells into the injured wound, leading to the amelioration of symptoms such as itch and skin irritation. Therefore, the Emorsan® Gel improved the speed and percentage of wound area closure by improving the tissue remodeling process, prompting vascular-endothelial growth factor (VEGF) and transforming growth factor (TGF)- ß production and reducing the expression of adhesion molecules. Emorsan® Gel, by its ability to inhibit free radicals, could reduce local inflammation and oxidative stress, thus enhancing the speed of wound healing.

Properties of Rice-Based Beverages Fermented with Lactic Acid Bacteria and Propionibacterium.

In recent times, consumers have shown increasing interest in plant substitutes for fermented dairy products. This study aimed to investigate the properties of yogurt-type rice-based beverages fermented with lactic acid bacteria and Propionibacterium. The changes in pH, viable population of bacteria, physical properties, and carbohydrate content of these beverages were tested. Fermentation using only Propionibacterium was insufficient to obtain a product with an acidity level similar to that of milk-based yogurt (pH < 4.5). After fermentation, the tested beverages had a high number of Lactobacillus sp. (7.42−8.23 log10 CFU/mL), Streptococcus thermophilus (8.01−8.65 log10 CFU/mL), and Bifidobacterium animalis subsp. lactis (8.28−8.50 log10 CFU/mL). The hardness (2.90−10.40 N) and adhesiveness (13.79−42.16 mJ) of the samples after 14 days of storage at 6 °C varied depending on the starter culture used. The syneresis of all samples ranged between 29% and 31%, which was lower or close to that of milk-based yogurts. The content of individual sugars in the samples also varied depending on the starter culture used for fermentation. The results suggest that the combination of lactic and propionic fermentation helps in the production of rice-based yogurt-type milk substitutes.

Rapid identification of new isolates of Acidipropionibacterium acidipropionici by fluorescence in situ hybridization (FISH).

Acidipropionibacterium acidipropionici is widely used for many applications, such as propionic acid production, cereal silage, and also as probiotic. Due to this plethora of applications, new isolates of A. acidipropionici with improved features are being searched for. These new isolates must be accurately identified, however, most approaches become expensive and time-consuming when the number of isolates is high. On the contrary, fluorescence in situ hybridization allows the affordable, reliable, and rapid identification of microorganisms in pure cultures and environmental and medical samples. Therefore, the aim of this work was to apply a fluorescent in situ hybridization probe for the reliable identification of new A. acidipropionici isolates. To this end, probe Pap446, specific for A. acidipropionici, was validated by hybridization assays with strains of this species from different origins, other species of the same genus or family, and unrelated genera. Eight isolates with propionibacterium characteristics were obtained from milk and feces of cows. Probe Pap446, hybridized only with isolates III and VI. The identity of these isolates was further confirmed by PCR using group and species-specific primers for propionibacteria and 16S rDNA sequencing.

Fermentative production of propionic acid: prospects and limitations of microorganisms and substrates.

Propionic acid is an important organic acid with wide industrial applications, especially in the food industry. It is currently produced from petrochemicals via chemical routes. Increasing concerns about greenhouse gas emissions from fossil fuels and a growing consumer preference for bio-based products have led to interest in fermentative production of propionic acid, but it is not yet competitive with chemical production. To improve the economic feasibility and sustainability of bio-propionic acid, fermentation performance in terms of concentration, yield, and productivity must be improved and the cost of raw materials must be reduced. These goals require robust microbial producers and inexpensive renewable feedstocks, so the present review focuses on bacterial producers of propionic acid and promising sources of substrates as carbon sources. Emphasis is placed on assessing the capacity of propionibacteria and the various approaches pursued in an effort to improve their performance through metabolic engineering. A wide range of substrates employed in propionic acid fermentation is analyzed with particular interest in the prospects of inexpensive renewable feedstocks, such as cellulosic biomass and industrial residues, to produce cost-competitive bio-propionic acid. KEY POINTS: • Fermentative propionic acid production emerges as competitor to chemical synthesis. • Various bacteria synthesize propionic acid, but propionibacteria are the best producers. • Biomass substrates hold promise to reduce propionic acid fermentation cost.

Improving the drying of Propionibacterium freudenreichii starter cultures.

Propionibacterium freudenreichii is a beneficial food-grade actinobacterium, widely implemented, and thus consumed, in various food products. As the main application, P. freudenreichii is used as a cheese-ripening starter, mostly in hard type cheeses. Indeed, during manufacture of "Swiss-type" cheeses (or opened-body cheeses), the technological process favors propionibacteria growth, as well as the corresponding propionic fermentation. This leads to the characteristic flavor of these cheeses, through the release of short chain fatty acids and through lipolysis, as well as to their specific texture. To fulfil this ripening, massive amounts of propionibacteria are industrially produced, dried and stored, prior to cheese making. Furthermore, P. freudenreichii is commercialized in various probiotic food supplements aiming at preserving intestinal health and comfort, in line with its ability to produce beneficial metabolites (short chain fatty acids, vitamins), as well as immunomodulatory compounds. Other industrial applications of P. freudenreichii include the production of food-grade vitamins of the B group, of trehalose, of conjugated linoleic acid, and of biopreservatives. For these different applications, maintaining survival and activity of propionibacteria during production, drying, storage and finally implementation, is crucial. More widely, maintaining live and active probiotic bacteria represents a challenge as the market for probiotic products increases. Probiotic bacteria are, for a bulk majority, freeze-dried, but spray drying is also more and more considered. Indeed, this process is both continuous and more cost-efficient, as it utilizes less energy compared to freeze-drying; on the other hand, it exposes bacteria to higher heat and oxidative stresses. Apart from process optimization and strain selection, it is possible to enhance the resistance of bacteria by taking advantage of their adaptation capacity. Indeed, P. freudenreichii stress tolerance can be boosted by different pretreatments applied before the drying step, thus considerably increasing its final survival. In particular, adaptation to hyperosmotic conditions improves stress tolerance, while the presence of osmoprotectants may mitigate this improvement. Thermal adaptation also modulates tolerance towards these technological challenges. The composition of the growth medium, including the ratio between the carbohydrates provided and the non-protein nitrogen, plays a key role in driving the accumulation of osmoprotectants. This, in turn, determines P. freudenreichii tolerance towards different stresses, and overall towards both freeze-drying and spray-drying. As an example, the accumulation of trehalose enhances its spray-drying survival, while the accumulation of glycine betaine enhances its freeze-drying survival. Growth of propionibacteria in hyperconcentrated whey was used to trigger multiple stress tolerance acquisition, underpinned by overexpression of key stress protein, accumulation of cytoplasmic storage compounds, and leading to enhanced spray-drying survival. A simplified process, from cultivation to atomization, was developed by using whey as a 2-in-1 medium in which propionibacteria were grown, protected and dried with minimal cell death. This innovative process was then subjected to scaling up at the industrial level. In this aim, a gentle multi-stage drying process offering mild drying conditions by coupling spray drying with belt drying, led to final probiotic survival close to 100% when stress tolerance acquisition was previously implemented. Such innovation opens new avenues for the efficient, cost-effective and sustainable development of new probiotic production technologies, as well as probiotic application in the context of food and feed. KEY POINTS: • Propionibacteria acquire multi-stress tolerance when grown in hyper-concentrated whey. • Spray drying of osmo-adapted probiotic bacteria is possible with limited cell death. • A two-in-one drying method is developed to grow and dry probiotic bacteria in the same matrix.

In vivo model of Propionibacterium (Cutibacterium) spp. biofilm in Drosophila melanogaster.

OBJECTIVES: Acne vulgaris is a common inflammatory disorder of the pilosebaceous unit and Propionibacterium acnes biofilm-forming ability is believed to be a contributing factor to the disease development. In vivo models mimicking hair follicle environment are lacking. The aim of this study was to develop an in vivo Propionibacterium spp. biofilm model in Drosophila melanogaster (fruit fly). METHODS: We created a sterile line of D. melanogaster able to sustain Propionibacterium spp. biofilms in the gut. In order to mimic the lipid-rich, anaerobic environment of the hair follicle, fruit flies were maintained on lipid-rich diet. Propionibacterium spp. biofilms were visualized by immunofluorescence and scanning electron microscopy. We further tested if the biofilm-dispersal activity of DNase I can be demonstrated in the developed model. RESULTS: We have demonstrated the feasibility of our in vivo model for development and study of P. acnes, P. granulosum and P. avidum biofilms. The model is suitable to evaluate dispersal as well as other agents against P. acnes biofilm. CONCLUSIONS: We report a novel in vivo model for studying Propionibacterium spp. biofilms. The model can be suitable for both mechanistic as well as interventional studies.

Bioaugmentation as a strategy for tailor-made volatile fatty acid production.

This study aimed to develop a novel strategy for tailor-made volatile fatty acid (VFA) composition. For this purpose, the mixed microbial culture was bioaugmented by Propionibacterium acidipropionici. Anaerobic sequencing batch reactors were operated with cheese wastewater under alkali pH. While the maximum propionic acid production almost four times increased (3779 ± 201 mgCODeq propionic acid/L in the bioaugmented reactor and 942 ± 172 mgCODeq propionic acid/L in the control reactor), there was no significant difference in VFA composition. The gene copy number of P.acidipropionici increased 20 times after the bioaugmentation. Furthermore, the gene copy number of P.acidipropionici was positively correlated with total VFA and isovaleric acid concentration. The relative abundance of family Flavobacteriaceae increased in the bioaugmented reactor, which might be caused by the syntrophic relation between Flavobacteriaceae and P. acidipropionici. The cycle analysis results showed that the shorter cycle (6h) could ensure the same efficiency.