Microbial community of anammox bacteria immobilized in polyethylene glycol gel carrier.

Anaerobic ammonium oxidation (anammox) is a recently discovered microbial pathway in the biological nitrogen cycle and a new cost-effective way to remove ammonium from wastewater. We have so far developed new immobilization technique that anammox bacteria entrapped in polyethylene glycol (PEG) gel carrier. However, fate and behavior of anammox bacteria in a gel carrier is not well understood. In the present study, we focused on the population changes of anammox bacteria in a gel carrier. Three specific primer sets were designed for real-time PCR. For quantification of anammox bacteria in a gel carrier, real-time PCR was performed. The anammox bacteria related to HPT-WU-N03 clone were increased the rate in anammox population, and found to be a major population of anammox bacteria in a gel carrier. Furthermore, from the results of nitrogen removal performance and quantification of anammox bacteria, the correlation coefficient between copy numbers of anammox bacteria and nitrogen conversion rate was calculated as 0.947 in total anammox population. This is the first report that population changes of anammox bacteria immobilized in a gel carrier were evaluated.

Recovery oriented phosphorus adsorption process in decentralized advanced Johkasou.

Decentralized advanced wastewater treatment using adsorption and desorption process for recovery and recycling oriented phosphorus removal was developed. Adsorbent particles made of zirconium were set in a column, and it was installed as subsequent stage of BOD and nitrogen removal type Johkasou, a household domestic wastewater treatment facility. The water quality of the effluent of adsorption column in a number of experimental sites was monitored. The effluent phosphorus concentration was kept below 1 mg l(-1) during 90 days at all the sites. Furthermore, over 80% of the sites achieved 1 mg l(-1) of T-P during 200 days. This adsorbent was durable, and deterioration of the particles was not observed over a long duration. The adsorbent collected from each site was immersed in alkali solution to desorb phosphorus. Then the adsorbent was reactivated by soaking in acid solution. The reactivated adsorbent was reused and showed almost the same phosphorus adsorption capacity as a new one. Meanwhile, the desorbed phosphorus was recovered with high purity as trisodium phosphate by crystallization. It is proposed as a new decentralized system for recycling phosphorus that paves the way to high-purity recovery of finite phosphorus.

Evaluation of constructed wetlands by wastewater purification ability and greenhouse gas emissions.

Domestic wastewater is a significant source of nitrogen and phosphorus, which cause lake eutrophication. Among the wastewater treatment technologies, constructed wetlands are a promising low-cost means of treating point and diffuse sources of domestic wastewater in rural areas. However, the sustainable operation of constructed wetland treatment systems depends upon a high rate conversion of organic and nitrogenous loading into their metabolic gaseous end products, such as N2O and CH4. In this study, we examined and compared the performance of three typical types of constructed wetlands: Free Water Surface (FWS), Subsurface Flow (SF) and Vertical Flow (VF) wetlands. Pollutant removal efficiency and N2O and CH4 emissions were assessed as measures of performance. We found that the pollutant removal rates and gas emissions measured in the wetlands exhibited clear seasonal changes, and these changes were closely associated with plant growth. VF wetlands exhibited stable removal of organic pollutants and NH3-N throughout the experiment regardless of season and showed great potential for CH4 adsorption. SF wetlands showed preferable T-N removal performance and a lower risk of greenhouse gas emissions than FWS wetlands. Soil oxidation reduction potential (ORP) analysis revealed that water flow structure and plant growth influenced constructed wetland oxygen transfer, and these variations resulted in seasonal changes of ORP distribution inside wetlands that were accompanied by fluctuations in pollutant removal and greenhouse gas emissions.

Use of real-time PCR to examine the relationship between ammonia oxidizing bacterial populations and nitrogen removal efficiency in a small decentralized treatment system 'Johkasou'.

The aim of this study was to examine the relationship between ammonia oxidizing bacterial populations and biological nitrogen removal in a small on-site domestic wastewater treatment system "Johkasou". The population dynamics of ammonia oxidizing bacteria (AOB) in six full-scale advanced Johkasous was surveyed using real-time PCR assay over a period of one year. These Johkasous were selected to compare the AOB populations in different treatment performance. When the effluent NH4-N concentration was higher than 2 mg L(-1), it was difficult to meet the effluent standard of advanced Johkasous (T-N 10 mg L(-1)). In contrast, the nitrogen removal efficiency was hardly affected by nitrite oxidation and denitrification in these systems. In other words, ammonia oxidation was a rate-limiting step. Furthermore, we focused on the relationship between NH4-N loading per AOB cell and nitrogen removal. Real time PCR monitoring results demonstrated that it is important to regulate NH4-N loading per AOB cell below 210 pg cell(-1) day(-1) to meet the effluent standard of advanced Johkasou. It is considered that NH4-N loading per AOB cell is a useful parameter for determining suitable nitrogen loading and small decentralized system design.

Evaluation of sludge reduction and phosphorus recovery efficiencies in a new advanced wastewater treatment system using denitrifying polyphosphate accumulating organisms.

A new biological nutrient removal process, anaerobic-oxic-anoxic (A/O/A) system using denitrifying polyphosphate-accumulating organisms (DNPAOs), was proposed. To attain excess sludge reduction and phosphorus recovery, the A/O/A system equipped with ozonation tank and phosphorus adsorption column was operated for 92 days, and water quality of the effluent, sludge reduction efficiency, and phosphorus recovery efficiency were evaluated. As a result, TOC, T-N and T-P removal efficiency were 85%, 70% and 85%, respectively, throughout the operating period. These slightly lower removal efficiencies than conventional anaerobic-anoxic-oxic (A/A/O) processes were due to the unexpected microbial population in this system where DNPAOs were not the dominant group but normal polyphosphate-accumulating organisms (PAOs) that could not utilize nitrate and nitrite as electron acceptor became dominant. However, it was successfully demonstrated that 34-127% of sludge reduction and around 80% of phosphorus recovery were attained. In conclusion, the A/O/A system equipped with ozonation and phosphorus adsorption systems is useful as a new advanced wastewater treatment plant (WWTP) to resolve the problems of increasing excess sludge and depleted phosphorus.

Cloning, characterization and expression of beta-N-acetylglucosaminidase gene from Streptomyces thermoviolaceus OPC-520(1).

The nagB gene encoding beta-N-acetylglucosaminidase from S. thermoviolaceus OPC-520 was cloned and sequenced. The nagB gene could encode a protein of 541 amino acids with a calculated molecular mass of 58274. NagB revealed significant similarities to beta-N-acetylhexosaminidases and chitobiases from bacteria, which are classified into family 20 glycosyl hydrolases. NagB effectively hydrolyzed all of the chitin oligosaccharides from dimer to hexamer.

Cloning and sequence analysis of the gene encoding a thermostable chitinase from Streptomyces thermoviolaceus OPC-520.

The gene (chi40) encoding a thermostable chitinase from Streptomyces thermoviolaceus OPC-520 was cloned in Escherichia coli JM109 using pUC18. The nucleotide (nt) sequence of chi40 has been determined. A single open reading frame (ORF) encoded a protein consisting of 414 amino acids (aa) with a M(r) of 43,838. The deduced aa sequence of the cloned chitinase (Chi40) showed striking homology (74%) with Chi63 from Streptomyces plicatus. Comparison with other chitinases revealed that Chi40 contained the two conserved regions common to microbial and plant chitinases. Furthermore, the putative promoter region of chi40, which might be involved in the repression and induction of such catabolite-controlled genes, was detected by the DNA sequence alignments.

Gene sequence, purification and characterization of N-acetyl-beta-glucosaminidase from a marine bacterium, Alteromonas sp. strain O-7.

The gene (cht60) encoding N-acetyl-beta-glucosaminidase (Cht; EC 3.2.1.30) from the marine bacterium Alteromonas sp. strain O-7 was cloned into pUC18 in Escherichia coli JM109. The nucleotide (nt) sequence of cht60 was determined. A 1797-bp open reading frame encoded a polypeptide of 598 amino acids (aa) (M(r) 64,535). The aa sequence of the cloned enzyme (Cht60) deduced from the nt sequence showed no significant sequence homologies with available aa sequences from databases. Cht60 was purified from the periplasmic fraction of E. coli cells carrying pCHT982. The enzyme was most active towards p-nitrophenyl-N-acetyl-beta-D-glucosaminide(PNP-beta-GlcNAc) and diacetylchitobiose. The optimum pH and temperature of the enzyme were pH 7.5 and 37 degrees C, respectively. The N-terminal 11 aa residues of Cht60 were sequenced, and the location of the signal peptide cleavage site was clarified.

Cloning and sequence of an alkaline serine protease-encoding gene from the marine bacterium Alteromonas sp. strain O-7.

The gene (aprII) encoding alkaline serine protease (AprII; subtilase) from Alteromonas sp. strain O-7 was cloned in plasmid pUC19 and transformed into Escherichia coli JM109. The nucleotide (nt) sequence of aprII has been determined. A single open reading frame (ORF) encoded a protein consisting of 621 amino acids (aa) with a M(r) of 63,958. The results of aa sequence analysis indicated that AprII is produced as a large precursor consisting of four domains: the signal sequence, the N-terminal pro-region (AprII-N), the mature AprII (AprII-M) and the C-terminal pro-region (AprII-C). The aa sequence of AprII-M shows high sequence homology with those of class-II subtilases. Two conserved sequences were found in AprII-N which might play a critical role in the maintenance of chaperone-like activity. Repeated aa sequences were observed in AprII-C (AprII-C1 and AprII-C2). The aa sequences of AprII-C1 and AprII-C2 show high sequence homology with those of the C-terminal pro-region of the other known proteases.

Synthesis of chitinase in Streptomyces thermoviolaceus is regulated by a two-component sensor-regulator system.

The chiS and chiR genes located upstream of the chitinase locus (chi40) on the chromosome of Streptomyces thermoviolaceus OPC-520 were cloned and sequenced. The deduced amino acid sequences revealed that ChiS (390 amino acids, 40.9 kDa) and ChiR (213 amino acids, 22 kDa) show significant sequence similarities to histidine kinases and response regulators, respectively, of typical prokaryotic two-component regulatory systems. The extracellular chitinase activity of Streptomyces lividans 66 (pTSR2 (bearing chiS, chiR and chi40)) was significantly enhanced by a high dosage of the chiS and chiR genes.

Factors influencing joint-preserving operations in the treatment of the late stages of osteoarthritis of the hip.

Between November 1983 and December 1992, 136 hips (119 patients) with coxarthritis were operated on using joint-preserving techniques based on the rationale of Pauwels' osteotomy. The criterion for selection was a patient in whom the height of the joint space in the weight-bearing area of the hip was less than 1 mm. The mean age at operation was 48 years and the mean follow-up 109 months (60 to 171). Hips were categorised using Bombelli's classification of osteoarthritis, into atrophic and non-atrophic types. The endpoint was defined as that at which the height of the joint space became less than 1 mm again. The Kaplan-Meier curve showed that the rate of survival of the non-atrophic group was significantly better than that of the atrophic group. Cox's proportional hazard model indicated that the factors influencing the results of joint-preserving operations included Bombelli's classification, postoperative incongruence of the joint and the height of the joint space.

Emission and control of nitrous oxide from a biological wastewater treatment system with intermittent aeration.

Nitrous oxide (N2O) can be emitted as a by-product of the process of nitrogen removal from wastewater. Two methods of complete denitrification and media application were studied in lab-scale intermittent aeration reactors fed with domestic wastewater to refine methods of controlling the N2O emission rate. A study on cyclic patterns showed that the highest N2O emission rate was at the beginning of the aerobic phase rather than the anoxic phase. This was probably because the nitrifying bacteria had accumulated nitrite nitrogen (NO2-) under low DO conditions. Methanol as an external carbon source was added during the anoxic phase to reduce nitrate nitrogen (NO3-) when denitrification was completed. The N2O emission rates in both the aerobic and anoxic phases were significantly influenced by residual NO3-, increasing monotonically as the concentration of NO3- in the reactor increased. Over 95% of average N2O emissions in both the aerobic and anoxic phases were prevented when methanol was added. The biofilm reactor showed similar patterns to those of the non-biofilm reactor in track behavior, but the former was more effective in the reduction of N2O emissions.

Microbial community analysis in the denitrification process of saline-wastewater by denaturing gradient gel electrophoresis of PCR-amplified 16S rDNA and the cultivation method.

The metallurgic wastewater generated from the processes of recovering precious metals from industrial wastes contains high concentrations of nitrogen compounds and salts. Biological nitrogen removal from this wastewater was attempted using a circulating bioreactor system equipped with an anaerobic packed bed or an anaerobic fluidized bed. The denitrification capability of the system with the anaerobic packed bed was more stable than that of the system with the anaerobic fluidized bed. The NOx removal rate of the anaerobic packed bed was as high as 97%. Microbial community analysis by denaturing gradient gel electrophoresis (DGGE) of PCR-amplified 16S ribosomal DNA (rDNA) fragments and the cultivation method revealed that the community diversity varied in accordance with wastewater composition such as the level of salinity and so on. Phylogenetic analysis suggested that the taxonomic affiliation of the dominant species in the anaerobic reactors was to the gamma-Proteobacteria including Halomonadaceae species. The PCR-DGGE method as a non-cultivation method was found to be a powerful tool for analysis of the microbial community, because the cultivation method could detect only a fraction of the microbial species present in these systems. The genetic diversity of the isolated bacteria belonging to the gamma-Proteobacteria which reduced both nitrate and nitrite in the anaerobic packed bed was higher than that of the bacteria in the anaerobic fluidized bed. This suggested that a genetically diverse microbial community stabilized the denitrifying performance in the anaerobic packed bed.

Measurements of N2O and CH4 from the aerated composting of food waste.

Emissions of N2O and CH4 from an aerated composting system were investigated using small-scale simulated reactors. The results show relatively high emissions of N2O at the beginning of composting, in proportion to the application amount of food waste. After 2 days, the N2O emission decreased to 0.53 ppmv on average, near to the background level in the atmosphere (0.45 ppmv). The addition of composted cattle manure increased N2O emissions not only at the beginning of composting, but also during the later period and resulted in two peak emission curves. Good correlation was observed between the N2O concentration at the air outlet and NO2- concentration in waste, suggesting a generation pathway for N2O from NO2- to N2O. Methane was only detected in treatments containing composted cattle manure. The high emission of methane illustrates the involvement of anoxic/anaerobic microorganisms with the addition of composted manure. The result suggests the existence of anoxic or anaerobic microsite inside the waste particles even though ventilation was employed during the composting process.

Degradation of microcystin by biofilm in practical treatment facility.

Potential for degradation of microcystin by biofilm was examined by some batch experiments using biofilm scraped from practical biological treatment facility combined with conventional treatment processes. The viable cells of Microcystis viridis, which produced microcystin LR, RR and YR were degraded at 6 to 10 days by the addition of biofilm. Biofilm collected in summer season had especially higher potential for degradation of Microcystis with complete degradation at 6 days. In all seasons, Monas spp. grew remarkably, accompanied with the higher decrease of the viable cells of Microcystis and the micro-animals were considered as a main predator for Microcystis cells. Intracellular microcystin LR, RR, YR were degraded simultaneously with high reduction of Microcystis cells. Dissolved microcystin LR of 1,000 microg l(-1) was effectively degraded by indigenous aquatic bacteria on biofilm during 5 days, the degradability became higher with the increase in the concentration of microcystin LR. From the results of our research, it was clarified that the aggregated microorganisms consisting of biofilm had high potential for degradation of intracellular and dissolved microcystin.

Effects of SRT and DO on N2O reductase activity in an anoxic-oxic activated sludge system.

Nitrous oxide (N2O) is emitted from wastewater treatment processes, and is known to be a green house gas contributing to global warming. It is thus important to develop technology that can suppress N2O emission. The effects of sludge retention time (SRT) and dissolved oxygen (DO) on N2O emission in an anoxic-oxic activated sludge system were estimated. Moreover, the microbial community structure in the sludge, which plays an important role in N2O suppression, was clarified based on nitrous oxide reductase (nosZ) gene analysis by molecular biological techniques. The results showed that under low SRT conditions, nitrification efficiency was reduced and the N2O emission rate in the oxic reactors was increased. It was also observed that N2O emission was enhanced under low DO conditions, where the available oxygen is insufficient for nitrification. Moreover, molecular analysis revealed that the clones identified in this study were closely related to Ralstonia eutropha and Paracoccus denitrificans. The fact that the identified sequences are not closely related to known culturable denitrifier nosZ sequences indicates a substantial in situ diversity of denitrifiers contributing to N2O suppression, which are not reflected in the cultivatable fraction of the population. The further application of these new molecular techniques should serve to enhance our knowledge of the microbial community of denitrifying bacteria contributing to N2O suppression in wastewater treatment systems.

Comparison of detection specificity of nitrifying bacteria in biofilm using fluorescence in situ hybridization and in situ fluorescent antibody methods.

The in situ fluorescent antibody and fluorescence in situ hybridization (FISH) methods are very useful in the in situ detection of specific bacteria like nitrifiers in a biofilm. In this study, simultaneous staining using the FISH and in situ fluorescent antibody methods was examined. As a result, no specific fluorescence was observed with either method when FISH was performed followed by the in situ fluorescent antibody method; however, when the in situ fluorescent antibody method was performed first followed by FISH, specific fluorescence was observed in both cases. Moreover, it was suggested that the detection specificities of FISH and the in situ fluorescent antibody method are almost identical.

Detection and quantification of expression of amoA by competitive reverse transcription-pCR.

Ammonia oxidation by chemolithoautotrophic ammonia-oxidizing bacteria is an important step in the biological nitrogen removal process. The first conversion step, the oxidation of ammonia to hydroxylamine is catalyzed by ammonia monooxygenase (AMO). To investigate the activity of ammonia oxidation, mRNA (designated as amoA) encoding a subunit of AMO was quantified by competitive reverse transcription (RT)-PCR. As a result, it was possible to detect and quantify amoA expression in cultured Nitrosomonas europaea and even complex microbial communities such as nitrifying bacterial aggregates by competitive RT-PCR. It was estimated that amoA concentration in cultured N. europaea was 2.3 x 10(8) copies x ml(-1). Additionally, it was calculated that the copy number of amoA in nitrifying bacterial aggregates was 1.0 x 10(12) copies x ml(-1) (5.1 x 10(10) copies x mg(-1)-dry weight). On the other hand, amoA expression in the natural activated sludge in a household Gappei-Johkaso was undetectable, whereas 16S rRNA of ammonia-oxidizing bacteria was detected by RT-PCR. Then, four days cultivation of this sludge in inorganic artificial wastewater resulted in increasing amoA expression to a quantifiable amount by competitive RT-PCR. In conclusion, the competitive RT-PCR was effective to investigate the expression of amoA as an indicator of ammonia oxidation activity by autotrophic ammonia-oxidizing bacteria.

PCR-DGGE analysis of denitrifying bacteria in a metallurgic wastewater treatment process.

The wastewater generated from the processes of recovering precious metals from industrial wastes contains high concentrations of acids such as nitric acid and of salts. Biological nitrogen removal from this wastewater was attempted by using a circulating bioreactor system equipped with an anoxic packed bed or an anoxic fluidized bed and an aerobic three-phase fluidized bed. The system was found to effectively remove nitrogen from the diluted wastewater (T-N; 1,000-4,000 mg litre(-1)). The microbial population structure of activated sludge in an anoxic reactor was analyzed by denaturing gradient gel electrophoresis (DGGE) of PCR-amplified 16S ribosomal DNA (rDNA) fragments. DGGE analysis under different operating conditions demonstrated the presence of some distinguishable bands in the separation pattern, which were most likely derived from many different species constituting the microbial communities. Furthermore, the population diversity varied in accordance with the nitrate-loading rate, water temperature and reactor condition. Some major DGGE bands were excised, reamplified and directly sequenced. It was revealed that the dominant population in the anoxic reactor were affiliated with the beta subclass of the class Proteobacteria.

Characterization of microbial community in nitrogen removal process of metallurgic wastewater by PCR-DGGE.

The metallurgic wastewater generated from the processes of recovering precious metals from industrial wastes contains high concentrations of nitrogen compounds such as ammonia and nitric acid and of salts such as sodium chloride and sodium sulfate. Biological nitrogen removal from this wastewater was attempted by a circulating bioreactor system equipped with an anoxic packed bed and an aerobic fluidized bed. The anoxic packed bed of this system was found to effectively remove nitrite and nitrate from the wastewater by denitrification at a removal ratio of 97%. As a result of denitrification activity tests at various NaCl concentrations, the sludge obtained from the anoxic packed bed exhibited accumulation of nitrite at 5.0 and 8.4% NaCl concentrations, suggesting that the reduction of nitrite is the key step in the denitrification pathway under hypersaline conditions. The microbial community analysis by denaturing gradient gel electrophoresis (DGGE) of PCR-amplified 16S ribosomal DNA (rDNA) fragments revealed that the community diversity varied in accordance with water temperature, nitrate-loading rate and ionic strength. When particular major DGGE bands were excised, reamplified and directly sequenced, the dominant species in the anoxic packed bed were affiliated with the beta and gamma subclasses of the class Proteobacteria such as Alcaligenes defragrans and Pseudomonas spp., respectively.