Set-style yoghurts made from goat milk bases fortified with whey protein concentrates.

This research paper addresses the hypothesis that the fortification of goat milk base with whey protein concentrate (WPC) could affect both the textural and the biofunctional properties of set-style yoghurt. The effect of fortification of goat milk base with two different WPCs on thermophilic bacteria counts, proteolysis, physical and biofunctional properties of set-style yoghurts was studied at specific sampling points throughout a 4-week storage period. Fortification and storage did not influence thermophilic counts. Physical properties were affected significantly (P < 0.05) by the composition of the protein and the mineral fraction of the WPC but not by the storage. ACE-inhibitory activity was moderate in accordance to low lactobacilli counts and lack of proteolysis. DPPH-radical scavenging activity, Fe2+-chelating activity and superoxide scavenging activity were high. At 28 d an anti-inflammatory effect was observed, which was not affected by WPC addition.

Influence of Salting and Ripening Conditions on the Characteristics of a Reduced-Fat, Semi-Hard, Sheep Milk Cheese.

This study aimed to assess the effect of salting and ripening conditions on the features of sheep milk, reduced-fat, semi-hard cheese. Eight groups of cheese, with an average fat content of ≅10.5%, moisture on non-fat substances (MNFS) ≅ 56%, a protein-to-fat ratio of 2.9 and pH 5.1, were manufactured and analyzed throughout ripening. The experimental factors were the salting method (brine- or dry-salting), the salt content (control- and reduced-salt) and the ripening temperature sequence (11 or 18 °C at the 3rd and 4th week). Brine-salted cheese exhibited significantly more adequate (p < 0.05) textural and organoleptic characteristics compared to its dry-salted counterpart, i.e., lower hardness, gumminess and adhesiveness, with higher lightness and flavor scores. The mean salt reduction from 2.1 to 1.6% exhibited significant effects (p < 0.05), i.e., increased moisture and MNFS, decreased hardness, gumminess, chewiness and adhesiveness, and increased lightness and meltability of cheese without affecting the microbiological stability or impairing the organoleptic parameters. Ripening at 18 °C at weeks 3-4 significantly increased (p < 0.05) proteolysis and concentrations of lactic and citric acid without affecting meltability, textural or organoleptic features. In conclusion, brine-salting, salt reduction by 20% and the elevation of temperature at a particular ripening period improved the characteristics of this type of reduced-fat sheep milk cheese.

Incorporation of Yogurt Acid Whey in Low-Lactose Yogurt Ice Cream.

Yogurt acid whey (YAW), a by-product of strained yogurt production, is a strong environmental pollutant because of its high organic load. Hence, efforts are made for its utilization to minimize its disposal in the environment. This study deals with the incorporation of YAW in yogurt ice cream (YIC) by partial replacement of yogurt with simultaneous lactose hydrolysis (LH) of the formulated YIC mix. Six YIC mix formulations were made, two without YAW (non-LH- and LH-control samples, A and AH), two with 12.5% YAW (samples B and BH), and two with 18.75% YAW (samples C and CH). The results showed that the partial replacement of yogurt with YAW decreased significantly (p < 0.05) the total solids of B, BH, C, and CH products (31.72 ± 0.14%, 31.92 ± 0.21%, 30.94 ± 0.14%, and 31.27 ± 0.10%, respectively) compared to the total solids of control products A and AH (33.30 ± 0.36% and 33.74 ± 0.06%, respectively). In contrast, the overruns increased (51.50 ± 2.36%, 58.26 ± 0.09%, 56.86 ± 1.92%, and 65.52 ± 1.30% for the B, BH, C, and CH products, respectively) compared to control samples (42.02 ± 2.62% and 49.53 ± 2.12% for A and AH, respectively). LH significantly decreased the freezing point and the viscosity of the YIC mixes but increased the overruns of the products as shown previously. YAW significantly decreased the hardness of the B and C products (56.30 ± 2.11 N and 43.43 ± 3.91 N, respectively) compared to control A (81.14 ± 9.34 N), and LH decreased it even more, leading to a rather soft scoop YIC. AH, BH, and CH YICs exhibited better melting properties despite the lack of fat destabilization in all samples. After 60 days of storage, counts of yogurt starter microorganisms were still >107 cfu/g and DPPH radical scavenging activity had increased in all products. In the sensory evaluation test, lactose-hydrolyzed samples AH, BH, and CH had less intense sandiness and, as expected, more intense sweetness. In conclusion, in the framework of the circular economy, it is possible for the YAW to be used as a resource material at a ratio of 12.5% to produce a YIC product without leaving behind any new waste.

Effect of Modified Manufacturing Conditions on the Composition of Greek Strained Yogurt and the Quantity and Composition of Generated Acid Whey.

Greek strained yogurt is produced in high quantities worldwide. This production leaves behind acid whey, a by-product that is an environmental challenge. Hence, efforts are made to minimize the acid whey generation. In this study, the combined effect of the different heat treatment levels of milk and the different time of straining on the composition of the produced strained yogurt, as well as on the quantity and composition of the expelled acid whey, was investigated. The initial yogurts were prepared with bovine milk heated at 85 °C/16 s or 100 °C/16 s or 90 °C/5 min, and the acid whey was removed by centrifugation (5500 rpm, 5 min, 25 °C) either immediately after incubation or after 24 h. The results showed that, regardless of the heat treatment of milk, straining after 24 h resulted in an 8% increase in the yield in strained yogurt and about an 11% decrease in the generated acid whey, compared to straining immediately after incubation. The heat treatment level of milk significantly influenced the fat, lactose, and total solids contents of the strained yogurts, as well as the residual whey proteins, protein, and total solids contents of acid whey. Yogurt's sensory properties were not affected significantly. It was concluded that the quantity of the acid whey expelled during the production of Greek strained yogurt could be decreased without affecting the general quality of the yogurt.

Novel Processing Technology of Dairy Products.

Milk has been processed into dairy products using traditional methods for hundreds of years [...].

CHEESE and WHEY: The Outcome of Milk Curdling.

The present Special Issue is dedicated to both products of the cheesemaking process, that is cheese and whey [...].

Quark-Type Cheese: Effect of Fat Content, Homogenization, and Heat Treatment of Cheese Milk.

The effect of homogenization and fat reduction in combination with variable heating conditions of cow milk on the characteristics of Quark-type cheese were investigated. The mean composition of full-fat cheeses was 71.96% moisture, 13.95% fat, and 10.31% protein, and that of its reduced-fat counterparts was 73.08%, 10.39%, and 12.84%, respectively. The increase of heat treatment intensity increased moisture retention and improved the mean cheese protein-to-fat ratio from 0.92 to 1. Homogenization increased the moisture and protein retention in cheese, but the effect was less intense for milk treated at 90 °C for 5 min. The extended denaturation of whey proteins resulted in harder, springier, and less cohesive cheese (p < 0.05). Treatment of milk at 90 °C for 5 min resulted in higher residual lactose and citric acid and lower water-soluble nitrogen contents of cheese (p < 0.05); the latter was also true for homogenization (p < 0.05). Storage did not affect the composition and texture but decreased galactose and increased citric acid and soluble nitrogen fractions (p < 0.05). In conclusion, heat treatment conditions of milk that induced a considerable denaturation of ß-lactoglobulin and left a considerable amount of native α-lactalbumin was adequate for the manufacture of a "clean-label" Quark-type cheese, whereas homogenization was more effective for full-fat cheese.

Microfiltration of Ovine and Bovine Milk: Effect on Microbial Counts and Biochemical Characteristics.

The aim of this research work was to assess the effect of the microfiltration (ceramic membranes 1.4 µm, 50 °C) of partially defatted ovine milk (fat 0.4%) and bovine milk (fat 0.3%) characteristics. Feed milks, permeates and retentates were analyzed for microbial counts, gross composition, protein fractions, the indigenous enzymes cathepsin D and alkaline phosphatase and the behavior during renneting. It was showed that the microbial quality of both ovine and bovine permeate was improved by reduction of the total mesophilic microflora about 4 Log and 2 Log, respectively. The protein contents and the total solids contents of both permeates were significantly (p < 0.05) reduced. A further analysis of protein fractions by Reversed Phase -High Performance Liquid Chromatography (RP-HPLC) revealed lower αs1- and ß-casein and higher κ-casein contents in permeates. The activity of alkaline phosphatase followed the allocation of the fat content, while activity of cathepsin D in permeates was not influenced, although somatic cells counts were removed. Regarding cheesemaking properties, the firmness of ovine curd made from the feed milk did not differ significantly from that made from the permeate. The obtained results suggested that microfiltration could be used for pre-treating of ovine milk prior to cheesemaking.

Influence of Salting Method on the Chemical and Texture Characteristics of Ovine Halloumi Cheese.

The effects of dry salting for 24 h, or brine salting under different conditions (i.e., 7%, 10%, or 13% NaCl (w/w) at 4 or 20 °C for 3, 6, 24, or 48 h) on ovine Halloumi cheese composition and textural properties were studied. In the brine-salted cheeses, the moisture content, ranging from 45.53 ± 0.7 to 53.55 ± 0.6 g/100 g, was decreased as the concentration and temperature of brine and salting time were increased. In contrast, the salt content, ranging from 2.17 ± 0.01 to 4.97 ± 0.10 g/100 g, increased by increasing the salting time and brine concentration, and the increased sodium content of cheeses was correlated with their decreased potassium content. Cheeses dry-salted for 24 h contained higher levels of calcium (1064-1093 mg/100 g) than brine-salted cheeses kept for 24 or 48 h (751-922 mg/100 g). The same trend was observed for phosphorus, magnesium, and potassium content. In addition, dry-salted cheeses showed significantly (p < 0.05) lower hardness and fracturability values, compared to cheeses brine salted at 13% brine for more than 24 h, independently of the brine temperature. It was concluded that dry salting of Halloumi cheese for one day was the most appropriate salting method for dietary and nutritious reasons.

Study of caprine beta-casein using reversed-phase high-performance liquid chromatography and mass spectroscopy: identification of a new genetic variant.

The genotypes and the main phosphorylation levels of beta-casein of goat milk were studied using RP-HPLC/ESI-MS. A new variant of caprine beta-casein named E has been characterized using RP-HPLC/ESI-MS, MALDI-MS and NanoESI MS/MS methods. Its sequence differed from that of variant A in the mono amino acid substitution D47 --> Y47, which resulted in a 48 Da experimental mass difference between them. The calculated molecular mass of the new variant E 6 P was estimated as 23,869 Da. Its phosphorylation pattern was similar to that of variant A, the most abundant types being those with 5 and 6 P in similar quantities.

Evolution of microbial populations during traditional Feta cheese manufacture and ripening.

In three different dairies (A, B and C) located in Peloponess region (Southern Greece), traditional Feta cheese trials took place February to March using mixtures of sheep's and goat's milk. Only small variations in the evolution of microbial groups were observed during the whole ripening period. The main groups, such as thermophilic cocci, mesophilic lactococci, thermophilic lactobacilli, nonstarter lactic acid bacteria (NSLAB), presumptive Leuconostoc, enterococci and micrococci, reached their highest levels during the first 16 days, and then declined approximately 1-2 log units until the end of ripening. The remaining groups investigated, comprising yeasts, coliforms and Escherichia coli, were highest at day 4. The yeasts remained constant, while coliforms and E. coli decreased sharply and were not detectable after 120 days of ripening. A number of 146 isolates (dairy A) taken from all stages of the manufacturing and ripening process were purified and studied. Lactobacillus plantarum (58/146) and isolates of related species Lactobacillus pentosus and Lactobacillus paraplantarum (16/146) were the most common microorganisms found during cheese ripening. Streptococcus thermophilus (23/146) and Lactobacillus delbrueckii subsp. bulgaricus (20/146) were detected in high levels up to 20 days, and then gradually reduced. Enterococcus faecium (29/146) was found in all manufacturing and ripening stages.

Assessment of heat treatment of various types of milk.

Raw milk (RM), reconstituted condensed milk (CM) and three types of reconstituted milk powders (SMPs) were heated indirectly at 80-140°C for 4 s. Native ß-lactoglobulin after 90°C treatment of RM was 1132±167 mg/L but no reliable quantities were estimated at temperatures >100°C, whereas 218±43 mg/L residual α-lactalbumin were found at 130°C. Average lactulose contents from 51 to 1549 mg/L were detected at ⩾100°C; average furosine was 1.9 and 126.5 mg/L in raw and 140°C treated milks respectively. The behaviour of heated CM was similar to that of heated RM except for higher furosine concentration. Reconstituted SMPs contained high quantities of lactulose and furosine, the ratio of which was lower than in similarly treated RM. Among the market milks analysed, the group of high-pasteurised milks was highly variable; i.e. native ß-lactoglobulin was 69-2831 mg/L, lactulose 0-824 mg/L and furosine 3.3-68.8 mg/L.

Purification and characterization of chymosin and pepsin from kid.

The objective of this work was to study the characteristics of the gastric aspartic proteinases chymosin and pepsin which are constituents of the kid rennet. The two enzymes were extracted from abomasal tissue of one kid from a local indigenous breed, separated from each other by DEAE-cellulose chromatography and then were purified by gel filtration and anion-exchange chromatography. The molecular weights of the purified kid chymosin and pepsin as determined by gel filtration were 36 kDa and 40 kDa respectively. The isoelectric point of kid chymosin was as multiple forms of 3-6 zones at pH 4.6-5.1, while that of kid pepsin was at pH < or =3.0. Kid pepsin contained 0.37 molecules phosphorous per molecule and was totally inhibited by 5 muM pepstatin A, being more sensitive than kid chymosin. Both enzymes were almost equally as proteolytic as calf chymosin on total casein at pH 5.6. Kid pepsin activity was more pH and temperature dependent than kid chymosin activity. In comparison with the calf chymosin temperature sensitivity, the order of increased sensitivity was: calf chymosin