ABSTRACT
Solanum lycopersicum (Tomato) leaves and stems are considered waste. Valorization of this waste can be achieved by for example the extraction of proteins. This prospect is promising but currently not feasible, since protein extraction yields from tomato leaves are low, amongst other due to the (physical) barrier formed by the plant cell walls. However, the molecular aspects of the relationship between cell wall properties and protein extractability from tomato leaves are currently not clear and thus objective of this study. To fill this knowledge gap the biochemical composition of plant cell walls was measured and related to protein extraction yields at different plant ages, leaf positions, and across different tomato accessions, including two Solanum lycopersicum cultivars and the wildtype species S. pimpinellifolium and S. pennellii. For all genotypes, protein extraction yields from tomato leaves were the highest in young tissues, with a decreasing trend towards older plant material. This decrease of protein extraction yield was accompanied by a significant increase of arabinose and galacturonic acid content and a decrease of galactose content in the cell walls of old-vs-young tissues. This resulted in strong negative correlations between protein extraction yield and the content of arabinose and galacturonic acid in the cell wall, and a positive correlation between the content of galactose and protein extraction yield. Overall, these results point to the importance of the pectin network on protein extractability, making pectin a potential breeding target for enhancing protein extractability from tomato leaves.
Subject(s)
Hexuronic Acids , Solanum lycopersicum , Solanum lycopersicum/genetics , Arabinose , Galactose , Plant Breeding , Cell Wall/metabolism , Plant Leaves/metabolism , Pectins/metabolismABSTRACT
Non-covalent interactions of phenolics with proteins cannot always be readily identified, often leading to contradictory results described in the literature. This results in uncertainties as to what extent phenolics can be added to protein solutions (for example for bioactivity studies) without affecting the protein structure. Here, we clarify which tea phenolics (epigallocatechin gallate (EGCG), epicatechin and gallic acid) interact with the whey protein ß-lactoglobulin by combining various state-of-the-art-methods. STD-NMR revealed that all rings of EGCG can interact with native ß-lactoglobulin, indicating multidentate binding, as confirmed by the small angle X-ray scattering experiments. For epicatechin, unspecific interactions were found only at higher protein:epicatechin molar ratios and only with 1H NMR shift perturbation and FTIR. For gallic acid, none of the methods found evidence for an interaction with ß-lactoglobulin. Thus, gallic acid and epicatechin can be added to native BLG, for example as antioxidants without causing modification within wide concentration ranges.
Subject(s)
Catechin , Catechin/chemistry , Phenol , Tea/chemistry , Lactoglobulins/chemistry , Phenols/analysis , Antioxidants/chemistry , Gallic AcidABSTRACT
Selective removal of phenolic compounds (PCs) from de-oiled sunflower kernel is generally considered a key step for food applications, but this often leads to protein loss. PC removal yield and protein loss were assessed during an aqueous or aqueous ethanol washing process with different temperatures, pH-values and ethanol contents. PC yield and protein loss increased when the ethanol content was < 60% or when a higher temperature was applied. Our main finding is that preventing protein loss should be the key objective when selecting process conditions. This can be achieved using solvents with high ethanol content. Simulation of the multi-step exhaustive process showed that process optimization is possible with additional washing steps. PC yield of 95% can be achieved with only 1% protein loss using 9 steps and 80% ethanol content at 25â. The functional properties of the resulting concentrates were hardly altered with the use of high ethanol solvents.
Subject(s)
Ethanol/chemistry , Helianthus/chemistry , Phenols/isolation & purification , Seeds/chemistry , Hydrogen-Ion Concentration , Phenols/chemistry , Plant Proteins/chemistry , Solvents/chemistry , Sunflower Oil/chemistry , Temperature , Water/chemistryABSTRACT
Concentrated soy protein isolate (SPI) - pectin blends acquire fibrous textures by shear-induced structuring while heating. The objective of this study was to determine the viscoelastic properties of concentrated SPI-pectin blends under similar conditions as during shear-induced structuring, and after cooling. A closed cavity rheometer was used to measure these properties under these conditions. At 140⯰C, SPI and pectin had both a lower G* than the blend of the two and also showed a different behavior in time. Hence, the viscoelastic properties of the blend are richer than those of a simple composite material with stable physical phase properties. In addition, the G'pectin was much lower compared with the G'SPI and G'SPI-pectin upon cooling, confirming that pectin formed a weak dispersed phase. The results can be explained by considering that the viscoelastic properties of the blend are influenced by thermal degradation of the pectin phase. This degradation leads to: i) release of galacturonic acid, ii) lowering of the pH, and iii) water redistribution from the SPI towards the pectin phase. The relative importance of those effects are evaluated.
Subject(s)
Elasticity/physiology , Pectins/analysis , Pectins/chemistry , Soybean Proteins/analysis , Soybean Proteins/chemistry , Soybean Proteins/physiology , ViscosityABSTRACT
Leaf membrane proteins are an underutilised protein fraction for food applications. Proteins from leaves can contribute to a more complete use of resources and help to meet the increasing protein demand. Leaf protein extraction and purification is applied by other disciplines, such as proteomics. Therefore, this study analysed proteomic extraction methods for membrane proteins as an inspiration for a food-grade alternative process. Sugar beet leaves were extracted with two proteomic protocols: solvent extraction and Triton X-114 phase partitioning method. Extraction steps contributed to protein purity and/or to selective fractionation, enabling the purification of specific proteins. It was observed that membrane proteins distributed among different solvents, buffers and solutions used due to their physicochemical heterogeneity. This heterogeneity does not allow a total membrane protein extraction by a unique method or even combinations of processing steps, but it enables the creation of different fractions with different physicochemical properties useful for food applications.
Subject(s)
Beta vulgaris/chemistry , Chemical Fractionation/methods , Food Handling/methods , Membrane Proteins/isolation & purification , Plant Leaves/chemistry , Octoxynol , Polyethylene Glycols , Proteomics , SolventsABSTRACT
We here report on the use of water as a 'green' extraction solvent for the isolation of isoflavones from okara, a by-product of soymilk production. At a low liquid-to-solid ratio of 20 to 1 and 20 °C, 47% of the isoflavones that can be extracted with 70% aqueous ethanol were extracted. The malonyl-glucosides were fully recovered with a ratio of 20 to 1, while ß-glucosides were recovered with an increased liquid-to-solid ratio of 40 to 1. The extraction of aglycones was better at higher ratios, but leveled off before reaching a 100% yield. Temperature hardly affected the total amount of isoflavones. At a 20 to 1 ratio, 20 °C, and pH 10, there was no significant difference (p>0.05) between isoflavone extraction in water and in 70% aqueous ethanol. The results suggest that water may be used as a green alternative for separation of isoflavones from okara.